Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
140–25K
625–50K
1750–75K
1575–100K
21100–150K
12150K+
85 reports with mileage · 33 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Power Train. Review the 64 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports2 fire reports4 injury reports
What owners actually said
118 reports
59,959 miles · Dec 5, 2022
Power Train
The contact owns a 2012 Ford Expedition. The contact stated while driving approximately 45 MPH, the vehicle suddenly failed to accelerate while depressing the accelerator pedal. The vehicle independently decelerated and nearly caused the vehicle to be rear ended by a tractor trailer. The contact indicated that the vehicle was dr…
Read full complaint
The contact owns a 2012 Ford Expedition. The contact stated while driving approximately 45 MPH, the vehicle suddenly failed to accelerate while depressing the accelerator pedal. The vehicle independently decelerated and nearly caused the vehicle to be rear ended by a tractor trailer. The contact indicated that the vehicle was driven home with the transmission stuck in 3rd gear. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure. The failure mileage was 59,959.
NHTSA ODI #11496107
Mileage unknown · Sep 21, 2022
Power Train
Uncommanded downshift to first gear in 6R80 transmission. While driving at approximately 30mph, transmission downshifted into 1st gear. Problem repeated itself several times. No "codes" or warning lights. I put the transmission in "3" and drove slowly back home. This is the same issue that has occurred in F-150's. The proble…
Read full complaint
Uncommanded downshift to first gear in 6R80 transmission. While driving at approximately 30mph, transmission downshifted into 1st gear. Problem repeated itself several times. No "codes" or warning lights. I put the transmission in "3" and drove slowly back home. This is the same issue that has occurred in F-150's. The problem was intermittent at first. Had this occurred at highway speeds it may have resulted in a rear end "lock-up", loss of control and possible accident. Took the vehicle to the repair shop where they were initially unable to get a "code". Later, I was able to repeat the problem and got warning lights and codes showing failure of the transmission output speed sensor which is located on the molded lead frame. This is the same failure as on the F-150. The molded lead frame was not available as single piece so it was necessary to replace the entire valve body unit.
NHTSA ODI #11485590
Mileage unknown · Jun 6, 2022
Electrical SystemUnknown Or OtherVehicle Speed Control
My vehicle suddenly shifted downward, my gas pedal had no effect, my speedometer stopped working and my fuel and tire sensor lights came on. This happened multiple times on my drive this morning and would have caused an accident if I was being tailgated.
NHTSA ODI #11467696
150,000 miles · May 2, 2022
Engine
The contact owns a 2012 Ford Expedition. The contact stated while driving at approximately 30 MPH, the vehicle independently slowed to approximately 2 MPH. The contact observed that the check engine warning light illuminated. Additionally, the speedometer went blank. The contact stated that when she depressed the accelerator, th…
Read full complaint
The contact owns a 2012 Ford Expedition. The contact stated while driving at approximately 30 MPH, the vehicle independently slowed to approximately 2 MPH. The contact observed that the check engine warning light illuminated. Additionally, the speedometer went blank. The contact stated that when she depressed the accelerator, the vehicle would jerk forward. The contact pulled off of the road and turned off the vehicle. The contact stated that when she restarted the vehicle the vehicle failed to respond when shifted into drive with the accelerator pedal depressed. The contact stated that she drove the vehicle to her residence. The vehicle was diagnosed by an independent mechanic who could not duplicate the failure. The vehicle was not repaired. The contact stated that the failure recurred intermittently. The manufacturer had not been informed of the failure. The failure mileage was approximately 150,000.
NHTSA ODI #11463039
Mileage unknown · Mar 29, 2022
Service Brakes
My wife backed my vehicle out of the garage and began her drive to work. She stopped a few times at stop light through town before she got to the freeway. Driving on the highway she notice/got a message on the dash that stated Low Brake Fluid. She wasn't sure what that meant as the brakes were working fine. On her drive to work …
Read full complaint
My wife backed my vehicle out of the garage and began her drive to work. She stopped a few times at stop light through town before she got to the freeway. Driving on the highway she notice/got a message on the dash that stated Low Brake Fluid. She wasn't sure what that meant as the brakes were working fine. On her drive to work she has 2 stop lights that are on the highway. Coming up to the first stop light she was unable to stop as the brake pedal went all the way to the floor. Her inability to stop caused to to run the red light at around 40 mph. I am a mechanic of 20 years. I went to her work to inspect the vehicle. There were no leaks or broken hoses, the master cylinder was empty except for the front of the reservoir that had maybe an 1/8" of fluid in it. Upon doing some internet research I found that 2013 - 2014 F-150 had the exact same problem with the master cylinder leaking into the brake booster causing the loss of the service brake system to function properly. More research found that the master cylinder in question is the same part number used on all f150 and expeditions from 2010 -2014. The recall number is 16s24. I called Ford customer service and was told that my vehicle had no open recalls. I explained to the agent that I understood recalls are VIN specific but my vehicle has the same master cylinder (based on part number) as the ones failing in the F150 and it has failed in the exact same way (brake fluid leaking, or being sucked into the brake booster) as described in the recall for this issue. This is a serious issue as the brakes worked as designed one minute and there was no brakes the next when needed. The only warning was a low brake fluid light/message. My wife could have been killed or killed someone else had there been another vehicle entering the intersection. There easily could have been a crash/fire/injury or fatality. How many failures/deaths do there need to be before a recall is issued and Ford does the right thing.
