NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
30 reportsClear category filter139,400 miles · May 23, 2014
Electrical SystemEngineFuel System, Gasoline
I TURNED A CORNER AND WAS ONLY GOING 20 MPH WHEN THE VEHICLE WENT DEAD. I HAD NO CONTROL SO LUCKILY I WASN'T GOING FAST. I STOPPED THE VEHICLE. I HAD TO GET IT TOWED. ONE MECHANIC SAID MY COILS AND SPARK PLUGS WERE BAD BECAUSE OF THE FUEL RAIL PRESSURE SENSOR MALFUNCTION. SECOND OPINION - THE PCM NEEDED TO BE REPROGRAMMED OR REP…
Read full complaint
I TURNED A CORNER AND WAS ONLY GOING 20 MPH WHEN THE VEHICLE WENT DEAD. I HAD NO CONTROL SO LUCKILY I WASN'T GOING FAST. I STOPPED THE VEHICLE. I HAD TO GET IT TOWED. ONE MECHANIC SAID MY COILS AND SPARK PLUGS WERE BAD BECAUSE OF THE FUEL RAIL PRESSURE SENSOR MALFUNCTION. SECOND OPINION - THE PCM NEEDED TO BE REPROGRAMMED OR REPLACED. THIRD OPINION - ALL OF THE ABOVE. IT COSTS $1900 AND TWO TOW BILLS ($275). THE ENGINE LIGHT HAD BEEN ON FOR SEVERAL MONTHS. THE ONLY CODE WAS THE FUEL RAIL PRESSURE SENSOR HIGH INPUT (P0193 GENERIC). *TR
NHTSA ODI #10593745
63,000 miles · Apr 19, 2014
Fuel System, GasolineVehicle Speed Control
TWO REGULAR ONGOING ISSUES......WHEN DRIVING, IF FOOT IS TAKEN OFF GAS PEDAL TO EASE UP SPEED, GAS PEDAL THEN STICKS AS IF SOMETHING IS BLOCKING IT (NOTHING IS BLOCKING), NO AMOUNT OF PRESSING WILL MOVE IT, AFTER SOME SECONDS OR A MINUTE, IT WILL FUNCTION AGAIN. HAPPENS MOST OFTEN WHEN COLD, OR WHEN JUST STARTING OUT. CAR CON…
Read full complaint
TWO REGULAR ONGOING ISSUES......WHEN DRIVING, IF FOOT IS TAKEN OFF GAS PEDAL TO EASE UP SPEED, GAS PEDAL THEN STICKS AS IF SOMETHING IS BLOCKING IT (NOTHING IS BLOCKING), NO AMOUNT OF PRESSING WILL MOVE IT, AFTER SOME SECONDS OR A MINUTE, IT WILL FUNCTION AGAIN. HAPPENS MOST OFTEN WHEN COLD, OR WHEN JUST STARTING OUT. CAR CONTINUES TO DECELERATE UNTIL THE GAS PEDAL BEGINS TO FUNCTION AGAIN. SECOND ISSUE.......ENGINE LIGHT WITH CODE P0455 IS ON MOST OF THE TIME, GAS CAP LOOSE LIGHT WILL ALSO COME ON , REPLACING GAS CAP DID NOT HELP. *TR
NHTSA ODI #10583684
183,000 miles · Apr 1, 2014
Electrical SystemFuel System, GasolineSteering
I WAS DRIVING MY FORD ESCAPE 2005 AND IT COMPLETELY SHUTS OFF, THE STEERING WHEEL GOT VERY HARD!!! IT WAS VERY DIFFICULT TO STEER, *TR
NHTSA ODI #10576556
64,000 miles · Mar 13, 2014
Fuel System, GasolineVehicle Speed Control
WE FIRST EXPERIENCED THE STICKING GAS PEDAL IN MAYBE 2008. WE BROUGHT IT TO HAWK FORD IN OAK LAWN, ILL AND THEY SAID THERE WAS NOTHING WRONG WITH OUR TRUCK.. THIS PROBLEM CONTINUED ON AND OFF FOR YEARS. THE LAST STRAW WAS WHEN MY HUSBAND HAD TO DRIVE APPROXIMATELY 50 MILES WITH HIS FOOT ON THE BRAKE AND THE GAS PEDAL TO GET TO O…
Read full complaint
