NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
49 reportsClear category filter116,000 miles · Sep 1, 2015
SteeringStructure
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 30 MPH, THE CONTACT STATED THAT THE VEHICLE WAS NOT STEERING PROPERLY AND PULLED TO THE RIGHT. THE FRONT PASSENGER SIDE SUBFRAME FRACTURED. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT THE SUBFRAME FRACTURED. THE MANUFA…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 30 MPH, THE CONTACT STATED THAT THE VEHICLE WAS NOT STEERING PROPERLY AND PULLED TO THE RIGHT. THE FRONT PASSENGER SIDE SUBFRAME FRACTURED. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT THE SUBFRAME FRACTURED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 116,000.
NHTSA ODI #10760761
83,000 miles · Aug 27, 2015
Service BrakesSteeringSuspension
THE SUB-FRAME RUSTED THROUGH CAUSING BOTH FRONT WHEELS TO TOE OUT AND ALSO TO CAMBER IN AT THE TOP. THE ABS WARNING LIGHT ALSO TRIGGERED. THE STEERING NOW PULLS TO THE LEFT AND THERE IS TIRE SQUEEL EVEN ON GRADUAL RIGHT HAND TURNS. THERE IS A RECALL FOR THIS EXACT PROBLEM FOR THE FORD ESCAPE MODEL YEARS 2001-2004. IT IS OBVI…
Read full complaint
THE SUB-FRAME RUSTED THROUGH CAUSING BOTH FRONT WHEELS TO TOE OUT AND ALSO TO CAMBER IN AT THE TOP. THE ABS WARNING LIGHT ALSO TRIGGERED. THE STEERING NOW PULLS TO THE LEFT AND THERE IS TIRE SQUEEL EVEN ON GRADUAL RIGHT HAND TURNS. THERE IS A RECALL FOR THIS EXACT PROBLEM FOR THE FORD ESCAPE MODEL YEARS 2001-2004. IT IS OBVIOUS THAT THIS SAME PROBLEM EXISTS FOR THIS MODEL YEAR 2005 FORD ESCAPE. I VERIFIED THAT MY VIN WAS NOT COVERED IN THE RECALL. I THEN CALLED FORD TO SEE IF THEY WOULD REMEDY THE PROBLEM AS IT WAS OBVIOUS THAT THIS WAS THE SAME PROBLEM AS IN THEIR OTHER RECALL - THEY SAID THEY COULDN'T HELP. THIS IS A LOW MILEAGE, WELL MAINTAINED VEHICLE SO IT SHOULD BE OBVIOUS THAT THE SUB-FRAME IS FAULTY.
NHTSA ODI #10759718
230,000 miles · Aug 9, 2015
Steering
MID DAY, MILD WEATHER IN THE 70'S, POWER STEERING WENT OUT WITHOUT WARNING, ALMOST HAD AN ACCIDENT AS I WAS IN A TURN, IT'S REALLY HARD TO TURN THIS VEHICLE. WHY IS THERE NOT A RECALL FOR THIS SIGNIFICANT SAFETY ISSUE?
NHTSA ODI #10747262
120,000 miles · Aug 6, 2015
SteeringSuspensionUnknown Or Other
SUB-FRAME RUST PROBLEM. THERE WAS A RECALL ON 2001 TO 2004 FORD ESCAPE FOR THIS PROBLEM. FORD MOTOR COMPANY HAS RECALLED ESCAPE CROSSOVERS FROM MODEL YEARS 2001-2004 IN STATES THAT USE A LOT OF ROAD SALT. IN AFFECTED VEHICLES, PART OF THE CAR COULD SUFFER DAMAGE FROM RUST AND EVEN LOSE STEERING CONTROL.
NHTSA ODI #10746694
158,000 miles · Jul 22, 2015
SteeringStructure
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING AT 35 MPH, THE CONTACT HEARD AN ABNORMAL NOISE COMING FROM THE REAR OF THE VEHICLE. IN ADDITION, THE CONTACT STATED THAT THE REAR OF THE VEHICLE FAILED TO STAY IN POSITION AND VEERED LEFT OR RIGHT. THE ENGINE WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE CONTACT NOTICED THAT…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING AT 35 MPH, THE CONTACT HEARD AN ABNORMAL NOISE COMING FROM THE REAR OF THE VEHICLE. IN ADDITION, THE CONTACT STATED THAT THE REAR OF THE VEHICLE FAILED TO STAY IN POSITION AND VEERED LEFT OR RIGHT. THE ENGINE WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE CONTACT NOTICED THAT THERE WAS CORROSION AROUND THE REAR PASSENGER SHOCKS AND WHEEL HOUSE AREA. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 158,000.
