TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT THE VEHICLE WAS VERY DIFFICULT TO STEER AND WOULD SPORADICALLY SHAKE VIOLENTLY. THE DEALER MADE TWO ATTEMPTS TO DUPLICATE THE FAILURE BY REPLACING THE RACK AND PINION HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. NO REPAIRS WE…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT THE VEHICLE WAS VERY DIFFICULT TO STEER AND WOULD SPORADICALLY SHAKE VIOLENTLY. THE DEALER MADE TWO ATTEMPTS TO DUPLICATE THE FAILURE BY REPLACING THE RACK AND PINION HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. NO REPAIRS WERE PERFORMED. THE CURRENT MILEAGE WAS 203,481 AND THE APPROXIMATE FAILURE MILEAGE WAS 79,500.
NHTSA ODI #10434855
47,000 miles · Aug 31, 2011
Power TrainSteeringSuspension
LOUD SQUEAKY NOISE FROM RIGHT FRONT END. TOOK TO MECHANIC. THEY SAY BOTH FRONT GREASE BOOTS ARE CRACKED WHICH ALLOWS DIRT, DUST, ETC. TO GET IN AND UP AROUND THE BALL JOINTS AND TIE ROD ASSEMBLIES. THE RIGHT FRONT BALL JOINT HAD GONE BAD DUE TO THIS BOOT CRACK SO WE HAD TO REPLACE IT. THEY RECOMMEND REPLACING BOTH TIE RODS, …
Read full complaint
LOUD SQUEAKY NOISE FROM RIGHT FRONT END. TOOK TO MECHANIC. THEY SAY BOTH FRONT GREASE BOOTS ARE CRACKED WHICH ALLOWS DIRT, DUST, ETC. TO GET IN AND UP AROUND THE BALL JOINTS AND TIE ROD ASSEMBLIES. THE RIGHT FRONT BALL JOINT HAD GONE BAD DUE TO THIS BOOT CRACK SO WE HAD TO REPLACE IT. THEY RECOMMEND REPLACING BOTH TIE RODS, BOOTS AND BALL JOINTS, BUT WE COULD ONLY AFFORD TO REPLACE THE BALL JOINT THAT WAS BAD AT THIS TIME BECAUSE WE JUST SPENT $3350 PUTTING A NEW TRANSMISSION IN THE CAR. THIS VEHICLE HAS LESS THAN 50,000 MILES ON IT. UNBELIEVABLE!!!! WHAT IS FORD BUILDING THESE CARS WITH??? I SUSPECT THE CHEAPEST PARTS THEY CAN GET REGARDLESS OF THEIR QUALITY SO THEY CAN MAKE MORE MONEY. IN THE MEANTIME THE AVERAGE WORKING FAMILY HAS TO PAY TWICE FOR A VEHICLE'S PARTS THAT SHOULD NOT GO BAD SO QUICKLY. *TR
NHTSA ODI #10422826
104,000 miles · May 23, 2011
Electrical SystemEngine And Engine CoolingSteering
I AM A WEDDING PHOTOGRAPHER AND WHILE TRAVELING ABOUT 4.5 HOURS AWAY FROM HOME TO SHOOT A WEDDING I HAD PROBLEMS ABOUT 2 HOURS INTO MY TRIP. I WAS ON INTERSTATE 20 JUST OUTSIDE OF COLUMBIA, SC. I WAS IN THE LEFT HAND LANE BEHIND A SEMI TRUCK, THERE WAS ANOTHER SEMI TRUCK IN THE RIGHT LANE BESIDE ME AND BEHIND ME I HAD A LARGE VA…
Read full complaint
