IllustrationSee attached document for complaint.
2021 Ford E-450
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all E-450 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 8 of 27 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
Steering complaints
11 reportsThe contact owns a 2021 Ford E-450. The contact stated while parking the vehicle, the steering wheel and brake pedal became stiff, and the vehicle failed to slow down as intended. The contact stated that the brake pedal was continuously depressed for the vehicle to come to a stop. The vehicle was towed to an independent mechanic…
Read full complaint
The contact owns a 2021 Ford E-450. The contact stated while parking the vehicle, the steering wheel and brake pedal became stiff, and the vehicle failed to slow down as intended. The contact stated that the brake pedal was continuously depressed for the vehicle to come to a stop. The vehicle was towed to an independent mechanic where it was diagnosed that the power steering hose and fluids needed to be flushed and refilled. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 14,104.
My RV is make from 2021 Ford E-450. The power steering fluid leaked out and hard to steer the RV, and lost break. Ford has a recall 2021E-450 under similar situation, but my Vin did not received any recall notice.
We received the two recall notice letters from Ford Motor Company, 20V795 & 22V089, for our 2021 Jayco Redhawk class C RV. Upon receiving the first recall notice, 20V795, an appointment was made with our local Ford Dealer, Spradley Ford Lincoln Mercury, in Pueblo, CO, on Oct 1, 2021 to have it inspected and recall taken care of.…
Read full complaint
We received the two recall notice letters from Ford Motor Company, 20V795 & 22V089, for our 2021 Jayco Redhawk class C RV. Upon receiving the first recall notice, 20V795, an appointment was made with our local Ford Dealer, Spradley Ford Lincoln Mercury, in Pueblo, CO, on Oct 1, 2021 to have it inspected and recall taken care of. Upon arrival that morning, was told they did not have the parts, would have to order them & their technician just called in "sick". Appointment was rescheduled once they had the recall parts in for Nov 15, 2021, again at our local Ford Dealer, Spradley Ford Lincoln Mercury, in Pueblo, CO. Upon arrival that morning to drop the unit off for the recall repair, was turned away again & told I'd have to reschedule as they had a break-in overnight & their technicians' had some tools stolen & would not be working today & they would have the service manager call me to reschedule the appointment once again, which never happened. In March of 2022, we received the second recall notice, 22V089, advising to take it to the local Ford dealer for inspection & repair. I called the Ford Dealer, now Alpine Ford, in Pueblo, CO, several times having to leave a message without a return call. On April 6, 2022, I spoke with [XXX] in Service at Alpine Ford & was informed Alpine Ford would not do the recalls as the new owners refused to do them after purchasing the dealership & referred me to Camping World. I had an appointment at Camping World in Colorado Springs this same day & they contacted Ford Dealers in Pueblo, Colorado Springs, Canon City, & all refused to handle the recalls. I called Ford Corporate & expressed my displeasure with dealers failing to comply with recall notices causing safety concerns for use of the unit & was told the were not "refusing" to do the recalls just did not have any technicians or locations except maybe O'Mera Ford in Northglenn, CO, who might handle it, which is unacceptable as they are 2 hours & 100 miles away. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FO
The contact owns a 2021 Ford E-450. The contact received notification of NHTSA Campaign Number: 22V089000 (Steering, Service Brakes, Hydraulic). The contact stated that the vehicle was taken to the dealer where the vehicle was inspected however, while making a turn into a service station, the steering wheel became difficult to m…
Read full complaint
The contact owns a 2021 Ford E-450. The contact received notification of NHTSA Campaign Number: 22V089000 (Steering, Service Brakes, Hydraulic). The contact stated that the vehicle was taken to the dealer where the vehicle was inspected however, while making a turn into a service station, the steering wheel became difficult to maneuver. No warning lights were illuminated. The contact then stated that she was directed to a leak coming from the vehicle. The contact notified the dealer, and the vehicle was towed to an independent mechanic where it was diagnosed that the hydro-boost power failed and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure and covered the cost of the tow, but no further assistance was provided. The failure mileage was 4,826.
2021 FORD E-450. CONSUMER WRITES IN REGARD TO SAFETY RECALL NOTICE 22S08. THE CONSUMER REQUESTED ASSISTANCE LOCATING A DEALER WITHIN A REASONABLE DISTANCE TO PERFORM THE RECALL REPAIR.
