NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,394 reportsMileage unknown · Dec 8, 2015
StructureSuspensionUnknown Or Other
HEARD A NOISE NEAR REAR WHEEL HOUSE. UPON INSPECTION IT WAS DISCOVERED THAT THE WHEEL HOUSE ON THE PASSENGER REAR WAS COMPLETELY RUSTED TO THE POINT THAT THE SHOCK WAS JUST BARELY HANGING ON. THE REPAIR WOULD COST MORE THAN THE VEHICLE IS WORTH. LOTS OF COMPLAINTS ON SAME ISSUE THAT FORD REFUSES TO ADDRESS OR CORRECT. SHOULD BE …
Read full complaint
HEARD A NOISE NEAR REAR WHEEL HOUSE. UPON INSPECTION IT WAS DISCOVERED THAT THE WHEEL HOUSE ON THE PASSENGER REAR WAS COMPLETELY RUSTED TO THE POINT THAT THE SHOCK WAS JUST BARELY HANGING ON. THE REPAIR WOULD COST MORE THAN THE VEHICLE IS WORTH. LOTS OF COMPLAINTS ON SAME ISSUE THAT FORD REFUSES TO ADDRESS OR CORRECT. SHOULD BE COMPENSATION AND/OR A RECALL. ALSO LOOKS LIKE THE SAME THING IS HAPPENING TO THE OTHER SIDE. NICE JOB FORD!
NHTSA ODI #10809016
Mileage unknown · Dec 4, 2015
Hybrid Propulsion System
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V526000 (HYBRID PROPULSION SYSTEM) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOT…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V526000 (HYBRID PROPULSION SYSTEM) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
NHTSA ODI #10808457
170,000 miles · Dec 2, 2015
Suspension
THE PASSENGER SIDE REAR WHEEL WELL IS COMPLETELY RUSTED OUT. THE STRUT IS NO LONGER CONNECTED TO THE BODY OF THE CAR.
NHTSA ODI #10807915
67,200 miles · Dec 1, 2015
EngineFuel/propulsion SystemSteering
DROVE FROM WASHINGTON STATE TO UTAH ON FAMILY VACATION 14NOV15. FILLED UP WITH GAS IN BOISE, I.D. AND 1 MILE INTO THAT DRIVE FELT A SURGE AND THEN SLIGHT LOSS OF POWER DRIVING AT 70MPH. THEN IT WAS FINE. WHEN WE GOT INTO SPANISH FORK, UT. WE HAD A LOSS OF POWER WHEN WE CAME OFF THE HIGH WAY AND CONTACTED OUR FRIEND WHO'S DAD OWN…
Read full complaint
DROVE FROM WASHINGTON STATE TO UTAH ON FAMILY VACATION 14NOV15. FILLED UP WITH GAS IN BOISE, I.D. AND 1 MILE INTO THAT DRIVE FELT A SURGE AND THEN SLIGHT LOSS OF POWER DRIVING AT 70MPH. THEN IT WAS FINE. WHEN WE GOT INTO SPANISH FORK, UT. WE HAD A LOSS OF POWER WHEN WE CAME OFF THE HIGH WAY AND CONTACTED OUR FRIEND WHO'S DAD OWNS HIS OWN MECHANIC SHOP K&K AUTO IN SPANISH FORK, UT. HE GOT THE CODES CLEARED AND SAID THE CODES WERE NOT MAKING ANY SENSE AS TO THE POSSIBLE LOSS IN POWER. THE VEHICLE RAN REAL GOOD AFTER GETTING CODES CLEARED. THE NEXT MORNING WE HEADED OUT ON I15 ON OUR TRIP TO OUR VACATION DESTINATION AND IT DID IT AGAIN AS WE GOT ON THE HIGH WAY, I USE AN INJECTOR CLEANER IN CASE THAT WAS THE PROBLEM AS MY FRIENDS DAD HAD SUGGESTED. WE GOT TO FILLMORE, UT. AND WE LOSS TOTAL POWER AND STEERING CONTROL. WE COASTED OFF ONTO AN EXIT RAMP THERE WE WERE ABOUT TO PASS WHEN IT HAPPENED. HAD OUR VEHICLE TOWED TO THE ONLY MECHANIC OPENED AT THE TIME ON A SATURDAY AFTERNOON. HE SAID THE SAME THING ABOUT THE CODES. THEN HE SAID WE HAD A BAD CATALACK-CONVERTER. WE HAD IT TOWED BACK TO OUR FRIENDS DADS SHOP AN HOUR AND A HALF NORTH. THE NEXT DAY HE SAID HE THINKS IT MAY BE THE COILS BUT THE CODES SAY ALL OF THEM. SO WE HAD HIM TAKE IT TO FORD IN PROVO, UT WHILE WE RENTED A CAR AND HAD SOME OF OUR VACATION, MOST OF IT WE MISSED SPENDING DAYS WAITING ON A WORD FROM FORD SERVICE AFTER WE GOT IN FROM OUR COUPLE OF DAYS WE DID GET IN OF OUR VACATION. WE THOUGHT THEY WERE GOING TO DO THE WORK WHILE WE WERE GONE, BUT NO. NOW WE ARE HOME AFTER PAYING $730.- FOR INJECTORS AND A NEW COIL. (I THOUGHT) THEY STILL HAVE OUR VEHICLE IN THE BAY GETTING NEW CATALACK CONVERTERS PUT ON(BOTH) AND IS AN ADDITIONAL $1900.- PLUS TO MAKE IT WORSE THEY CALLED TODAY AND SAID ALL THE COILS HAVE TO BE REPLACED. I THOUGHT THAT WAS DONE, APPARENTLY NOT, AND THIS IS NOT RARE FOR 2005 ESCAPES, OH.
