2019 Ford Ecosport

My 2019 Ford EcoSport suffered sudden low oil pressure and catastrophic engine failure 10 months after receiving service under Safety Recall 23S64. NHTSA Campaign 23V905. The Authorized dealership is refusing to inspect the vehicle or honor Ford's engine replacement remedy, claiming the recall is closed and too much time has passed. This leaves me with an un-remedied safety hazard.

The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling). The local dealer was contacted, but the vehicle was not diagnosed or repaired. The contact called another dealer, Shottenkirk Ford Jasper (868 GA-515, Jasper, GA 30143); and the contact was informed that the vehicle had to experience the failure before the recall repair would be performed. The manufacturer was contacted by email, but was unable to assist with having the vehicle serviced. The contact had not experienced a failure.

The contact owns a 2019 Ford EcoSport. The contact stated that while stopped at a red light, the vehicle stalled and failed to restart. The vehicle was towed to a dealer where it was diagnosed and determined that the starter needed to be replaced. The vehicle was repaired. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that the catalytic converter, a cracked flex pipe, exhaust clamps, turbo connection, and a vacuum pump assembly needed to be replaced. The vehicle was repaired. The contact was then informed of an unknown recall. The contact stated that on another occasion while driving, the check engine warning light illuminated, and the following day while driving the vehicle, the check engine warning light was flashing, and the low oil pressure message was displayed. The vehicle was towed to a dealer where it was determined that the engine long block and the turbo needed to be replaced, and coolant needed to be added to the coolant reservoir. The vehicle was taken to the dealer to be repaired under NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling). The vehicle was repaired, but after a while, the A/C became inoperable. The vehicle was taken to an independent mechanic, and it was determined that the A/C was unplugged, the wires were stuck in the clutch pulley, the amp micro fuse, the wiring, and amp fuse needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 37,028.

A young teenage driver faced a terrifying highway emergency when her vehicle suffered an abrupt, dangerous loss of motive power at 70+ MPH on the interstate due to sudden turbocharger failure. Moving at high speeds in heavy traffic, the sudden drop in acceleration left the driver vulnerable to rear-end collisions from oncoming semi-trucks. The vehicle was driven into the shop with a failed turbocharger and a completely contaminated oil ecosystem. The engine block has not seized yet, but all components are highly contaminated. The affected components are preserved and available for federal inspection. The root cause is a completely choked oil pump pick up tube screen. After a week-long standoff where the consumer had to escalate the case to Ford Corporate to force the dealership to drop the oil pan, teardown photos revealed the intake mesh was blanketed and impacted by a thick, suffocating mat of degraded wet belt fibers. This debris choked off oil pressure, proving the dealer fraudulently certified Safety Recall 23S64 as complete while leaving the lethal hazard trapped inside. In addition to this extreme debris, internal Ford OASIS logs admit the technician snapped a tensioner bolt during the recall. They drilled it out but failed to clean the engine, trapping sharp metallic shards that circulated into the oil system, destroying the turbocharger seals and scorching the gaskets. The dealer was given urgent warnings on April 7, 2026, when the driver reported interstate stalling ("limp mode at 70+ mph") and an AutoZone turbo pressure code. The dealer treated this severe safety risk as a low-priority task, failed to check the oil pressure, and released the car. After the forced pan drop in July, Ford Corporate denied coverage for a new long block and turbocharger, instructing the consumer to pay over $8,000 out of pocket for repairs caused entirely by their own botched recall.

For a month, every time I put gas in my car whether I filled up or just put half a tank my car will not start for 10-15 minutes. I took it to the ford place and my extended warranty wouldn't cover it. It seems like an evap valve would be covered. I have only had my car 11 months. This is going to cost over $1,000 to fix. It seems like ford should be responsible for the repairs.

No issues with vehicle until failure, properly maintained, regular oil changes. While driving the vehicle the engine lost power and check engine light came on. The vehicle RPM's increased but had no power. Was able to drive the vehicle home but was at inconstant speeds / RPMS could not get above 40 MPH. Low oil light came on while driving home as well. Made appointment at Ford local dealership, they verbally told me the engine blew and there was no oil in vehicle and metal in oil pan. The vehicle never missed a oil change. As a result I had to replace the engine with a used one the dealership had. Total engine failure at 98956 miles. This appears to be a recall on the 1.0 engine for same issue. My wife and kids were in car when it failed, in traffic.

The contact owns a 2019 Ford EcoSport. The contact stated that while driving approximately 60 MPH, the vehicle decelerated, and the RPM was lowered. After parking and restarting the vehicle, the vehicle failed to accelerate above 20 MPH with the wrench icon displayed. The vehicle was slowly driven to the residence. The cause of the failure was not determined. The local dealer was notified of the failure. The manufacturer was not yet contacted. The contact stated that the vehicle was previously serviced under NHTSA Campaign Number: 23V905000 (ENGINE AND ENGINE COOLING). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 44,212.

I brought my Ford EcoSport into the Baxter. Ford, in Papillion, Nebraska, because it was malfunctioning, the oil pressure got real low and my car was not accelerating like it should Also I advise them that there is an open recall on the vehicle. As well and I that the recall and the engine malfunction are related. They told me that it wasn't, and I'm sure it was. Then, they advised me that after speaking with Ford. Ford agreed to pay $3000 for a new engine, while I was responsible for the remaining $4000, I asked if I can have an email showing the communication with Ford, I was advised that they don't have access to that. They're unable to forward me an email, which is a red flag i would like to get a second opinion on the diagnosis of my engine in the fort. Ecosport. I don't understand why they would not be able to forward me an email of the communication between them and Ford. When asked the service manager about that, he advised that he does not have access to it. Which is a red flag? Is there anything you guys can do?Please let me know.Thank you have a good day