WHILE DRIVING MY VEHICLE ON A HIGHWAY, I COULD HERE A LOUD CLUNKING SOUND COMING FROM THE REAR. AFTER INVESTIGATING, IT WAS VISIBLY NOTICEABLE THAT THE SHOCK TOWER ON THE REAR PASSENGER SIDE RUSTED COMPLETELY OFF THE VEHICLE. THIS ALLOWED THE WHEEL TO BOUNCE FREELY AND THE SHOCK TO JAM UP INTO THE WHEEL WELL REPEATEDLY. THE VEHI…
Read full complaint
WHILE DRIVING MY VEHICLE ON A HIGHWAY, I COULD HERE A LOUD CLUNKING SOUND COMING FROM THE REAR. AFTER INVESTIGATING, IT WAS VISIBLY NOTICEABLE THAT THE SHOCK TOWER ON THE REAR PASSENGER SIDE RUSTED COMPLETELY OFF THE VEHICLE. THIS ALLOWED THE WHEEL TO BOUNCE FREELY AND THE SHOCK TO JAM UP INTO THE WHEEL WELL REPEATEDLY. THE VEHICLE IS UNSAFE TO DRIVE.
NHTSA ODI #10907410
Mileage unknown · Aug 22, 2016
Suspension
TL* THE CONTACT OWNS A 2006 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 40 MPH, THE REAR PASSENGER SIDE SHOCK PLATE DETACHED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE SHOCK PLATE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE…
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 40 MPH, THE REAR PASSENGER SIDE SHOCK PLATE DETACHED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE SHOCK PLATE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE AND VIN WERE UNKNOWN.
NHTSA ODI #10897689
105,500 miles · Aug 13, 2016
Suspension
A FEW MONTHS AGO I NOTICED A THUMPING NOISE WHEN DRIVING. THE PASSENGER SIDE REAR WHEEL WELL STARTED TO HAVE THE BLACK COATING FLAKE OFF OF THE INSIDE REVEALING RUST. SINCE THEN MY STRUT HAS BROKEN OFF FROM MY FRAME & THE SHOCK HAS COMPLETELY BROKEN. FROM THE RESEARCH I HAVE BEEN DOING THOUSANDS OF PEOPLE HAVE HAD THE SAME PROBL…
Read full complaint
A FEW MONTHS AGO I NOTICED A THUMPING NOISE WHEN DRIVING. THE PASSENGER SIDE REAR WHEEL WELL STARTED TO HAVE THE BLACK COATING FLAKE OFF OF THE INSIDE REVEALING RUST. SINCE THEN MY STRUT HAS BROKEN OFF FROM MY FRAME & THE SHOCK HAS COMPLETELY BROKEN. FROM THE RESEARCH I HAVE BEEN DOING THOUSANDS OF PEOPLE HAVE HAD THE SAME PROBLEM. THERE NEEDS TO BE A RECALL FOR THIS. MY CAR IS UN-DRIVEABLE & MOST LIKELY SO EXPENSIVE TO FIX THAT I MIGHT AS WELL BUY A NEW CAR.
NHTSA ODI #10895560
Mileage unknown · Aug 8, 2016
Suspension
THERE SHOULD BE A RECALL ON FORD ESCAPE 2006 VEHICLES. WE BOUGHT OUR VEHICLE USED ONE YEAR AGO, 117K MILES ON IT AND THE WHEEL WELLS/SHOCK TOWERS LOOKED FINE. AFTER ONE WINTER THE REAR PASSENGER WHEEL WELL IS RUSTED THROUGH (THERE IS LITERALLY A RUST HOLE) AND THE DRIVER IS ALMOST AS BAD. WE HAD THE VEHICLE INSPECTED AT A FOR…
Read full complaint
THERE SHOULD BE A RECALL ON FORD ESCAPE 2006 VEHICLES. WE BOUGHT OUR VEHICLE USED ONE YEAR AGO, 117K MILES ON IT AND THE WHEEL WELLS/SHOCK TOWERS LOOKED FINE. AFTER ONE WINTER THE REAR PASSENGER WHEEL WELL IS RUSTED THROUGH (THERE IS LITERALLY A RUST HOLE) AND THE DRIVER IS ALMOST AS BAD. WE HAD THE VEHICLE INSPECTED AT A FORD DEALERSHIP PRIOR TO PURCHASING IT A YEAR AGO - THEY DIDN'T EVEN POINT OUT ANY CORROSION. MEANING, WITHIN A YEAR IT CORRODED SO BAD IT NEEDED $1300 WORTH OR REPAIR. OUR LOCAL MECHANIC TOLD US THERE WAS A RECALL ON THE ISSUE, BUT SEARCHING ONLINE AND ASKING OUR LOCAL FORD DEALER WE DISCOVERED THERE WASN'T. THIS ISN'T THE TYPE OF COSMETIC RUST OF THE BODY, BUT RUST OF THE STRUCTURAL INTEGRITY OF THE VEHICLE. IT IS A DESIGN FLAW THAT WHOEVER ENGINEERED THE BODY SHOULD BE ASHAMED OF. I CAN FIND RECALLS ONLINE FOR 2001 -2004 ESCAPES FOR SIMILAR STRUCTURAL RUST, SO WHY ISN'T FORD RECALLING 2006 ESCAPES WHEN THE PROBLEM IS STILL OCCURRING? THE FORD DEALER TOLD US, KEEP THE REPAIR RECEIPT IN CASE FORD ISSUES A RECALL, THEN WE COULD BE REIMBURSED. THIS RUST ISN'T JUST AND EYESORE, BUT A SAFETY ISSUE.
