WHILE TRAVELING ON THE INTERSTATE IN THE LEFT LANE DURING RUSH HOUR TRAFFIC, THE GAS PEDAL STUCK AND WOULD NOT ACCELERATE ANY LONGER. CAUSED OTHER CARS TO SUDDENLY SLOW WHILE TRYING TO GET OFF TO THE RAMP. THE PEDAL WOULD NOT RELEASE FOR APPROXIMATELY 10 MINUTES. THEN AFTER TRAVELING MAYBE 20 YARDS, THE PEDAL STUCK AGAIN FOR …
Read full complaint
WHILE TRAVELING ON THE INTERSTATE IN THE LEFT LANE DURING RUSH HOUR TRAFFIC, THE GAS PEDAL STUCK AND WOULD NOT ACCELERATE ANY LONGER. CAUSED OTHER CARS TO SUDDENLY SLOW WHILE TRYING TO GET OFF TO THE RAMP. THE PEDAL WOULD NOT RELEASE FOR APPROXIMATELY 10 MINUTES. THEN AFTER TRAVELING MAYBE 20 YARDS, THE PEDAL STUCK AGAIN FOR ANOTHER 5 MINUTES. *TR
NHTSA ODI #10483596
110,000 miles · Nov 7, 2012
Vehicle Speed Control
DURING COLD WEATHER, THE GAS PEDAL WILL STICK AND NOT ACCELERATE OR RELEASE. IT WILL NOT RELEASE FOR SOMETIMES UP TO TEN MINUTES. THIS HAPPENS SEVERAL TIMES OVER SEVERAL DAYS IN A WEEK DURING COLDER MONTHS. THIS HAS BEEN CONSISTENTLY HAPPENING SINCE 2009. THE MOST RECENT ON 11/5/2012. *TR
NHTSA ODI #10483595
67,000 miles · Nov 5, 2012
Vehicle Speed Control
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED WHILE ATTEMPTING TO ACCELERATE FROMA TRAFFIC STOP THE VEHICLE STALLED. THE DEALER WAS NOTIFIED WHO ADVISED THE CONTACT TO TRY TO REACH OUT TO THE MANUFACTURER AND DID NOT OFFER ANY ADDITIONAL ASSISTANCE. THE VEHICLE WAS NOT INSPECTED OR REPAIRED. THE MANUFACTURER WAS MA…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED WHILE ATTEMPTING TO ACCELERATE FROMA TRAFFIC STOP THE VEHICLE STALLED. THE DEALER WAS NOTIFIED WHO ADVISED THE CONTACT TO TRY TO REACH OUT TO THE MANUFACTURER AND DID NOT OFFER ANY ADDITIONAL ASSISTANCE. THE VEHICLE WAS NOT INSPECTED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED ON ANY RECALLS. THE FAILURE MILEAGE WAS 67,000.
NHTSA ODI #10483335
Mileage unknown · Oct 30, 2012
Fuel/propulsion SystemVehicle Speed Control
SON WAS DRIVING VEHICLE WHEN GAS PEDAL STUCK AND WOULD NOT GO DOWN--HE PUSHED PEDAL DOWN WITH ALL HIS STRENGTH BUT IT WOULD NOT MOVE. *TR
NHTSA ODI #10482618
Mileage unknown · Oct 10, 2012
Vehicle Speed Control
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING 20 MPH THE ACCELERATOR PEDAL BECAME STUCK. THE CONTACT MENTIONED THAT THE FAILURE WOULD OCCUR DURING COLD WEATHER. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DUPLICATE THE FAILURE AND STATED THAT THE VEHICLE WAS NOT INCLUDED ON ANY RECALLS.…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING 20 MPH THE ACCELERATOR PEDAL BECAME STUCK. THE CONTACT MENTIONED THAT THE FAILURE WOULD OCCUR DURING COLD WEATHER. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DUPLICATE THE FAILURE AND STATED THAT THE VEHICLE WAS NOT INCLUDED ON ANY RECALLS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 0 AND THE CURRENT MILEAGE WAS 100,000. ..UPDATED 12/06/12 *BF THE CONSUMER STATED THE ACCELERATOR PEDAL WOULD STICK WHEN THE ENGINE WAS COLD AND IN COLD WEATHER. UPDATED 12/06/12
NHTSA ODI #10479518
116,000 miles · Oct 8, 2012
Fuel/propulsion SystemVehicle Speed Control
THE ACCELERATOR PEDAL IS VERY DIFFICULT TO PRESS AND SOMETIMES CANNOT BE PRESSED DOWN AT ALL. *TR
NHTSA ODI #10479245
130,000 miles · Sep 24, 2012
Vehicle Speed Control
WHILE DRIVING, THE GAS PEDAL STICKS. IT FEELS LIKE THERE IS A BRICK UNDER THE GAS PEDAL AND IT WON'T BUDGE. I MASH DOWN ON THE PEDAL AND EVEN STOMP IT. IT WILL DEPRESS AFTER SEVERAL MINUTES OR WHEN IT FEELS LIKE IT. THIS SEEMS TO BE HAPPENING MORE AS THE WEATHER GETS COLDER. WHEN I RESEARCHED THIS ONLINE, I FOUND RECALLS FOR THE…
Read full complaint
WHILE DRIVING, THE GAS PEDAL STICKS. IT FEELS LIKE THERE IS A BRICK UNDER THE GAS PEDAL AND IT WON'T BUDGE. I MASH DOWN ON THE PEDAL AND EVEN STOMP IT. IT WILL DEPRESS AFTER SEVERAL MINUTES OR WHEN IT FEELS LIKE IT. THIS SEEMS TO BE HAPPENING MORE AS THE WEATHER GETS COLDER. WHEN I RESEARCHED THIS ONLINE, I FOUND RECALLS FOR THE 2000 - 2004 FORD ESCAPES EXPERIENCING THIS ISSUE SPEED CONTROL CABLES), BUT NOTHING FOR MY VEHICLE. I HAVE ALSO FOUND, THROUGH A SIMPLE INTERNET SEARCH, THAT THIS IS A COMMON PROBLEM WITH FORD ESCAPE OWNERS, BUT FORD HAS NOT DONE ANYTHING ABOUT IT. *TR
