DRIVERS RETRACTABLE RUNNING BOARD MALFUNCTIONS GOING UP AND EXTENDING. THE RUNNING BOARD HAS STOPPED MIDWAY DURING EXTENSION AND HAVE CAUSED OCCUPANTS TO FALL DUE TO THE RUNNING BOARD SUDDENLY COLLAPSING TO NORMAL HEIGHT WITH WEIGHT OF THE OCCUPANT ON THE RUNNING BOARD. RETRACTION OF THE RUNNING BOARDS IS ROUGH AND MAY TAKE SEVE…
Read full complaint
DRIVERS RETRACTABLE RUNNING BOARD MALFUNCTIONS GOING UP AND EXTENDING. THE RUNNING BOARD HAS STOPPED MIDWAY DURING EXTENSION AND HAVE CAUSED OCCUPANTS TO FALL DUE TO THE RUNNING BOARD SUDDENLY COLLAPSING TO NORMAL HEIGHT WITH WEIGHT OF THE OCCUPANT ON THE RUNNING BOARD. RETRACTION OF THE RUNNING BOARDS IS ROUGH AND MAY TAKE SEVERAL ATTEMPTS TO RETRACT. THE VEHICLE IS WELL MAINTAINED BY THE DEALERSHIP. THERE ARE NO LUBRICATION POINTS TO ENABLE MAINTENANCE OF THE RUNNING BOARDS. AT THIS TIME THE RUNNING BOARDS ARE TURNED OFF AND ARE IN THE RETRACTED POSITION. THIS HAPPENS WHEN THE VEHICLE IS STATIONARY ON A STREET OR PARKING LOT AND THE DRIVER AND LEFT PASSENGER DOORS ARE OPENED/CLOSED FOR ENTERING OR EXITING THE VEHICLE. THIS ONLY HAPPENS TO DRIVER SIDE RUNNING BOARD. THIS PROBLEM HAS BEEN ON-GOING FOR THE PAST YEAR. THE DEALERSHIP HAS USED A SPRAY LUBRICANT ON THE HINGES OF THE RUNNING BOARD BUT IT IS A SHORT TERM FIX FOR A LONG TERM ISSUE. THERE HAS BEEN NO DAMAGE TO THE RUNNING BOARDS, NO ADJUSTMENT TO THE RUNNING BOARD MOTOR OR MECHANISM. THE RUNNING BOARD MOTOR APPEARS TO OVER OR UNDER TRAVEL AND DOES NOT MOVE THE RUNNING BOARD TO THE CORRECT LOCATION IN THE MOVEMENT CYCLE. *TR
NHTSA ODI #11328022
55,000 miles · Dec 10, 2019
Structure
WINTER 2019, PASSENGER SIDE DOOR WOULD NOT STAY CLOSED. APPEARS TO ONLY HAPPEN WHEN TEMPERATURES ARE BELOW FREEZING. STARTED TO HAPPEN ON DRIVERS SIDE A DAY LATER. I'VE NOTICED WATER INSIDE ON THE SILL PLATE OF THE VEHICLE AFTER IT RAINS. I SUSPECT WATER IS MAKING IT'S WAY INTO THE DOOR. THE ISSUE HAS RETURNED. TRIED TO GET WARR…
Read full complaint
WINTER 2019, PASSENGER SIDE DOOR WOULD NOT STAY CLOSED. APPEARS TO ONLY HAPPEN WHEN TEMPERATURES ARE BELOW FREEZING. STARTED TO HAPPEN ON DRIVERS SIDE A DAY LATER. I'VE NOTICED WATER INSIDE ON THE SILL PLATE OF THE VEHICLE AFTER IT RAINS. I SUSPECT WATER IS MAKING IT'S WAY INTO THE DOOR. THE ISSUE HAS RETURNED. TRIED TO GET WARRANTY REPAIRS FROM ORIGINAL DEALERSHIP BUT HAS GONE UNANSWERED. APPEARS THIS IS A KNOW ISSUE AND REPAIRS ARE COVERED BY AN EXTENDED WARRANTY. WHICH I DID NOT GET. WORKING WITH BBB AND FORD CORPORATE ON THAT ISSUE. THE PASSENGER DOOR WAS NOT FIXED EITHER.
