Illustrationvehicle shifting erratically and shows fuel mileage low and loss of speedometer
2012 Ford Expedition
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2012 Ford Expedition do not stand out strongly from the model-year median of 155.
About this comparison →How this year compares
Owner complaints by model year
Compare all Expedition years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
140–25K
625–50K
1750–75K
1575–100K
21100–150K
12150K+
85 reports with mileage · 33 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 64 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports2 fire reports4 injury reports
What owners actually said
118 reportsvehicle shifting erratically and shows fuel mileage low and loss of speedometer
The contact owns a 2012 Ford Expedition. The contact stated that while his wife was driving 30 MPH, the transmission unexpectedly downshifted, causing the occupants to lunge forward. The tires squealed and the wheels locked up. The vehicle was turned off but failed to restart. No warning light was illuminated. The contact stated…
Read full complaint
The contact owns a 2012 Ford Expedition. The contact stated that while his wife was driving 30 MPH, the transmission unexpectedly downshifted, causing the occupants to lunge forward. The tires squealed and the wheels locked up. The vehicle was turned off but failed to restart. No warning light was illuminated. The contact stated the failure was associated with NHTSA Campaign Number: 16V248000 (Power Train). A tow truck company was contacted, and was able to restart the vehicle, but the failure persisted. The local dealer was contacted and confirmed that there was no recall coverage associated with the VIN. The vehicle was not diagnosed or repaired. An attempt was made to contact the manufacturer, but there was no response. The failure mileage was approximately 166,000.
While exiting the freeway at approximately 45 to 50 mph, the transmission downshifted to 1st gear locking up the tires.
The speedometer will quit working and the vehicle will not shift out of 1st gear, if you can work through it it will start throwing error messages such as zero miles to empty, tire moniter system fault, etc. This is a very dangerous situation especially in high traffic areas. There was a customer satisfaction program on it but…
Read full complaint
The speedometer will quit working and the vehicle will not shift out of 1st gear, if you can work through it it will start throwing error messages such as zero miles to empty, tire moniter system fault, etc. This is a very dangerous situation especially in high traffic areas. There was a customer satisfaction program on it but only up to 150,000 miles. This program should last the life of the vehicle, also, if it was fixed before ownership, why did it go bad again
Over a period of time this problem is occurring more often. The vehicle will downshift into first gear. I pull over check engine light is on. I turn off wait turn back on and no problem for awhile. Within the last month this has occurred many times . Each time the check engine light comes on but also now the advance track light.…
Read full complaint
Over a period of time this problem is occurring more often. The vehicle will downshift into first gear. I pull over check engine light is on. I turn off wait turn back on and no problem for awhile. Within the last month this has occurred many times . Each time the check engine light comes on but also now the advance track light. Each time I have the same codes pulled. Driving on the highway with my daughter at 65mph it downshifted and the back tires locked up . Vehicles had to swerve to miss us. The check engine light was on advance track light same codes pulled. The dealership said it’s not in the recall even though it was built in Jefferson co Kentucky 9/2011. I don’t understand why this vehicle wasn’t recalled . I have to continue to drive it’s my only vehicle. I’m so scared for my life.
The contact owns a 2012 Ford Expedition. The contact stated that the image displayed on the back over prevention screen was either upside down, distorted, static only, or completely black. The failure was intermittent. During the failure, the contact was able to restart the vehicle to fix the image; however, the fix was intermit…
Read full complaint
The contact owns a 2012 Ford Expedition. The contact stated that the image displayed on the back over prevention screen was either upside down, distorted, static only, or completely black. The failure was intermittent. During the failure, the contact was able to restart the vehicle to fix the image; however, the fix was intermittent. The vehicle was not taken to the dealer. The vehicle was not diagnosed or repaired. The contact researched and found information on NHTSA Campaign Number: 25V270000 (Back Over Prevention); however, the VIN and model year was not included. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 78,000.
I was driving my 2012 expedition and suddenly the vehicle went from doing 60 to 40 immediately the tires squealed and threw me into the right lane . This vehicle transmission has a recall for down shifting and power train issues. My vin number does not fit the Recall but my vehicle has all the symptoms of mult…
Read full complaint
I was driving my 2012 expedition and suddenly the vehicle went from doing 60 to 40 immediately the tires squealed and threw me into the right lane . This vehicle transmission has a recall for down shifting and power train issues. My vin number does not fit the Recall but my vehicle has all the symptoms of multiple recalls and is not safe to drive . Had i not known how to drive i and my daughter would be in the hospital due to the faulty transmission lead frame and power train . I contacted Ford head quarters they were no help even though there is clearly a recall . I also took the truck to ford of valparaiso and had to pay the 1,000 dollars for the lead frame to be replaced which was in the recall and I shouldn't have had to pay anything .. them replacing the lead frame did nothing the car is still not drive able and is extremely unsafe its my only vehicle and I am a single mother of 2 kids .