WE FIRST EXPERIENCED THE STICKING GAS PEDAL IN MAYBE 2008. WE BROUGHT IT TO HAWK FORD IN OAK LAWN, ILL AND THEY SAID THERE WAS NOTHING WRONG WITH OUR TRUCK.. THIS PROBLEM CONTINUED ON AND OFF FOR YEARS. THE LAST STRAW WAS WHEN MY HUSBAND HAD TO DRIVE APPROXIMATELY 50 MILES WITH HIS FOOT ON THE BRAKE AND THE GAS PEDAL TO GET TO OUR HOUSE. I HAD PREVIOUSLY REPORTED THIS LIFE-THREATENING SITUATION TO YOUR DATABASE A FEW YEARS AGO. I FOLLOWED UP WITH SEVERAL LETTERS/E-MAILS TO FORD, ALL OF WHICH WERE UNSYMPATHETIC AND MET WITH VEILED SARCASM AND LACK OF INTEREST. I STILL WONDER HOW THEY SLEEP AT NIGHT KNOWING THIS TERRIBLE AND DANGEROUS DEFECT IS REAL. *TR
NHTSA ODI #10569179
100,000 miles · Jan 7, 2014
Fuel System, GasolineVehicle Speed Control
I HAVE EXPERIENCED SEVERAL CASES OVER THE YEARS WITH THE 2005 FORD ESCAPE SEEMING TO IDLE VERY-VERY LOW AND WHEN ATTEMPTING TO ACCELERATE (FOR INSTANCE FROM A STOP SIGN) THE ACCELERATION IS VERY VERY SLOW AND THEN RAMPS UP AFTER A FEW SECONDS.THIS OCCURS INTERMITTENTLY BUT REGULARLY AND DESPITE TAKING IT TO SEVERAL REPAIR SHOPS,…
Read full complaint
I HAVE EXPERIENCED SEVERAL CASES OVER THE YEARS WITH THE 2005 FORD ESCAPE SEEMING TO IDLE VERY-VERY LOW AND WHEN ATTEMPTING TO ACCELERATE (FOR INSTANCE FROM A STOP SIGN) THE ACCELERATION IS VERY VERY SLOW AND THEN RAMPS UP AFTER A FEW SECONDS.THIS OCCURS INTERMITTENTLY BUT REGULARLY AND DESPITE TAKING IT TO SEVERAL REPAIR SHOPS, NONE HAVE MANAGED TO PROVIDE A REASONABLE EXPLANATION BUT HAVE ALL RECOGNIZED IT. RECENTLY I HAVE NOTICED ISSUES, ESPECIALLY AT HIGHWAYS SPEEDS, OF THE VEHICLE "SHUDDERING" AS IF THE BRAKES ARE HAVING TROUBLE SLOWING THE VEHICLE WHICH IM CONCERNED MAY BE FROM THE THROTTLE NOT DISENGAGING PROPERLY WHEN RELEASED (ALMOST LIKE ITS STUCK OR FROZEN). WE HAVE RECENTLY IN MY REGION OF THE COUNTRY BEEN EXPERIENCING A FEW COLD SNAPS AND THAT BRINGS ME TO THE MOST RECENT ISSUE. WHEN ATTEMPTING TO USE THE VEHICLE TODAY, I NOTICED THAT THE ACCELERATOR SEEMED "STUCK" OR FROZEN. I DEPRESSED IT A FEW TIMES, NO LUCK AS IT SEEMED "FROZEN". I TOOK IT TO MEAN THAT THE COLD (IT GOT DOWN BELOW 15* F. IN GEORGIA) AND LET IT RUN FOR A BIT TO WARM. I PUSHED ACCELERATOR AND IT SEEMED UNSTUCK. I PUT IN REVERSE AND ATTEMPTED TO ACCELERATE BACKWARDS. I FOUND THE PEDAL WOULD NOT COME OFF THE FLOORBOARD. I STOPPED THE VEHICLE AND AFTER LOOKING AT THE PEDAL, I WAS ABLE TO MOVE IT FREELY AND LOOKING AT THE CONNECTION I THOUGHT IT HAD BROKEN OR BECAME DISCONNECTED. I CAME BACK FROM WORK AFTER GETTING RIDE FROM WIFE AND WENT TO INSPECT IT. THE PEDAL THIS TIME ACTED AS EXPECTED ALTHOUGH I COULD HEAR SQUEAKING AND IT THUMPED WHEN I HIT THE BRAKES. IT SEEMS THAT THE COD HAD FROZEN SOMETHING OR EXACERBATED WHATEVER WAS CAUSING ISSUES IN GENERAL. I CALLED FORD AND THEY MENTIONED SOMETHING HAD BEEN DONE IN 06 AND THEN I READ ARTICLE ABOUT 17 YEAR OLD WHO DIED AFTER HER ESCAPE THROTTLE BECAME STUCK IN A SIMILAR WAY AFTER HAVING A RECENT REPAIR. *TR
