NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
90 reportsClear category filter67,064 miles · Jan 20, 2012
Engine And Engine CoolingPower Train
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE STOPPED AT A TRAFFIC STOP, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE FAILURE RECURRED SPORADICALLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS WHERE THE TECHNICIAN STATED THAT THE TORQUE CONVERTER WOULD HAVE TO BE REPLACED. THE VE…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE STOPPED AT A TRAFFIC STOP, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE FAILURE RECURRED SPORADICALLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS WHERE THE TECHNICIAN STATED THAT THE TORQUE CONVERTER WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 67,064. UPDATED 02/15/12*BF UPDATED 03/16/12
NHTSA ODI #10444660
110,000 miles · Jan 14, 2012
Electrical SystemEngine And Engine CoolingVehicle Speed Control
THE FIRST ISSUE I HAD WITH MY CAR WAS IN DECEMBER OF 2010. I IMMEDIATELY TOOK MY CAR TO A REPAIR PLACE AND THEY TOLD ME THAT THE COILS AND THE PLUGS WERE OUT AND THAT THEY NEEDED TO BE REPLACED. I ASSUMED THAT THIS WAS JUST TIME TO GET THIS REPAIRED BECAUSE MY CAR WAS RIGHT OVER THE 100,000 MILE MARK. EVERYTHING SEEMED FINE UNTI…
Read full complaint
THE FIRST ISSUE I HAD WITH MY CAR WAS IN DECEMBER OF 2010. I IMMEDIATELY TOOK MY CAR TO A REPAIR PLACE AND THEY TOLD ME THAT THE COILS AND THE PLUGS WERE OUT AND THAT THEY NEEDED TO BE REPLACED. I ASSUMED THAT THIS WAS JUST TIME TO GET THIS REPAIRED BECAUSE MY CAR WAS RIGHT OVER THE 100,000 MILE MARK. EVERYTHING SEEMED FINE UNTIL MAY OF 2011 WHEN THE PROBLEM RETURNED. THIS TIME I TOOK MY CAR TO A FORD SERVICE CENTER. THIS TIME I NOTICED THAT MY CAR WOULD RUN OK UP TO ABOUT 35 MPH AND THEN AFTER THAT SPEED IT WOULD START JERKING. IF I TAKE MY FOOT OFF THE GAS IT STOPS, BUT IF I LEAVE MY FOOT ON THE GAS AND CONTINUE TO ACCELERATE, THE CAR SHUTS OFF COMPLETELY. I HAVEN'T TAKEN MY CAR ANYWHERE THAT I HAVE TO DRIVE OVER 45MPH BUT RECENTLY I NOTICED THAT IF I TRY TO ACCELERATE PAST 35, THAT INSTEAD OF JERKING TO TURN MY CAR OFF, THE HARDER I PUSH THE GAS, IT FEELS LIKE I AM PUSHING THE BRAKE WITH THAT SAME INTENSITY WHEN I HAVEN'T EVEN TOUCHED THE BRAKE. IM AFRAID THAT WHILE PUSHING THE GAS, THE CAR IS GOING TO BRAKE AND THAT SOMEONE ELSE IS GOING TO SLAM INTO THE BACK OF MY CAR AND HURT MY 2 YR OLD SON IN HIS CARSEAT IN THE BACK. I AVOID DRIVING THIS CAR UNLESS I ABSOLUTELY HAVE TO BECAUSE IT IS DANGEROUS. IT SEEMS THAT MANY OTHER OWNERS OF THE SAME CAR I HAVE ARE HAVING THE SAME OR A SIMILAR ISSUE. THIS REALLY NEEDS TO BE CHECKED INTO BECAUSE FORD IS AWARE THAT THIS IS A COMMON ISSUE BUT WILL DO NOTHING ABOUT IT. IT SEEMS LIKE THEY ARE WAITING FOR SOMEONE TO GET HURT BEFORE THE ASSUME RESPONSIBILITY. *TR
NHTSA ODI #10443788
58,000 miles · Jan 9, 2012
