NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
40 reportsClear category filterMileage unknown · Dec 3, 2025
Service Brakes
I had just started up my 05 Ford hybrid Escape reversed out of a parking space, applied my brakes and a loud warning noise went off, the ABS light & the Brake light went on, then I tried to brake while backing out of the parking stall. I had no brakes, petal went all the way to the floor. I shifted into drive to pull forward. Th…
Read full complaint
I had just started up my 05 Ford hybrid Escape reversed out of a parking space, applied my brakes and a loud warning noise went off, the ABS light & the Brake light went on, then I tried to brake while backing out of the parking stall. I had no brakes, petal went all the way to the floor. I shifted into drive to pull forward. The car wouldn’t stop petal just went right to the floor, had very little resistance. I almost drove through the front glass doors of the P/T office across from the pharmacy in Cool, CA. The roads are mountainous windy and steep. I was definitely scared for my safety. I had to coast very slowly on the way home. I was on my way to work but instead I dropped it off at home and called ride share to take me to work! I had to use my emergency brake to make the turn up my dirt road. I still had little to no brakes to stop the car. I parked it and haven’t driven it since. Much to dangerous to drive this car. I could have easily been killed not having brakes. It Showed no codes, had no warning at all. I just bought the car about 6 months prior. The next day it was as if it never happened.
NHTSA ODI #11702633
Mileage unknown · Nov 30, 2021
Service Brakes
Brake Hydraulic Control Unit failed loss of braking.
NHTSA ODI #11442127
Mileage unknown · Sep 17, 2021
Service Brakes
Abs and master cylinder causing an unsafe braking condition hard brake pedal making it very difficult to stop the car. I replaced the entire brake system including the master cylinder assembly with pedal travel sensor attached. As recommended by Ford dealership. Then I was told that the brake system system had to be bled 2 times…
Read full complaint
Abs and master cylinder causing an unsafe braking condition hard brake pedal making it very difficult to stop the car. I replaced the entire brake system including the master cylinder assembly with pedal travel sensor attached. As recommended by Ford dealership. Then I was told that the brake system system had to be bled 2 times. Well after doing this 3 times and replacing the calipers and pads and rotors again. The same situation exists. Now I am told that this car has a different problem and a bulletin was issued by Ford stating that this is a problem with Ford Escape hybrid has to be reprogrammed to allow the master cylinder assembly to link up with the computer to rectify the issue. My car has 42000 miles on the vehicle and I is very dangerous to drive because of the unreliable braking action. Ford does not acknowledge the problem. But there are many people who have had this same issue. What can I do ? Please help me.
NHTSA ODI #11433380
140,000 miles · Oct 1, 2019
Exterior LightingService BrakesSuspension
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 35 MPH, THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD WHEN ATTEMPTING TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE REAR PASSENGER SIDE SHOCK TOWER HOUSING WAS FRACTURED AND PUNCTURED THROUGH THE SUBFRAME. DURING THE …
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 35 MPH, THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD WHEN ATTEMPTING TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE REAR PASSENGER SIDE SHOCK TOWER HOUSING WAS FRACTURED AND PUNCTURED THROUGH THE SUBFRAME. DURING THE FAILURE, THE BRAKE LINE AND REAR BRAKE LIGHT WIRE WERE SEVERED, WHICH CAUSED BRAKE FLUID TO LEAK AND THE REAR BRAKE LIGHT TO MALFUNCTION. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000. *JS
NHTSA ODI #11265404
Mileage unknown · Aug 11, 2019
Service Brakes
COMPLETE BRAKE FAILURE. DRIVEN HOME AT 40 MPH AND THE BRAKE LIGHT AND THE ABS LIGHT CAME ON AND THERE WAS A BEEP. THERE WERE THEN NO BRAKES AT ALL. LUCKILY, I WAS ABLE TO GET TO THE SIDE OF THE ROAD AND COAST TO A STOP. TURNED OFF THE TRUCK AND STARTED IT AGAIN AND IT HAD BRAKES. ON THIS LAST INCIDENT, THE SAME THING IN THE SAM…
Read full complaint
COMPLETE BRAKE FAILURE. DRIVEN HOME AT 40 MPH AND THE BRAKE LIGHT AND THE ABS LIGHT CAME ON AND THERE WAS A BEEP. THERE WERE THEN NO BRAKES AT ALL. LUCKILY, I WAS ABLE TO GET TO THE SIDE OF THE ROAD AND COAST TO A STOP. TURNED OFF THE TRUCK AND STARTED IT AGAIN AND IT HAD BRAKES. ON THIS LAST INCIDENT, THE SAME THING IN THE SAME ORDER HAPPENED. THIS PROBLEM IS VERY DANGEROUS. IT IS INTERMITTENT THUS MAKING IT HARD TO DIAGNOSE.
NHTSA ODI #11243058
127,000 miles · Mar 30, 2018
EngineService BrakesSteering
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED WHILE DRIVING AT 10 MPH, THE ENGINE STALLED AS THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE BRAKE PEDAL WAS DEPRESSED BUT FAILED TO RESPOND. THE CONTACT STATED THAT THE POWER STEERING AND BRAKING ABILITY SEIZED. THE VEHICLE WAS ABLE TO RESTART AFTER NUMEROUS ATTEMPTS…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED WHILE DRIVING AT 10 MPH, THE ENGINE STALLED AS THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE BRAKE PEDAL WAS DEPRESSED BUT FAILED TO RESPOND. THE CONTACT STATED THAT THE POWER STEERING AND BRAKING ABILITY SEIZED. THE VEHICLE WAS ABLE TO RESTART AFTER NUMEROUS ATTEMPTS. THE VEHICLE WAS TAKEN TO (BEACH FORD 2717 VIRGINIA BEACH BLVD, VIRGINIA BEACH, VA 23452 (757) 486-2717) BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 127,000.
