IllustrationEXCESSIVE WHEEL WELL RUST SUCH THAT THE SHOCK MOUNT HAS DISCONNECTED. *TR
2005 Ford Escape
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2005 Ford Escape do not stand out strongly from the model-year median of 996.
About this comparison →How this year compares
Owner complaints by model year
Compare all Escape years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
880–25K
7425–50K
11950–75K
23375–100K
488100–150K
209150K+
1,211 reports with mileage · 183 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 459 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 434 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 153 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
40 crash reports20 fire reports20 injury reports
What owners actually said
1,394 reportsTL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT HEARD AN ABNORMAL NOISE COMING FROM THE REAR PASSENGER SIDE OF THE VEHICLE. THE CONTACT DISCOVERED THAT THE WHEEL WELL WAS RUSTED OUT. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE SHOCK MOUNT WAS RUSTED. THE VE…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT HEARD AN ABNORMAL NOISE COMING FROM THE REAR PASSENGER SIDE OF THE VEHICLE. THE CONTACT DISCOVERED THAT THE WHEEL WELL WAS RUSTED OUT. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE SHOCK MOUNT WAS RUSTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 92,300.
PASSENGER SIDE REAR WHEEL WELL IS RUSTED OUT AN SEVERAL PLACES TO WERE THAT STRUT MOUNT IS LOOSE AN FALLING APART, AN WILL CAUSE AN ACCIDENT IF NOT FIXED. THIS IS A KNOWN ISSUE ON THAT EXACT TIRE AN THE EXACT YEAR IN THOUSANDS OF FORD ESCAPES. THIS IS OVER $2000 AND IS APPARENT ON DRIVERS SIDE AS WELL. VEHICLE FAILED SAFETY INS…
Read full complaint
PASSENGER SIDE REAR WHEEL WELL IS RUSTED OUT AN SEVERAL PLACES TO WERE THAT STRUT MOUNT IS LOOSE AN FALLING APART, AN WILL CAUSE AN ACCIDENT IF NOT FIXED. THIS IS A KNOWN ISSUE ON THAT EXACT TIRE AN THE EXACT YEAR IN THOUSANDS OF FORD ESCAPES. THIS IS OVER $2000 AND IS APPARENT ON DRIVERS SIDE AS WELL. VEHICLE FAILED SAFETY INSPECTION AND WITH 2 SMALL CHILDREN TO TRANSPORT AND NO FUNDS TO REPLACE VEHICLE. I HAVE READ THOUSANDS OF POST ONLINE OF PEOPLE HAVING THE SAME ISSUES AND WITH RECENT RECALLS FOR SIMILAR BODY/SUSPENSION PART FAILURES IN FORD VEHICLES OF SIMILAR YEARS FEEL THIS IS A RECALL ISSUE. PLEASE LOOK START INVESTIGATION AND PROTECT THE CONSUMERS. THANK YOU. *TR
PASSENGER SIDE REAR WHEEL WELL IS RUSTED OUT AN SEVERAL PLACES TO WERE THAT STRUT MOUNT IS LOOSE AN FALLING APART, AN WILL CAUSE AN ACCIDENT IF NOT FIXED. THIS IS A KNOWN ISSUE ON THAT EXACT TIRE AN THE EXACT YEAR IN THOUSANDS OF FORD ESCAPES. THIS IS OVER $2000 TO REPAIR AT WHICH THE VEHICLE IS NOT EVEN WORTH THAT MUCH. I AM A…
Read full complaint
PASSENGER SIDE REAR WHEEL WELL IS RUSTED OUT AN SEVERAL PLACES TO WERE THAT STRUT MOUNT IS LOOSE AN FALLING APART, AN WILL CAUSE AN ACCIDENT IF NOT FIXED. THIS IS A KNOWN ISSUE ON THAT EXACT TIRE AN THE EXACT YEAR IN THOUSANDS OF FORD ESCAPES. THIS IS OVER $2000 TO REPAIR AT WHICH THE VEHICLE IS NOT EVEN WORTH THAT MUCH. I AM A SINGLE PARENT AN NOT GOOD ENOUGH CREDIT TO GET A NEW CAR DUE TO HAVING CANCER A FEW YEARS AGO HAVING TO LET MY CREDIT GO. NOR DO I HAVE $2000 TO FIX THIS PROBLEM. I STILL OWE $4000 ON THE CAR AS WELL. *TR