Electrical SystemEngine And Engine Cooling
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT IN AN ATTEMPT TO START THE VEHICLE, THE VEHICLE WOULD BEGIN TO SMOKE AND STALL WITHOUT WARNING. THE DEALER DIAGNOSED THAT THERE WAS A SHORT IN THE SPARK PLUGS, CAUSING THE VEHICLE TO STALL. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE …
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT IN AN ATTEMPT TO START THE VEHICLE, THE VEHICLE WOULD BEGIN TO SMOKE AND STALL WITHOUT WARNING. THE DEALER DIAGNOSED THAT THERE WAS A SHORT IN THE SPARK PLUGS, CAUSING THE VEHICLE TO STALL. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 58,000 AND THE CURRENT MILEAGE WAS 68,200. UPDATED 02/09/12*LJ THE VEHICLE WAS REAIRED. UPDATED 02/13/12
NHTSA ODI #10443171
71,000 miles · Jan 9, 2012
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE BEGAN TO SHAKE VIGOROUSLY AND STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THE CONTACT THAT COIL PACK NUMBER ONE NEEDED TO BE REP…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE BEGAN TO SHAKE VIGOROUSLY AND STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THE CONTACT THAT COIL PACK NUMBER ONE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 71,000.
NHTSA ODI #10443136
112,670 miles · Dec 7, 2011
Electrical SystemEngine And Engine Cooling
IN MY 2005 FORD ESCAPE XLT V6 3.0L ON 11/16/11, I WAS DRIVING EAST BOUND ON I55 TOWARDS CHICAGO AT APPROXIMATELY 55 MPH WHEN THE ENGINE STARTED BAD MISFIRING AND THE COMPLETELY DIED (NO POWER OR ENGINE). WITH NO POWER STEERING AND NO BRAKES, I ATTEMPTED TO STEERED TOWARD THE SHOULDER. I WAITED ABOUT 10 MINUTES AND TRIED TO RESTA…
Read full complaint
IN MY 2005 FORD ESCAPE XLT V6 3.0L ON 11/16/11, I WAS DRIVING EAST BOUND ON I55 TOWARDS CHICAGO AT APPROXIMATELY 55 MPH WHEN THE ENGINE STARTED BAD MISFIRING AND THE COMPLETELY DIED (NO POWER OR ENGINE). WITH NO POWER STEERING AND NO BRAKES, I ATTEMPTED TO STEERED TOWARD THE SHOULDER. I WAITED ABOUT 10 MINUTES AND TRIED TO RESTART AND WAS UNABLE. I HAD THE VEHICLE TOWED TO ROESCH FORD 333 W GRAND AVE BENSENVILLE, IL 60106. I WAS ADVISED BY THE SERVICE MANAGER THAT THE ENGINE WAS MISFIRING ON 4 OF THE 6 CYLINDERS AND THAT THEY WOULD NEED TO REPLACE THE PCM, 6 COILS, 6 PLUGS AND CALIBRATE, TOTAL $2,114.21. I DECIDED TO DO SOME RESEARCH ONLINE AND FOUND NUMEROUS PEOPLE EXPERIENCING THE SAME PROBLEM. THERE ARE MULTIPLE TSB: TSB 05-11-1,TSB 09-02-06 TSB 09-02-06 AND TSB 10-18-10. THE PROBLEM IS: THE WRONG SPARK PLUGS WERE INSTALLED AT THE FACTORY. THIS COMBO OF WRONG PLUGS CAUSES THE COILS TO SEND EMI/RFI BACK TO THE PCM (POWERTRAIN CONTROL MODULE) BURNING OUT THE PCM.EMI/RFI IS EMITTED FROM SPARKING DEVICE,IN THIS CASE A SET OF BAD SPARK PLUGS. THIS CAUSES THE VEHICLE TO MISS-FIRE, LOSE POWER, OR IN MANY CASES, HAVE TOTAL ENGINE FAILURE. WRONG SPARK PLUGS/BAD COP'S/UN-SHIELDED PCM BOX/POORLY ENGINEERED & UN-TESTED, MULTI-CHANGED, RARE PCM AND IT'S THE $12.50 RADIO FREQUENCY INTERFERENCE DEVICE. MULTIPLE ONLINE COMPLAINTS/PROBLEMS: HTTP://WWW.CARCOMPLAINTS.COM/FORD/ESCAPE/2005/ELECTRICAL/POWERTRAIN_CONTROL_MODULE_PCM_FAILURE.SHTML HTTP://WWW.FORDFORUMSONLINE.COM/FORUM/FORD-ESCAPE/643-2005-FORD-ESCAPE-PCM-ECM-COMPUTER-FAILURE.HTML HTTP://WWW.YELLOWBULLET.COM/FORUM/SHOWTHREAD.PHP?T=199403 REPAIRED. THEN CHECK ENGINE LIGHT. NOW IT NEEDS 2 CATALYTIC CONVERTERS $2,500 BECAUSE OF PCM/COIL. TOTAL $4,500 NUMEROUS COMPLAINTS EXTREME SAFETY ISSUE! [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10438938
55,000 miles · Dec 5, 2011
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT THE VEHICLE STALLED WHILE DRIVING 60 MPH. THE CONTACT ALSO STATED THAT THE FAILURE OCCURRED A TOTAL OF AT LEAST FOUR TIMES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE COMPUTER SYSTEM WAS REPLACED. THE FAILURE CONTINUED. THE MANUFACTURER WAS MADE AWARE OF…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT THE VEHICLE STALLED WHILE DRIVING 60 MPH. THE CONTACT ALSO STATED THAT THE FAILURE OCCURRED A TOTAL OF AT LEAST FOUR TIMES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE COMPUTER SYSTEM WAS REPLACED. THE FAILURE CONTINUED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 55,000.
NHTSA ODI #10438579
91,855 miles · Nov 12, 2011
Engine And Engine CoolingPower Train
THIS 2005 ESCAPE FAILED WHEN DRIVING THROUGH THE MOUNTAINS IN NORTHERN CALIFORNIA. FORD HAS DOCUMENTED THAT SPARK PLUGS INSTALLED BY FORD AT THE FACTORY CAN CAUSE ALL COILS AND THE PCM TO FAIL AS THEY DID IN THIS CASE. THREE TSB'S HAVE BEEN GENERATED RELATED TO THIS PROBLEM. MY CAR WAS REPAIRED UNDER WARRANTY AT APPROXIMATELY …
Read full complaint
THIS 2005 ESCAPE FAILED WHEN DRIVING THROUGH THE MOUNTAINS IN NORTHERN CALIFORNIA. FORD HAS DOCUMENTED THAT SPARK PLUGS INSTALLED BY FORD AT THE FACTORY CAN CAUSE ALL COILS AND THE PCM TO FAIL AS THEY DID IN THIS CASE. THREE TSB'S HAVE BEEN GENERATED RELATED TO THIS PROBLEM. MY CAR WAS REPAIRED UNDER WARRANTY AT APPROXIMATELY 60000 MILES AND THE PLUGS WERE NOT CHECKED AND REPLACED AS REQUIRED IN THE FORD TSB'S. THIS WAS AN EXPENSIVE $2300 + REPAIR THAT FORD SHOULD TAKE RESPONSIBILITY FOR. GOOD FAITH WAS NOT DEMONSTRATED IN SOLVING THIS PROBLEM AND FORD REFUSES TO ACKNOWLEDGE THEIR RESPONSIBILITY. *TR
NHTSA ODI #10435367
Mileage unknown · Nov 1, 2011
Engine And Engine Cooling
2005 FORD ESCAPE. CONSUMER STATES PROBLEMS WITH VEHICLE STALLING WHILE DRIVING. *TGW
NHTSA ODI #10433381
84,503 miles · Oct 30, 2011
Engine And Engine CoolingPower Train
DRIVING ALONG INTERSTATE ENGINE SUDDENLY LOST POWER, WOULD NOT GO ABOVE 20MPH, NO CHECK ENGINE LIGHT. TOOK TO REPAIR SHOP AND FIRST CATALYTIC CONVERTER COMPLETELY CLOGGED, NUMBER 2 CONVERTER PARTIALLY CLOGGED. VEHICLE ONLY HAS 84,000 MILES. WARRANTY EXPIRED AT 80,000 MILES FOR EXHAUST. REPAIR SHOP THIS HAPPENS A LOT FOR…
