NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
64 reportsClear category filterMileage unknown · May 7, 2001
Engine And Engine CoolingService Brakes, HydraulicSuspension
THE FAULTY ENGINE MOUNT AND REAR AXLE SHOCK ABSORBER CAUSE EXTREME VIBRATION IN THE ENTIRE VEHICLE WHILE DRIVING, THE ENGINE IS NOT HARMONICALLY BALANCED AND SETS UP A VIBRATION THAT EXTENDS TO THE FRAME AND THE REAR SHOCK ABSORBERS. *YH . CONSUMER STATES THAT THIS PROBLEM IS A MANUFACTURER DEFECT, BUT MANUFACTURER IS N OT WILL…
Read full complaint
THE FAULTY ENGINE MOUNT AND REAR AXLE SHOCK ABSORBER CAUSE EXTREME VIBRATION IN THE ENTIRE VEHICLE WHILE DRIVING, THE ENGINE IS NOT HARMONICALLY BALANCED AND SETS UP A VIBRATION THAT EXTENDS TO THE FRAME AND THE REAR SHOCK ABSORBERS. *YH . CONSUMER STATES THAT THIS PROBLEM IS A MANUFACTURER DEFECT, BUT MANUFACTURER IS N OT WILLING TO TAKE ANY RESPONSIBILITY, CONSUMER WAS ADVISED BECAUSE OF THE AGE AND THE MILEAGE IT WOULD BE THE CONSUMER'S RESPONSIBILITY,*JB
NHTSA ODI #561085
Mileage unknown · Mar 16, 2001
Engine And Engine CoolingService Brakes, Hydraulic
ENGINE BACKFIRE CAUSES SUDDEN LOSS OF BRAKES. SEVEN VACUUM HOSES TIE INTO THE ONE PIPE AND THEN INTO THE INTAKE MANIFOLD. ONLY THE BRAKE VACUUM ASSIST HAS A CLAMP ON THE HOSE. WHEN THE ENGINE BACKFIRES INTO THE INTAKE MANIFOLD, IT BLEW OFF THREE OF THESE HOSES RESULTING IN INADEQUATE VACUUM FOR THE POWER ASSIST BRAKES. THE ENGIN…
Read full complaint
ENGINE BACKFIRE CAUSES SUDDEN LOSS OF BRAKES. SEVEN VACUUM HOSES TIE INTO THE ONE PIPE AND THEN INTO THE INTAKE MANIFOLD. ONLY THE BRAKE VACUUM ASSIST HAS A CLAMP ON THE HOSE. WHEN THE ENGINE BACKFIRES INTO THE INTAKE MANIFOLD, IT BLEW OFF THREE OF THESE HOSES RESULTING IN INADEQUATE VACUUM FOR THE POWER ASSIST BRAKES. THE ENGINE FUNS VERY ROUGH BUT MAYBE IT WILL SMOOTH OUT WHEN DRIVEN A LITTLE. SO, YOU DRIVE AND SUDDENLY FIND NO BRAKES. IF YOU ARE LUCKY, YOU HAVE TIME AND ROOM ENOUGH TO STOP.
