NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,394 reports123,000 miles · Dec 4, 2012
Electrical SystemElectronic Stability Control (esc)
I WAS DRIVING ON THE INTERSTATE AT 70MPH AT NIGHT WHEN MY 2005 FORD ESCAPE STARTED JUMPING AND THEN COMPLETELY LOST POWER WITH NO WARNING. I IMMEDIATELY PUSHED THE FLASHER BUTTON AND COASTED OFF OF THE INTERSTATE, I WAS ABLE TO CRANK THE VEHICLE BACK UP AND GET TO THE NEAREST EXIT AND CALL FOR HELP. THE REPAIR SHOP FOUND THE …
Read full complaint
I WAS DRIVING ON THE INTERSTATE AT 70MPH AT NIGHT WHEN MY 2005 FORD ESCAPE STARTED JUMPING AND THEN COMPLETELY LOST POWER WITH NO WARNING. I IMMEDIATELY PUSHED THE FLASHER BUTTON AND COASTED OFF OF THE INTERSTATE, I WAS ABLE TO CRANK THE VEHICLE BACK UP AND GET TO THE NEAREST EXIT AND CALL FOR HELP. THE REPAIR SHOP FOUND THE # 4 IGNITION COIL HAD BURNED UP. THANK GOD THERE WAS NOT AN 18 WHEELER KNOCKING ON MY BACK DOOR, WOULD NOT BE HERE TO COMPLAIN AND NO ONE WOULD HAVE EVER FIGURED OUT WHAT HAPPENED. *TR
NHTSA ODI #10487357
71,104 miles · Dec 4, 2012
Power Train
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, A RUMBLING NOISE WAS HEARD FROM AROUND THE CONSOLE AREA. THE CONTACT MERGED TO THE SHOULDER OF THE ROAD AND SHIFTED INTO NEUTRAL. THE RUMBLING NOISE THEN CEASED. THE CONTACT ALSO STATED THAT THE VEHICLE WAS SHIFTED BACK INTO DRIV…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, A RUMBLING NOISE WAS HEARD FROM AROUND THE CONSOLE AREA. THE CONTACT MERGED TO THE SHOULDER OF THE ROAD AND SHIFTED INTO NEUTRAL. THE RUMBLING NOISE THEN CEASED. THE CONTACT ALSO STATED THAT THE VEHICLE WAS SHIFTED BACK INTO DRIVE AND THE RUMBLING NOISE STARTED AGAIN. THE FOLLOWING DAY WHILE DRIVING UPHILL, THE NOISE BECAME LOUDER AND ALL OF THE GEARS FAILED. THE VEHICLE WAS TOWED TO THE CONTACT'S HOME AND WAS NOT TAKEN TO A DEALER FOR A DIAGNOSTIC TESTING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 71,104.
NHTSA ODI #10487331
114,000 miles · Nov 28, 2012
Vehicle Speed Control
RECURRENT PROBLEM: THE SUDDEN INABILITY TO ACCELERATE BECAUSE THE GAS PEDAL WON'T BUDGE. THE THROTTLE CABLE IS BINDING SOMEWHERE. A COUPLE OF YEARS AGO THE THROTTLE CABLE SNAPPED ON OUR 2005 FORD ESCAPE, BREAKING OFF BEHIND THE ACCELERATOR PEDAL INSIDE THE CABIN. (WE HAD TAKEN THE CAR IN FOR THIS HARD-TO-PRESS-GAS-PEDAL PROBLEM…
Read full complaint
RECURRENT PROBLEM: THE SUDDEN INABILITY TO ACCELERATE BECAUSE THE GAS PEDAL WON'T BUDGE. THE THROTTLE CABLE IS BINDING SOMEWHERE. A COUPLE OF YEARS AGO THE THROTTLE CABLE SNAPPED ON OUR 2005 FORD ESCAPE, BREAKING OFF BEHIND THE ACCELERATOR PEDAL INSIDE THE CABIN. (WE HAD TAKEN THE CAR IN FOR THIS HARD-TO-PRESS-GAS-PEDAL PROBLEM WHEN THE CAR WAS VERY NEW, AND AT THE TIME THE DEALERSHIP DID NOT DISCOVER THE CAUSE AND COULD NOT REPRODUCE THE PROBLEM.) AFTER IT SNAPPED, THE CABLE WAS REPLACED BY THE FORD DEALERSHIP AT OUR (CONSIDERABLE) EXPENSE. NOW THE GAS PEDAL IS ONCE AGAIN REFUSING TO BUDGE SEVERAL TIMES ON EACH DRIVE, AND WE HAVE TO TAKE THE VEHICLE IN AGAIN FOR INSPECTION. THE SUDDEN INABILITY TO ACCELERATE INCREASES THE LIKELIHOOD OF REAR-END COLLISIONS. IF THE THROTTLE CABLE BINDS AS YOU'RE MERGING ONTO A HIGHWAY, A HIGH SPEED REAR-END COLLISION COULD OCCUR. IF YOU'RE UNABLE TO ACCELERATE AS YOU'RE CROSSING A ROAD WHERE CROSS TRAFFIC DOES NOT HAVE TO STOP, YOU CAN BE A SITTING DUCK FOR A BROADSIDE COLLISION. *TR