Read full complaint
DRIVING ALONG INTERSTATE ENGINE SUDDENLY LOST POWER, WOULD NOT GO ABOVE 20MPH, NO CHECK ENGINE LIGHT. TOOK TO REPAIR SHOP AND FIRST CATALYTIC CONVERTER COMPLETELY CLOGGED, NUMBER 2 CONVERTER PARTIALLY CLOGGED. VEHICLE ONLY HAS 84,000 MILES. WARRANTY EXPIRED AT 80,000 MILES FOR EXHAUST. REPAIR SHOP THIS HAPPENS A LOT FOR THESE VEHICLES. *TR
NHTSA ODI #10433588
111,000 miles · Sep 6, 2011
Engine And Engine Cooling
CATALYTIC CONVERTERS AND FLEX PIPE THE CATALYTIC CONVERTERS HAVE BEEN DIAGNOSED AS HAVING SIGNIFICANT RESTRICTION TO CAUSE DRAMATIC POWER LOSS TO THE VEHICLE WHILE DRIVING. THIS CONDITION CAUSES ABNORMAL BACK PRESSURES IN THE EXHAUST SYSTEM WHICH ALSO CAUSES MULTIPLE MISFIRES AND SETS THE CHECK ENGINE LIGHT. THE FLEX PIPE IS A…
Read full complaint
CATALYTIC CONVERTERS AND FLEX PIPE THE CATALYTIC CONVERTERS HAVE BEEN DIAGNOSED AS HAVING SIGNIFICANT RESTRICTION TO CAUSE DRAMATIC POWER LOSS TO THE VEHICLE WHILE DRIVING. THIS CONDITION CAUSES ABNORMAL BACK PRESSURES IN THE EXHAUST SYSTEM WHICH ALSO CAUSES MULTIPLE MISFIRES AND SETS THE CHECK ENGINE LIGHT. THE FLEX PIPE IS ALSO DEFECTIVE AND LEAKS. I HAVE OWNED MANY FORD VEHICLES THROUGH THE YEARS. ONE WAS A 1994 LINCOLN TOWN CAR WITH OVER 400,000 MILES. ANOTHER WAS A 1998 TOWN CAR WITH OVER 200,000 MILES. NEVER ONCE DID I HAVE TO REPLACE ANYTHING ON THE EXHAUST SYSTEM,ESPECIALLY CATALYTIC CONVERTERS (THE MOST EXPENSIVE PART IN THE SYSTEM). THIS IS UNACCEPTABLE AND A RECALL NEEDS TO BE INITIATED TO RESOLVE THIS. NOT ONLY IS THIS A SAFETY AND MORAL ISSUE BUT AN ENVIRONMENTAL ON AS WELL. *TR
NHTSA ODI #10424009
Official recalls
4Sep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence & remedy
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Sep 3, 2014
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
Consequence & remedy
Consequence: If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
Apr 7, 2006
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITHOUT SIDE AIR CURTAINS OR MOONROOFS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT ABOVE THE PERMITTED LIMIT AT THE LEFT HAND A-PILLAR TRIM AREA.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
Remedy: DEALERS WILL MAKE MODIFICATIONS TO THE ENERGY ABSORBING MATERIAL LOCATED ABOVE THE HEADLINER IN THE AFFECTED AREA FREE OF CHARGE. THE RECALL BEGAN ON MAY 19, 2006. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Dec 20, 2004
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
Consequence & remedy
Consequence: IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
Remedy: DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP12006 · Electronic Throttle Body Malfunction
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Engine
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.
AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
Illustration