ABS CPU control system. Error Code B1342-EC. Antilock braking system electronic control unit defect.
JULY 2025 MY 2012 FORD EXPEDITION THREW A P0742 CODE FOR A STUCK TORQUE CONVERTER CLUTCH. THE VEHICLE HAD JUST UNDER 150K MILES AND STARTED TO JERK IN AND OUT OF GEAR AND THE WRENCH LIGHT ILLUMINATED SO I, THANKFULLY WAS GOING APPROXIMATELY 45 MPH WHEN IT HAPPENED AND WAS ABLE TO PULL THE VEHICLE OVER AS IT WAS IN LIMP MODE. WHE…
Read full complaint
JULY 2025 MY 2012 FORD EXPEDITION THREW A P0742 CODE FOR A STUCK TORQUE CONVERTER CLUTCH. THE VEHICLE HAD JUST UNDER 150K MILES AND STARTED TO JERK IN AND OUT OF GEAR AND THE WRENCH LIGHT ILLUMINATED SO I, THANKFULLY WAS GOING APPROXIMATELY 45 MPH WHEN IT HAPPENED AND WAS ABLE TO PULL THE VEHICLE OVER AS IT WAS IN LIMP MODE. WHEN I CLEARED THE DTC CODE THE PROBLEM WENT AWAY TEMPORARILY BUT EVENTUALLY LOCKED BACK UP AGAIN WITHIN A MILE FROM MY HOME. UNFORTUNATELY, FORD DEALERSHIPS WILL NOT STAND BEHIND THE CUSTOMER SERVICE NUMBER THAT THEY HAVE LISTED FOR A REPLACEMENT OF THE TRANSMISSION LEAD FRAME. I PROVIDED THE LOCAL DEALERSHIP WITH ALL OF THE NECESSARY INFORMATION AS WELL AS AN INDEPENDENT DIAGNOSIS BY A TRANSMISSION SPECIALIST. LOOKS LIKE I'LL JUST HAVE TO WAIT FOR THE DAY THAT IT CAUSES A MASSIVE ACCIDENT BY DOWNSHIFTING INTO 1ST GEAR AT 65MPH. TERRIBLE CUSTOMER SERVICE AND I CAN ONLY HOPE THIS DOESN'T COST SOMEONE THEIR LIFE.
Official recalls
316V248000 · Power Train:automatic Transmission
Apr 27, 2016
Ford Motor Company (Ford) is recalling certain model year 2011-2012 Ford F-150 trucks, 2012 Ford Expedition, Lincoln Navigator, and Ford Mustang vehicles. The affected vehicles are equipped with an automatic transmission that may unexpectedly downshift to first gear, regardless of vehicle speed.
Consequence & remedy
Consequence: An unexpected downshift into first gear can cause the vehicle to slow down suddenly without warning and the rear tires may slide or lock, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module with updated software, free of charge. The recall began on September 19, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S19.
12V190000 · Exterior Lighting:back Up Lights; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
May 3, 2012
FORD IS RECALLING CERTAIN MODEL YEAR 2011-2012 FORD F-150, 2012 EXPEDITION AND LINCOLN NAVIGATOR, AND 2012-2013 MUSTANG VEHICLES, FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NOS. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT" AND 108 LAMPS, REFLECTIVE DEVICES AND ASSOCIATED EQUIPMENT. THESE VEHICLES MAY HAVE A TRANSMISSION RANGE SENSOR (TRS) THAT WAS CALIBRATED OUT OF SPECIFICATION FOR REVERSE GEAR.