NHTSA ODI #10486292
133,000 miles · Nov 24, 2012
EnginePower Train
I WAS DRIVING TO WORK ON US 41 SOUTH WHEN MY 2005 FORD ESCAPE JUST STARTED TO BUCK AND WOULD NOT ACCELERATE, I WAS GOING APPROXIMATELY 45 MPH AND THE CAR JUST SHUT OFF. I COULD NOT STEER OR START IT AGAIN AND WAS ALMOST HIT BY AN 18 WHEEL VEHICLE AND KILLED. I IMMEDIATELY PUT MY FLASHERS ON AND KEPT RETRYING TO START THE CAR TO …
Read full complaint
I WAS DRIVING TO WORK ON US 41 SOUTH WHEN MY 2005 FORD ESCAPE JUST STARTED TO BUCK AND WOULD NOT ACCELERATE, I WAS GOING APPROXIMATELY 45 MPH AND THE CAR JUST SHUT OFF. I COULD NOT STEER OR START IT AGAIN AND WAS ALMOST HIT BY AN 18 WHEEL VEHICLE AND KILLED. I IMMEDIATELY PUT MY FLASHERS ON AND KEPT RETRYING TO START THE CAR TO GET IT OFF THE ROAD. THIS COULD HAVE KILLED ME AND OTHERS THIS MORNING! THIS IS A FORD MOTOR COMPANY MECHANICAL ISSUE AND THEY KNEW ABOUT THIS PROBLEM WITH THIS MODEL VEHICLE AND CHOOSE TO NOT RECALL IT!! HOW MANY PEOPLE HAVE DIED FROM THIS PROBLEM THAT WE ARE NOT AWARE OF??? I TOOK THE CAR AND HAD IT CHECKED OUT AND THEY SAID THAT FORD ISSUED A BULLETIN ON THIS EXACT ISSUE AND HOW TO FIX IT! ONLY NOW, ITS GOING TO COST ME, THE CONSUMER $2000 OR MORE TO FIX!! I AM SO UPSET FROM IT, I AM ALMOST PAID OFF ON THIS VEHICLE AND I FEEL THAT THIS ISSUE SHOULD BE LOOKED INTO BY THE ATTORNEY GENERAL AND BY THE TRANSPORTATION DEPARTMENT OF SAFETY! *TR
NHTSA ODI #10485914
75,000 miles · Nov 18, 2012
Electrical SystemEnginePower Train
PRIOR TO THE INCIDENT IN QUESTION THE CAR HAD A FEW DAYS OF ABNORMAL BEHAVIOR INCLUDING HESITATION AND ROUGH IDLE. THE INCIDENT OCCURRED ON CHRISTMAS EVE WHILE I WAS DRIVING DOWN A TWO LANE HIGHWAY. WHILE TRAVELING 50 MPH THE CAR LOST POWER AND ALTHOUGH I WAS TERRIBLY SCARED, I MANAGED TO GET OFF THE HIGHWAY SAFELY. I WAS TOLD…
Read full complaint
PRIOR TO THE INCIDENT IN QUESTION THE CAR HAD A FEW DAYS OF ABNORMAL BEHAVIOR INCLUDING HESITATION AND ROUGH IDLE. THE INCIDENT OCCURRED ON CHRISTMAS EVE WHILE I WAS DRIVING DOWN A TWO LANE HIGHWAY. WHILE TRAVELING 50 MPH THE CAR LOST POWER AND ALTHOUGH I WAS TERRIBLY SCARED, I MANAGED TO GET OFF THE HIGHWAY SAFELY. I WAS TOLD THAT THE COMPUTER FAILED (PCM) WHICH IS VERY EXPENSIVE TO FIX HENCE THE REASON IT HAS BEEN ALMOST A YEAR. I AM A RETIRED WIDOW RAISING MY 12 YEAR OLD GRANDDAUGHTER FEELING STUCK BETWEEN A ROCK AND A HARD PLACE; NOT ABLE TO AFFORD THE REPAIRS AND UNABLE TO DO THINGS WITHOUT A CAR. I SEE THAT MANY MANY OTHERS HAVE HAD THIS SAME ISSUE, PLEASE HELP FORD FACE THEIR NEGLECT WITH REGARD TO THIS ISSUE. THANK YOU *TR
