Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 6 of 6 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Power Train. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Wheels. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
6 reports
80,329 miles · Nov 1, 2021
SuspensionWheels
The contact rented a 2015 Ford E-450. The contact stated that while driving, the vehicle was shaking in the rear. The contact had to maintain an approximate speed of 40 MPH to control the vehicle. The fuel warning light was illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufactur…
Read full complaint
The contact rented a 2015 Ford E-450. The contact stated that while driving, the vehicle was shaking in the rear. The contact had to maintain an approximate speed of 40 MPH to control the vehicle. The fuel warning light was illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The contact stated that the rear wheels were cracked. The contact was concerned about driving the vehicle. The failure mileage was approximately 80,329.
NHTSA ODI #11438925
25,025 miles · Nov 6, 2020
Wheels
THE TIRE THREAD SHREDDED OFF OF BOTH SIDES OF THE WHEEL WHILE DRIVING, DAMAGING MUD FLAPS, ETC. 2015 JAYCO GREYHAWK RV (FORD 450 CHASIS). MILEAGE WAS ONLY 25000 MILES. OTHER TIRES APPEAR TO ALREAY DISPLAY SOFT SPOTS AND CRACKING - ESPECIALLY NEAR THE THREAD, VEHICLE IS GARAGE WHEN NOT IN USE.
NHTSA ODI #11373481
36,755 miles · Jun 21, 2018
Power Train
THIS IS A SCHOOL BUS. WHEN STOPPED AT A STOP SIGN THE SCHOOL BUS WOULD NOT ENGAGE IN ANY GEAR, FORWARD OR REVERSE. THE SCHOOL BUS HAD TO BE TOWED TO THE FORD DEALERSHIP WHERE THEY FOUND THAT THE COAST CLUTCH DRUM, RETURN SPRING, PISTON AND ONE WAY CLUTCH NEEDED TO BE REPLACED. THIS IS THE 4TH SCHOOL BUS WE HAVE HAD THIS ISSUE…
Read full complaint
THIS IS A SCHOOL BUS. WHEN STOPPED AT A STOP SIGN THE SCHOOL BUS WOULD NOT ENGAGE IN ANY GEAR, FORWARD OR REVERSE. THE SCHOOL BUS HAD TO BE TOWED TO THE FORD DEALERSHIP WHERE THEY FOUND THAT THE COAST CLUTCH DRUM, RETURN SPRING, PISTON AND ONE WAY CLUTCH NEEDED TO BE REPLACED. THIS IS THE 4TH SCHOOL BUS WE HAVE HAD THIS ISSUE WITH.
NHTSA ODI #11102982
65,000 miles · Feb 14, 2018
Power Train
TL* THE CONTACT OWNS A 2015 FORD E-350. WHILE OPERATING THE VEHICLE, THE "SERVICE VEHICLE" WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER (MORRIS BUFFALO FORD, 702 E. HIGHWAY 55, BUFFALO MN) WHERE IT WAS DIAGNOSED THAT THE CLUTCH CYLINDER WELL INSIDE THE TRANMISSION WAS CRACKED AND THE TRANSMISSION NEED…
Read full complaint
TL* THE CONTACT OWNS A 2015 FORD E-350. WHILE OPERATING THE VEHICLE, THE "SERVICE VEHICLE" WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER (MORRIS BUFFALO FORD, 702 E. HIGHWAY 55, BUFFALO MN) WHERE IT WAS DIAGNOSED THAT THE CLUTCH CYLINDER WELL INSIDE THE TRANMISSION WAS CRACKED AND THE TRANSMISSION NEEDED TO BE REBUILT. THE MANUFACTURER WAS NOTIFIED AND NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 65,000.