I WAS TRAVELING AT A RATE OF SPEED OF 70 MHR ON I-95 GOING DOWN SOUTH. AS L WAS TRAVELING I SUDDEN HAD TO GET OFF THE EXIT TO GET SOME GAS AS I WAS APPROACHING THE EXIT I STARTED TO SLOW DOWN TO COME TO A STOP MY TRUCK STILLED WHILE THE TRUCK WAS STILL IN DRIVE MODE. NO LIGHTS ON THE DASH BOARD LITE UP INDACATING THERE WAS A PR…
Read full complaint
I WAS TRAVELING AT A RATE OF SPEED OF 70 MHR ON I-95 GOING DOWN SOUTH. AS L WAS TRAVELING I SUDDEN HAD TO GET OFF THE EXIT TO GET SOME GAS AS I WAS APPROACHING THE EXIT I STARTED TO SLOW DOWN TO COME TO A STOP MY TRUCK STILLED WHILE THE TRUCK WAS STILL IN DRIVE MODE. NO LIGHTS ON THE DASH BOARD LITE UP INDACATING THERE WAS A PROBLEM, NO CHECK ENGINE LIGHT CAME ON. I THEN PUT THE TRUCK IN PARK IT STARTED RIGHT UP, BUT I THEN HAD TO DRIVE WITH ONE FOOT ON THE GAS AND THE OTHER ON THE BRAKES. TOOK MY TRUCK TO MY MACHANIC AND WAS TOLD IT WAS TORQUE CONVERTOR (TRANSMISSION ) SOMETHING HAS TO DO WITH TRANSMISSION. ANOTHER INCIDENT HAPPEN ON THE WAS COMING BACK TO ATLANTA TRAVELING AT 70 MPH AGAIN TRAFFIC ALL OF A SUDDEN COME TO A STOP,ONCE AGAIN WHEN I CAME TO A STOP THE TRUCK STALLED AGAIN IT STALLED SEVERAL TIMES, IT STALLED SO MUCH I HAD TO PULL OVER ON THE SIDE OF THE RODE AND SAT THERE FOR ABOUT 1HR IN ODER TO DRIVE WITHOUT STALLING BUT THAT DID NOT HELP IT KEEP STALLING EVERY TIME I HAD TO SLOW DOWN TO STOP .SMH.SCARED. TRAVELING WITH MY KIDS..... THIS HAS HAPPEN SOME MANY TIME UNTIL I AFRAID TO DRIVE MY TRUCK ANYWHERE IT STALLS IF I DRIVE AT 60 MPH OR 70 MPH. IF YOU ARE AWARE OF DRIVING A MANUAL CAR WHEN YOU PUT YOUR FOOT ON THE BRAKES TO STOP AND YOU DON'T USE THE CLUTH TO PUT THE CAR IN NEUTRAL TO STOP AND IT STALLS , WELL THAT'S WHAT IT LIKE DRIVE THIS TRUCK WHEN YOU COME TO A STOP WHOLE DRIVE FOR A PERIOD OF TIME I HAVE ALSO HAD TO PUT THIS TRUCK IN NEUTRAL IN ORDER FOR THE TRUCK NOT TO STALL.. I HAVE HAD THIS TRUCK MODEL TO AT BY SO MANY MACHANIC AND BECAUSE THE ENGINE LIGHT DOES NOT COME ON ITS HAD TO DIAGNOSE THE PROBLEM. SOME SAY IT ELECTRICAL PROBLEM AND SOME SAY TORQUE CONVERTOR... IT NEED TO BE A RECALL ON THIS MAKE AND MODEL TO HAVE THE TIRQUE CONVERTOR FIX BEFORE THIS PROBLEM KILLS ANYONE THAT'S HAVING THIS PROBLEM.... *TR
A SEVERE RATTLE STARTED IN THE RIGHT REAR WHEEL WELL OF MY 2005 FORD ESCAPE HYBRID. A BODY SHOP DETERMINED THAT THE RIGHT REAR WHEEL WELL HAD NEARLY COMPLETELY DISINTEGRATED DUE TO RUST AND THAT THE SHOCK MOUNT WAS HANGING BY A THREAD. AN INTERNET SEARCH PERFORMED BY THE SHOP REVEALED THAT THIS IS A COMMON PROBLEM TO THIS M…
Read full complaint
A SEVERE RATTLE STARTED IN THE RIGHT REAR WHEEL WELL OF MY 2005 FORD ESCAPE HYBRID. A BODY SHOP DETERMINED THAT THE RIGHT REAR WHEEL WELL HAD NEARLY COMPLETELY DISINTEGRATED DUE TO RUST AND THAT THE SHOCK MOUNT WAS HANGING BY A THREAD. AN INTERNET SEARCH PERFORMED BY THE SHOP REVEALED THAT THIS IS A COMMON PROBLEM TO THIS MAKE AND MODEL MANUFACTURED IN THE YEARS AROUND 2005 AND THAT IT OCCURS ONLY THE IN RIGHT REAR WHEEL WELL. THE LEFT REAR WHEEL WELL IS INTACT AND SOLID. *TR
RIGHT REAR STRUT MOUNT COMPLETELY RUSTED THROUGH TO WHERE MOUNT HAD NOTHING TO MOUNT TO. STRUT BANGING ON WHEEL WELL. *TR