I AM A WEDDING PHOTOGRAPHER AND WHILE TRAVELING ABOUT 4.5 HOURS AWAY FROM HOME TO SHOOT A WEDDING I HAD PROBLEMS ABOUT 2 HOURS INTO MY TRIP. I WAS ON INTERSTATE 20 JUST OUTSIDE OF COLUMBIA, SC. I WAS IN THE LEFT HAND LANE BEHIND A SEMI TRUCK, THERE WAS ANOTHER SEMI TRUCK IN THE RIGHT LANE BESIDE ME AND BEHIND ME I HAD A LARGE VAN. I WAS GOING ABOUT 65-70 WHEN SUDDENLY, THE CAR LOST ALL POWER INCLUDING THE STEERING AND ALL THE WARNING LIGHTS BLINKED ON. I SOMEHOW REGAINED CONTROL OF THE CAR BY SHIFTING IN NEUTRAL AND RESTARTING. I HATE TO THINK WHAT WOULD HAVE HAPPENED HAD I NOT BEEN ABLE TO REACT AS FAST AS I DID AS THE VAN BEHIND ME HAD TO SLAM ON HIS BREAKS TO KEEP FROM HITTING ME. ONCE THE SEMI TRUCK WAS CLEARED OF THE RIGHT LANE I GOT OVER AND TURNED ON MY FLASHERS. SINCE I HAD IT RUNNING I WAS TOO SCARED TO PULL OVER ON THE SIDE. I GOT TO MY NEAREST EXIT AND PULLED OVER. I TURNED OFF THE VEHICLE AND ALL THE WARNING LIGHTS WENT OFF EXCEPT THE ABS AND THE CHECK ENGINE LIGHT. I RESTARTED AND DROVE ABOUT A MILE TO A MECHANIC. THEY COULD NOT SEE ANYTHING WRONG BUT HEARD THE MISFIRE. THE CAR WAS TOWED TO CLASSIC FORD IN COLUMBIA, SC. I HAD TO RENT A CAR TO FINISH MY TRIP AS I COULDN'T LET DOWN A COUPLE ABOUT TO BE MARRIED. I JUST GOT THE ESTIMATE TO THE TUNE OF OVER $2700.00. IT'S THE PCM MODULE ALONG WITH COIL, SPARK PLUGS AND A FEW OTHER THINGS. I AM NOW DEBATING ABOUT WEATHER TO FIX IT OR NOT AS ALL THE REVIEWS I HAVE READ IT SEEMS LIKE PEOPLE CONTINUE TO HAVE PROBLEMS AFTER IT'S FIXED. IT SOUNDS LIKE FORD REALLY NEEDS TO FIGURE OUT A WAY TO FIX THIS CHRONIC PROBLEM BEFORE SOMEONE DIES IN AN ACCIDENT.
NHTSA ODI #10403293
69,000 miles · Apr 11, 2011
Steering
TOOK MY 2005 FORD ESCAPE IN FOR AN INSPECTION AND WAS TOLD IT WOULD NOT PASS UNLESS I HAD THE LEFT FRONT TIE ROD REPLACED. BEFORE FRIDAY, I HAD NEVER EVEN HEARD OF A TIE ROD, MUCH LESS HAD TO HAVE ONE REPLACED. I HAD SEVERAL USED VEHICLES BEFORE I GOT MY NEW ESCAPE IN 2004 AND NONE OF THEM EVER HAD TO HAVE A TIE ROD REPLACED. …
Read full complaint
TOOK MY 2005 FORD ESCAPE IN FOR AN INSPECTION AND WAS TOLD IT WOULD NOT PASS UNLESS I HAD THE LEFT FRONT TIE ROD REPLACED. BEFORE FRIDAY, I HAD NEVER EVEN HEARD OF A TIE ROD, MUCH LESS HAD TO HAVE ONE REPLACED. I HAD SEVERAL USED VEHICLES BEFORE I GOT MY NEW ESCAPE IN 2004 AND NONE OF THEM EVER HAD TO HAVE A TIE ROD REPLACED. LONG STORY SHORT, BOTH FRONT TIE RODS WERE REPLACED, A FRONT END ALIGNMENT HAD TO BE PERFORMED AND ALL TOTAL IT COST ME $690.00. I'M VERY UPSET ABOUT IT, BECAUSE I TAKE EXCELLENT CARE OF MY CAR AND WAS HAVING NO STEERING PROBLEMS WHATSOEVER. I WOULD LIKE TO KNOW IF THERE WAS A RECALL ON THIS PART THAT I WASN'T MADE AWARE OF AND IF ANYONE ELSE HAD TO HAVE ONE OR MORE TIE RODS REPLACED. *TR