The contact owns a 2021 Ford E-450. The contact received notification of NHTSA Campaign Numbers: 20V795000 (Engine) and 22V089000 (Steering, Service Brakes, Hydraulics) however, the parts to do the recall repairs were not yet available. The dealer was made aware of the issue. The contact stated that the manufacturer had exceeded…
Read full complaint
The contact owns a 2021 Ford E-450. The contact received notification of NHTSA Campaign Numbers: 20V795000 (Engine) and 22V089000 (Steering, Service Brakes, Hydraulics) however, the parts to do the recall repairs were not yet available. The dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. VIN tool confirms parts not available and Parts distribution disconnect respectively.
Regarding the recall #22S08 Hydroboost or Hydromax power steering pressure line. We took our Motorhome in to have the recall addressed and for service before a planned camping trip. Apparantly the recall was worded "to inspect OR replace" and our vehicle was only inspected. On our ruined Mother's Day vacation, we were driving hi…
Read full complaint
Regarding the recall #22S08 Hydroboost or Hydromax power steering pressure line. We took our Motorhome in to have the recall addressed and for service before a planned camping trip. Apparantly the recall was worded "to inspect OR replace" and our vehicle was only inspected. On our ruined Mother's Day vacation, we were driving highway speeds at a downgrade coming into Nevada and lost all power steering which took our motorhome and trailer we were pulling off of the highway and dangerously close to falling off the highway and tumbling down a hill. We went to exit at the next offramp to look at the power steering issue and found that we also had no brakes. By downshifting, we were able to stop safely. There were no warning lights or signals, and no warning signs what so ever. The motorhome is currently being looked at and hopefully repaired at a Rush Truck Center in Las Vegas. Ford Motor Company and the original dealership have been notified. Our main concern is the word "OR" in the recall verbiage, which we blame Ford Motor Co. The problem is clearly this part must be replaced, not just inspected. A change in the verbiage literally will save lives. We really should have been dead on the side of the road, but we were lucky and are contemplating hiring a lawyer, as we feel that the unacceptable recall wording by Ford unneccessarily put our lives at risk. Our Ford Claim number is: CAS-36721973-S8H5X3
The contact owns a 2021 Ford E-450. The contact received notification of NHTSA Campaign Number: 22V089000 (Steering, Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer…
Read full complaint
The contact owns a 2021 Ford E-450. The contact received notification of NHTSA Campaign Number: 22V089000 (Steering, Service Brakes, Hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
The contact owns a 2021 Ford E-450. The contact received notification of NHTSA Campaign Number: 22V089000 (Steering, Service Brakes, Hydraulic). The contact stated that while driving at an undisclosed speed, several unknown warning lights illuminated. The vehicle then experienced a loss of power steering assist. The dealer was m…
Read full complaint
The contact owns a 2021 Ford E-450. The contact received notification of NHTSA Campaign Number: 22V089000 (Steering, Service Brakes, Hydraulic). The contact stated that while driving at an undisclosed speed, several unknown warning lights illuminated. The vehicle then experienced a loss of power steering assist. The dealer was made aware of the failure but informed the contact that they were not equipped to perform recall repairs on RVs. The manufacturer was made aware of the failure and informed the contact that the nearest dealer able to perform the recall repair was more than 100 miles away. The vehicle was not repaired. The failure mileage was approximately 3,000.
Official recalls
625V793000 · Engine
Nov 17, 2025
Ford Motor Company (Ford) is recalling certain 2021 E-350 and E-450 vehicles that received an incomplete software update under recall 20V795. The engine cover may become excessively hot.
Consequence & remedy
Consequence: Direct contact with certain areas of engine cover surface in the passenger compartment may increase the risk of injury or burns to the skin of the driver or front seat passenger.
Remedy: Dealers will update the powertrain calibration for heat management under elevated idle conditions, free of charge. Owner notification letters were mailed January 7, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SC7. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning December 22, 2025.
24V097000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings; Steering:hydraulic Power Assist:hose, Piping, And Connections
Feb 9, 2024
Ford Motor Company (Ford) is recalling certain 2021-2022 E-350 and E-450 vehicles equipped with dual rear wheels. An inadequate connection between the power steering pressure line and the brake hydroboost unit may result in a sudden loss of power steering fluid.