NHTSA ODI #10735701
105,900 miles · Jun 23, 2015
SteeringStructureWheels
WHILE DRIVING, I NOTICED THAT MY STEERING WHEEL WAS NOT ALIGNED. I DIDN'T NOTICE IT WAS LIKE THIS UNTIL I WAS ALREADY DRIVING DOWN THE ROAD. WHEN I STOPPED, I CHECKED MY TIRES AND THOUGHT THAT THEY LOOKED SLIGHTLY OFF. IT SEEMED AS IF THE PASSENGER SIDE TIRE WAS POINTED SLIGHTLY OUTWARD. THE CAR SAT IN MY DRIVEWAY FOR THE NEXT C…
Read full complaint
WHILE DRIVING, I NOTICED THAT MY STEERING WHEEL WAS NOT ALIGNED. I DIDN'T NOTICE IT WAS LIKE THIS UNTIL I WAS ALREADY DRIVING DOWN THE ROAD. WHEN I STOPPED, I CHECKED MY TIRES AND THOUGHT THAT THEY LOOKED SLIGHTLY OFF. IT SEEMED AS IF THE PASSENGER SIDE TIRE WAS POINTED SLIGHTLY OUTWARD. THE CAR SAT IN MY DRIVEWAY FOR THE NEXT COUPLE OF DAYS AND IT APPEARED TO HAVE GOTTEN WORSE. I TOOK MY CAR OUT FOR A TEST DRIVE AND NOTICED THAT EACH TIME I TURNED THE WHEEL, THE TIRES SCREECHED. I TOOK THE CAR TO A SHOP AND AFTER GIVING IT AN EVALUATION, THEY SAID THAT THE CONTROL ROD WAS RUSTED AND STARTING TO BREAK. AFTER SOME RESEARCH ONLINE, IT LOOKED LIKE THERE WAS A RECALL ON 2001-2004 FORD ESCAPES FOR THE SAME ISSUE THAT I WAS HAVING.
NHTSA ODI #10726916
56,000 miles · Apr 24, 2015
EngineSteering
I HAD PURCHASED A USED ESCAPE, IN VERY GOOD CONDITION, IN AUG 2014. I BOUGHT FROM THE ORIGINAL OWNER, A FAMILY MEMBER, WITH ONLY 55K MILEAGE OVER THEIR 10 YEARS OF OWNERSHIP (THEY WERE UPGRADING). I DROVE THE CAR AN ADDITIONAL 1,500 MILES HERE (TO 56K, TOTAL) OVER MY FIRST TWO MONTHS OF OWNERSHIP, AND THE CAR HAD PASSED ALL ITS …
Read full complaint
I HAD PURCHASED A USED ESCAPE, IN VERY GOOD CONDITION, IN AUG 2014. I BOUGHT FROM THE ORIGINAL OWNER, A FAMILY MEMBER, WITH ONLY 55K MILEAGE OVER THEIR 10 YEARS OF OWNERSHIP (THEY WERE UPGRADING). I DROVE THE CAR AN ADDITIONAL 1,500 MILES HERE (TO 56K, TOTAL) OVER MY FIRST TWO MONTHS OF OWNERSHIP, AND THE CAR HAD PASSED ALL ITS REGULAR ANNUAL INSPECTIONS. SUDDENLY ONE NIGHT ON THE ROAD THE CAR'S ENGINE BEGAN CHUGGING WHEN I ATTEMPTED TO TRAVEL BEYOND 45MPH, AND A BLINKING YELLOW CHECK ENGINE LIGHT APPEARED. UPON RESTARTING THAT INDICATOR DID NOT COME BACK ON, BUT THE ENGINE WAS STILL SLUGGISH AND SO I ATTEMPTED TO COAST HOME AT MANAGED SPEEDS (AS I WAS ONLY A MILE AWAY) TO HAVE A MECHANIC CHECK IT OUT DURING BUSINESS HOURS. I DIDN'T EVEN MAKE IT HOME. THE ENGINE LIGHT WENT ON FULL AND I SOON LOST POWER COMPLETELY, WITH BARELY ENOUGH NOTICE TO PULL OFF THE 6 LANE HIGHWAY. THE SUDDEN POWER LOSS SEEMED VERY UNSAFE AS I HAD TO STEER MANUALLY WITH NO POWER STEERING NOR ACCELERATION. AFTER THE CAR STALLED OUT IT WOULD NOT EVEN RESTART FOR A LONG PERIOD OF TIME. I TOWED IT TO A MECHANIC THE NEXT DAY AND THEY READ ME A LONG LIST OF ERROR CODES THAT HAD BEEN IDENTIFIED, ALL OF WHICH WENT BACK TO THE POWER CONTROL MODULE (PCM) FAILURE, APPARENTLY, AS DESCRIBED IN TSB 10-18-10. I HAVE BEEN TOLD BY TWO DIFFERENT MECHANICS, INCLUDING MY LOCAL FORD DEALERSHIP, THAT IT WOULD COST AT LEAST $2,000 TO SERVICE THE PCM AND REPLACE ALL AFFECTED SPARK PLUGS, COILS AND CYLINDERS. DESPITE THE VERY LOW MILEAGE BELOW THE 80K PCM WARRANTY, THE VEHICLE REACTED RATHER SPORADICALLY AND UNPREDICTABLY AND IT CREATED AN UNSAFE CONDITION. I WOULD HAVE LIKED TO HAVE BEEN INFORMED SOONER OF THIS KNOWN ISSUE. THERE SHOULD HAVE BEEN A RECALL NOTICE SINCE THE PCM IS KNOWN TO CAUSE A HAZARD. I NOW SEE THAT THERE ARE 113 COMPLAINTS LOGGED AT CARCOMPLAINTS.COM, CITING SIMILAR PCM AND/OR ENGINE PROBLEMS. *TR