Consequence & remedy
Consequence: IF THIS CONDITION EXISTS, THE TRANSMISSION MAY NOT GO INTO REVERSE OR WHEN THE DRIVER PUSHES THE SHIFT LEVER IN THE REVERSE R POSITION AND THE VEHICLES TRANSMISSION DOES GO IN REVERSE, THE R MAY NOT ILLUMINATE ON THE DASHBOARD OF THE F-150, EXPEDITION, OR NAVIGATOR MODELS AND/OR THE BACKUP LAMP ON THE REAR OF THE F-150, EXPEDITION, NAVIGATOR, OR MUSTANG VEHICLES MAY NOT ILLUMINATE. THESE CONDITIONS INCREASE THE RISK OF A CRASH OR A PEDESTRIAN BEING STRUCK DUE TO THE VEHICLES NOT SIGNALING IT IS IN REVERSE.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND REPLACE THE TRS AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 11, 2012. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Additional source detail variants (2)
Exterior Lighting:back Up Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011-2012 FORD F-150, 2012 EXPEDITION AND LINCOLN NAVIGATOR, AND 2012-2013 MUSTANG VEHICLES, FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NOS. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT" AND 108 LAMPS, REFLECTIVE DEVICES AND ASSOCIATED EQUIPMENT. THESE VEHICLES MAY HAVE A TRANSMISSION RANGE SENSOR (TRS) THAT WAS CALIBRATED OUT OF SPECIFICATION FOR REVERSE GEAR.
Consequence: IF THIS CONDITION EXISTS, THE TRANSMISSION MAY NOT GO INTO REVERSE OR WHEN THE DRIVER PUSHES THE SHIFT LEVER IN THE REVERSE R POSITION AND THE VEHICLES TRANSMISSION DOES GO IN REVERSE, THE R MAY NOT ILLUMINATE ON THE DASHBOARD OF THE F-150, EXPEDITION, OR NAVIGATOR MODELS AND/OR THE BACKUP LAMP ON THE REAR OF THE F-150, EXPEDITION, NAVIGATOR, OR MUSTANG VEHICLES MAY NOT ILLUMINATE. THESE CONDITIONS INCREASE THE RISK OF A CRASH OR A PEDESTRIAN BEING STRUCK DUE TO THE VEHICLES NOT SIGNALING IT IS IN REVERSE.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND REPLACE THE TRS AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 11, 2012. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
FORD IS RECALLING CERTAIN MODEL YEAR 2011-2012 FORD F-150, 2012 EXPEDITION AND LINCOLN NAVIGATOR, AND 2012-2013 MUSTANG VEHICLES, FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NOS. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT" AND 108 LAMPS, REFLECTIVE DEVICES AND ASSOCIATED EQUIPMENT. THESE VEHICLES MAY HAVE A TRANSMISSION RANGE SENSOR (TRS) THAT WAS CALIBRATED OUT OF SPECIFICATION FOR REVERSE GEAR.
Consequence: IF THIS CONDITION EXISTS, THE TRANSMISSION MAY NOT GO INTO REVERSE OR WHEN THE DRIVER PUSHES THE SHIFT LEVER IN THE REVERSE R POSITION AND THE VEHICLES TRANSMISSION DOES GO IN REVERSE, THE R MAY NOT ILLUMINATE ON THE DASHBOARD OF THE F-150, EXPEDITION, OR NAVIGATOR MODELS AND/OR THE BACKUP LAMP ON THE REAR OF THE F-150, EXPEDITION, NAVIGATOR, OR MUSTANG VEHICLES MAY NOT ILLUMINATE. THESE CONDITIONS INCREASE THE RISK OF A CRASH OR A PEDESTRIAN BEING STRUCK DUE TO THE VEHICLES NOT SIGNALING IT IS IN REVERSE.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND REPLACE THE TRS AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 11, 2012. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
12V034000 · Seats:mid/rear Assembly
Feb 2, 2012
FORD IS RECALLING CERTAIN MODEL YEAR 2012 EXPEDITION AND LINCOLN NAVIGATOR VEHICLES, MANUFACTURED FROM NOVEMBER 19, 2011, THROUGH DECEMBER 2, 2011, FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 202, "HEAD RESTRAINTS." THESE VEHICLES MAY HAVE INADEQUATE WELDS ON THE HEAD RESTRAINT SUPPORT BRACKETS FOR THE SECOND ROW, RIGHT-HAND SEAT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT HEAD RESTRAINT MAY NOT PROVIDE THE REQUIRED STRENGTH, INCREASING THE RISK OF INJURY.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE HEAD RESTRAINTS AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 21, 2012. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ17010 · Unexpected Transmission Downshift
Opened Dec 25, 2017 · Closed Oct 22, 2019
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.
Additional source detail variants (2)
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.
Power Train:automatic Transmission
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.