NHTSA ODI #10894250
Mileage unknown · May 16, 2016
Suspension
WENT CHANGE THE SHOCKS AND THE WHOLE BRACKET SYSTEM HAD RUSTED OUT ON THE PASSENGER SIDE REAR. THEY HAVE RECALLED THESE FROM 2001-2004. IT IS FINE ON THE DRIVERS SIDE BUT THE PASSENGER SIDE IT TOTALLY RUSTED THRU IT IS GOING TO COST 3000 TO FIX. I HAVE ONLY HAD THIS VEHICLE A YEAR. IT MADE A CLUNK NOISE TWICE SO I TOOK IT IN…
Read full complaint
WENT CHANGE THE SHOCKS AND THE WHOLE BRACKET SYSTEM HAD RUSTED OUT ON THE PASSENGER SIDE REAR. THEY HAVE RECALLED THESE FROM 2001-2004. IT IS FINE ON THE DRIVERS SIDE BUT THE PASSENGER SIDE IT TOTALLY RUSTED THRU IT IS GOING TO COST 3000 TO FIX. I HAVE ONLY HAD THIS VEHICLE A YEAR. IT MADE A CLUNK NOISE TWICE SO I TOOK IT IN TO THE SHOP, I AM DRIVING TWO KIDS AROUND I AM A SINGLE MOM SUCK CRAP.
NHTSA ODI #10865089
215,000 miles · Feb 23, 2016
Suspension
REAR PASSENGER WHEEL WELL COMPLETELY RUSTED OUT. SUSPENSION NOT MOUNTED TO VEHICLE NOW, AND HAMMERS BOTTOM OF INTERIOR WHEN GOING OVER ANY BUMP IN THE ROAD. EVERY OTHER WHEEL WELL IS FINE. ALL MECHANICS I HAVE SPOKEN WITH, INCLUDING A FORD CERTIFIED BODY SHOP WILL NOT TOUCH THE ISSUE AND ADVISED ME TO SCRAP THE VEHICLE.
NHTSA ODI #10837661
135,000 miles · Jan 21, 2016
StructureSuspension
ESCAPE WHEEL WELL RUST CAUSED STRUT TO DETATCH FROM VEHICLE. I WAS DRIVING DOWN THE HIGHWAY WHEN I HEARD LOUD THUMPING NOISES, I CHECKED AND DIDN'T SEE ANYTHING THAT IT MIGHT BE SO I TOOK IT TO A MECHANIC WHO SHOWED ME THE EXCESSIVE WHEEL WELL RUST THAT CAUSED THE STRUT TO DETATCH FROM THE BODY. HE SAID IT WAS NOT SAFE TO DRIV…
Read full complaint
ESCAPE WHEEL WELL RUST CAUSED STRUT TO DETATCH FROM VEHICLE. I WAS DRIVING DOWN THE HIGHWAY WHEN I HEARD LOUD THUMPING NOISES, I CHECKED AND DIDN'T SEE ANYTHING THAT IT MIGHT BE SO I TOOK IT TO A MECHANIC WHO SHOWED ME THE EXCESSIVE WHEEL WELL RUST THAT CAUSED THE STRUT TO DETATCH FROM THE BODY. HE SAID IT WAS NOT SAFE TO DRIVE AND THAT IT MUST BE FIXED BY A BODY SHOP AS HE COULDN'T FIX IT. I GOT ESTIMATES FROM BODY SHOPS AS WELL AS FORD AND THEY ALL SAID IT WOULD BE AROUND $4,000 TO $5,000 THIS IS NO OTHER RUST ON THE VEHICLE OTHER THAN THE EXCESSIVE PASSENGER REAR WHEEL WELL RUST AND IS HAS ONLY 130-140K MILES ON IT. NOW I CANNOT DRIVE IT WITHOUT RISK OF A MAJOR ACCIDENT DUE TO THE PROBLEM SO IT IS SITTING IN MY GARAGE. I HAVE PHOTOS BUT AM UNABLE TO UPLOAD THEM TO THIS SITE AT THIS TIME.