NHTSA ODI #742534
Mileage unknown · Feb 2, 2001
Engine And Engine CoolingSuspension
FROM THE BEGINNING THE EXPLORER HAS HAD ENGINE VIBRATION,OIL LEAKAGE PROBLEMS,AT 98 MILES, OF BUYING THE EXPLORER FROM THE DEALER FROM BRAND NEW. AS TO DATE THE EXPLORER HAS NOT BEEN FIXED, AND WHEN I HAVE TAKEN THE EXPLORER IN TO BE FIXED,THEY ASK ME TO TAKE IT HOME FOR THEY DONE WANT TO FIX IT.I HAVE REPORTED IT TO THE ATTERNE…
Read full complaint
FROM THE BEGINNING THE EXPLORER HAS HAD ENGINE VIBRATION,OIL LEAKAGE PROBLEMS,AT 98 MILES, OF BUYING THE EXPLORER FROM THE DEALER FROM BRAND NEW. AS TO DATE THE EXPLORER HAS NOT BEEN FIXED, AND WHEN I HAVE TAKEN THE EXPLORER IN TO BE FIXED,THEY ASK ME TO TAKE IT HOME FOR THEY DONE WANT TO FIX IT.I HAVE REPORTED IT TO THE ATTERNEY GENERALS OFFICE,AND FORD WROTE THEM A LETTER AND SAID THERE WASN'T ANYTHING WRONG,BUT THEY LYIED???? THE ENGINE HAS BEEN FIXED 22 TIMES FOR OIL LEAKS,TRANSMITTION 3 TIMES,VIBRATION 12 TIMES OR MORE,3 TIMES FOR THE ENGINE MISSING,3 TIMES FOR THE ENGINE BEENING NOISEY,AND ONE DEALER WORKED ON IT HAS SAID IT CAN'T BE FIXED, THAT FORD SHOULD REPLACE IT, BUT THIS WAS DENIED BY FORD AS THE DEALER HAD MADE THE REQUEST. AFTER ALL OF THIS ?? THIS DOESN'T SEAM FAIR??? FOR WE STILL HAVE THE EXPLORER WITH ALL THE SAME PROBLEMS,OIL LEAKS ,VIBRATIONS,TRANSMITTION NOT RIGHT,GAS IN THE OIL,AND STILL MISSES. CAN ANYTHING BE DONE BY YOU??
NHTSA ODI #740356
Mileage unknown · Dec 26, 2000
Engine And Engine Cooling
2 FLYWHEELS WARPED AND CRACKED DUE TO METAL FATIGUE AT MOUNTING BOLTS: 11/1999 AND 12/2000 FOLLOWING SERVICE BY FORD (1) AND INDEPENDENT (2). *AK
NHTSA ODI #738301
Mileage unknown · Sep 24, 2000
Engine And Engine Cooling
VEHICLE JUST STALLED. TOOK VEHICLE TO THE DEALERSHIP, AND MECHANIC WAS ABLE TO DUPLICATE PROBLEM. REPLACED MODULE ASSEMBLY AND CRANK SENSOR. *AK
NHTSA ODI #871347
Mileage unknown · Aug 31, 2000
Engine And Engine Cooling
LEAKY READIATOR CAUSED WATER TO GET INTO THE TRANSMISSION WHICH RESULTED IN THE TRANSMISSION SLIPPING IN SECOND GEAR. NLM
NHTSA ODI #554223
Mileage unknown · Aug 18, 2000
Engine And Engine Cooling
WE BOUGHT A NEW RADIATOR FROM MODINE MANUFACTURING AND IT LEAKED ANTIFREEZE INTO OUR TRANSMISSION AND NOW WE HAVE A VECHICLE THAT NEEDS A NEW TRANSMISSION, BECAUSE ITS NOLONGER ANY GOOD.
NHTSA ODI #728336
Mileage unknown · Aug 15, 2000
Engine And Engine Cooling
ENGINE RUNNING ROUGH AT SLOW IDLE BUT OK AT FAST IDLE.