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING DOWNHILL ON A STEEP ROAD AT 40 MPH, THE VEHICLE STALLED. THE VEHICLE WAS ABLE TO RESTART BUT THE FAILURE RECURRED TWICE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000. UPDATED 12/24/14*L…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING DOWNHILL ON A STEEP ROAD AT 40 MPH, THE VEHICLE STALLED. THE VEHICLE WAS ABLE TO RESTART BUT THE FAILURE RECURRED TWICE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000. UPDATED 12/24/14*LJ UPDATED 9/28/2015*JS
VEHICLE WAS SHIPPED TO GERMANY DUE TO MILITARY DUTY. A WEEK LATER AFTER DELIVERED, MY WIFE WAS DRIVING IT GOING DOWN A SHORT HILL WHEN THE VEHICLE TURNED OFF COMPLETELY AND BRAKES WERE NOT FUNCTIONING. MY WIFE HAD TO STOP THE VEHICLE WITH PARKING BRAKE. AFTER THAT THE ENGINE WAS LOSING POWER AND THE ALARM WAS GOING OFF VERY OFTE…
Read full complaint
VEHICLE WAS SHIPPED TO GERMANY DUE TO MILITARY DUTY. A WEEK LATER AFTER DELIVERED, MY WIFE WAS DRIVING IT GOING DOWN A SHORT HILL WHEN THE VEHICLE TURNED OFF COMPLETELY AND BRAKES WERE NOT FUNCTIONING. MY WIFE HAD TO STOP THE VEHICLE WITH PARKING BRAKE. AFTER THAT THE ENGINE WAS LOSING POWER AND THE ALARM WAS GOING OFF VERY OFTEN. WE DROVE THE VEHICLE FEW OCCASIONS AND IT TURNED OFF COUPLE OF TIMES AGAIN.I ORDERED THE PART AND REPLACED IT IN 2014. THE VEHICLE IS RUNNING FINE, HOWEVER THE ALARM STILL GOING OFF AND ENGINE LIGHT IS ON AGAIN ON DASHBOARD. AT THIS POINT I DO NOT KNOW IF THE VEHICLE IS INDICATING THE SAME PROBLEM OR SOMETHING NEW. *TR
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING OVER BUMPS IN THE ROAD AT VARIOUS SPEEDS, THE CONTACT COULD HEAR A HARD KNOCKING SOUND COMING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE REAR PASSENGER SIDE WHEEL WELL WAS RUSTED AND CORRODED ALONG WITH PART OF THE S…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING OVER BUMPS IN THE ROAD AT VARIOUS SPEEDS, THE CONTACT COULD HEAR A HARD KNOCKING SOUND COMING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE REAR PASSENGER SIDE WHEEL WELL WAS RUSTED AND CORRODED ALONG WITH PART OF THE SUBFRAME. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 135,000.
Official recalls
415V606000 · Power Train:automatic Transmission:gear Position Indication (prndl); Power Train:automatic Transmission:lever And Linkage:floor Shift
Sep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence & remedy
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
14V526000 · Hybrid Propulsion System
Sep 3, 2014
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
Consequence & remedy
Consequence: If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
06V111000 · Seats:front Assembly:head Restraint
Apr 7, 2006
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITHOUT SIDE AIR CURTAINS OR MOONROOFS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT ABOVE THE PERMITTED LIMIT AT THE LEFT HAND A-PILLAR TRIM AREA.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
Remedy: DEALERS WILL MAKE MODIFICATIONS TO THE ENERGY ABSORBING MATERIAL LOCATED ABOVE THE HEADLINER IN THE AFFECTED AREA FREE OF CHARGE. THE RECALL BEGAN ON MAY 19, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
04V602000 · Latches/locks/linkages:doors:latch
Dec 20, 2004
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
Consequence & remedy
Consequence: IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP12006 · Electronic Throttle Body Malfunction
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Engine
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.
AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.