TL* THE CONTACT OWNS A 2005 FORD ESCAPE. AFTER DRIVING OVER A BUMP, THERE WAS AN ABNORMAL NOISE COMING FROM THE REAR OF THE VEHICLE. THE CONTACT DISCOVERED THAT THE REAR SHOCK TOWERS WERE RUSTED. IN ADDITION, THE CONTACT STATED THAT A FUEL ODOR EMITTED INSIDE THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTUR…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. AFTER DRIVING OVER A BUMP, THERE WAS AN ABNORMAL NOISE COMING FROM THE REAR OF THE VEHICLE. THE CONTACT DISCOVERED THAT THE REAR SHOCK TOWERS WERE RUSTED. IN ADDITION, THE CONTACT STATED THAT A FUEL ODOR EMITTED INSIDE THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 74,000.
NHTSA ODI #10726490
150,000 miles · Jun 16, 2015
StructureSuspension
RIGHT REAR WHEEL WELL IS SO RUSTED OUT THAT THE SHOCK MOUNT HAS COMPLETELY DETACHED FROM THE BODY. DEFINITE SAFETY ISSUE. 2005 FORD ESCAPE XLT.
NHTSA ODI #10725653
125,000 miles · Jun 16, 2015
SuspensionUnknown Or Other
PASSENGER SIDE REAR WHEEL WELL (HIDDEN AREA ONLY) RUSTED OUT AT THE SHOCK MOUNT CAUSING THE SHOCK TO PUNCH INTO THE INTERIOR. EXPENSIVE REPAIR. SAD PART IS THAT THE REST OF THE VEHICLE IS IN VERY GOOD SHAPE, NEVER SUSPECTED SUCH A RUSTING ISSUE LIKE THAT. I SEE IT IS A COMMON FLAW OF THIS VEHICLE. POOR ENGINEERING OF A CRITI…
Read full complaint
PASSENGER SIDE REAR WHEEL WELL (HIDDEN AREA ONLY) RUSTED OUT AT THE SHOCK MOUNT CAUSING THE SHOCK TO PUNCH INTO THE INTERIOR. EXPENSIVE REPAIR. SAD PART IS THAT THE REST OF THE VEHICLE IS IN VERY GOOD SHAPE, NEVER SUSPECTED SUCH A RUSTING ISSUE LIKE THAT. I SEE IT IS A COMMON FLAW OF THIS VEHICLE. POOR ENGINEERING OF A CRITICAL MOUNTING POINT. FORTUNATELY NO INJURIES IN THIS CASE, BUT COULD EASILY HAVE CAUSED PANIC RESULTING IN AN SERIOUS ACCIDENT. VERY SURPRISED THIS IS NOT A FORD RECALL ITEM WITH AN AVAILABLE MANUFACTURED REINFORCING PART.
NHTSA ODI #10725485
143,636 miles · Jun 14, 2015
Service BrakesSuspension
THE UPPER SHOCK MOUNT ON THE REAR PASSENGER SIDE RUSTED RIGHT THROUGH AND FELL OFF WHICH CUT MY BREAKLINE WHICH COULD'VE LED TO A FATAL ACCIDENT. I ALSO HAVE A CHILD, THIS IS EXTREMELY DANGEROUS AND SHOULD BE RECALLED. THE SYSTEM CHECK AND ABS LIGHT NEVER CAME ON EITHER.
NHTSA ODI #10725167
137,000 miles · Jun 8, 2015
Suspension
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING AT 25 MPH, THE SUSPENSION FAILED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE REAR SUSPENSION RUSTED AND THAT THERE WAS A POSSIBILITY OF THE SUSPENSION SEPARATING FROM THE BODY OF THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANU…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING AT 25 MPH, THE SUSPENSION FAILED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE REAR SUSPENSION RUSTED AND THAT THERE WAS A POSSIBILITY OF THE SUSPENSION SEPARATING FROM THE BODY OF THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 137,000.
NHTSA ODI #10724074
81,297 miles · Jun 5, 2015
Suspension
WHILE DRIVING HEARD A LOUD KNOTTING IN THE RIGHT REAR OF THE VEHICLE, GOING OVER MINOR BUMPS. LOOKED UNDER THE RIGHT REAR WHEEL WELL FOUND TOP OF SHOCK RUSTING LOOSE FROM WHERE IT WAS ATTACHED. IF THIS BREAKS LOOSE COMPLETELY IT COULD CAUSE THE VEHICLE TO BOUNCE AND SWEVE RADICALLY CAUSING DRIVER TO LOSE CONTROL.
