2018 Ford Escape

Our vehicle is a 2018 Ford Escape with 54,843 miles. This vehicle was purchased Used from Ted Britt Ford, Chantilly, Va. and assured there was no issues with the vehicle. On or around February 20, 2024 my daughter notified me the check engine light is on. Dropped it off a local repair shop which identified there was a misfiring and needed a bore scope to see inside. Borescope discovered coolant in the cylinders indicating the head gasket is leaking. Call Ford US Customer Service same day (February 26, 2024), said they need Ford mechanic to look at it. Took to Chantilly who confirmed. Called Ford USA back, said they would talk with Ford Dealer and call me back, never returned a call. I've been calling them every 2-3 days since. Finally today they said 'there is no program to provide financial assistance' which really pisses me off. Reading industry material from reddit indicates this is a consistent problem experienced by many drivers of the Ford Escape. Seeing these reports indicate a bigger problem with the design and manufacturing of the Ford Escape. Consumers are left to pay the bill estimated at $13,000 - $15,000. Ford states there is no program to support this. I see this is a safety issue. What if a driver (in this case an 18yr old girl) has an engine seize stranding the driver. Ford America Customer Service Case # CXH-01638292

Went to start vehicle in morning after it had been sitting overnight. temperature gauge went all the way to red immediately and alert on dash said do not drive vehicle and turn engine off immediately. had it towed to dealer and they advised coolant was leaking which caused blown head gasket. only fix is to replace engine which will cost more than vehicle is worth

The contact owns a 2018 Ford Escape. The contact stated while driving 35 MPH, the vehicle started leaking fluid. The check engine warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the fuel line was cracked. The vehicle was not repaired. The vehicle was taken to an independent mechanic, who informed the contact that the failure was due to a cracked fuel line. The contact stated that the failure was related to Customer Satisfaction Program: 21N12. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 75,000.

The contact owns a 2018 Ford Escape. The contact stated while driving 30 MPH, the vehicle stalled. The message "Engine Overheating" was displayed and there was smoke coming from underneath the passenger's side of the hood. The contact was able to veer to the side of the road. The contact stated that she was able to restart the vehicle; however, the vehicle was sputtering. The vehicle was towed to the residence. The contact stated that she replaced the coolant reservoir herself, and added coolant to the vehicle; however, the coolant evaporated. The vehicle was then towed to an independent mechanic, where it was diagnosed that a coolant leak had caused damage to the timing belt, the pin, and the head gasket. The vehicle was repaired; however, the failure recurred six months later. The contact was able to pull to the side of the road and noticed that there was no coolant in the vehicle. The contact stated that she added coolant to the vehicle and drove to AutoZone, and a significant amount of coolant had poured out onto the ground. The vehicle was towed to the residence. The contact stated that the vehicle was undrivable. The dealer and the manufacturer were not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 90,000.

The day after paying off my wife's 2018 Escape with 102,000 miles on it started telling us to pull over while driving on the highway because the engine was getting hot We pulled over and it went away. The next time we drove it our daughter was driving with our grandson in the car and it would not go more than a mile or two without overheating. We took it to be looked at by a local mechanic and was told that these regularly have head gasket problems, that was the problem with ours and we would have to replace the engine for about $10,000.00. A quick call to the Ford dealer and a perusal of the internet confirmed what the mechanic stated. I see information about the faulty head gaskets on the 1.0 liter engines, when I look on line I see at least as many customer complaints about the 1.5 liter engine in the escapes. These engines both have the same faulty wet sleeve design that is going to fail prematurely. Why isn't Ford being forced to address the dangerous engines in the escapes as well as the ecosport?

The contact owns a 2018 Ford Escape. The contact stated that while driving at undisclosed speeds, the check engine warning light illuminated. The vehicle was taken to the local dealer, where it was diagnosed that coolant had intruded into the cylinders. The dealer recommended that the engine be replaced. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 77,000.

The contact owns a 2018 Ford Escape. The contact stated that while driving at an undisclosed speed, the High Engine Temperature message displayed, and the vehicle lost motive power. The vehicle was towed to the dealer, where it was diagnosed with coolant intrusion into the engine, and it was determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The contact was informed that the vehicle was included in Customer Satisfaction Program: 21N12 (Short Block Replacement After Coolant Intrusion); however, the vehicle had exceeded the mileage. The failure mileage was approximately 117,000.