NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
464 reports89,000 miles · Jul 29, 2013
Power Train
TL* THE CONTACT OWNS A 2006 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE FAILED TO ACCELERATE. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE POWER TRANSMISSION NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE APPROXIMATE…
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE FAILED TO ACCELERATE. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE POWER TRANSMISSION NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 89,000.
NHTSA ODI #10532403
117,000 miles · Jul 26, 2013
Structure
TL* THE CONTACT OWNS A 2006 FORD ESCAPE. THE CONTACT STATED THAT THERE WAS AN ABNORMAL BANGING IN THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE REAR INNER AND OUTER FENDER WELL WAS CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIF…
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD ESCAPE. THE CONTACT STATED THAT THERE WAS AN ABNORMAL BANGING IN THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE REAR INNER AND OUTER FENDER WELL WAS CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 117,000. UPDATED 08/15/13*LJ THE CONSUMER STATED THE RIGHT AND LEFT INNER WELLS RUSTED AWAY.
NHTSA ODI #10531945
88,000 miles · Jul 17, 2013
Power Train
TL* THE CONTACT OWNS A 2006 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE FAILED TO ACCELERATE. THE VEHICLE WAS TOWED TO DEALER FOR DIAGNOSIS. THE TECHNICIAN STATED THAT THE TRANSMISSION WOULD HAVE TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED…
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE FAILED TO ACCELERATE. THE VEHICLE WAS TOWED TO DEALER FOR DIAGNOSIS. THE TECHNICIAN STATED THAT THE TRANSMISSION WOULD HAVE TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 88,000. *TR
NHTSA ODI #10525355
103,000 miles · Jul 15, 2013
EngineVehicle Speed Control
MY VEHICLE DIES WHEN THE TRUCK IS WARMED UP AND I PUT IT IN GEAR WITH MY FOOT ON THE BRAKE. IT DIES AT STOP LIGHTS AND STOP SIGNS AND IN REVERSE. ANOTHER TECHNICIAN TOLD ME I WOULD HAVE TO RIDE AROUND WITH THAT PROBLEM BECAUSE IT WAS NOT THROWING A CODE. AFTER A WEEK, I TOOK IT BACK TO THE FORD DEALER IN CLEVELAND, MS, AND THE S…
Read full complaint
MY VEHICLE DIES WHEN THE TRUCK IS WARMED UP AND I PUT IT IN GEAR WITH MY FOOT ON THE BRAKE. IT DIES AT STOP LIGHTS AND STOP SIGNS AND IN REVERSE. ANOTHER TECHNICIAN TOLD ME I WOULD HAVE TO RIDE AROUND WITH THAT PROBLEM BECAUSE IT WAS NOT THROWING A CODE. AFTER A WEEK, I TOOK IT BACK TO THE FORD DEALER IN CLEVELAND, MS, AND THE SERVICE DEPARTMENT MANAGER TOLD ME IT WAS PROBABLY THE THROTTLE BODY ACTUATOR. BUT, THAT IT WAS ON NATIONAL BACK ORDER. I LEFT THE CAR WITH THE FORD DEALER, AND THEY SAID THEY REPLACED THE THROTTLE VALVE AT A COST OF $900. THE TRUCK DIED ON THE WAY HOME FROM THE DEALER WITH THE SAME PROBLEM. *TR
NHTSA ODI #10524861
154,000 miles · Jul 4, 2013
EngineVehicle Speed Control
MY CAR GAS PEDAL KEEPS STICKING LIKE THERE IS ROCK UNDER IT. I ALMOST WRECKED TONITE BECAUSE OF IT!!!! IT NEEDS TO BE FIXED AND THERE ARE A LOT OF OTHER PEOPLE WITH THE SAME ISSUE. *TR
NHTSA ODI #10523143
80,000 miles · Jun 11, 2013
Power Train
TL* THE CONTACT OWNS A 2006 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, THE OVER DRIVE WARNING LIGHT ILLUMINATED AND THE VEHICLE WOULD NOT ACCELERATE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE MECHANIC STATED THE TRANSMISSION WOULD HAVE TO BE REPLACED. THE MANUFACTURER WAS M…
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, THE OVER DRIVE WARNING LIGHT ILLUMINATED AND THE VEHICLE WOULD NOT ACCELERATE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE MECHANIC STATED THE TRANSMISSION WOULD HAVE TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 80,000. *TR
NHTSA ODI #10519343
80,000 miles · Jun 7, 2013
Power Train
TL* THE CONTACT OWNS A 2006 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE TRANSMISSION OVERDRIVE WARNING LIGHT ILLUMINATED AS THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO A TRANSMISSION MECHANIC TO HAVE A DIAGNOSTIC PERFORMED. THE FAILURE WAS LOCATED AT THE TRANSMISSION, WHICH NEEDED TO BE REPLACED. THE VEHICLE…
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE TRANSMISSION OVERDRIVE WARNING LIGHT ILLUMINATED AS THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO A TRANSMISSION MECHANIC TO HAVE A DIAGNOSTIC PERFORMED. THE FAILURE WAS LOCATED AT THE TRANSMISSION, WHICH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 80,000.