NHTSA ODI #11458800
Mileage unknown · Sep 29, 2021
Power Train
The speedometer went to zero when the vehicle was driven on the highway at 70MPH and the transmission would shift down the wrench symbol came on the LCD display. Had to pull over and shut the vehicle off and open the drivers door to make sure that the vehicle was fully off/reset. Started the vehicle and drove home. Dealer not…
Read full complaint
The speedometer went to zero when the vehicle was driven on the highway at 70MPH and the transmission would shift down the wrench symbol came on the LCD display. Had to pull over and shut the vehicle off and open the drivers door to make sure that the vehicle was fully off/reset. Started the vehicle and drove home. Dealer noted that this may be covered under the extended warranty on the lead frame issue... Since the vehicle has 167759 miles on it, that the warranty would not cover the issue (Warranty to 150000 miles). I will get the vehicle repaired at my cost since this is our family vehicle. Since this is a safety issue the warranty should be for all the vehicles that experience this issue. The vehicle was traveling on a highway and this is not an acceptable condition for the safety of my family or others around us when driving. I am confident in noting that the warranty should be amended for this issue. If this issue was caused by me due to carless driving I would not have an issue. Since this is a design/reliability issue I do not understand why I am responsible for the cost of the repair.
NHTSA ODI #11434868
Mileage unknown · Aug 25, 2021
Power Train
My gear shaft gets stuck in park as if it’s not recognizing that the break is getting pressed. It gets stuck for a while. There is no sticky substance that is causing this.
NHTSA ODI #11430432
164,000 miles · Jul 15, 2021
Power Train
The contact owns a 2012 Ford Expedition. The contact stated while driving 60 mph, the vehicle independently down shifted to first gear causing both rear tires to lock up. The contact stated that there was no warning light illuminated. The vehicle was not taken to the local dealer nor an independent mechanic to be diagnosed. The …
Read full complaint
The contact owns a 2012 Ford Expedition. The contact stated while driving 60 mph, the vehicle independently down shifted to first gear causing both rear tires to lock up. The contact stated that there was no warning light illuminated. The vehicle was not taken to the local dealer nor an independent mechanic to be diagnosed. The vehicle was not repaired. The contact related the failure to NHTSA campaign number: 16V248000 (Power train). The manufacturer had been informed of the failure and informed the contact that the Vin was not under recall. The failure mileage was approximately 164,000.
NHTSA ODI #11425032
Mileage unknown · Jun 30, 2021
Power Train
unexpected transmission downshift for no reason and it hesitate and it chugs along down shifts drops out and kicks back in
NHTSA ODI #11422969
130,000 miles · Jun 22, 2021
Power Train
The contact owns a 2012 Ford Expedition. The contact stated while driving at 45 mph, the vehicle lost motive power and stalled. The contact had to restart the vehicle and continued to drive. However, when leaving work the failure occurred again which at that time the contact had pulled the vehicle over to the side of the road an…
Read full complaint
The contact owns a 2012 Ford Expedition. The contact stated while driving at 45 mph, the vehicle lost motive power and stalled. The contact had to restart the vehicle and continued to drive. However, when leaving work the failure occurred again which at that time the contact had pulled the vehicle over to the side of the road and have it towed to the local dealer who inspected the vehicle but could not duplicate the failure, but diagnosed the failure as a front end harness issue with the transmission. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 130,000.
Ford Motor Company (Ford) is recalling certain model year 2011-2012 Ford F-150 trucks, 2012 Ford Expedition, Lincoln Navigator, and Ford Mustang vehicles. The affected vehicles are equipped with an automatic transmission that may unexpectedly downshift to first gear, regardless of vehicle speed.
Consequence & remedy
Consequence: An unexpected downshift into first gear can cause the vehicle to slow down suddenly without warning and the rear tires may slide or lock, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module with updated software, free of charge. The recall began on September 19, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S19.
FORD IS RECALLING CERTAIN MODEL YEAR 2011-2012 FORD F-150, 2012 EXPEDITION AND LINCOLN NAVIGATOR, AND 2012-2013 MUSTANG VEHICLES, FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NOS. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT" AND 108 LAMPS, REFLECTIVE DEVICES AND ASSOCIATED EQUIPMENT. THESE VEHICLES MAY HAVE A TRANSMISSION RANGE SENSOR (TRS) THAT WAS CALIBRATED OUT OF SPECIFICATION FOR REVERSE GEAR.