NHTSA ODI #11082138
Mileage unknown · Feb 27, 2018
Service Brakes
HYDRAULIC CONTROL UNIT FAILED. HCU. LITTLE OR NO BRAKES, CITY STREET
NHTSA ODI #11075284
112,000 miles · Jan 28, 2018
Electrical SystemService BrakesSteering
TERRIFYING! POTENTIALLY FATAL . POWER JUST CUT OUT ON HIGHWAY WHILE GOING APPROXIMATELY 55 MPH. NO STEERING, NO BRAKES. NO POWER. ALL WARRING LIGHTS ABLAZE, BUT NO WARNING BEFOREHAND! GRATEFULLY, I WAS IN THE RIGHT LANE AND MANAGED TO GET THE CAR INTO THE MEDIAN. AFTER SEVERAL MINUTES, CAR RESTARTED. LUCKILY I WAS ONLY 1/4 MILE …
Read full complaint
TERRIFYING! POTENTIALLY FATAL . POWER JUST CUT OUT ON HIGHWAY WHILE GOING APPROXIMATELY 55 MPH. NO STEERING, NO BRAKES. NO POWER. ALL WARRING LIGHTS ABLAZE, BUT NO WARNING BEFOREHAND! GRATEFULLY, I WAS IN THE RIGHT LANE AND MANAGED TO GET THE CAR INTO THE MEDIAN. AFTER SEVERAL MINUTES, CAR RESTARTED. LUCKILY I WAS ONLY 1/4 MILE FROM THE EXIT. I READ ABOUT THIS WELL KNOWN ELECTRICAL PROBLEM. IT IS THE PCM. APPARENTLY FORD USED FAULTY SPARK PLUGS. THE FIX IS TOO COSTLY. I WILL HAVE TO PURCHASE A NEW VEHICLE. FORD RECALLED THE 2005 ESCAPE HYBRID BUT NOT THIS MODEL? CRIMINAL
NHTSA ODI #11065559
105,000 miles · Jan 27, 2018
Service BrakesStructure
BACK WHEEL RIGHT WHEELWELL AROUND SHOCK RUSTED OUT, SON DROVE HOME FROM SCHOOL SAID BACK WHEEL MAKING NOISE, UPON FURTHER INSPECTION TOOK OFF BACK PANEL RIGHT SIDE, FOUND WHEELWELL RUSTED OUTBY SHOCK AND CAN SEE DAYLIGHT WHEEL WAS MAKING NOISE WHEN HE DROVE HOME, HAD BRAKE MAN LOOK AT FOUND DEBRIS FROM PANEL IN WHEEL WHERE BRAKE…
Read full complaint
BACK WHEEL RIGHT WHEELWELL AROUND SHOCK RUSTED OUT, SON DROVE HOME FROM SCHOOL SAID BACK WHEEL MAKING NOISE, UPON FURTHER INSPECTION TOOK OFF BACK PANEL RIGHT SIDE, FOUND WHEELWELL RUSTED OUTBY SHOCK AND CAN SEE DAYLIGHT WHEEL WAS MAKING NOISE WHEN HE DROVE HOME, HAD BRAKE MAN LOOK AT FOUND DEBRIS FROM PANEL IN WHEEL WHERE BRAKES ARE. FIXED AND CLEANED, CHECKED BRAKES, PUT BACK TOGETHER. WHEELWELL RUSTED OUT . WANT FORD TO DO SOMETHING. ALSO HAD CAR 1 YR BOUGHT FROM COLUMBIANA FORD WENT BACK TOLD DEALER THEY SHOULD HAVE TOLD US ABOUT THIS ISSUE MY SON COULD HAVE BEEN HURT OR ME.
NHTSA ODI #11065456
85,000 miles · Dec 3, 2017
Service BrakesVehicle Speed Control
THROTTLE CABLE STICKS WHEN THE 2001-2004 WAS RECALLED I QUESTIONED FORD THEY SAID TOO BAD EVEN THOUGH I PURCHASED THE VEHICLE IN APRIL OF 2004 IT IS A 2005 AND THEY WOULD NOT COVER ME ON THE RECALL GAS PEDAL STICKS A LOT USING BRAKES AT SAME TIME WHEN IN PARK IT WON'T GO UNTIL YOU DO GAS AND BRAKE
NHTSA ODI #11052056
Official recalls
4Sep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence & remedy
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Sep 3, 2014
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
Consequence & remedy
Consequence: If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
Apr 7, 2006
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITHOUT SIDE AIR CURTAINS OR MOONROOFS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT ABOVE THE PERMITTED LIMIT AT THE LEFT HAND A-PILLAR TRIM AREA.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
Remedy: DEALERS WILL MAKE MODIFICATIONS TO THE ENERGY ABSORBING MATERIAL LOCATED ABOVE THE HEADLINER IN THE AFFECTED AREA FREE OF CHARGE. THE RECALL BEGAN ON MAY 19, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Dec 20, 2004
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
Consequence & remedy
Consequence: IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP12006 · Electronic Throttle Body Malfunction
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Engine
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.
AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
Illustration