NHTSA ODI #10723619
89,000 miles · Jun 3, 2015
Suspension
PASSENGER SIDE REAR FENDER COMPLETELY RUSTED THROUGH CAUSING TOTAL DETACHMENT OF SHOCK ABSORBER MOUNT TOWER ORIGINALLY PART OF BODY/FRAME.
NHTSA ODI #10723195
117,000 miles · May 22, 2015
StructureSuspension
MY 2005 FORD ESCAPE REAR PASSENGER SIDE WHEEL WELL CRACKED. THE SHOCK ABSORBER IS HARDLY ATTACHED AND IS A SAFETY ISSUE. IF IT FALLS OFF IT COULD CAUSE AN ACCIDENT.
NHTSA ODI #10720940
130,000 miles · May 17, 2015
StructureSuspension
HEARD A THUDDING FROM REAR END. LOOKED UNDERNEATH AS NOTHING LOOSE IN THE VEHICLE. THE PASSENGER SIDE REAR WHEEL WELL IS VERY RUSTED. NO SUPPORT FOR SHOCKS. THERE WAS AN UNDERCOATING WITH DEBRIS UNDER IT. TOOK OUT A LOT OF SLUDGE/RUST/DEBRIS FROM UNDER THAT COATING. BODY SHOP SAYS $5000 TO FIX IT PROPERLY, AND THE OTHER SI…
Read full complaint
HEARD A THUDDING FROM REAR END. LOOKED UNDERNEATH AS NOTHING LOOSE IN THE VEHICLE. THE PASSENGER SIDE REAR WHEEL WELL IS VERY RUSTED. NO SUPPORT FOR SHOCKS. THERE WAS AN UNDERCOATING WITH DEBRIS UNDER IT. TOOK OUT A LOT OF SLUDGE/RUST/DEBRIS FROM UNDER THAT COATING. BODY SHOP SAYS $5000 TO FIX IT PROPERLY, AND THE OTHER SIDE IS STARTING TO RUST AS WELL (DRIVER REAR WHEEL WELL).
NHTSA ODI #10716952
Mileage unknown · May 17, 2015
Suspension
HAVE HEARD THIS NOISE LIKE A WINDOW OR DOOR RATTLING FOR AWHILE AND COULDN'T FIND THE PROBLEM. FINALLY LOOKED AT IT REALLY GOOD ONE DAY AND FOUND THE RIGHT WHEEL WELL AND SHOCK WERE COMPLETELY RUSTED OUT AND JUST SITTING THERE. UNSAFE TO DRIVE SO WE TOOK IT HOME AND PARKED IT. THIS CAR WAS BOUGHT FOR MY GRANDAUGHTER AND HER BAB…
Read full complaint
HAVE HEARD THIS NOISE LIKE A WINDOW OR DOOR RATTLING FOR AWHILE AND COULDN'T FIND THE PROBLEM. FINALLY LOOKED AT IT REALLY GOOD ONE DAY AND FOUND THE RIGHT WHEEL WELL AND SHOCK WERE COMPLETELY RUSTED OUT AND JUST SITTING THERE. UNSAFE TO DRIVE SO WE TOOK IT HOME AND PARKED IT. THIS CAR WAS BOUGHT FOR MY GRANDAUGHTER AND HER BABY TO BE A SAFE CAR FOR HER AND NOW WE HAVE TO PARK IT AND FIGURE OUT WHAT TO DO BECAUSE WE STILL OWE ON THIS VEHICLE AND CAN'T AFFORD TO PAY IT OFF OR GET ANOTHER ONE RIGHT NOW
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence & remedy
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
Consequence & remedy
Consequence: If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITHOUT SIDE AIR CURTAINS OR MOONROOFS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT ABOVE THE PERMITTED LIMIT AT THE LEFT HAND A-PILLAR TRIM AREA.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
Remedy: DEALERS WILL MAKE MODIFICATIONS TO THE ENERGY ABSORBING MATERIAL LOCATED ABOVE THE HEADLINER IN THE AFFECTED AREA FREE OF CHARGE. THE RECALL BEGAN ON MAY 19, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
Consequence & remedy
Consequence: IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
DP12006 · Electronic Throttle Body Malfunction
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Engine
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.
AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
Illustration