Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 3 of 5 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Structure. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel/propulsion System. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Tires. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
5 reports
Mileage unknown · Jul 11, 2026
Unknown Or Other
The L shaped bracket that supports the RV hydraulic/motor assembly for the auto leveling system has failed. The weld between two pieces of steel that makes up the bracket has failed. When the bracket fails the assembly is supported temporarily by electrical wires and hydraulic hoses. If it fails further and drags the road or sep…
Read full complaint
The L shaped bracket that supports the RV hydraulic/motor assembly for the auto leveling system has failed. The weld between two pieces of steel that makes up the bracket has failed. When the bracket fails the assembly is supported temporarily by electrical wires and hydraulic hoses. If it fails further and drags the road or separates completely, there is a possibility of fire under the vehicle and/or death or injury to other drivers on the road. There other safety recalls for this exact failure but my unit was not listed.
NHTSA ODI #11749775
111,059 miles · Feb 16, 2023
Structure
The contact owns a 2019 Ford E-450. The contact stated that the passenger's side rear door frame detached. The vehicle was taken to an independent mechanic who replaced the door rivets. The manufacturer was not made aware of the failure. The failure mileage was approximately 111,059.
NHTSA ODI #11507571
155,533 miles · Feb 16, 2023
Structure
The contact owns a 2019 Ford E-450. The contact stated that the passenger's side rear door frame had detached. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 155,533. The VIN was invalid.
NHTSA ODI #11507568
6,000 miles · Sep 8, 2022
Tires
The contact owns a 2019 Entegra Odyssey RV constructed on a 2019 Ford E450 chassis equipped with Hankook Tires, Tire Line: Dynapro HT, Tire Size: LT225/75/R16, DOT Number: BCXEHUH. The contact stated that upon inflating the tires, his brother was informed that the tires needed to be replaced as they had dry rotted. Additionally,…
Read full complaint
The contact owns a 2019 Entegra Odyssey RV constructed on a 2019 Ford E450 chassis equipped with Hankook Tires, Tire Line: Dynapro HT, Tire Size: LT225/75/R16, DOT Number: BCXEHUH. The contact stated that upon inflating the tires, his brother was informed that the tires needed to be replaced as they had dry rotted. Additionally, the contact stated that the tires were consistently becoming flat while driving. The Tire dealer and manufacturer were not made aware of the failure. The RV dealer and manufacturer were notified of the failure but provided no assistance. The tires were not replaced. The RV and tire failure mileage was 6,000.
NHTSA ODI #11483471
Mileage unknown · Sep 6, 2022
Fuel/propulsion System
When refueling the gas pump clicks off after a few seconds. Sometimes it doesn't click off but back splashes fuel out the gas filler hole. I have had gas spray back several times, getting all over the RV, the ground, and my clothes. Repair places have said there is nothing they can do because it is a design flaw cause the fill t…
Read full complaint
When refueling the gas pump clicks off after a few seconds. Sometimes it doesn't click off but back splashes fuel out the gas filler hole. I have had gas spray back several times, getting all over the RV, the ground, and my clothes. Repair places have said there is nothing they can do because it is a design flaw cause the fill tube is too flat. This seems like a huge fire risk to me.
NHTSA ODI #11483013
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2019 Ford E-450 Problems, Complaints & Recalls | Skip That Year
Illustration