NHTSA ODI #10515730
80,000 miles · May 28, 2013
Vehicle Speed Control
ACCELERATOR STICKS, WOULD NOT GO DOWN. STARTED STICKING WHEN STARTING ENGINE AND WOULD CONTINUE UNTIL DRIVEN FOR A FEW MILES. CONTINUED TO GET WORSE AND WOULD STICK WHEN PULLING OUT FROM A SIDE ROAD TO A BUSIER ROAD BELOW A HILL WHERE ONCOMING TRAFFIC COULD BE POPPING OVER HILL AND MY VEHICLE WOULD NOT MOVE. WOULD HAVE TO CON…
Read full complaint
ACCELERATOR STICKS, WOULD NOT GO DOWN. STARTED STICKING WHEN STARTING ENGINE AND WOULD CONTINUE UNTIL DRIVEN FOR A FEW MILES. CONTINUED TO GET WORSE AND WOULD STICK WHEN PULLING OUT FROM A SIDE ROAD TO A BUSIER ROAD BELOW A HILL WHERE ONCOMING TRAFFIC COULD BE POPPING OVER HILL AND MY VEHICLE WOULD NOT MOVE. WOULD HAVE TO CONTINUE TO STOMP ACCELERATOR, FINALLY WOULD TAKE OFF. STUCK SEVERAL TIMES WHEN DRIVING DURING SNOW STORM, HAD TO CONSTANTLY STOMP ACCELERATOR, WOULD TAKE OFF AT A HIGHER THAN SAFE SPEED AND THEN I WOULD HAVE TO USE BREAK WHICH WAS NOT SAFE ON SNOW COVERED ROAD. STUCK IN MIDDLE OF INTERSECTION. HAD TO CONTINUE TO STOMP ACCELERATOR, FINALLY MOVED BEFORE ANYONE STRUCK MY VEHICLE WAS TOLD BY DEALERSHIP THAT PROBLEM WAS DUE TO COLD WEATHER BUT LAST TIME IT STUCK THE WEATHER WAS WARM. DEALERSHIP FINALLY REPLACED THROTTLE BODY AT MY EXPENSE OF $400 WITH MILEAGE AT 89888.. *TR
NHTSA ODI #10513723
52,200 miles · May 17, 2013
Power Train
I WAS DRIVING HOME AND WITHOUT WARNING MY 2006 FORD ESCAPE LOST MOMENTUM. THE DRIVERS BEHIND ME COULD NOT REALIZE MY CAR WAS STOPPING BECAUSE I WAS STILL USING MY GAS AND NOT THE BRAKES. FORTUNATELY THERE WAS A CENTER TURNING LANE THAT I WAS ABLE TO USE AND AVOID A REAR END COLLISION. I WAS ABLE TO COAST INTO A GAS STATION. LONG…
Read full complaint
I WAS DRIVING HOME AND WITHOUT WARNING MY 2006 FORD ESCAPE LOST MOMENTUM. THE DRIVERS BEHIND ME COULD NOT REALIZE MY CAR WAS STOPPING BECAUSE I WAS STILL USING MY GAS AND NOT THE BRAKES. FORTUNATELY THERE WAS A CENTER TURNING LANE THAT I WAS ABLE TO USE AND AVOID A REAR END COLLISION. I WAS ABLE TO COAST INTO A GAS STATION. LONG NIGHT TURNED INTO A LONG WEEK AND A RE-MANUFACTURED TRANSMISSION FOR $3,220.70. MY FORD ESCAPE HAS 52,214 MILES ON IT. THE TRANSMISSION SPECIALIST TOLD ME THAT THE BEARINGS FAILED AND THAT THE TRANSMISSION FLUID LOOKED LIKE SILVER PAINT. SHOULD NEVER HAVE HAPPENED. FORD NEEDS TO RECALL THIS (MAZDA) TRANSMISSION. *TR
NHTSA ODI #10512552
Mileage unknown · Apr 20, 2013
Vehicle Speed Control
WHILE TRAVELING BETWEEN 25 AND 30 MPH, THE ACCELERATOR BECAME STUCK. I WAS UNABLE TO DEPRESS IT FURTHER AND IT DID NOT RELEASE. AFTER 3 OR 4 ATTEMPTS THE ACCELERATOR FREED UP. IT THEN WORKED FINE THE REMAINDER OF THE DAY. THIS OCCURRED FIVE TIMES SPORADICALLY DURING THE FIRST HALF OF 2012. THIS BEHAVIOR RETURNED APRIL 201…
Read full complaint
WHILE TRAVELING BETWEEN 25 AND 30 MPH, THE ACCELERATOR BECAME STUCK. I WAS UNABLE TO DEPRESS IT FURTHER AND IT DID NOT RELEASE. AFTER 3 OR 4 ATTEMPTS THE ACCELERATOR FREED UP. IT THEN WORKED FINE THE REMAINDER OF THE DAY. THIS OCCURRED FIVE TIMES SPORADICALLY DURING THE FIRST HALF OF 2012. THIS BEHAVIOR RETURNED APRIL 2013. THE ACCELERATOR STUCK AND FREED UP 3 OR 4 TIMES IN A ROW DURING A MORNING COMMUTE FOR SEVERAL DAYS. THE FORD DEALER REPLACED THE THROTTLE BODY (5L8Z*9E926*A BODY ASY) AND GASKET (4L5Z*9E936*AA) TOTAL COST WITH LABOR $474. *TR
NHTSA ODI #10508901
Official recalls
3Sep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence & remedy
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Sep 3, 2014
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
Consequence & remedy
Consequence: If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
Nov 9, 2005
ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.
Consequence & remedy
Consequence: AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
Remedy: DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR LINCOLN/MERCURY AT 1-800-521-4140.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP12006 · Electronic Throttle Body Malfunction
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Engine
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.
Illustration