NHTSA ODI #11072830
100,000 miles · Feb 14, 2018
Power Train
TL* THE CONTACT OWNS A 2015 FORD E-450. WHILE OPERATING THE VEHICLE, THE "SERVICE VEHICLE" WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER (MORRIS BUFFALO FORD, 702 E. HIGHWAY 55, BUFFALO MN) WHERE IT WAS DIAGNOSED THAT THE CLUTCH CYLINDER WELL INSIDE THE TRANMISSION HAD CRACKED AND THE TRANSMISSION NEED…
Read full complaint
TL* THE CONTACT OWNS A 2015 FORD E-450. WHILE OPERATING THE VEHICLE, THE "SERVICE VEHICLE" WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER (MORRIS BUFFALO FORD, 702 E. HIGHWAY 55, BUFFALO MN) WHERE IT WAS DIAGNOSED THAT THE CLUTCH CYLINDER WELL INSIDE THE TRANMISSION HAD CRACKED AND THE TRANSMISSION NEEDED TO BE REBUILT. THE MANUFACTURER WAS NOTIFIED AND NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 100,000.
NHTSA ODI #11072827
2,020 miles · Sep 17, 2015
EngineFuel/propulsion System
TL* THE CONTACT OWNS A 2015 FORD E-450. WHILE DRIVING AT 55 MPH, THE VEHICLE STALLED. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE AND THE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE TECHNICIAN WAS ABLE TO RESTART THE VEHICLE BUT WAS UNABLE TO DIAGNOSE OR REPAIR TH…
Read full complaint
TL* THE CONTACT OWNS A 2015 FORD E-450. WHILE DRIVING AT 55 MPH, THE VEHICLE STALLED. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE AND THE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE TECHNICIAN WAS ABLE TO RESTART THE VEHICLE BUT WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE FAILURE RECURRED AND THE VEHICLE WAS TOWED TO THE DEALER WHO DIAGNOSED THAT THE FUEL MODULE NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED; HOWEVER, THE CONTACT STATED THAT SHORTLY AFTER THE REPAIR, THE VEHICLE JERKED AND FAILED TO START AS THE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO A DEALER, BUT WAS UNABLE TO BE DIAGNOSED OR REPAIRED THE VEHICLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 2,020.
Mobility Transportation Services (MobilityTrans) is recalling certain 2014-2018 Ford Transit and Ram Promaster vehicles and 2014-2015 Ford Econoline vehicles modified to be equipped with Freedman GO-ES Foldaway Seats, part numbers 43705, 45467, 48923, and 75719. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: MobilityTrans will notify owners and Freedman Seating dealers will inspect and repair the foldaway seat, free of charge. The recall began May 19, 2019. Owners may contact Mobility Transportation Services customer service at 1-734-453-6452.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE18010 · Internal Transmission Failure
Opened Aug 21, 2018 · Closed Jul 16, 2019
Status: closed (inferred from source dates) · Power Train:automatic Transmission
By letter dated June 10, 2019, Ford Motor Company notified the Office of Defects Investigation (ODI) of a safety defect that may exist in certain model year (MY) 2009 through 2016 Ford Econoline vehicles equipped with a 5R110W transmission. Following the receipt of consumer complaints alleging transmission failures in vehicles built with a 5R110W transmission, NHTSA opened this investigation to assess the manufacturer's data including warranty claims, field reports, design changes, etc.Vehicles equipped with a 5R110W transmission contain a capacitive discharge weld within a coast clutch component in the transmission. A substandard weld may fatigue and fail, causing an elevated rate of loss of motive power in subject vehicle applications. Reports indicate that most of the weld failures occur when the torque is highest, which is when the driver attempts to accelerate from a stop.Analysis of the data provided by Ford Motor Company found that the risk of a transmission failure is very high in vehicles equipped with the combination of a W-MOD 5.4L SOHC EFI NA V8 G-NP engine and a 5R110W transmission. This vehicle population mainly consists of school buses and ambulances. A loss of mobility in school bus applications may result in the transfer of children when the vehicle is immobilized in a roadway, and a loss of vehicle mobility in ambulance applications may result in the delay of patient treatment.In response to this investigation, Ford Motor Company agreed to conduct recall 19V-432. Owners will be notified by mail and instructed to take their vehicle to a Ford or Lincoln dealer to have the coast clutch cylinder replaced and to replace the single-engaging coast one-way clutch with a dual-engaging one-way clutch. With recall action 19V-432 taken by Ford Motor Company this investigation is closed. Further use of agency resources does not appear to be warranted.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist on other model or MY vehicles outside of the recall scope. The agency reserves the right to take further action if warranted by the circumstances.
2015 Ford E-450 Problems, Complaints & Recalls | Skip That Year
Illustration