Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
880–25K
7425–50K
11950–75K
23375–100K
488100–150K
209150K+
1,211 reports with mileage · 183 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Suspension. Review the 459 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 434 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 153 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
40 crash reports20 fire reports20 injury reports
What owners actually said
1,394 reports
112,987 miles · Jul 9, 2014
Structure
MY 2005 FORD ESCAPE HAS 112,000 MILES ON IT. I HAVE OWNED IT SINCE 2010 AND PURCHASED IT FROM A FORD DEALERSHIP. WHILE DRIVING AT APPROX.. 30MPH DOWN A CITY STREET I NOTICED A LOUD BANGING SOUND IN THE REAR RIGHT PASSENGER SIDE EVERY TIME I WENT OVER A BUMP. AFTER ARRIVING HOME I LOOKED OVER THE ENTIRE REAR INTERIOR OF THE VEHI…
Read full complaint
MY 2005 FORD ESCAPE HAS 112,000 MILES ON IT. I HAVE OWNED IT SINCE 2010 AND PURCHASED IT FROM A FORD DEALERSHIP. WHILE DRIVING AT APPROX.. 30MPH DOWN A CITY STREET I NOTICED A LOUD BANGING SOUND IN THE REAR RIGHT PASSENGER SIDE EVERY TIME I WENT OVER A BUMP. AFTER ARRIVING HOME I LOOKED OVER THE ENTIRE REAR INTERIOR OF THE VEHICLE AND FOUND NO REASON FOR THE SOUND. I CHECKED THE REAR LEFT WHEEL AND IT WAS FINE. I THEN CHECKED THE REAR RIGHT WHEEL AND WAS SHOCKED TO SEE LARGE SECTIONS OF THE WHEEL WELL WERE MISSING AND THERE WAS EXTENSIVE RUSTING TO THE POINT THAT I CAN SEE THE UNDERSIDE OF THE TAN INTERIOR OF THE VEHICLE. THE REST OF MY VEHICLE IS PRETTY MUCH RUST FREE, SURPRISINGLY SINCE I LIVE IN MICHIGAN. THE OTHER 3 WHEEL WELLS SHOW MINIMAL EVIDENCE OF RUSTING. APPARENTLY FORD RECALLED THE 2001-2004 ESCAPES DUE TO "EXCESSIVE CORROSION". MY MECHANIC TOLD ME THIS IS HIS 4TH REAR RIGHT WHEEL WELL REPAIR ON A 2005 FORD ESCAPE IN THE PAST FEW MONTHS. THIS IS SO DANGEROUS! IF YOU EXPERIENCE THIS SAME ISSUE PLEASE FILE A VEHICLE SAFETY COMPLAINT. FORD MUST RECALL THIS VEHICLE. *TR
NHTSA ODI #10609416
98,000 miles · Jul 9, 2014
Service Brakes
SECOND TIME IN 3.8 YEARS ABS AND 4X4 BRAKES BROKE, ABS FLASHING, STEADY ON, 4X4 FLASHING LOOSE BRAKES TONE RING ISSUES, FORD DOES NOT RECOGNIZE THERE ARE ISSUES, TONS OF COMPLAINTS EXCESSIVELY EXPENSIVE TO FIX, UNSAFE, ALSO SUSPENSION BARING JOINTS BRAKE EASY, BRAKES WEAR OUT FAST, I DRIVE UNDER 12K A YEAR. EXHAUST A PIECE OF J…
Read full complaint
SECOND TIME IN 3.8 YEARS ABS AND 4X4 BRAKES BROKE, ABS FLASHING, STEADY ON, 4X4 FLASHING LOOSE BRAKES TONE RING ISSUES, FORD DOES NOT RECOGNIZE THERE ARE ISSUES, TONS OF COMPLAINTS EXCESSIVELY EXPENSIVE TO FIX, UNSAFE, ALSO SUSPENSION BARING JOINTS BRAKE EASY, BRAKES WEAR OUT FAST, I DRIVE UNDER 12K A YEAR. EXHAUST A PIECE OF JUNK, THERE SHOULD BE RECALLS, THEY REFUSE TO ACKNOWLEDGE ISSUE. *TR
NHTSA ODI #10609216
130,000 miles · Jul 9, 2014
Structure
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT THE UNDERCARRIAGE HAD EXTENSIVE RUST TO THE POINT OF CORROSION. THE CONTACT HEARD A LOUD RATTLING NOISE, WHICH WAS COMING FROM UNDERNEATH THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO DIAGNOSED THAT THE UNDERCARRIAGE NEEDED TO BE REPLACED. THE VEH…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT THE UNDERCARRIAGE HAD EXTENSIVE RUST TO THE POINT OF CORROSION. THE CONTACT HEARD A LOUD RATTLING NOISE, WHICH WAS COMING FROM UNDERNEATH THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO DIAGNOSED THAT THE UNDERCARRIAGE NEEDED TO BE REPLACED. THE VEHICLE WAS REPLACED FOR ANOTHER VEHICLE FROM THE FORD MANUFACTURER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.