Consequence & remedy
Consequence: A sudden loss of power steering fluid can result in a loss of power steering and power brake assist, increasing the risk of a crash.
Remedy: Dealers will replace the power steering pressure line and the hydroboost jumper line, free of charge. Vehicles in this recall were previously recalled under 22V-089 and owners will need to have the new remedy completed even if their vehicle was remedied under the prior recall. Owner notification letters were mailed on June 21, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S07.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Ford Motor Company (Ford) is recalling certain 2021-2022 E-350 and E-450 vehicles equipped with dual rear wheels. An inadequate connection between the power steering pressure line and the brake hydroboost unit may result in a sudden loss of power steering fluid.
Consequence: A sudden loss of power steering fluid can result in a loss of power steering and power brake assist, increasing the risk of a crash.
Remedy: Dealers will replace the power steering pressure line and the hydroboost jumper line, free of charge. Vehicles in this recall were previously recalled under 22V-089 and owners will need to have the new remedy completed even if their vehicle was remedied under the prior recall. Owner notification letters were mailed on June 21, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S07.
Steering:hydraulic Power Assist:hose, Piping, And Connections
Ford Motor Company (Ford) is recalling certain 2021-2022 E-350 and E-450 vehicles equipped with dual rear wheels. An inadequate connection between the power steering pressure line and the brake hydroboost unit may result in a sudden loss of power steering fluid.
Consequence: A sudden loss of power steering fluid can result in a loss of power steering and power brake assist, increasing the risk of a crash.
Remedy: Dealers will replace the power steering pressure line and the hydroboost jumper line, free of charge. Vehicles in this recall were previously recalled under 22V-089 and owners will need to have the new remedy completed even if their vehicle was remedied under the prior recall. Owner notification letters were mailed on June 21, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S07.
22V089000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings; Steering:hydraulic Power Assist:hose, Piping, And Connections
Feb 16, 2022
Ford Motor Company (Ford) is recalling certain 2021-2022 E-350 and E-450 vehicles equipped with dual rear wheels. An inadequate connection between the power steering pressure line and the brake Hydroboost unit may result in a sudden loss of power steering fluid.
Consequence & remedy
Consequence: A sudden loss of power steering fluid can result in a loss of power steering and power brake assist, increasing the risk of a crash.
Remedy: Dealers will inspect the connection between the power steering lines and the Hydroboost unit, and replace the power steering lines, as necessary, free of charge. Owner notification letters were mailed on March 18, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S08.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Ford Motor Company (Ford) is recalling certain 2021-2022 E-350 and E-450 vehicles equipped with dual rear wheels. An inadequate connection between the power steering pressure line and the brake Hydroboost unit may result in a sudden loss of power steering fluid.
Consequence: A sudden loss of power steering fluid can result in a loss of power steering and power brake assist, increasing the risk of a crash.
Remedy: Dealers will inspect the connection between the power steering lines and the Hydroboost unit, and replace the power steering lines, as necessary, free of charge. Owner notification letters were mailed on March 18, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S08.
Steering:hydraulic Power Assist:hose, Piping, And Connections
Ford Motor Company (Ford) is recalling certain 2021-2022 E-350 and E-450 vehicles equipped with dual rear wheels. An inadequate connection between the power steering pressure line and the brake Hydroboost unit may result in a sudden loss of power steering fluid.
Consequence: A sudden loss of power steering fluid can result in a loss of power steering and power brake assist, increasing the risk of a crash.
Remedy: Dealers will inspect the connection between the power steering lines and the Hydroboost unit, and replace the power steering lines, as necessary, free of charge. Owner notification letters were mailed on March 18, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S08.
20V795000 · Engine
Dec 17, 2020
Ford Motor Company (Ford) is recalling certain 2021 E-350 and E-450 vehicles. The underside of the engine cover may have mispositioned insulation, allowing the cover to get excessively hot.
Consequence & remedy
Consequence: Direct and continuous contact with certain areas of engine cover surface in the passenger compartment may increase the risk of injury or burns to the skin of the driver or front seat passenger.
