THE RIGHT REAR UPPER SHOCK MOUNT COMPLETELY RUSTED THRU THE TRUNK AREA&WAS PROTRUDING UP ABOUT A FOOT INTO TRUNK AREA-VERY GLAD I WASN'T GOING FAST WHEN THIS HAPPENED!!MOST LIKELY WOULD HAVE LOST CONTROL OF VEHICLE!!!!!!!!!THIS IS ONE OF FORDS BEST IDEAS EVER!!!!!!!!!!!!!!!!!!!!!!!!!!!VERY THIN SHEET METAL WITH A THICKER PIECE …
Read full complaint
THE RIGHT REAR UPPER SHOCK MOUNT COMPLETELY RUSTED THRU THE TRUNK AREA&WAS PROTRUDING UP ABOUT A FOOT INTO TRUNK AREA-VERY GLAD I WASN'T GOING FAST WHEN THIS HAPPENED!!MOST LIKELY WOULD HAVE LOST CONTROL OF VEHICLE!!!!!!!!!THIS IS ONE OF FORDS BEST IDEAS EVER!!!!!!!!!!!!!!!!!!!!!!!!!!!VERY THIN SHEET METAL WITH A THICKER PIECE WELDED TO IT TO SUPPORT 1 SIDE OF A VEHICLE.YEAH,THAT IS COMMON SENSE AT THE FINEST!!!!! THANKYOU FORD ENGINEERS!!!!!!!!!!!!!!!!!!!!&DESIGNERS!!!!!!!!!!!!!!!!!! THESE SAME COMMON SENSE PEOPLE HOPEFULLY PUT OUT A RECALL SO PEOPLE CAN GET IT FIXED&GET SOME MONEY BACK!! I DID HAVE MINE FIXED RIGHT AWAY_IT'S THE ONLY VEHICLE I HAVE. *TR
NHTSA ODI #10536656
155,000 miles · Jul 31, 2013
StructureWheels
I HAD BEEN HEARING SOME LOUD NOISES FROM THE BACK END OF MY CAR FOR A WEEK OR SO, WE HAD THOUGHT THE SPARE TIRE AND EQUIPMENT HADN'T BEEN PUT BACK PROPERLY SO WE RE-ADJUSTED IT AND THOUGHT WE HAD FIXED THE PROBLEM. A FEW DAYS LATER THE SOUND STARTED BACK UP. THEN IT GOT REALLY LOUD AND THERE WAS A LOUD POP. UPON FURTHER INVESTIG…
Read full complaint
I HAD BEEN HEARING SOME LOUD NOISES FROM THE BACK END OF MY CAR FOR A WEEK OR SO, WE HAD THOUGHT THE SPARE TIRE AND EQUIPMENT HADN'T BEEN PUT BACK PROPERLY SO WE RE-ADJUSTED IT AND THOUGHT WE HAD FIXED THE PROBLEM. A FEW DAYS LATER THE SOUND STARTED BACK UP. THEN IT GOT REALLY LOUD AND THERE WAS A LOUD POP. UPON FURTHER INVESTIGATION, WE FOUND OUT THE ENTIRE WHEEL WELL HAD RUSTED OUT IN A PERFECT CIRCLE AROUND THE SHOCK. THE SHOCK WAS NO LONGER ATTACHED TO THE CAR. I TOOK IT TO FORD AND THEY TOLD ME THIS HAD BEEN RECALLED ON THEIR MINI-VANS FOR THE SAME YEAR. FORD BODY SHOP STAFF INFORMED ME THAT THIS WAS THE ONLY RUST ON MY VEHICLE AND THIS RUST WOULD NOT BE CAUSED BY MIS-TREATMENT OF THE VEHICLE NOR NORMAL WEAR AND TEAR OF ANY CAR. FORD IS CURRENTLY UNABLE TO GET THE WHEEL HOUSE TO FIX THE CAR AND IT WILL NOT BE AVAILABLE FOR "MONTHS". ONCE I RESEARCHED THIS A LITTLE MORE, IT APPEARS TO BE A HIGHLY COMMON PROBLEM IN THE 2005 FORD ESCAPES. THE CAR IS NOT CURRENTLY FIXABLE OR DRIVE ABLE. *TR
NHTSA ODI #10532832
48,000 miles · Jul 30, 2013
StructureSuspension
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT UPON INSPECTION, IT WAS FOUND THAT THE PASSENGER'S SIDE REAR SHOCK HAD PENETRATED THE BODY OF THE VEHICLE DUE TO RUST. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE WAS CONFIRMED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FA…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT UPON INSPECTION, IT WAS FOUND THAT THE PASSENGER'S SIDE REAR SHOCK HAD PENETRATED THE BODY OF THE VEHICLE DUE TO RUST. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE WAS CONFIRMED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 48,000. THE CURRENT MILEAGE WAS 90,000.