NHTSA ODI #10609187
76,382 miles · Jul 8, 2014
Engine
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 25 MPH, ALL WARNING LIGHTS STARTED BLINKING AND ILLUMINATING ON THE CONTROL PANEL. THE CONTACT MENTIONED THAT IMMEDIATELY AFTER THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC BUT NO REPAIRS HAD BEEN MADE. THE DE…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 25 MPH, ALL WARNING LIGHTS STARTED BLINKING AND ILLUMINATING ON THE CONTROL PANEL. THE CONTACT MENTIONED THAT IMMEDIATELY AFTER THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC BUT NO REPAIRS HAD BEEN MADE. THE DEALER WAS CONTACTED AND STATED THAT THE TRANSMISSION NEEDED TO BE PULL APART TO DETERMINE IF THE TORQUE CONVERTER CAUSED THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 76,382.
NHTSA ODI #10609003
135,480 miles · Jul 7, 2014
Service Brakes
I WAS BACKING OUT OF MY GARAGE INTO MY DRIVEWAY, WHEN I TRIED TO STOP THERE WAS NO BRAKE CONTROL AT ALL. I KEPT ACCELERATING DOWN THE DRIVEWAY STOMPING ON THE BRAKES SEVERAL TIMES UNTIL I WAS ABLE TO STOP THE CAR BRIEFLY ENOUGH TO THROW THE CAR BACK INTO PARK. WHEN I EXITED THE VEHICLE I NOTICED A PUDDLE ON MY GARAGE FLOOR AS …
Read full complaint
I WAS BACKING OUT OF MY GARAGE INTO MY DRIVEWAY, WHEN I TRIED TO STOP THERE WAS NO BRAKE CONTROL AT ALL. I KEPT ACCELERATING DOWN THE DRIVEWAY STOMPING ON THE BRAKES SEVERAL TIMES UNTIL I WAS ABLE TO STOP THE CAR BRIEFLY ENOUGH TO THROW THE CAR BACK INTO PARK. WHEN I EXITED THE VEHICLE I NOTICED A PUDDLE ON MY GARAGE FLOOR AS WELL AS ALL OVER MY DRIVER SIDE FRONT TIRE. I CHECKED THE BRAKE FLUID LEVEL AND IT WAS COMPLETELY EMPTY. I HAD IT TOWED TO A SERVICE GARAGE AND THEY DIAGNOSED THE ISSUE AS BEING A CORRODED AND RUPTURED DRIVERS SIDE BRAKE LINE AND A PASSENGER SIDE BRAKE LINE THAT WAS CRACKED IN SEVERAL PLACES. I HAVE SINCE SEEN A FEW DOZEN COMPLAINTS ON THIS SITE REGARDING THE SAME ISSUE WITH MY VINTAGE FORD ESCAPE. I CANNOT BELIEVE THERE HAS NOT BEEN A RECALL ON THIS ISSUE. BOTH THE TOW TRUCK DRIVER AND THE SERVICE GARAGE SAID THEY HAVE HAD NUMEROUS FORDS WITH THE SAME ISSUE. I'M VERY DISAPPOINTED IN FORD FOR NOT ISSUING A RECALL ON SOMETHING AS DANGEROUS AS BRAKE FUNCTIONING. I HAVE BEEN A LIFELONG FORD BUYER BUT NOW I AM THINKING TWICE ABOUT BUYING ANOTHER ONE.....EVEN THOUGH I LOVE MY ESCAPE AND WAS GOING TO BE PURCHASING ANOTHER ONE WITHIN THE NEXT YEAR. I HOPE THAT NO ONE IS INJURED OR GOD FORBID DIES BECAUSE OF THIS ISSUE. FORD OWES IT TO THEIR OWNERS TO PERFORM RECALLS ON ANY ISSUE THAT COULD BE DANGEROUS OR LIFE THREATENING. I OF COURSE TOLD EVERYONE I KNOW THAT OWNS A FORD ESCAPE TO HAVE THEIR BRAKE LINES CHECKED IMMEDIATELY BEFORE IT'S TOO LATE. *JS
NHTSA ODI #10608767
103,852 miles · Jul 6, 2014
Suspension
PASSENGER SIDE REAR SHOCK ABSORBER UPPER MOUNT BROKE LOOSE DUE TO A CORRODED WHEEL WELL. *JS
NHTSA ODI #10608405
73,700 miles · Jul 5, 2014
Suspension
I JUST PURCHASED THIS 2005 FORD ESCAPE AT THE END OF MAY 2014 WITH ONLY 73333 MILES ON IT AND IT WAS RUNNING GREAT. THEN A MONTH LATER I STARTED HEARING A LOUD BANG UNDER THE REAR PASSENGER SEAT AREA AFTER GOING OVER A FEW NORMAL LITTLE BUMPS IN THE RESIDENTIAL STREETS.(LIKE CRACKS OR SEWER LID) I CHECK IT OUT THERE WAS SOME EXC…
Read full complaint