NHTSA ODI #10395427
59,000 miles · Aug 4, 2010
SteeringSuspensionCrash
WHEN ENTERING A HIGHWAY WE HIT A DEEP GROOVE IN THE ROAD AND THEN PROCEEDED ONTO THE HIGHWAY. WITHIN 10 SECONDS THE CAR WHEELS AND STEERING WHEEL WENT OUT OF CONTROL. THE CAR WEAVED AND BOBBED FOR ABOUT 200 FEET UNCONTROLLABLE. I WAS TOLD THE STEERING RACK AND TIE ROD SNAPPED. WE HIT SOMEONE WHILE OUR CAR SPUN AROUND INTO …
Read full complaint
WHEN ENTERING A HIGHWAY WE HIT A DEEP GROOVE IN THE ROAD AND THEN PROCEEDED ONTO THE HIGHWAY. WITHIN 10 SECONDS THE CAR WHEELS AND STEERING WHEEL WENT OUT OF CONTROL. THE CAR WEAVED AND BOBBED FOR ABOUT 200 FEET UNCONTROLLABLE. I WAS TOLD THE STEERING RACK AND TIE ROD SNAPPED. WE HIT SOMEONE WHILE OUR CAR SPUN AROUND INTO ON COMING TRAFFIC AND WE FLEW INTO THE GUARD RAIL AT SUCH FORCE THE CAR LIFTED AND GOT LODGED ON THE GUARD RAIL. THIS PROBABLY SAVED OUR LIVES BECAUSE AT THAT POINT WE HAD DONE A 180 AND WERE FACING ONCOMING TRAFFIC. CAN NOT GET AN HELP FROM FORD. *TR
NHTSA ODI #10347308
34,330 miles · Jul 16, 2008
SteeringSuspension
NOTICED A RATTLING IN FRONT END, CREAKING NOISE WHEN TURNING TOWARDS THE RIGHT, AFTER TAKING IT TO THE DEALERSHIP AND THEM TELLING ME IT WAS NOT COVERED UNDER MY BUMPER TO BUMPER WARRANTY, I TOOK IT TO A FRONT-END SPECIALIST IN MY TOWN. THE PASSENGERS SWAY BAR LINK HAD TO BE REPLACED, NOW 3 MONTHS LATER, SAME NOISE DIFFERENT SID…
Read full complaint
NOTICED A RATTLING IN FRONT END, CREAKING NOISE WHEN TURNING TOWARDS THE RIGHT, AFTER TAKING IT TO THE DEALERSHIP AND THEM TELLING ME IT WAS NOT COVERED UNDER MY BUMPER TO BUMPER WARRANTY, I TOOK IT TO A FRONT-END SPECIALIST IN MY TOWN. THE PASSENGERS SWAY BAR LINK HAD TO BE REPLACED, NOW 3 MONTHS LATER, SAME NOISE DIFFERENT SIDE. TOOK IT TO THE SAME PLACE AND THEY HAD TO REPLACE THE DRIVERS SIDE SWAY BAR LINK. THE FRONT END PLACE COMMENTED THAT THEY FIX A LARGE NUMBER OF THESE ON ESCAPES, MORE THAN ANY OTHER CAR. CURRENTLY THE PARTS CAN ONLY BE BOUGHT FROM FORD, WHICH MEANS THEY WILL GO BAD AGAIN IN 2 1/2 YEARS! *TR
NHTSA ODI #10234567
11,000 miles · Oct 28, 2006
SteeringSuspension
2005 FORD ESCAPE. NOISE IN THE FRONT END WHILE DRIVING DOWN THE ROAD AT ANY SPEED. HAS BEEN TO THE DEALER FOR SERVICE ON THREE SEPARATE APPOINTMENTS FOR THE SAME THING. FIRST THEY SAID IT WAS DUE TO A RECALL ON THE POWER STEERING PRESSURE HOSE. THE SECOND TIME THEY BLAMED IT ON TIRE ROTATION NEED. THE THIRD AND FINAL TIME TO THI…
Read full complaint