NHTSA ODI #10532668
112,000 miles · Jul 30, 2013
StructureSuspension
THE RIGHT REAR SHOCK MOUNT HAS RUSTED OUT, AND NOW BANGS AGAINST THE WHEEL HOUSING. *TR
NHTSA ODI #10532647
165,995 miles · Jul 25, 2013
StructureSuspensionWheels
THE WHEEL WELL RUSTED OUT AND THE SHOCK BROKE LOOSE AND WAS BANGING AROUND. BASICALLY THE WHOLE WHEEL WELL IS RUSTED OUT AND WILL NOT HOLD THE SHOCK ANY MORE. I CALLED THE LOCAL FORD DEALER TO SEE IF THERE WAS A RECALL. I WAS TOLD THERE WAS NO RECALL. WHEN I SEARCHED ONLINE I FOUND MANY WITH THE SAME EXPERIENCE, AND EVEN A FACEB…
Read full complaint
THE WHEEL WELL RUSTED OUT AND THE SHOCK BROKE LOOSE AND WAS BANGING AROUND. BASICALLY THE WHOLE WHEEL WELL IS RUSTED OUT AND WILL NOT HOLD THE SHOCK ANY MORE. I CALLED THE LOCAL FORD DEALER TO SEE IF THERE WAS A RECALL. I WAS TOLD THERE WAS NO RECALL. WHEN I SEARCHED ONLINE I FOUND MANY WITH THE SAME EXPERIENCE, AND EVEN A FACEBOOK PAGE. I'M DISAPPOINTED THAT FORD ISN'T TAKING CARE OF THIS. *TR
NHTSA ODI #10531845
205,000 miles · Jul 25, 2013
StructureSuspension
RIGHT REAR WHEEL HOUSING THAT ALSO IS THE TOP RIGHT REAR SHOCK MOUNT IS COMPLETELY RUSTED LOOSE. *TR
NHTSA ODI #10531773
93,800 miles · Jul 14, 2013
StructureSuspension
WHILE DRIVING MY VEHICLE HOME FROM WORK, I HEARD A CLANGING SOUND COMING FROM THE REAR PASSENGER SIDE. THINKING THE SHOCK NEEDED TO BE REPLACED, I DROVE IT UNTIL THE END OF THE WEEK AND MADE AN APPOINTMENT TO GET IT SERVICED. WHILE THE TECHNICIAN WAS CHECKING OUT MY CAR HE NOTICED THE INNER WHEEL HOUSE AND SHOCK WERE COMPLETEL…
Read full complaint
WHILE DRIVING MY VEHICLE HOME FROM WORK, I HEARD A CLANGING SOUND COMING FROM THE REAR PASSENGER SIDE. THINKING THE SHOCK NEEDED TO BE REPLACED, I DROVE IT UNTIL THE END OF THE WEEK AND MADE AN APPOINTMENT TO GET IT SERVICED. WHILE THE TECHNICIAN WAS CHECKING OUT MY CAR HE NOTICED THE INNER WHEEL HOUSE AND SHOCK WERE COMPLETELY RUSTED. THE SHOCK WAS DETACHED FROM THE VEHICLE AND THE FRAME IS RUSTED AND CRACKED. HE RECOMMENDED ME TO TAKE IT TO A BODY SHOP TO SEE IF IT COULD EVEN BE FIXED. I THEN TOOK IT TO A VERY REPUTABLE BODY SHOP IN MY TOWN AND THEY HAVE NEVER SEEN ANYTHING LIKE THIS BEFORE. THEY WORK ON ALL MAKE AND MODELS OF DIFFERENT YEARS AND SAID THIS IS NOT NORMAL WEAR AND TEAR TO A VEHICLE. THEY SAID UNDERNEATH THE VEHICLE IS MADE TO SUSTAIN ANY TYPE OF CONDITION AND THIS VEHICLE WAS POORLY MADE. THERE IS BARELY ANYTHING HOLDING THE BACK END OF THE VEHICLE TOGETHER AND FOR THIS REASON I WAS TOLD THE VEHICLE IS UNSAFE TO DRIVE BECAUSE IF I AM IN ANY SORT OF ACCIDENT THERE WILL BE NO PROTECTION TO ME AND THE VEHICLE WILL PROBABLY BE SPLIT IN TWO. DUE TO THE LOCATION OF THE DEFECT WHO KNOWS HOW LONG MY VEHICLE HAS BEEN DANGEROUS TO DRIVE AND IT MAKES ME SICK TO THINK ABOUT WHAT COULD HAVE HAPPENED IF I WAS IN AN ACCIDENT AND I HAVE HAD MY TWO YOUNG CHILDREN IN MY BACKSEAT. THE ESTIMATE FROM THE BODY SHOP WAS OVER $13,000 TO FIX. I HAVE HAD THIS VEHICLE SINCE 2005 AND IT HAS BEEN A GREAT, RELIABLE CAR UNTIL ALL THIS HAS HAPPENED. IT HAS NOT BEEN IN ANY ACCIDENTS OR HAD ANY OTHER MAJOR REPAIRS. *TR
NHTSA ODI #10524781
112,100 miles · Jul 10, 2013
StructureSuspension