NHTSA ODI #728028
Mileage unknown · Jun 6, 2000
Engine And Engine CoolingService Brakes, Hydraulic
AFTER PURCHASING THIS UV FROM A DEALER.PAYING TOP DOLLAR FOR THIS EDDIE BAUER UV,I HAVE HAD NOTHING BUT PROBLEMS WITH THE VEHICLE. COULD NOT GO MORE THAN 60 MILES AN HIUR,UV WAS SHAING SO BAD. OIL LEAKING ,BRAKES BAD. IT WAS BANDAIDED T SELL I AM SURE. A 8 YEAR OLD CAR WITH ONLY 52,000MILES AND IN THIS HORRIBLE REPAIR CONDITION,…
Read full complaint
AFTER PURCHASING THIS UV FROM A DEALER.PAYING TOP DOLLAR FOR THIS EDDIE BAUER UV,I HAVE HAD NOTHING BUT PROBLEMS WITH THE VEHICLE. COULD NOT GO MORE THAN 60 MILES AN HIUR,UV WAS SHAING SO BAD. OIL LEAKING ,BRAKES BAD. IT WAS BANDAIDED T SELL I AM SURE. A 8 YEAR OLD CAR WITH ONLY 52,000MILES AND IN THIS HORRIBLE REPAIR CONDITION,IS ALMOST SUSPECT TO INQUIRE Y OF A ODOMETER TURN BACK, LUCKILY I BOUGHT INS, TOOK TO A FORD DEALERAND HAD REPAIRS TOTOALLING ALMOST $2500.OF WHICH I HAD TO PAY $800. OUT OF MY OWN POCKET. THE BRAKES NEEDED TO BE WORKED ON, THER WERE 3 RECA;LLS WHICH WERE TAKEN CARE OF. THE ENGINE WAS NEEDING SEALS AND MUCH MORE . THE DRIVER SEAT BELT IS BROKE,NOW AND THE ENGINE IS NOW LEAKING AGAIN AND I HAVE TO PUT A QT. OF OIL EVERY WEK. THE CAR IS BASICALLY UNSFAE TO DRIVE,BETWEEEN THE BRAKES AND THE ENGINE LEAKING OIL,WHICH I WAS TOLD IF IT GOT INTO THE GEAR BOX,IT WOULD START A FIRE. THIS WAS THE WORDS OF THE FORD DEALER.WHRE I HAD THE UV SERVICED. RECENTLY I NOTICED AN ARTICLE IN THE NEWSPAPER COMMENTING ONTHE FROD GASKET FLAW.I HAVE BEEN TRYING FRO DAYS TO CALL THEIR TOLL FREE NUMBER FOR INFROMATION LINE ALWAYS BUSY. THEY DO RECALL SOME OF THIS MODEL.IDONT KNOW WHERE TO TURN TO ANY MORE I HAVE 3 CHILDREN AND AM CONCERNED ABOUT THEIR SAFTEY,A SINGLE MOTHER WITH NO INCOME OTHER THAN 900.. AMONTH FROM WORKMASN COMP. CANT AFFORD ANYMORE REPAIRS NEEED HELP TO WHERE I NEED TO GO, I FEEL THE UV IS NOT SAFE AND I FEEL THAT THE ODOMETER MAY HAVE BEEN SET BACK, THE DEALERS WHERE I PURCHASED ARE TIRED OF HERING MY COMPLAINTS. THEY WORKED ONTHE UV ONCE, BUT NEVER GAVE ME A LIST OF WHAT WORK THEY DID AFTER HAVING THE CAR IN THEIR SHOP FOR 10 DAYS. I WOULD LIKE MY MONEY BACK,BUT I WILL HAVE TO PROVE THE CAR IS NOT SAFE . TELL ME WHAT I CAN DO. I CAN FGAX YOU ALL THE COPIES OF REPAIR WORK THAT WAS SERVICED ON THIS CAR IN FEB. IF YOU NEED THEM IT MAY HELP U MAKE A DESICION AS TO WHERE I TURN TO NEXT. PLEASE RESPOND WHAT DO I DO??*AK
NHTSA ODI #723657
Mileage unknown · Apr 14, 2000
Electrical SystemEngine And Engine CoolingFire
WHILE DRIVING ABOUT 20 MPH VEHICLE WAS LOSING POWER. VEHICLE WAS ON FIRE, FLAMES WERE COMING OUT FROM UNDER THE ENGINE COMPARTMENT. *AK.ET.