NHTSA ODI #10485050
95,000 miles · Nov 17, 2012
Vehicle Speed Control
AFTER STARTING THE CAR, THE GAS PEDAL FELT LIKE IT HAD A BRICK UNDER IT. IT WOULD NOT MOVE. AFTER THE CAR WARMED UP, IT WORKED AGAIN. DURING THE LAST MONTH, THIS HAS HAPPENED IN TRAFFIC, FORCING ME TO PULL OFF THE ROAD SINCE I COULD NOT ACCELERATE, SEVERAL TIMES IN VERY HEAVY TRAFFIC. WHILE DRIVING RECENTLY, ON THE HIGHWAY, HOUR…
Read full complaint
AFTER STARTING THE CAR, THE GAS PEDAL FELT LIKE IT HAD A BRICK UNDER IT. IT WOULD NOT MOVE. AFTER THE CAR WARMED UP, IT WORKED AGAIN. DURING THE LAST MONTH, THIS HAS HAPPENED IN TRAFFIC, FORCING ME TO PULL OFF THE ROAD SINCE I COULD NOT ACCELERATE, SEVERAL TIMES IN VERY HEAVY TRAFFIC. WHILE DRIVING RECENTLY, ON THE HIGHWAY, HOURS AFTER BEGINNING MY TRIP, THE ACCELERATOR BECAME STUCK, FOR 2 OR 3 SECONDS, CAUSING ME GREAT CONCERN. NOW, EVERY MORNING I HAVE TO WAIT ABOUT 15 MINUTES FOR THE PEDAL TO FREE ITSELF IN ORDER TO BE ABLE TO DRIVE THE VEHICLE. IT STICKS OFF AND ON AT LEAST TWICE DURING THE WARM UP PERIOD. I DON'T HAVE EXACT DATES, BUT THIS HAS HAPPENED SEVERAL TIMES DURING THE LAST FEW MONTHS INTERMITTENTLY AND HAS BEEN VERY FRIGHTENING WHEN IT HAPPENS IN TRAFFIC. THIS HAPPENED TO ME A FEW YEARS AGO, A TIME OR TWO, BUT THE PROBLEM WENT AWAY. NOW IT IS A DAILY OCCURRENCE. THE COOLER TEMPERATURE SEEMS TO BE A FACTOR. I AM RELUCTANT TO BRING THE VEHICLE TO A FORD DEALER SINCE I HAVE READ MANY POSTINGS FROM PEOPLE WHO HAVE BEEN UNSUCCESSFUL GETTING THE PROBLEM CORRECTED, EVEN AFTER SPENDING A SIZEABLE AMOUNT OF MONEY. ADDITIONALLY, I CANT FIND ANY EVIDENCE THAT FORD HAS ANY IDEA HOW TO CORRECT THE PROBLEM. *TR
NHTSA ODI #10485004
131,000 miles · Nov 16, 2012
Electrical SystemEnginePower Train
ON WAY HOME, CAR SHUT OFF WHILE GOING 35 MPH. COILS STARTED TO SMOKE. TOWED TO NEAREST DEALER AND WAS TOLD ALL COILS, PLUGS AND POWERTRAIN MODULE NEEDS TO BE REPLACED AT $2500. RESEARCHED LEGITIMATE WEBSITES AND FOUND MANY OWNERS WITH SAME PROBLEM THAT HAD FIXED MORE THAN ONCE AT $2500. WAS TOLD BY DEALER THAT NHTSA ONLY RECALLS…
Read full complaint
ON WAY HOME, CAR SHUT OFF WHILE GOING 35 MPH. COILS STARTED TO SMOKE. TOWED TO NEAREST DEALER AND WAS TOLD ALL COILS, PLUGS AND POWERTRAIN MODULE NEEDS TO BE REPLACED AT $2500. RESEARCHED LEGITIMATE WEBSITES AND FOUND MANY OWNERS WITH SAME PROBLEM THAT HAD FIXED MORE THAN ONCE AT $2500. WAS TOLD BY DEALER THAT NHTSA ONLY RECALLS FOR SAFETY & EMISSIONS. THIS IS CLEARLY A SAFETY ISSUE, ESPECIALLY IF GOING A HIGH SPEED ON INTERSTATE AND CAR SHUTS OFF WITHOUT WARNING. THANKFULLY MY KIDS WERE NOT IN CAR. *TR
NHTSA ODI #10484976
150,000 miles · Nov 14, 2012
Vehicle Speed Control
I WAS DRIVING ON THE HIGHWAY GOING ABOUT 65 MPH. WHEN I TRIED TO PRESS DOWN ON THE GAS IT WAS STUCK I COULD NOT ACCELERATE. I PRESSED AS HARD AS I COULD AND IT WAS STUCK. I HAD TO PUT IT IN NEUTRAL AND PULL OVER. *TR
NHTSA ODI #10484705
101,000 miles · Nov 14, 2012
Vehicle Speed Control