NHTSA ODI #10807654
170,000 miles · Nov 29, 2015
Unknown Or Other
ON NOV,28,2015 9:15AM ME AND MY TWO YEAR OLD DAUGHTER WERE HEADING TO NEW YORK CITY ON I95 NORTH BOUND WHEN MY CAR STARTING MAKING WEIRD SOUNDS THE VEHICLE STARTED TO SLOW DOWN AS I WAS DRIVING ON THE HIGHWAY I WASN'T ABLE TO MOVE THE VEHICLE BECAUSE THE GEARS WAS NOT WORKING PROPERLY I WAS ABLE TO PULL OVER TO THE RIGHT SIDE OF…
Read full complaint
ON NOV,28,2015 9:15AM ME AND MY TWO YEAR OLD DAUGHTER WERE HEADING TO NEW YORK CITY ON I95 NORTH BOUND WHEN MY CAR STARTING MAKING WEIRD SOUNDS THE VEHICLE STARTED TO SLOW DOWN AS I WAS DRIVING ON THE HIGHWAY I WASN'T ABLE TO MOVE THE VEHICLE BECAUSE THE GEARS WAS NOT WORKING PROPERLY I WAS ABLE TO PULL OVER TO THE RIGHT SIDE OF THE HIGHWAY TO SEE WHAT WAS THE PROBLEM I TRYED TO PUT THE VEHICLE IN PARK BUT IT DIDN'T LET ME THE VEHICLE STARTED GOING IN THE WRONG DIRECTION IT WANT BACKWARD I PUT MY FOOT ON THE BRAKE BUT IT CONTINUE TO MOVE IN ROLL BACKWARDS I HAD TO PULL THE SAFETY BRAKE THREE TIMES FOR THE VEHICLE TO STOP MOVING.
NHTSA ODI #10807341
Mileage unknown · Nov 27, 2015
StructureSuspensionUnknown Or Other
WAS DRIVING ALONG CITY STREET WHEN I WENT OVER A SMALL BUMP, HEARD A LOUD THUD! THE WHEEL WELL ON BACK PASSENGER SIDE WAS RUSTED AWAY WHERE THE STRUT CONNECTS. OR WHERE IT WAS ONCE CONNECTED... 155,673 MILES, THIS IS MY ONLY VEHICLE AND UNSAFE TO DRIVE MY FAMILY IN.
NHTSA ODI #10807245
100,000 miles · Nov 25, 2015
Suspension
SON CAME HOME ONE DAY SAID THERE IS A LOT OF NOISE IN THE BACK OF THE ESCAPE. ONCE LOOKING INSIDE THE BACK OF THE TRUCK, I NOTICED I COULD SEE THE DRIVEWAY AND TIRE. ONCE I WENT TO LOOK IN THE WHEEL WELL, I COULD SEE A VERY LARGE HOLE IN THE WHEEL. TOTAL RUST OUT OF PASSENGER SIDE INNER WHEEL WELL AND SHOCK TOWER. THE HOL…
Read full complaint
SON CAME HOME ONE DAY SAID THERE IS A LOT OF NOISE IN THE BACK OF THE ESCAPE. ONCE LOOKING INSIDE THE BACK OF THE TRUCK, I NOTICED I COULD SEE THE DRIVEWAY AND TIRE. ONCE I WENT TO LOOK IN THE WHEEL WELL, I COULD SEE A VERY LARGE HOLE IN THE WHEEL. TOTAL RUST OUT OF PASSENGER SIDE INNER WHEEL WELL AND SHOCK TOWER. THE HOLE HAS TO TO BE AT LEAST 16" WIDE AND 13" HEIGHT. THE REAR SHOCK IS COMPLETELY DISCONNECTED FROM THE BODY SHEET METAL. IT IS ONLY BEING HELD IN PLACE BY THE LOWER SHOCK ABSORBER BOLT AND NUT. VEHICLE ONLY HAS ABOUT 100,000 MILES. TOTALLY AFRAID TO LET MY SON DRIVE THIS TO COLLEGE. SITTING IN DRIVEWAY UNTIL I CAN FIND SOMEONE TO FIX IT. CALLED TWO FORD DEALERSHIPS AND SAID THERE IS NOT RECALL AND IT IS UP TO ME TO FIND SOMEONE TO FIX IT. THEY TOLD ME OVER THE PHONE IT WOULD BE $5,000 TO REPAIR THIS. THIS WILL BE THE LAST FORD WE EVER BUY IF WE HAVE TO SCRAPE THIS BECAUSE OF THIS ISSUE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *JB
NHTSA ODI #10806800
Mileage unknown · Nov 21, 2015
Vehicle Speed Control
I RECEIVED MY ESCAPE AS A BIRTHDAY GIFT TWO YEARS AGO. ON SEVERAL OCCASIONS SINCE MY GAS PEDAL STOPS WORKING AND I HAVE BEEN UNABLE TO PRESS IT DOWN, IT WON'T GO. THIS HAS HAPPENED WHILE ON CITY STREETS AND ON INTERSTATES. ON A COUPLE OF OCCASIONS I HAVE BEEN ABLE TO PULL OVER OR OFF THE ROAD, PUT IT IN PARK, TURN OFF THE ENGINE…