Remedy: Ford will notify owners, and dealers will inspect the engine cover for gaps between the rubber seal and the insulation. If gaps are present, the dealer will install engine cover insulation patches in the right hand and left hand inner lower corners of the engine cover. The dealer will also update the powertrain calibration for heat management under elevated idle conditions should a vehicle be equipped with SEIC or BCP, free of charge. The recall began February 15, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S73.
20V175000 · Electrical System:wiring; Electronic Stability Control (esc); Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Mar 23, 2020
Ford Motor Company (Ford) is recalling certain 2021 E-350 and E-450 vehicles. A wire harness in the rear of the vehicle may contact the vehicle frame, resulting in damage to the circuits that support the fuel pump and the anti-lock braking system (ABS).
Consequence & remedy
Consequence: Damage to the fuel pump circuit in the wiring harness could result in an unexpected engine stall. Damage to the ABS wiring can lead to reduction of ABS functionality and a loss of roll stability control (RSC) functionality. These scenarios increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the wire harness for damage. If no damage is found, dealers will apply anti-abrasion tape over the area and ensure clearance to surrounding components. If damage is found, dealers will splice in new wire and apply anti-abrasion tape over the area and ensure clearance to surrounding components. All services will be performed free of charge. The recall began May 18, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S13.
Additional source detail variants (3)
Electronic Stability Control (esc)
Ford Motor Company (Ford) is recalling certain 2021 E-350 and E-450 vehicles. A wire harness in the rear of the vehicle may contact the vehicle frame, resulting in damage to the circuits that support the fuel pump and the anti-lock braking system (ABS).
Consequence: Damage to the fuel pump circuit in the wiring harness could result in an unexpected engine stall. Damage to the ABS wiring can lead to reduction of ABS functionality and a loss of roll stability control (RSC) functionality. These scenarios increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the wire harness for damage. If no damage is found, dealers will apply anti-abrasion tape over the area and ensure clearance to surrounding components. If damage is found, dealers will splice in new wire and apply anti-abrasion tape over the area and ensure clearance to surrounding components. All services will be performed free of charge. The recall began May 18, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S13.
Electrical System:wiring
Ford Motor Company (Ford) is recalling certain 2021 E-350 and E-450 vehicles. A wire harness in the rear of the vehicle may contact the vehicle frame, resulting in damage to the circuits that support the fuel pump and the anti-lock braking system (ABS).
Consequence: Damage to the fuel pump circuit in the wiring harness could result in an unexpected engine stall. Damage to the ABS wiring can lead to reduction of ABS functionality and a loss of roll stability control (RSC) functionality. These scenarios increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the wire harness for damage. If no damage is found, dealers will apply anti-abrasion tape over the area and ensure clearance to surrounding components. If damage is found, dealers will splice in new wire and apply anti-abrasion tape over the area and ensure clearance to surrounding components. All services will be performed free of charge. The recall began May 18, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S13.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Ford Motor Company (Ford) is recalling certain 2021 E-350 and E-450 vehicles. A wire harness in the rear of the vehicle may contact the vehicle frame, resulting in damage to the circuits that support the fuel pump and the anti-lock braking system (ABS).
Consequence: Damage to the fuel pump circuit in the wiring harness could result in an unexpected engine stall. Damage to the ABS wiring can lead to reduction of ABS functionality and a loss of roll stability control (RSC) functionality. These scenarios increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the wire harness for damage. If no damage is found, dealers will apply anti-abrasion tape over the area and ensure clearance to surrounding components. If damage is found, dealers will splice in new wire and apply anti-abrasion tape over the area and ensure clearance to surrounding components. All services will be performed free of charge. The recall began May 18, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S13.
20V099000 · Power Train:driveline:differential Unit; Power Train:driveline:driveshaft
Feb 21, 2020
Ford Motor Company (Ford) is recalling certain 2020 F-550 and 2021 E-350 and E-450 vehicles. The rear axle differential fluid may be below the minimum level, possibly resulting in a failure of the rear axle assembly and driveshaft separation.
Consequence & remedy
Consequence: If the driveshaft separates, there may be a loss of drive, increasing the risk of crash. Additionally, if the parking brake is not applied, unintended vehicle movement can occur and increase the risk of injury or crash.
Remedy: Ford will notify owners, and dealers will inspect the rear axle differential fluid level and adjust it, or replace the rear axle as necessary, free of charge. The recall began March 19, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S09.