NHTSA ODI #10558962
141,565 miles · Dec 14, 2013
Fuel System, GasolineVehicle Speed Control
BACKING OUT OF GARAGE CAR DIED. TRYING TO ACCELERATE AT STOP LIGHTS TRIES TO DIE HESITATES JERKS THEFT LIGHT CONES ON. UPON TRYING TO ACCELERATE TO ENTER FREEWAY SAME THING AND WHEN TRYING TO PASS A CAR. CAME UPON S HILL AND IT ALMOST DIED N WOULD NOT GO OVER 50 MPH ALMOST CAUSING WRECKS VERY SCARY DAY. EARLIER IN WEEK DIED A C…
Read full complaint
BACKING OUT OF GARAGE CAR DIED. TRYING TO ACCELERATE AT STOP LIGHTS TRIES TO DIE HESITATES JERKS THEFT LIGHT CONES ON. UPON TRYING TO ACCELERATE TO ENTER FREEWAY SAME THING AND WHEN TRYING TO PASS A CAR. CAME UPON S HILL AND IT ALMOST DIED N WOULD NOT GO OVER 50 MPH ALMOST CAUSING WRECKS VERY SCARY DAY. EARLIER IN WEEK DIED A COUPLE TIMES WHILE IDLING BUT THIS ACCELERATING PROBLEM IS HAZARDOUS. IF IT IS THROTTLE BODY WHICH IT PROBABLY IS FROM WHAT I'M READING ON THE INTERNET. PLEASE DO A RECALL AND FIX THIS!!!!!!!! *TR
NHTSA ODI #10556089
52,000 miles · Dec 6, 2013
EngineFuel System, GasolinePower Train
FROM A STOP THIS VEHICLE HAS A PROBLEM WITH THE THROTTLE. IT IS INTERMITTENT, BUT WHEN IT OCCURS YOU UNABLE TO PRESS THE THROTTLE. IT IS JAMMED. IT SEEMS IF I PLACE THE GEAR SHIFT BACK INTO PARK THEN TO DRIVE IT WILL BE FREE AGAIN AND DRIVE NORMALLY. THIS STARTED HAPPENING ONCE IN A WHILE YEARS AGO, BUT SEEMS TO BE OCCURRING A L…
Read full complaint
FROM A STOP THIS VEHICLE HAS A PROBLEM WITH THE THROTTLE. IT IS INTERMITTENT, BUT WHEN IT OCCURS YOU UNABLE TO PRESS THE THROTTLE. IT IS JAMMED. IT SEEMS IF I PLACE THE GEAR SHIFT BACK INTO PARK THEN TO DRIVE IT WILL BE FREE AGAIN AND DRIVE NORMALLY. THIS STARTED HAPPENING ONCE IN A WHILE YEARS AGO, BUT SEEMS TO BE OCCURRING A LOT MORE FREQUENTLY NOW. *TR
NHTSA ODI #10555011
90,150 miles · Jul 19, 2013
Electrical SystemEngineFuel System, Gasoline
WITHIN 1/4 MILE OF STARTING AND DRIVING FROM HOME, THE ENGINE BEGAN TO RUN VERY ROUGH, MISFIRING, IDLING ROUGH, ETC. PULLED OVER, OPENED HOOD, ENGINE WAS IDLING VERY ROUGH. NO CHECK ENGINE LIGHT. BROUGHT IT BACK HOME. TOTAL TRIP WAS LESS THAN 1 MILE. NEXT DAY, STARTED IT UP AGAIN, RAN SMOOTHER, BUT HAD NO POWER; VERY DIFFICULT T…
Read full complaint
WITHIN 1/4 MILE OF STARTING AND DRIVING FROM HOME, THE ENGINE BEGAN TO RUN VERY ROUGH, MISFIRING, IDLING ROUGH, ETC. PULLED OVER, OPENED HOOD, ENGINE WAS IDLING VERY ROUGH. NO CHECK ENGINE LIGHT. BROUGHT IT BACK HOME. TOTAL TRIP WAS LESS THAN 1 MILE. NEXT DAY, STARTED IT UP AGAIN, RAN SMOOTHER, BUT HAD NO POWER; VERY DIFFICULT TO GET ABOVE 20-30MPH. BROUGHT IT TO REPAIR SHOP. THEY DETERMINED THAT ALL THREE CATALYTIC CONVERTERS WERE CLOGGED UP FROM BROKEN/MELTED CATALYTIC CONVERTER INTERNAL PARTS. REPLACED ALL