I JUST PURCHASED THIS 2005 FORD ESCAPE AT THE END OF MAY 2014 WITH ONLY 73333 MILES ON IT AND IT WAS RUNNING GREAT. THEN A MONTH LATER I STARTED HEARING A LOUD BANG UNDER THE REAR PASSENGER SEAT AREA AFTER GOING OVER A FEW NORMAL LITTLE BUMPS IN THE RESIDENTIAL STREETS.(LIKE CRACKS OR SEWER LID) I CHECK IT OUT THERE WAS SOME EXCESSIVE RUST IN THE WHEEL WELL AREA. I DROVE IT FOR ANOTHER WEEK WITH THIS ANNOYING SOUND THEN IT GOT WORSE MAKING LOOSE CLANKING AND SQUEAKING NOISE CONSTANTLY WITH THE BANGING NOISE. I SEARCHED UNDER THE VEHICLE AND IN THE WHEEL WELL, IT'S COMPLETELY RUSTED THROUGH. THE SHOCK/STRUT? ARE MOUNTED TO NOTHING BUT CRUMBLING RUST. IT IS JUST FREE FROM THE WHEEL WELL NOW. I CAN'T EVEN DRIVE IT. FROM THE OTHER COMPLAINTS I CAN SEE THIS WILL NOT BE AN EASY FIX NOR DOES FORD COMPANY RECOGNIZE THIS IS A FAULTY ISSUE WITH THIS VEHICLE AND SHOULD TAKE RESPONSIBILITY FOR THE EARLY CORROSION IN THE WHEEL WELL AREAS WITH THIS VEHICLE. *TR
NHTSA ODI #10608273
150,000 miles · Jul 3, 2014
Suspension
THE ENTIRE WHEEL WELL IS RUSTED OUT AND THE SHOCK IS STICKING INTO THE REAR OF THE BACK OF THE CAR. IT IS DANGEROUS AND FORD HAS A RECALL ON 2000 - 2004 FOR THIS ISSUE NOT THE 2005. *TR
NHTSA ODI #10608160
124,714 miles · Jul 1, 2014
Suspension
TL-THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED WHILE DRIVING 35 MPH, THE VEHICLE MADE A LOUD THUMPING NOISE FROM THE REAR PASSENGER SIDE. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE REAR PASSENGER SIDE WHEEL WELL WAS CORRODED AND THE SHOCK MOUNT HAD COMPLETELY SEPARATED. THE VEHICLE HAD NOT…
Read full complaint
TL-THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED WHILE DRIVING 35 MPH, THE VEHICLE MADE A LOUD THUMPING NOISE FROM THE REAR PASSENGER SIDE. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE REAR PASSENGER SIDE WHEEL WELL WAS CORRODED AND THE SHOCK MOUNT HAD COMPLETELY SEPARATED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE MILEAGE WAS 124,714. PAM
NHTSA ODI #10607384
113,000 miles · Jun 30, 2014
SuspensionCrash
TL * THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 10 MPH, THE REAR PASSENGER SIDE OF THE VEHICLE RATTLED AS THE VEHICLE CRASHED INTO AN UNKNOWN OBJECT. THERE WERE NO INJURIES. THE DEALER STATED THAT THE STRUTS HOUSING WAS DECAYED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER…
Read full complaint
TL * THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 10 MPH, THE REAR PASSENGER SIDE OF THE VEHICLE RATTLED AS THE VEHICLE CRASHED INTO AN UNKNOWN OBJECT. THERE WERE NO INJURIES. THE DEALER STATED THAT THE STRUTS HOUSING WAS DECAYED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 113,000.
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence & remedy
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
Consequence & remedy
Consequence: If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITHOUT SIDE AIR CURTAINS OR MOONROOFS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT ABOVE THE PERMITTED LIMIT AT THE LEFT HAND A-PILLAR TRIM AREA.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
Remedy: DEALERS WILL MAKE MODIFICATIONS TO THE ENERGY ABSORBING MATERIAL LOCATED ABOVE THE HEADLINER IN THE AFFECTED AREA FREE OF CHARGE. THE RECALL BEGAN ON MAY 19, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
Consequence & remedy
Consequence: IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
DP12006 · Electronic Throttle Body Malfunction
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Engine
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.
AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
Illustration