Additional source detail variants (2)
Power Train:driveline:differential Unit
Ford Motor Company (Ford) is recalling certain 2020 F-550 and 2021 E-350 and E-450 vehicles. The rear axle differential fluid may be below the minimum level, possibly resulting in a failure of the rear axle assembly and driveshaft separation.
Consequence: If the driveshaft separates, there may be a loss of drive, increasing the risk of crash. Additionally, if the parking brake is not applied, unintended vehicle movement can occur and increase the risk of injury or crash.
Remedy: Ford will notify owners, and dealers will inspect the rear axle differential fluid level and adjust it, or replace the rear axle as necessary, free of charge. The recall began March 19, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S09.
Power Train:driveline:driveshaft
Ford Motor Company (Ford) is recalling certain 2020 F-550 and 2021 E-350 and E-450 vehicles. The rear axle differential fluid may be below the minimum level, possibly resulting in a failure of the rear axle assembly and driveshaft separation.
Consequence: If the driveshaft separates, there may be a loss of drive, increasing the risk of crash. Additionally, if the parking brake is not applied, unintended vehicle movement can occur and increase the risk of injury or crash.
Remedy: Ford will notify owners, and dealers will inspect the rear axle differential fluid level and adjust it, or replace the rear axle as necessary, free of charge. The recall began March 19, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S09.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ24003 · Loss Of Power Brake/steering Assist Post Recall 22V089 Inspection.
Opened Feb 27, 2024 · Closed May 11, 2026
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:hydraulic:hoses, Lines/piping, And Fittings; Steering:hydraulic Power Assist:hose, Piping, And Connections
The Office of Defects Investigation (ODI) opened Recall Query (RQ) 24003 on February 27, 2024, to evaluate the scope and remedy effectiveness of NHTSA recall 24V097. On February 16, 2022, Ford Motor Company (Ford) issued a safety recall, NHTSA recall 22V089, for certain 2021-2022 Ford E-350 and E-450 vehicles equipped with dual rear wheels. According to the filing, specific hydraulic lines could leak resulting in a sudden loss of power steering and power brake assist, increasing the risk of a crash. The remedy involved a dealer inspection of the lines and their replacement as necessary. Only vehicles that failed the inspection received updated parts. On February 9, 2024, Ford issued a new recall, NHTSA recall 24V097, to replace the specific hydraulic lines on any vehicle that had not yet been inspected and on any vehicle which had passed inspection within the previous twelve months. However, vehicles which had passed the inspection more than twelve months ago would not be included within the scope of the new recall, as Ford deemed them to have a low likelihood of failure. ODI opened this RQ to better understand Ford's scoping of recall 24V097, specifically concerning the inspected-only vehicles not included in the new recall filing. ODI sent Ford an information request letter on April 18, 2024. Ford responded, in full, on May 31, 2024. ODI reviewed Ford's data which showed that the vehicles not included in the new recall had a predicted failure rate of less than 0.25% within 10 years from the date of inspection. By comparison, the vehicles included in the new filing have had a failure rate of approximately 2% prior to being recalled again. ODI analysis of complaint and warranty data further supports Ford's assessment that vehicles that passed inspection more than twelve months prior to recall 24V097 are unlikely to experience the defect condition. ODI is closing this RQ without a manufacturer action. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) opened Recall Query (RQ) 24003 on February 27, 2024, to evaluate the scope and remedy effectiveness of NHTSA recall 24V097. On February 16, 2022, Ford Motor Company (Ford) issued a safety recall, NHTSA recall 22V089, for certain 2021-2022 Ford E-350 and E-450 vehicles equipped with dual rear wheels. According to the filing, specific hydraulic lines could leak resulting in a sudden loss of power steering and power brake assist, increasing the risk of a crash. The remedy involved a dealer inspection of the lines and their replacement as necessary. Only vehicles that failed the inspection received updated parts. On February 9, 2024, Ford issued a new recall, NHTSA recall 24V097, to replace the specific hydraulic lines on any vehicle that had not yet been inspected and on any vehicle which had passed inspection within the previous twelve months. However, vehicles which had passed the inspection more than twelve months ago would not be included within the scope of the new recall, as Ford deemed them to have a low likelihood of failure. ODI opened this RQ to better understand