WHILE DRIVING ON INTERSTATE, HIT A BUMP AND HEARD LOUD SOUND ON RIGHT REAR SIDE OF VEHICLE. AFTER I STOPPED TO INSPECT, FOUND THAT THE RIGHT REAR STRUT HAD NO SUPPORT AS THE RIGHT REAR INNER PANEL WAS CORRODED ALL THE WAY THROUGH WITH VERY THIN METAL AROUND THE ENTIRE AREA. LUCKILY THE STRUT DID NOT COME UP THROUGH INTERIOR. …
Read full complaint
WHILE DRIVING ON INTERSTATE, HIT A BUMP AND HEARD LOUD SOUND ON RIGHT REAR SIDE OF VEHICLE. AFTER I STOPPED TO INSPECT, FOUND THAT THE RIGHT REAR STRUT HAD NO SUPPORT AS THE RIGHT REAR INNER PANEL WAS CORRODED ALL THE WAY THROUGH WITH VERY THIN METAL AROUND THE ENTIRE AREA. LUCKILY THE STRUT DID NOT COME UP THROUGH INTERIOR. SEEMS VERY UNSAFE AND LIKELY TO CAUSE ACCIDENT IF DRIVEN. THIS APPEARS TO A MANUFACTURERS DEFECT AS THE CORROSION PROTECTION WAS NOT APPLIED CORRECTLY. I CALLED FORD MOTOR CUSTOMER SERVICE AND THEY JUST INDICATED THAT THERE WE NO RECALLS YET ON THIS PROBLEM. THIS SEEMS TO BE A PROBLEM ON THE 2004-2005 FORD ESCAPES ON THE RIGHT REAR. I TOOK TO BODY SHOP AND HAVE ESTIMATES FROM $1,400 TO $1,700 TO REPAIR. THE VEHICLE IS IN VERY GOOD SHAPE EXCEPT FOR THIS ONE OBVIOUS DEFECT. *TR
NHTSA ODI #10524228
122,000 miles · Jul 9, 2013
StructureCrash
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT REAR PASSENGER'S SIDE WHEEL WELL EXHIBITED EXTENSIVE RUST. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE ENTIRE REAR PANEL WOULD NEED TO BE REPLACED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE DIAGNOSIS WAS CONF…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT REAR PASSENGER'S SIDE WHEEL WELL EXHIBITED EXTENSIVE RUST. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE ENTIRE REAR PANEL WOULD NEED TO BE REPLACED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE DIAGNOSIS WAS CONFIRMED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 122,000.
NHTSA ODI #10523990
166,000 miles · Jul 9, 2013
Structure
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, HE HEARD A LOUD THUMP FROM THE REAR PASSENGER'S SIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO STATED THAT THE FAILURE WAS CONTRIBUTED TO RUST CORROSION NEAR THE REAR END OF THE FRAME. THE VEHICLE WAS NOT…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, HE HEARD A LOUD THUMP FROM THE REAR PASSENGER'S SIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO STATED THAT THE FAILURE WAS CONTRIBUTED TO RUST CORROSION NEAR THE REAR END OF THE FRAME. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 166,000. UPDATED 8/19/13 *CN
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence & remedy
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
Consequence & remedy
Consequence: If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITHOUT SIDE AIR CURTAINS OR MOONROOFS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT ABOVE THE PERMITTED LIMIT AT THE LEFT HAND A-PILLAR TRIM AREA.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
Remedy: DEALERS WILL MAKE MODIFICATIONS TO THE ENERGY ABSORBING MATERIAL LOCATED ABOVE THE HEADLINER IN THE AFFECTED AREA FREE OF CHARGE. THE RECALL BEGAN ON MAY 19, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
Consequence & remedy
Consequence: IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
DP12006 · Electronic Throttle Body Malfunction
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Engine
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.
AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
Illustration