Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 2 of 4 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Wheels. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
4 reports
Mileage unknown · Oct 24, 2022
Tires
The contact owns a 2012 Forest River Sunseeker built on a 2012 Ford E-450 chassis, equipped with Michelin Tires, Tire Line: LTX MS2, Tire Size: LT225/75/R16. The contact stated while driving at an undisclosed speed, there was an abnormal vibration in the front end. The contact became aware that the driver’s side front tire belt …
Read full complaint
The contact owns a 2012 Forest River Sunseeker built on a 2012 Ford E-450 chassis, equipped with Michelin Tires, Tire Line: LTX MS2, Tire Size: LT225/75/R16. The contact stated while driving at an undisclosed speed, there was an abnormal vibration in the front end. The contact became aware that the driver’s side front tire belt was going through the side wall. There were no warning lights illuminated. The vehicle was taken to an independent mechanic who changed another tire. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The tire failure mileage was approximately 13,000. The vehicle failure mileage was unknown.
NHTSA ODI #11490651
23,337 miles · Dec 4, 2020
EnginePower Train
WHILE DRIVING ON THE INTERSTATE THE MOTOR BLOCK BLEW. THERE WAS A LOUD, FAST CLICKING NOISE FOLLOWED BY CLUNKING AND SMOKE FROM UNDER THE VEHICLE. ALL FLUIDS WERE GOOD BUT THERE WAS A FEW DROPS OF OIL ON THE GROUND. THE MECHANIC SAID IT WAS A MANUFACTURE DEFECT THAT HE HAS PREVIOUSLY SEEN. THE VEHICLE WAS MAINTAINED AND THOROUGH…
Read full complaint
WHILE DRIVING ON THE INTERSTATE THE MOTOR BLOCK BLEW. THERE WAS A LOUD, FAST CLICKING NOISE FOLLOWED BY CLUNKING AND SMOKE FROM UNDER THE VEHICLE. ALL FLUIDS WERE GOOD BUT THERE WAS A FEW DROPS OF OIL ON THE GROUND. THE MECHANIC SAID IT WAS A MANUFACTURE DEFECT THAT HE HAS PREVIOUSLY SEEN. THE VEHICLE WAS MAINTAINED AND THOROUGHLY CHECKED BEFORE THE ROAD TRIP.
NHTSA ODI #11377864
16,600 miles · Jul 22, 2020
Wheels
TL* THE CONTACT OWNS A 2012 FORD E-450. THE CONTACT STATED THAT THE PASSENGER'S SIDE REAR LUG NUT LOOSENED CAUSING THE WHEEL HUB TO DETACH FROM THE VEHICLE. THE CONTACT STATED THAT THE WRONG TYPE OF WHEEL WAS INSTALLED ON THE VEHICLE. THE CONTACT STATED THAT AN ALUMINUM WHEEL WAS INSTALLED ON THE VEHICLE INSTEAD OF THE REQUIRED …
Read full complaint
TL* THE CONTACT OWNS A 2012 FORD E-450. THE CONTACT STATED THAT THE PASSENGER'S SIDE REAR LUG NUT LOOSENED CAUSING THE WHEEL HUB TO DETACH FROM THE VEHICLE. THE CONTACT STATED THAT THE WRONG TYPE OF WHEEL WAS INSTALLED ON THE VEHICLE. THE CONTACT STATED THAT AN ALUMINUM WHEEL WAS INSTALLED ON THE VEHICLE INSTEAD OF THE REQUIRED STEEL WHEEL. THE CONTACT STATED THAT VEHICLE SPECS CALLED FOR A HUB CENTRIC WHEEL. THE VEHICLE WAS TOWED TO AN RV CENTER TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE FAILURE WAS CAUSED BY THE INCORRECT WHEEL BEING INSTALLED ON THE VEHICLE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE MANUFACTURER CONFIRMED THAT THE WRONG STYLE WHEEL WAS INSTALLED ON THE VEHICLE. THE APPROXIMATE FAILURE MILEAGE WAS 16,600. *LN*JB*DT*JB
NHTSA ODI #11340859
Mileage unknown · Mar 6, 2014
Wheels
TL* THE CONTACT OWNS A 2012 FORD E-450 (N/A). THE CONTACT STATED THAT UPON INSPECTION, IT WAS FOUND THAT THE REAR TIRES WERE FLAT. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS FOUND THAT THE FAILURE WAS DUE TO THE WHEEL SIMULATORS SEVERING THE VALVE STEMS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED …
Read full complaint
TL* THE CONTACT OWNS A 2012 FORD E-450 (N/A). THE CONTACT STATED THAT UPON INSPECTION, IT WAS FOUND THAT THE REAR TIRES WERE FLAT. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS FOUND THAT THE FAILURE WAS DUE TO THE WHEEL SIMULATORS SEVERING THE VALVE STEMS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE. *TR
Farber Specialty Vehicles (Farber) is recalling various specialty vehicles modified by Farber and equipped with model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.
Consequence & remedy
Consequence: If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.
Remedy: Farber will notify owners to take their vehicles to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on March 24, 2015. Owners may contact Farber customer service at 1-800-331-3188, or Ricon customer service at 1-800-322-2884. Farber's number for this recall is 14E-041.
Elkhart Coach (Elkhart) is recalling certain model year 2006-2014 Ford E-350 and Ford E-450 vehicles manufactured January 1, 2006, to May 1, 2014 and equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.
Consequence & remedy
Consequence: If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.
Remedy: Elkhart will notify owners to take the vehicles to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on October 1, 2014. Owners may contact Ricon customer service at 1-800-322-2884. Owners may also contact Elkhart customer service at 1-574-264-5179. This recall has been superseded by campaign 15V-768.
Adrian Steel Company (Adrian) is recalling certain model year 2012 Ford E-150, E-250 and E-350 Commercial Cargo Vans modified by Adrian between September 21, 2012, to September 24, 2012. The affected vehicles are equipped with certain propane fuel system conversion kits with an aluminum fuel line fitting manufactured by Roush CleanTech. Due to a reaction between the different metals, the affected kits may develop a propane leak where the aluminum fuel line fitting contacts the brass supply valve housing.
Consequence & remedy
Consequence: A propane leak in the presence of an ignition source increases the risk of a fire.
Remedy: Adrian will notify owners, and dealers will replace the aluminum fuel line fittings with stainless steel fittings, free of charge. The recall began during July 2014. Owners may contact Adrian customer service at 1-800-677-2726.
Roush Performance Products, Inc. (Roush) is recalling certain model year 2010-2012 Ford E-150 Wagons and Cargo Vans, E-250 Cargo Vans and Extended Cargo Vans, E-350 Wagons, Extended Wagons, Cargo Vans, and Extended Vans, and E-450 Cutaway models. These models were modified by Roush to be equipped with certain propane fuel system conversion kits manufactured January 2011 to August 2012 with an aluminum fuel line fitting. Due to a reaction between the different metals, the affected kits may develop a propane leak where the aluminum fuel line fitting contacts the brass supply valve housing.
Consequence & remedy
Consequence: A propane leak in the presence of an ignition source increases the risk of a fire.
Remedy: Roush will notify owners and will replace the aluminum fuel line fittings with new stainless steel fittings, free of charge. The recall began on September 1, 2014. Owners may contact Roush customer service at 1-800-597-6874.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2012 Ford E-450 Problems, Complaints & Recalls | Skip That Year
Illustration