Ford's scoping of recall 24V097, specifically concerning the inspected-only vehicles not included in the new recall filing. ODI sent Ford an information request letter on April 18, 2024. Ford responded, in full, on May 31, 2024. ODI reviewed Ford's data which showed that the vehicles not included in the new recall had a predicted failure rate of less than 0.25% within 10 years from the date of inspection. By comparison, the vehicles included in the new filing have had a failure rate of approximately 2% prior to being recalled again. ODI analysis of complaint and warranty data further supports Ford's assessment that vehicles that passed inspection more than twelve months prior to recall 24V097 are unlikely to experience the defect condition. ODI is closing this RQ without a manufacturer action. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Service Brakes, Hydraulic:power Assist:hydraulic:hoses, Lines/piping, And Fittings
The Office of Defects Investigation (ODI) opened Recall Query (RQ) 24003 on February 27, 2024, to evaluate the scope and remedy effectiveness of NHTSA recall 24V097. On February 16, 2022, Ford Motor Company (Ford) issued a safety recall, NHTSA recall 22V089, for certain 2021-2022 Ford E-350 and E-450 vehicles equipped with dual rear wheels. According to the filing, specific hydraulic lines could leak resulting in a sudden loss of power steering and power brake assist, increasing the risk of a crash. The remedy involved a dealer inspection of the lines and their replacement as necessary. Only vehicles that failed the inspection received updated parts. On February 9, 2024, Ford issued a new recall, NHTSA recall 24V097, to replace the specific hydraulic lines on any vehicle that had not yet been inspected and on any vehicle which had passed inspection within the previous twelve months. However, vehicles which had passed the inspection more than twelve months ago would not be included within the scope of the new recall, as Ford deemed them to have a low likelihood of failure. ODI opened this RQ to better understand Ford's scoping of recall 24V097, specifically concerning the inspected-only vehicles not included in the new recall filing. ODI sent Ford an information request letter on April 18, 2024. Ford responded, in full, on May 31, 2024. ODI reviewed Ford's data which showed that the vehicles not included in the new recall had a predicted failure rate of less than 0.25% within 10 years from the date of inspection. By comparison, the vehicles included in the new filing have had a failure rate of approximately 2% prior to being recalled again. ODI analysis of complaint and warranty data further supports Ford's assessment that vehicles that passed inspection more than twelve months prior to recall 24V097 are unlikely to experience the defect condition. ODI is closing this RQ without a manufacturer action. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Steering:hydraulic Power Assist:hose, Piping, And Connections
The Office of Defects Investigation (ODI) opened Recall Query (RQ) 24003 on February 27, 2024, to evaluate the scope and remedy effectiveness of NHTSA recall 24V097. On February 16, 2022, Ford Motor Company (Ford) issued a safety recall, NHTSA recall 22V089, for certain 2021-2022 Ford E-350 and E-450 vehicles equipped with dual rear wheels. According to the filing, specific hydraulic lines could leak resulting in a sudden loss of power steering and power brake assist, increasing the risk of a crash. The remedy involved a dealer inspection of the lines and their replacement as necessary. Only vehicles that failed the inspection received updated parts. On February 9, 2024, Ford issued a new recall, NHTSA recall 24V097, to replace the specific hydraulic lines on any vehicle that had not yet been inspected and on any vehicle which had passed inspection within the previous twelve months. However, vehicles which had passed the inspection more than twelve months ago would not be included within the scope of the new recall, as Ford deemed them to have a low likelihood of failure. ODI opened this RQ to better understand Ford's scoping of recall 24V097, specifically concerning the inspected-only vehicles not included in the new recall filing. ODI sent Ford an information request letter on April 18, 2024. Ford responded, in full, on May 31, 2024. ODI reviewed Ford's data which showed that the vehicles not included in the new recall had a predicted failure rate of less than 0.25% within 10 years from the date of inspection. By comparison, the vehicles included in the new filing have had a failure rate of approximately 2% prior to being recalled again. ODI analysis of complaint and warranty data further supports Ford's assessment that vehicles that passed inspection more than twelve months prior to recall 24V097 are unlikely to experience the defect condition. ODI is closing this RQ without a manufacturer action. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.