NHTSA ODI #11288162
76,000 miles · Apr 9, 2019
Structure
ALUMINUM LIFT GATE PAINT IS CRACKING AND PEELING SIMIAR TO ALL OTHER YEARS OF EXPEDITION. PREVIOUS AND POST YEARS CONTINUE TO HAVE THE SAME ISSUE. NOT A FLUKE OR ONE OFF IN PAINT PREPARATION DEFECTS.
NHTSA ODI #11195274
100,000 miles · Sep 19, 2017
Structure
ON 8/21/17, THE LATCHING BACK WINDOW OF OUR 2011 FORD EXPEDITION BLEW OUT WHILE MY HUSBAND WAS PARKING ON A PRIVATE LOT. WE DID NOT HIT ANYTHING, AND THE GLASS BLEW OUT, NOT IN. FORTUNATELY NO ONE WAS IN THE PATH OF THE FLYING GLASS. FORD REFUSES TO REIMBURSE US FOR ITS REPLACEMENT.
NHTSA ODI #11024170
48,000 miles · Aug 25, 2017
Structure
THE PAINT FINISH ON THE REAR LIFTGATE HAS SEVERAL "BUBBLING" AREAS AND HAS STARTED TO FLAKE OFF IN SEVERAL AREAS. THIS ISSUE WAS FIRST NOTICED WHEN THE VEHICLE WAS LESS THAN 5 YEARS OLD. THERE HAS NEVER BEEN ANY PHYSICAL DAMAGE TO THIS AREA NOR HAS IT BEEN REPAINTED. I HAVE RESEARCHED ONLINE AND DISCOVERED THAT THIS WAS DUE TO …
Read full complaint
THE PAINT FINISH ON THE REAR LIFTGATE HAS SEVERAL "BUBBLING" AREAS AND HAS STARTED TO FLAKE OFF IN SEVERAL AREAS. THIS ISSUE WAS FIRST NOTICED WHEN THE VEHICLE WAS LESS THAN 5 YEARS OLD. THERE HAS NEVER BEEN ANY PHYSICAL DAMAGE TO THIS AREA NOR HAS IT BEEN REPAINTED. I HAVE RESEARCHED ONLINE AND DISCOVERED THAT THIS WAS DUE TO A CONTAMINANT AT THE PAINT FACILITY FOR THESE VEHICLES AT THE TIME, IS A VERY COMMON PROBLEM FOR THESE MODEL YEARS, AND THAT FORD REFUSES TO TAKE RESPONSIBILITY OR ISSUE A RECALL TO HAVE THIS ISSUE REPAIRED. WHEN I CONTACTED FORD ABOUT THE ISSUE, THEY RECOMMENDED I SUBMIT A COMPLAINT WITH YOUR AGENCY.
NHTSA ODI #11019583
Mileage unknown · Dec 12, 2016
Structure
VISIBLE CORROSION AND BUBBLING PAINT ON ALUMINUM REAR LIFT GATE
NHTSA ODI #10934681
44,977 miles · Sep 8, 2016
Electrical SystemLatches/locks/linkagesStructure
TL* THE CONTACT OWNS A 2011 FORD EXPEDITION. THE CONTACT STATED THAT THE KEY FOB FAILED TO UNLOCK THE DOORS INTERMITTENTLY. IN ADDITION, THE CONTACT STATED THAT THE KEY PAD LOCATED ON THE DRIVER SIDE DOOR FAILED TO OPERATE. AS A RESULT, THE CONTACT WAS UNABLE TO ACCESS THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS …
Read full complaint
TL* THE CONTACT OWNS A 2011 FORD EXPEDITION. THE CONTACT STATED THAT THE KEY FOB FAILED TO UNLOCK THE DOORS INTERMITTENTLY. IN ADDITION, THE CONTACT STATED THAT THE KEY PAD LOCATED ON THE DRIVER SIDE DOOR FAILED TO OPERATE. AS A RESULT, THE CONTACT WAS UNABLE TO ACCESS THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE LOCK MOTOR ON ALL THE DOORS FAILED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 44,977.
NHTSA ODI #10904721
15,000 miles · Jan 29, 2016
Structure
PAINT BLISTERING/BUBBLING ON ALUMINUM HOOD AND TAILGATE, FORD REPAINTED SAYING IT WAS TOTALLY REPAIRABLE. SIX MONTHS LATER IT IS BACK.