2005 FORD ESCAPE. NOISE IN THE FRONT END WHILE DRIVING DOWN THE ROAD AT ANY SPEED. HAS BEEN TO THE DEALER FOR SERVICE ON THREE SEPARATE APPOINTMENTS FOR THE SAME THING. FIRST THEY SAID IT WAS DUE TO A RECALL ON THE POWER STEERING PRESSURE HOSE. THE SECOND TIME THEY BLAMED IT ON TIRE ROTATION NEED. THE THIRD AND FINAL TIME TO THIS PARTICULAR SERVICE DEPARTMENT, THEY SAID IT WAS IN NEED OF A FOUR WHEEL ALIGNMENT BUT THE NOISE WOULD STILL BE PRESENT. THE VEHICLE DID NOT PULL LEFT OR RIGHT. I REFUSED THEIR SERVICE THIS TIME BUT THEY DIDN'T SEEM TO CARE ABOUT LOSING A CUSTOMER. THAT WAS THEIR DEMEANOR EVERYTIME I WENT THERE. *NM
NHTSA ODI #10172043
4,056 miles · Jun 19, 2005
Steering
2005 FORD ESCAPE XLT: PULLS TO THE LEFT, VIBRATION IN FRONT, STEERING POOR. IT'S BEEN SERVICED AT THE DEALER 3 TIMES: AT 2000 MILES, 2600 MILES, AND 3800 MILES. IT'S GOING BACK A 4TH TIME. THANK GOD FOR THE LEMON LAW IN MN. THIS IS A SERIOUS STEERING DEFECT FROM THE FACTORY. FORD NEEDS TO CORRECT THIS BEFORE THEY LOOSE ALL MARKE…
Read full complaint
2005 FORD ESCAPE XLT: PULLS TO THE LEFT, VIBRATION IN FRONT, STEERING POOR. IT'S BEEN SERVICED AT THE DEALER 3 TIMES: AT 2000 MILES, 2600 MILES, AND 3800 MILES. IT'S GOING BACK A 4TH TIME. THANK GOD FOR THE LEMON LAW IN MN. THIS IS A SERIOUS STEERING DEFECT FROM THE FACTORY. FORD NEEDS TO CORRECT THIS BEFORE THEY LOOSE ALL MARKET SHARE TO QUALITY MANUFACTURERS LIKE HONDA AND TOYOTA.
NHTSA ODI #10125717
700 miles · Nov 12, 2004
Steering
CONSUMER COMPLAINED THAT POWER STEERING ASSIST FAILED WHILE DRIVING DOWN A MOUNTAIN AT 30-40 MPH. CONSUMER WAS WAITING FOR ROADSIDE ASSISTANCE TO PICK UP THE VEHICLE. *AK
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence & remedy
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
Consequence & remedy
Consequence: If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITHOUT SIDE AIR CURTAINS OR MOONROOFS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT ABOVE THE PERMITTED LIMIT AT THE LEFT HAND A-PILLAR TRIM AREA.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
Remedy: DEALERS WILL MAKE MODIFICATIONS TO THE ENERGY ABSORBING MATERIAL LOCATED ABOVE THE HEADLINER IN THE AFFECTED AREA FREE OF CHARGE. THE RECALL BEGAN ON MAY 19, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
Consequence & remedy
Consequence: IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
DP12006 · Electronic Throttle Body Malfunction
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Engine
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.
AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
Illustration