2015 Ford Expedition

The contact owns a 2015 Ford Expedition. The contact stated that the doors rocker panels were corroded. Additionally, the contact stated that the front blower motor was intermittently inoperable. The contact received notification of NHTSA Campaign Number: 22V648000 (Visibility, Electrical System). The vehicle was taken to the dealer, where the recall repair was performed; however, the failure persisted due to the blower motor resistor connection failure at the wiring harness plug. The dealer was notified of the failure and informed the contact that he would be charged a repair fee because the additional repair was not included in the recall repair. The manufacturer was not notified of the failure. The failure mileage was approximately 124,000. The VIN was unavailable.

Smelled smoke, then a small amount of dark smoke was noted to be coming from A/C vents I pulled over & turned off car The smoke stopped. I exited the car & called my husband. I opened the car hood to inspect. There was nothing suspicious. No source of the smell or smoke was identified. I re-entered the car, turned on the engine, and lots of dark smoke exuded from of A/C Vents & the engine. I turned off the engine, left the car & moved away. I called 911. A passer by went into the Post office, returned with a fire extinguisher & sprayed the engine. This seemed to temporize things for a very short time. while on the phone with 911 the car fire started and rather quickly the car became nearly totally engulfed in flames. Then the Police arrived first, followed by the Fire engine. Essentially, "everything that could burn did" (except the gas tank). Known recall (manufacturer #22S56, NHTSA #22V648

The contact owns a 2015 Ford Expedition. The contact stated that while the vehicle was started, the A/C system was inoperable. The contact stated that he observed wires hanging down that were melted. The vehicle was taken to a dealer where it was diagnosed that the blower motor speed control connector needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 138,000.

My vehicle falls under recall 22V648. For has contacted me about doing the repair. I have replaced the blower motor speed controller twice in the last few months and it is bad again due to the recalled blower motor. How can this part not also get replaced as part of the recall?? The recalled part is burning up the wires going to the speed controller/resistor and melting the connection at the resistor.

The contact owns a 2015 Ford Expedition. The contact stated that while operating the vehicle, the air conditioning blower unit would intermittently shutoff. The vehicle was taken to the local dealer who serviced the vehicle under NHTSA Campaign Number: 22V648000 (Visibility, Electrical System). The contact was informed that while servicing the vehicle it was discovered that the air conditioner blower motor unit had failed, and blower motor electrical resistor and connector had melted and needed to also be replaced. The vehicle was repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 130,000.

The contact owns a 2015 Ford Expedition. The contact stated that the steering wheel control buttons were inoperable. There was no warning light illuminated. The vehicle was taken to the dealer, where the control buttons were replaced; however, the failure persisted. The dealer diagnosed that the steering wheel wiring had failed, and that the steering wheel needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 72,000.

HAD TO FIGHT TO GET CELLA FORD TO COMPLY WITH RECALL ON FRONT BLOWER FAN. FIRST HAD TO FIGHT TO GET APPOINTMENT AND THEM NOT CANCEL DUE TO PARTS NOT AVAILABLE WHEN COULD HAVE FIXED WITH AFTERMARKET PART. WHEN PART IS REPLACED, BAD HUM AND DASH/STEERING WHEEL VIBRATING AND UNIT IS SURGING. CELLA ADMITS TO FAULTY REPLACEMENT PART AND REPLACES AGAIN TO HAVE THE SAME THING CONTINUE TO HAPPEN AND STATE THAT THE SURGING IS NOT THEIR FAULT. SO, RECALL NOT COMPLETE, SAFETY HAZARD STILL ALIVE IN THIS VEHICLE DUE TO NO AIR CONDITIONING SYSTEM WORKING AND UNABLE TO DEFOG WINDSHIELD. THIS DEALERSHIP SHOULD REALLY BE LOOKED INTO ABOUT THIS RECALL.