Consequence & remedy
Consequence: IF THIS CONDITION EXISTS, THE TRANSMISSION MAY NOT GO INTO REVERSE OR WHEN THE DRIVER PUSHES THE SHIFT LEVER IN THE REVERSE R POSITION AND THE VEHICLES TRANSMISSION DOES GO IN REVERSE, THE R MAY NOT ILLUMINATE ON THE DASHBOARD OF THE F-150, EXPEDITION, OR NAVIGATOR MODELS AND/OR THE BACKUP LAMP ON THE REAR OF THE F-150, EXPEDITION, NAVIGATOR, OR MUSTANG VEHICLES MAY NOT ILLUMINATE. THESE CONDITIONS INCREASE THE RISK OF A CRASH OR A PEDESTRIAN BEING STRUCK DUE TO THE VEHICLES NOT SIGNALING IT IS IN REVERSE.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND REPLACE THE TRS AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 11, 2012. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Additional source detail variants (2)
Exterior Lighting:back Up Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011-2012 FORD F-150, 2012 EXPEDITION AND LINCOLN NAVIGATOR, AND 2012-2013 MUSTANG VEHICLES, FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NOS. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT" AND 108 LAMPS, REFLECTIVE DEVICES AND ASSOCIATED EQUIPMENT. THESE VEHICLES MAY HAVE A TRANSMISSION RANGE SENSOR (TRS) THAT WAS CALIBRATED OUT OF SPECIFICATION FOR REVERSE GEAR.
Consequence: IF THIS CONDITION EXISTS, THE TRANSMISSION MAY NOT GO INTO REVERSE OR WHEN THE DRIVER PUSHES THE SHIFT LEVER IN THE REVERSE R POSITION AND THE VEHICLES TRANSMISSION DOES GO IN REVERSE, THE R MAY NOT ILLUMINATE ON THE DASHBOARD OF THE F-150, EXPEDITION, OR NAVIGATOR MODELS AND/OR THE BACKUP LAMP ON THE REAR OF THE F-150, EXPEDITION, NAVIGATOR, OR MUSTANG VEHICLES MAY NOT ILLUMINATE. THESE CONDITIONS INCREASE THE RISK OF A CRASH OR A PEDESTRIAN BEING STRUCK DUE TO THE VEHICLES NOT SIGNALING IT IS IN REVERSE.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND REPLACE THE TRS AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 11, 2012. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
FORD IS RECALLING CERTAIN MODEL YEAR 2011-2012 FORD F-150, 2012 EXPEDITION AND LINCOLN NAVIGATOR, AND 2012-2013 MUSTANG VEHICLES, FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NOS. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT" AND 108 LAMPS, REFLECTIVE DEVICES AND ASSOCIATED EQUIPMENT. THESE VEHICLES MAY HAVE A TRANSMISSION RANGE SENSOR (TRS) THAT WAS CALIBRATED OUT OF SPECIFICATION FOR REVERSE GEAR.
Consequence: IF THIS CONDITION EXISTS, THE TRANSMISSION MAY NOT GO INTO REVERSE OR WHEN THE DRIVER PUSHES THE SHIFT LEVER IN THE REVERSE R POSITION AND THE VEHICLES TRANSMISSION DOES GO IN REVERSE, THE R MAY NOT ILLUMINATE ON THE DASHBOARD OF THE F-150, EXPEDITION, OR NAVIGATOR MODELS AND/OR THE BACKUP LAMP ON THE REAR OF THE F-150, EXPEDITION, NAVIGATOR, OR MUSTANG VEHICLES MAY NOT ILLUMINATE. THESE CONDITIONS INCREASE THE RISK OF A CRASH OR A PEDESTRIAN BEING STRUCK DUE TO THE VEHICLES NOT SIGNALING IT IS IN REVERSE.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND REPLACE THE TRS AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 11, 2012. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
FORD IS RECALLING CERTAIN MODEL YEAR 2012 EXPEDITION AND LINCOLN NAVIGATOR VEHICLES, MANUFACTURED FROM NOVEMBER 19, 2011, THROUGH DECEMBER 2, 2011, FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 202, "HEAD RESTRAINTS." THESE VEHICLES MAY HAVE INADEQUATE WELDS ON THE HEAD RESTRAINT SUPPORT BRACKETS FOR THE SECOND ROW, RIGHT-HAND SEAT.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT HEAD RESTRAINT MAY NOT PROVIDE THE REQUIRED STRENGTH, INCREASING THE RISK OF INJURY.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE HEAD RESTRAINTS AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 21, 2012. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
RQ17010 · Unexpected Transmission Downshift
Opened Dec 25, 2017 · Closed Oct 22, 2019
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.
Additional source detail variants (2)
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.
Power Train:automatic Transmission
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.
2012 Ford Expedition Problems, Complaints & Recalls | Skip That Year
Illustration