NHTSA ODI #10821429
130,000 miles · Dec 21, 2015
StructureSuspensionUnknown Or Other
THE RIGHT WHEEL WELL OF MY 2006 FORD ESCAPE (LIMITED) IS COMPLETELY RUSTED OUT. I CAN NO LONGER DRIVE THIS VEHICLE BECAUSE THE SHOCK IS ABOUT TO BREAK THROUGH THE INTERIOR OF THE VEHICLE. THE RUST HAS CAUSED EXHAUST TO POUR INTO THE VEHICLE. BEFORE KNOWING ABOUT THIS, I TOOK MY VEHICLE TO SEVERAL DIFFERENT MECHAINCS BECAUSE I CO…
Read full complaint
THE RIGHT WHEEL WELL OF MY 2006 FORD ESCAPE (LIMITED) IS COMPLETELY RUSTED OUT. I CAN NO LONGER DRIVE THIS VEHICLE BECAUSE THE SHOCK IS ABOUT TO BREAK THROUGH THE INTERIOR OF THE VEHICLE. THE RUST HAS CAUSED EXHAUST TO POUR INTO THE VEHICLE. BEFORE KNOWING ABOUT THIS, I TOOK MY VEHICLE TO SEVERAL DIFFERENT MECHAINCS BECAUSE I COULD SMELL EXHAUST. THEY COULDN'T FIND ANYTHING. A CANADIAN AUTO BODY PERSON (I LOVE ON THE BORDER) TOLD ME THAT IT WAS COMING FROM THE HOLES IN THE RIGHT WHEEL WELL AND SHOWED ME THE LARGE HOLE WHERE EXHAUST IS LEAKING IN. THIS IS A SERIOUS SAFETY ISSUE THAT ALL ESCAPE OWNERS (2006 AT LEAST) NEED TO BE MADE AWARE OF!!! I CAN'T TAKE AND ATTACH PHOTOS AT THIS TIME DUE TO THE WEATHER BUT CAN PROVIDE THEM ANOTHER TIME, UPON REQUEST. I SHOULD NOTE THAT I LIVE IN NORTHERN MICHIGAN AND THAT I HAVE TAKEN METICULOUS CARE OF THIS VEHICLE.
NHTSA ODI #10811436
85,000 miles · Sep 25, 2015
Suspension
TL* THE CONTACT OWNS A 2006 FORD ESCAPE. WHILE DRIVING AT APPROXIMATELY 5 MPH, THERE WAS A LOUD BUMP FROM THE REAR PASSENGER SIDE. THE CONTACT OBSERVED RUST ON THE REAR TIRE. THE FAILURE RECURRED CONTINUOUSLY, CAUSING THE VEHICLE TO BECOME INOPERABLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT T…
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD ESCAPE. WHILE DRIVING AT APPROXIMATELY 5 MPH, THERE WAS A LOUD BUMP FROM THE REAR PASSENGER SIDE. THE CONTACT OBSERVED RUST ON THE REAR TIRE. THE FAILURE RECURRED CONTINUOUSLY, CAUSING THE VEHICLE TO BECOME INOPERABLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SHOCK ABSORBER NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS 85,000. ...UPDATED 02/03/16 *BF; UPDATED 4/6/18*JB THE CONSUMER STATED THE VEHICLE WAS REPAIRED. *TR
NHTSA ODI #10776559
200 miles · Sep 15, 2015
SteeringStructureSuspension
RIGHT REAR WHEEL HOUSING COMPLETELY GONE. FIRST INDICATION OF ANY ISSUE WAS WHEN SHOCK NO LONGER PROPERLY SUPPORTS. RUST AND TOTAL DE-LAMINATION OF METAL HOUSING SUPPORTING SHOCK. FEAR OF SHOCK PUNCHING THROUGH - INTO CARGO HOLD IN THE AREA OF THE JACK STORAGE.
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence & remedy
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
Consequence & remedy
Consequence: If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.
Consequence & remedy
Consequence: AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
Remedy: DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR LINCOLN/MERCURY AT 1-800-521-4140.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
DP12006 · Electronic Throttle Body Malfunction
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Engine
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.
Illustration