I OWN AT 2005 FORD ESCAPE. IN 2007 AND 2009 I HAD TWO INCIDENTS OF BEING AT A RED LIGHT AND WHEN I PUSHED ON THE ACCELERATOR IT FELT HARD TO PRESS AND WOULD NOT BUDGE. I HAD TO PULL OVER AND CONTINUALLY PUSH ON THE ACCELERATOR AND THE CAR WOULD FINALLY GO. THIS MORNING I HAD THE SAME THING HAPPEN. THE FIRST TWO INCIDENTS RESULTE…
Read full complaint
I OWN AT 2005 FORD ESCAPE. IN 2007 AND 2009 I HAD TWO INCIDENTS OF BEING AT A RED LIGHT AND WHEN I PUSHED ON THE ACCELERATOR IT FELT HARD TO PRESS AND WOULD NOT BUDGE. I HAD TO PULL OVER AND CONTINUALLY PUSH ON THE ACCELERATOR AND THE CAR WOULD FINALLY GO. THIS MORNING I HAD THE SAME THING HAPPEN. THE FIRST TWO INCIDENTS RESULTED IN MY TAKING THE CAR TO THE DEALERSHIP AND THEY REPLACED THE THROTTLE BODY STATING THAT IT WAS A DEFECTIVE PART. AFTER THIS MOST RECENT INCIDENT I AM PLANNING ON TAKING THE CAR TO THE DEALERSHIP AGAIN. *TR
NHTSA ODI #10484580
30,000 miles · Nov 13, 2012
Vehicle Speed Control
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE PARKED SHE ATTEMPTED TO START THE VEHICLE WHEN SHE NOTICED THE GAS PEDAL WAS STICKING CAUSING THE VEHICLE TO ACCELERATE. THE CONTACT STARTED TO TAP THE GAS PEDAL AND MANAGED TO UNLODGED THE PEDAL. ALSO THE CONTACT MENTIONED THAT THE FAILURE OCCURS CONSTANTLY …
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE PARKED SHE ATTEMPTED TO START THE VEHICLE WHEN SHE NOTICED THE GAS PEDAL WAS STICKING CAUSING THE VEHICLE TO ACCELERATE. THE CONTACT STARTED TO TAP THE GAS PEDAL AND MANAGED TO UNLODGED THE PEDAL. ALSO THE CONTACT MENTIONED THAT THE FAILURE OCCURS CONSTANTLY DURING THE WINTER. THE VEHICLE WAS TAKEN TO THE DEALER FOR A DIAGNOSTIC TESTING. THE TECHNICIAN STATED THE THROTTLE NEEDED TO BE SPRAYED WITH WD-40. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 100,000.
NHTSA ODI #10484478
Official recalls
4Sep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence & remedy
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Sep 3, 2014
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
Consequence & remedy
Consequence: If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
Apr 7, 2006
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITHOUT SIDE AIR CURTAINS OR MOONROOFS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT ABOVE THE PERMITTED LIMIT AT THE LEFT HAND A-PILLAR TRIM AREA.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
Remedy: DEALERS WILL MAKE MODIFICATIONS TO THE ENERGY ABSORBING MATERIAL LOCATED ABOVE THE HEADLINER IN THE AFFECTED AREA FREE OF CHARGE. THE RECALL BEGAN ON MAY 19, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Dec 20, 2004
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
Consequence & remedy
Consequence: IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP12006 · Electronic Throttle Body Malfunction
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Engine
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.
AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
Illustration