THREE CATALYTIC CONVERTERS, BUT REPAIR SHOP COULD NOT DETERMINE THE CAUSE OF THE INITIAL MISFIRING AND CATALYTIC CONVERTER DAMAGE. CHECK ENGINE LIGHT NEVER CAME ON AT ANY TIME. TOTAL REPAIR COST $2350.00. CAR HAD BEEN IN THE SAME SHOP EARLIER THAT WEEK FOR STATE INSPECTION AND LUBE-OIL-FILTER. NO ISSUES FOUND AT THAT TIME. BATTERY HAD FAILED TWO DAYS BEFORE THE PROBLEM, AND WAS REPLACED THE MORNING OF THE PROBLEM. THE ISSUE APPEARED UPON FIRST DRIVING THE CAR AFTER THE BATTERY WAS CHANGED. *TR
NHTSA ODI #10525712
100,000 miles · Jan 30, 2012
Engine And Engine CoolingFuel System, GasolineFire
#5 SPARK PLUG BLEW OUT OF CYL HEAD CAUSING MINOR FIRE FROM FUEL IN CYLINDER WHEN INJECTOR FIRED. COULD HAVE BEEN MAJOR, HAVE HEARD MANY OTHER FORD OWNERS WITH SAME PROBLEM. *TT
NHTSA ODI #10445866
80,000 miles · Nov 9, 2011
Fuel System, GasolineVehicle Speed Control
STICKING GAS PEDAL. SEEMS TO BE MORE PREVALENT IN THE COOLER WEATHER. THE PEDAL WILL LOCK UP AND NO AMOUNT OF FORCE WILL MAKE IT DEPRESS. ESPECIALLY DANGEROUS WHEN A BIG TRUCK IS BARRELING DOWN YOU. HAVE LUBRICATED THE ASSEMBLY BUT THIS DOES NOT HELP. ONLY WAY TO FIX ( AND IT DOESN'T ALWAYS HAPPEN RIGHT AWAY ) IS TO MANIPULATE T…
Read full complaint
STICKING GAS PEDAL. SEEMS TO BE MORE PREVALENT IN THE COOLER WEATHER. THE PEDAL WILL LOCK UP AND NO AMOUNT OF FORCE WILL MAKE IT DEPRESS. ESPECIALLY DANGEROUS WHEN A BIG TRUCK IS BARRELING DOWN YOU. HAVE LUBRICATED THE ASSEMBLY BUT THIS DOES NOT HELP. ONLY WAY TO FIX ( AND IT DOESN'T ALWAYS HAPPEN RIGHT AWAY ) IS TO MANIPULATE THE PEDAL WITH MY FOOT AND TRY DIFFERENT PRESSURE POINTS. *TR
NHTSA ODI #10435052
Official recalls
4Sep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence & remedy
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Sep 3, 2014
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
Consequence & remedy
Consequence: If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
Apr 7, 2006
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITHOUT SIDE AIR CURTAINS OR MOONROOFS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT ABOVE THE PERMITTED LIMIT AT THE LEFT HAND A-PILLAR TRIM AREA.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
Remedy: DEALERS WILL MAKE MODIFICATIONS TO THE ENERGY ABSORBING MATERIAL LOCATED ABOVE THE HEADLINER IN THE AFFECTED AREA FREE OF CHARGE. THE RECALL BEGAN ON MAY 19, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Dec 20, 2004
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
Consequence & remedy
Consequence: IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP12006 · Electronic Throttle Body Malfunction
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Engine
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.
AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
Illustration