Read full complaint
I RECEIVED MY ESCAPE AS A BIRTHDAY GIFT TWO YEARS AGO. ON SEVERAL OCCASIONS SINCE MY GAS PEDAL STOPS WORKING AND I HAVE BEEN UNABLE TO PRESS IT DOWN, IT WON'T GO. THIS HAS HAPPENED WHILE ON CITY STREETS AND ON INTERSTATES. ON A COUPLE OF OCCASIONS I HAVE BEEN ABLE TO PULL OVER OR OFF THE ROAD, PUT IT IN PARK, TURN OFF THE ENGINE, RESTART MY CAR AND GET IT GOING AGAIN. I HAVE TRIED POUNDING ON THE GAS AND THAT DOES NOTHING, IT WON'T BUDGE. I HAVE NO IDEA WHEN THIS WILL HAPPEN, SO I CANNOT JUST EXPECT IT TO, IT HAPPENS, DAY OR NIGHT, HOT OR COLD TEMPERATURE, DRIVING DOWN A STRAIGHT HIGHWAY OR TURNING ON A CITY STREET. I AM AFRAID IT WILL HAPPEN WHILE I AM DRIVING IN THE SNOW OR WHILE ONE OF MY KIDS ARE DRIVING IT. I HAVE TRIED EXPLAINING TO THEM WHAT TO DO, BUT OF ALL THE THINGS THEY NEED TO WORRY ABOUT WHILE DRIVING, THE GAS PEDAL STICKING SHOULD NOT BE ONE OF THEM.
NHTSA ODI #10795244
136,547 miles · Nov 19, 2015
StructureSuspensionWheels
WHILE DRIVING THE VEHICLE, THERE WAS A NOISE IN THE BACK PASSENGER SIDE OF THE VEHICLE WHEN GOING OVER BUMPS ONLY. WE COULD NOT LOCATE THE NOISE INSIDE THE VEHICLE. (IT SOUNDS LIKE THE GLASS OR THE TIRE JACK, WERE NOT SECURE.) THE AUTO SHOP EXPLAINED, THAT THE VEHICLE IS NOT ATTACHED TO THE SHOCK, AND IT ALONG WITH EXHAUST IS …
Read full complaint
WHILE DRIVING THE VEHICLE, THERE WAS A NOISE IN THE BACK PASSENGER SIDE OF THE VEHICLE WHEN GOING OVER BUMPS ONLY. WE COULD NOT LOCATE THE NOISE INSIDE THE VEHICLE. (IT SOUNDS LIKE THE GLASS OR THE TIRE JACK, WERE NOT SECURE.) THE AUTO SHOP EXPLAINED, THAT THE VEHICLE IS NOT ATTACHED TO THE SHOCK, AND IT ALONG WITH EXHAUST IS COMING IN THROUGH THE TRUCK AREA. EXPLAINED THAT THE VEHICLE WAS A 'DEATH TRAP' IF HIT FROM BEHIND, THE VEHICLE THAT HIT THIS ONE WOULD GO RIGHT THOUGH THIS VEHICLE. ACCORDED TO THE AUTO SHOP, THE ISSUE IS NOT FIXABLE.
NHTSA ODI #10794804
274,000 miles · Nov 15, 2015
Structure
TOTAL RUST IN REAR PASSENGER SIDE WHEEL WELL.
NHTSA ODI #10790456
Official recalls
4Sep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence & remedy
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Sep 3, 2014
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
Consequence & remedy
Consequence: If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
Apr 7, 2006
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITHOUT SIDE AIR CURTAINS OR MOONROOFS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT ABOVE THE PERMITTED LIMIT AT THE LEFT HAND A-PILLAR TRIM AREA.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
Remedy: DEALERS WILL MAKE MODIFICATIONS TO THE ENERGY ABSORBING MATERIAL LOCATED ABOVE THE HEADLINER IN THE AFFECTED AREA FREE OF CHARGE. THE RECALL BEGAN ON MAY 19, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Dec 20, 2004
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
Consequence & remedy
Consequence: IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP12006 · Electronic Throttle Body Malfunction
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Engine
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.
AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
Illustration