NHTSA ODI #10476895
100,000 miles · Sep 12, 2012
Vehicle Speed Control
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT THE DRIVER OF THE VEHICLE WAS TRAVELING 55 MPH WHEN THE VEHICLE BEGAN TO ACCELERATE INDEPENDENTLY. THE DRIVER SHIFTED INTO NEUTRAL AND TURNED THE VEHICLE OFF. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION OR REPAIRS. THE MANUFACTURER WAS CONTACTED AND ADVI…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT THE DRIVER OF THE VEHICLE WAS TRAVELING 55 MPH WHEN THE VEHICLE BEGAN TO ACCELERATE INDEPENDENTLY. THE DRIVER SHIFTED INTO NEUTRAL AND TURNED THE VEHICLE OFF. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION OR REPAIRS. THE MANUFACTURER WAS CONTACTED AND ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 12V353000 (VEHICLE SPEED CONTROL:CABLES). THE FAILURE MILEAGE WAS 100,000.
NHTSA ODI #10475195
88,545 miles · Aug 29, 2012
Service BrakesVehicle Speed Control
ON AUGUST 18TH 2012 I WAS RETURNING HOME FROM GROCERY SHOPPING IN DOWNTOWN HAMILTON MT WHEN OUR 2005 FORD ESCAPE ACCELERATED OUT OF CONTROL AND WOULD NOT STOP. I MANAGED TO DODGE TRAFFIC AND PEOPLE AND PUT IT IN PARK AND HOLD MY FOOT DOWN ON THE BRAKE BUT IT KEPT SPEEDING. IT CONTINUED TO RACE DOWN THE STREET ABOUT MILE OR MOR…
Read full complaint
ON AUGUST 18TH 2012 I WAS RETURNING HOME FROM GROCERY SHOPPING IN DOWNTOWN HAMILTON MT WHEN OUR 2005 FORD ESCAPE ACCELERATED OUT OF CONTROL AND WOULD NOT STOP. I MANAGED TO DODGE TRAFFIC AND PEOPLE AND PUT IT IN PARK AND HOLD MY FOOT DOWN ON THE BRAKE BUT IT KEPT SPEEDING. IT CONTINUED TO RACE DOWN THE STREET ABOUT MILE OR MORE UNTIL I CAME TO A PLACE I WAS ABLE TO TURN OFF THE STREET INTO A PARKING AREA WITH A CORRAL WHICH HAD AN IRON GATE ON THE FENCE THAT I FELT WOULD STOP ME. IT FINALLY SLOWED DOWN AND I WAS ABLE TO TURN OFF THE KEY AND STOP; THANK GOD WITHOUT HITTING OR HARMING ANYONE STILL IT WAS A TERRIFYING EVENT. *TR
NHTSA ODI #10472945
20,000 miles · Jul 31, 2012
Vehicle Speed Control
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING AT ANY SPEED THE ACCELERATOR PEDAL WOULD STICK IN A PARTIALLY DEPRESSED POSITION AND THE VEHICLE WOULD BECOME INOPERABLE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC AND THE THROTTLE BODY WAS REPAIRED. THE FAILURE RECURRED. THE VEHICLE WAS THEN TAKEN …
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING AT ANY SPEED THE ACCELERATOR PEDAL WOULD STICK IN A PARTIALLY DEPRESSED POSITION AND THE VEHICLE WOULD BECOME INOPERABLE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC AND THE THROTTLE BODY WAS REPAIRED. THE FAILURE RECURRED. THE VEHICLE WAS THEN TAKEN TO AN AUTHORIZED DEALER, WHERE THEY WERE UNABLE TO DIAGNOSE A FAILURE. NO FURTHER ASSISTANCE WAS OFFERED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 20,000 AND THE CURRENT MILEAGE WAS 89,000. UPDATED 08/28/12*LJ THE CONSUMER STATED THE THROTTLE BODY WAS CLEANED. THE GAS PEDAL STICKING HAPPENED QUITE OFTEN. UPDATED 08/29/12
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence & remedy
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
Consequence & remedy
Consequence: If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITHOUT SIDE AIR CURTAINS OR MOONROOFS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT ABOVE THE PERMITTED LIMIT AT THE LEFT HAND A-PILLAR TRIM AREA.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
Remedy: DEALERS WILL MAKE MODIFICATIONS TO THE ENERGY ABSORBING MATERIAL LOCATED ABOVE THE HEADLINER IN THE AFFECTED AREA FREE OF CHARGE. THE RECALL BEGAN ON MAY 19, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
Consequence & remedy
Consequence: IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
DP12006 · Electronic Throttle Body Malfunction
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Engine
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.
AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
Illustration