NHTSA ODI #10823102
40,000 miles · Jan 28, 2014
Structure
WHEN WASHING MY VEHICLE, I NOTICE ON THE BACK DOOR (THE BACK END OF THE VEHICLE) PAINT MISSING. IT IS RIGHT WHERE THE HANDLE TO OPEN THE DOOR. I CAN SEE THE WHITE MATERIAL UNDER THE PAINT.. IT IS LIKE IT PEELED RIGHT OFF OR FLAKED OFF. THIS IS IN A COUPLE OTHER SPOTS AROUND THE HANDLE. I AM LOOKING FOR A RECALL BUT HAVE NO…
Read full complaint
WHEN WASHING MY VEHICLE, I NOTICE ON THE BACK DOOR (THE BACK END OF THE VEHICLE) PAINT MISSING. IT IS RIGHT WHERE THE HANDLE TO OPEN THE DOOR. I CAN SEE THE WHITE MATERIAL UNDER THE PAINT.. IT IS LIKE IT PEELED RIGHT OFF OR FLAKED OFF. THIS IS IN A COUPLE OTHER SPOTS AROUND THE HANDLE. I AM LOOKING FOR A RECALL BUT HAVE NOT BEEN SENT ONE. VERY DISAPPOINTING. *TR
NHTSA ODI #10561856
17,000 miles · Jan 24, 2012
StructureInjury
TL* THE CONTACT OWNS A 2011 FORD EXPEDITION. THE CONTACT STATED THAT WHEN THE REAR DRIVER SIDE DOOR WAS AJAR, THE RETRACTABLE RUNNING BOARDS RETRACTED AND CAUSED A PASSENGER'S FOOT TO BE CUT BY THE RUNNING BOARDS. THE VEHICLE WAS NOT TAKEN TO THE DEALER, THE MANUFACTURER WAS NOT CONTACTED AND THE VEHICLE WAS NOT REPAIRED. THE F…
Read full complaint
TL* THE CONTACT OWNS A 2011 FORD EXPEDITION. THE CONTACT STATED THAT WHEN THE REAR DRIVER SIDE DOOR WAS AJAR, THE RETRACTABLE RUNNING BOARDS RETRACTED AND CAUSED A PASSENGER'S FOOT TO BE CUT BY THE RUNNING BOARDS. THE VEHICLE WAS NOT TAKEN TO THE DEALER, THE MANUFACTURER WAS NOT CONTACTED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 17,000 AND THE CURRENT MILEAGE WAS 18,000.
NHTSA ODI #10445103
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
RQ17010 · Unexpected Transmission Downshift
Opened Dec 25, 2017 · Closed Oct 22, 2019
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.
Additional source detail variants (2)
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.
Power Train:automatic Transmission
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of transmissions unexpectedly downshifting to a lower gear without input from the driver on model year (MY) 2011-2013 Ford F-150, Expedition and Navigator vehicles. ODI has received 455 unique reports related to the alleged problem that were not covered under a previous recall for this issue (16V-248).Expedition and Navigator complaint rates are lower than F-150 complaints. Of those 455 reports, 34.7% claimed that the rear wheels locked up when the transmission downshifted. There were 4 accident claims with no injuries. There are many instances where drivers report leaving their lane or the road because of this issue.In response to ODI's Information Request (IR) letter, Ford Motor Company (Ford) responded with 783 unique reports related to the alleged problem. There were 6 accident claims with 3 injuries. Ford also submitted 1206 warranty claims related to transmission downshifting failures. The failure can occur at any time, but typically at higher speed, and include symptoms such as sudden transmission downshifting, loss of speedometer, erratic shifting of transmission, and transmission stuck in one gear. The failures typically occur without warning and may result in the rear wheels momentarily locking up. The driver often had to fully stop the vehicle and restart it to get the vehicle to shift properly.On February 2nd, 2019 Ford notified ODI that it would conduct a safety recall (19V-075) to remedy transmission downshifting failures on all 2011-2013 F-150 vehicles. Ford will also offer extended warranties to 2011-2013 Expedition and Navigator vehicles with the same issue. Per Ford, some vehicles may experience an intermittent loss of Transmission Output Speed Sensor (OSS) signal to the Powertrain Control Module (PCM), potentially resulting in a temporary unintended downshift into first gear. Ford will reprogram the PCM with software that will prevent an unintended downshift into first gear and illuminate the Malfunction Indicator Light in the event of an intermittent OSS signal loss.The recall action initiated by the manufacturer appears to address the safety risks of concern to ODI.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the identification (ODI) numbers found in the attached list.
2011 Ford Expedition Problems, Complaints & Recalls | Skip That Year
Illustration