NHTSA ODI #860393
NHTSA investigations
14EA00012 · Spare Tire Winch Cable
Opened Apr 14, 2000 · Closed Oct 20, 2000
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE99072 · Spare Tire Winch Cable
Opened Nov 30, 1999 · Closed Apr 14, 2000
Status: closed (inferred from source dates) · Structure
FROM THE BEGINNING OF THE 1991 MODEL YEAR PRODUCTION UNTIL THE MIDDLE OF THE 1994 MODEL YEAR PRODUCTION, FORD USED A GALVANIZED STEEL CABLE TO LIFT AND HOLD IN STORED POSITION, THE EXPLORER SPARE TIRE.ON MAY 19, 1994, BASED ON THE RESULTS OF FORD DURABILITY TESTING , FORD CHANGED TO A 4.00MM STAINLESS STEEL CABLE.THERE HAVE BEEN OVER 100 INCIDENTS IN WHICH THE ORIGINAL GALVANIZED STEEL CABLE FAILED ALLOWING THE SPARE TIRE TO DROP FROM ITS REAR STORAGE WELL.ONE OF THESE INCIDENTS CAUSED A FOLLOWING VEHICLE TO BE INVOLVED IN A COLLISION AND ON SIX OTHER OCCASIONS THE WHEEL MADE CONTACT WITH FOLLOWING VEHICLES, RESULTING IN PROPERTY DAMAGE.
RQ99016 · Liftgate Support Bracket Failure
Opened Jul 29, 1999 · No close date supplied
Status: open (inferred from source dates) · Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Additional source detail variants (2)
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
EA99004 · Blower Assembly Fires
Opened Jan 15, 1999 · Closed Apr 18, 2000
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
BASED ON THE RELATIVELY LOW FAILURE FREQUENCY MEASURED OVER AN EXTENDED EXPOSURE TIME AND THE FACT THAT THE GREAT MAJOITY OF INCIDENTS ARE CONFINED WITHIN THE BLOWER HOUSING, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
DP98008 · Heater Blower Assembly Fire
Opened Sep 4, 1998 · Closed Sep 11, 1998
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
PE98048 · Blower Assembly Fires
Opened Sep 4, 1998 · Closed Jan 15, 1999
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
DP98001 · Heavy Lateral Vibration
Opened Jan 6, 1998 · Closed Feb 4, 1998
Status: closed (inferred from source dates) · Structure
NHTSA WAS PETITIONED TO COMMENCE A DEFECT INVESTIGATION OF THE SUBJECT VEHICLES ON JANUARY 6, 1998.THE PETITION ALLEGES THAT EARLY MODEL FORD EXPLORER SPORT UTILITY VEHICLES DEVELOP HEAVY LATERAL VIBRATIONS AT SPEEDS ABOVE 55 MPH AND WHEN ENCOUNTERING BUMPS AT LOW SPEEDS.THE PETITION FURTHER ALLEGES THAT THESE VIBRATIONS COULD POSSIBLY CAUSE LOSS OF VEHICLE CONTROL.THE ANALYSIS OF THE PETITION IS PRESENTED IN THE ATTACHED NOTICE WHICH IS PUBLISHED IN THE FEDERAL REGISTER.
EA97011 · Sunroof Shattering And Separation
Opened May 23, 1997 · Closed Jan 20, 1998
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Additional source detail variants (2)
Structure
There is no summary currently available
Structure
There is no summary currently available
PE96074 · Sunroof (air Roof) Shatter
Opened Dec 17, 1996 · Closed May 23, 1997
Status: closed (inferred from source dates) · Structure
THE SUNROOF SHATTERED OR WAS BLOWN OFF.IN ALL BUT ONE CASE THIS OCCURRED WHILE DRIVING.
EA95018 · Separation Of Master Cylinder
Opened Jun 19, 1995 · Closed Apr 2, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Additional source detail variants (2)
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
PE95001 · Brake Master Cylinder/booster Separation
Opened Jan 3, 1995 · Closed Jun 19, 1995
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE94044 · Engine Cooling Fan Cracks
Opened Jun 10, 1994 · Closed Aug 31, 1994
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA93004 · Auto Trans Prndl Misalign
Opened Jan 29, 1993 · Closed Jul 29, 1994
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
PE92078 · Auto Trans.prndl Misalign
Opened Sep 9, 1992 · Closed Jan 29, 1993
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
Illustration