NHTSA ODI #10712763
98,000 miles · Mar 21, 2015
Air BagsService BrakesSteeringCrashInjury
I WAS DRIVING ON THE FREEWAY IN THE FAST LANE AT 60MPH AND A CAR CUT ME SHORT AND BRAKE SO I APPLIED MY BRAKE MY WHEEL HAD YANKED TO THE LEFT AND I TRIED TO GAIN CONTROL OF THE WHEEL BY PULLING IT TO THE RIGHT BUT IT YANKED AGAIN TO THE LEFT CAUSING ME TO HIT INTO THE MEDIAN DUE TO THE IMPACT MY CAR TURNED OVER AND DRAGGED ACROS…
Read full complaint
I WAS DRIVING ON THE FREEWAY IN THE FAST LANE AT 60MPH AND A CAR CUT ME SHORT AND BRAKE SO I APPLIED MY BRAKE MY WHEEL HAD YANKED TO THE LEFT AND I TRIED TO GAIN CONTROL OF THE WHEEL BY PULLING IT TO THE RIGHT BUT IT YANKED AGAIN TO THE LEFT CAUSING ME TO HIT INTO THE MEDIAN DUE TO THE IMPACT MY CAR TURNED OVER AND DRAGGED ACROSS THE OTHER 3 LANES AND TITLED BACK OVER. ALTHOUGH MY CAR IS TOTALED I SUSTAINED MINOR INJURY TO MY NECK AND LEFT SIDE. ALSO MY AIRBAGS DID NOT DEPLOY. *TR
NHTSA ODI #10700833
114,000 miles · Jan 23, 2015
SteeringSuspensionWheels
WHILE TRAVELING APPROXIMATELY 35 MPH, THE REAR PASSENGER SIDE SHOCK PUNCTURED THROUGH A COMPLETELY RUSTED OUT REAR WHEEL WELL ON MY 2005 FORD ESCAPE. THE CAR IS UNDRIVABLE AND THE AUTO REPAIR/BODY SHOP QUOTED ME $3,000.00 TO REPAIR THIS. I CONTACTED FORD AND THEY STATED THAT ONLY THE 2001-2004 MODELS ARE COVERED UNDER A RECALL …
Read full complaint
WHILE TRAVELING APPROXIMATELY 35 MPH, THE REAR PASSENGER SIDE SHOCK PUNCTURED THROUGH A COMPLETELY RUSTED OUT REAR WHEEL WELL ON MY 2005 FORD ESCAPE. THE CAR IS UNDRIVABLE AND THE AUTO REPAIR/BODY SHOP QUOTED ME $3,000.00 TO REPAIR THIS. I CONTACTED FORD AND THEY STATED THAT ONLY THE 2001-2004 MODELS ARE COVERED UNDER A RECALL FOR THIS EXACT SAME PROBLEM. I HAVE RESEARCHED THIS PROBLEM AND HAVE READ HUNDREDS OF PEOPLE WITH THE SAME PROBLEM. . *TR
NHTSA ODI #10678470
174,033 miles · Jan 16, 2015
SteeringSuspension
THE VEHICLE'S REAR PASSENGER WHEEL WELL RUSTED OUT COMPLETELY. THIS ALLOWED THE REAR SHOCK TO BECOME DANGEROUSLY LOOSE AND PRODUCED A LOUD BANGING NOISE. HAD THE SHOCK COME LOOSE THERE WOULD HAVE BEEN A SUBSTANTIAL LOSS OF STEERING. CAR IS NOW UNSAFE TO DRIVE. *TR
NHTSA ODI #10676157
Official recalls
4Sep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence & remedy
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Sep 3, 2014
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
Consequence & remedy
Consequence: If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
Apr 7, 2006
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITHOUT SIDE AIR CURTAINS OR MOONROOFS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT ABOVE THE PERMITTED LIMIT AT THE LEFT HAND A-PILLAR TRIM AREA.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
Remedy: DEALERS WILL MAKE MODIFICATIONS TO THE ENERGY ABSORBING MATERIAL LOCATED ABOVE THE HEADLINER IN THE AFFECTED AREA FREE OF CHARGE. THE RECALL BEGAN ON MAY 19, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Dec 20, 2004
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
Consequence & remedy
Consequence: IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP12006 · Electronic Throttle Body Malfunction
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Engine
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.
AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
Illustration