AS THE DRIVER APPROACHED AN INTERSECTION THE BRAKE PEDAL LOCKED UP AND THE VEHICLE COULD NOT SLOW TO STOP CAUSING AN ACCIDENT AS THE VEHICLE PROCEEDED THROUGH THE INTERSECTION ON A RED LIGHT. THE SAME ISSUE HAPPENED APPROXIMATELY TWO MONTHS BEFORE AND WAS SUPPOSEDLY REPAIRED BY THE DEALER. HOWEVER THE SAME PROBLEM HAPPENED AGA…
Read full complaint
AS THE DRIVER APPROACHED AN INTERSECTION THE BRAKE PEDAL LOCKED UP AND THE VEHICLE COULD NOT SLOW TO STOP CAUSING AN ACCIDENT AS THE VEHICLE PROCEEDED THROUGH THE INTERSECTION ON A RED LIGHT. THE SAME ISSUE HAPPENED APPROXIMATELY TWO MONTHS BEFORE AND WAS SUPPOSEDLY REPAIRED BY THE DEALER. HOWEVER THE SAME PROBLEM HAPPENED AGAIN. (THIS COMPLAINT IS SIMILAR TO COMPLAINT NUMBER 10918568 AND THAT COMPLAINT IMPROPERLY NOTED THAT THERE WAS NO POLICE REPORT - THE REPORT IS ATTACHED WITH THIS COMPLAINT. ALSO, THIS COMPLAINT SUPPLEMENTS THE PRIOR INFORMATION BY PROVIDED THE SERVICE TICKET. THE TICKET SHOWS A FUEL PUMP RELAY FUSE MELTED.
NHTSA ODI #10918721
200 miles · Jan 7, 2011
SteeringSuspension
12/1/2010 EXPLANATION OF TWO LIFE THREATENING SITUATIONS SITUATION ONE: ON MAY 4, 2010, I THE CONSUMER, WAS DRIVING FROM JOHNS CREEK, GEORGIA TO CHATTANOOGA, TENN. THE TRIP WAS ON GEORGIA HWY 400 SOUTH FROM OLD MILTON PKWY TO I-285 WEST AND NORTH ON I-75. THE TIME WAS BETWEEN 3:30 PM AND 5:30PM. THE VAN WAS DIFFICULT TO …
Read full complaint
12/1/2010 EXPLANATION OF TWO LIFE THREATENING SITUATIONS SITUATION ONE: ON MAY 4, 2010, I THE CONSUMER, WAS DRIVING FROM JOHNS CREEK, GEORGIA TO CHATTANOOGA, TENN. THE TRIP WAS ON GEORGIA HWY 400 SOUTH FROM OLD MILTON PKWY TO I-285 WEST AND NORTH ON I-75. THE TIME WAS BETWEEN 3:30 PM AND 5:30PM. THE VAN WAS DIFFICULT TO CONTROL AND WAS MOVING FROM THE LEFT TO THE RIGHT SIDES OF THE TRAFFIC LANE. THE TRAFFIC WAS CONSIDERED NORMAL FOR I-75 WITH 18 WHEEL TRUCK AND PASSENGER CAR TRAFFIC. THE VAN WAS DRIVEN WITH THE FLOW OF TRAFFIC APPROXIMATELY BETWEEN 65 AND 75 MPH. IN THE DALTON, GEORGIA AREA OF I-75 THE VAN WAS APPROACHING AN OVERPASS. AT THE OVERPASS THE PAVEMENT MUST HAVE CHANGED IN LEVEL BECAUSE THE VAN JUMPED IN THE AIR AND TURNED SLIGHTLY TO THE LEFT APPROACHING THE LEFT GUARD RAIL. FORTUNATELY, THE CONSUMER DRIVER WAS ABLE TO REGAIN CONTROL BEFORE HITTING THE GUARD RAIL OR THE TRUCK ON THE RIGHT. THE VAN WAS RETURNED TO CHEROKEE FORD ON MAY 5, 2010 FOR CORRECTION OF THE DIFFICULT CONTROL PROBLEM. THE PROBLEM HAS NOT BEEN REPAIRED TO DATE. SITUATION TWO: ON OCTOBER 15, 2010 I THE CONSUMER, WAS DRIVING SOUTH ON GEORGIA HWY 400 FROM OLD MILTON PKWY TO THE ABERNATHY EXIT. THE TIME WAS BETWEEN 2:30PM TO 2:45PM. TRAFFIC WAS HEAVY WITH PASSENGER CAR TRAFFIC AND THE VAN WAS TRAVELING IN THE MIDDLE LEFT LANE OF THE FOUR LANE HIGHWAY. TRAFFIC SPEED WAS NORMAL FOR GEORGIA 400 ABOUT 65 TO 75 MPH. THE VAN WAS DIFFICULT TO CONTROL AND WAS MOVING FROM THE LEFT TO THE RIGHT SIDES OF THE TRAFFIC LANE, SIMILAR WITH SITUATION ONE. FOR NO APPARENT REASON AND WITH NO CHANGE IN THE STEERING WHEEL DIRECTION THE VAN WENT LEFT INTO THE FAR LEFT LANE. I TRIED TO RETURN TO THE MIDDLE LEFT LANE, BUT THE VAN WOULD NOT RESPOND WITH A SLIGHT TURN TO THE RIGHT. AFTER SOME DISTANCE, UNKNOWN, THE VAN DID RESPOND AND RETURNED TO THE MIDDLE LEFT LANE.
MobilityWorks (WMK Inc.) is recalling certain model year 2006-2014 Ford E-150, E-250, and E-350 vans modified by MobilityWorks to be equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.
Consequence & remedy
Consequence: If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.
Remedy: MobilityWorks will notify owners, and Ricon dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on December 15, 2015. Owners may contact MobilityWorks customer service at 1-800-769-8267, or Ricon Customer Service at 1-800-322-2884. Note: These vehicles and wheelchair lifts were subject to a similar recall in 2014. All vehicles that received that recall remedy are still affected by this recall as well.
Cummings Mobility Conversion & Supply (Cummings) is recalling certain model year 2006-2014 Ford E-150, E-250, E-350, Chevrolet Express, 2006-2008 Dodge Sprinter, and 2009-2014 Mercedes-Benz Sprinter, and 2013 Ford Transit Connect vehicles manufactured January 1, 2006, to October 8, 2014, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation after January 1, 2006. The platform side plate of the affected wheelchair lifts may crack.
Consequence & remedy
Consequence: If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.
Remedy: Cummings will notify owners to take buses to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began January 13, 2015. Owners may contact Cumming's customer service at 1-800-639-5438 or Ricon customer service at 1-800-322-2884. Cumming's number for this recall is 14E-041.
National Van Builders, Inc. (National Van) is recalling certain 2007-2014 Ford E-150 and E-250 vehicles manufactured February 26, 2007, to August 19, 2014, and equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.
Consequence & remedy
Consequence: If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.
Remedy: National Van will notify owners to take buses to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on October 3, 2014. Owners may contact National Van customer service at 1-800-527-7477. National Van's number for this recall is Ricon2014.
Roush Performance Products, Inc. (Roush) is recalling certain model year 2010-2012 Ford E-150 Wagons and Cargo Vans, E-250 Cargo Vans and Extended Cargo Vans, E-350 Wagons, Extended Wagons, Cargo Vans, and Extended Vans, and E-450 Cutaway models. These models were modified by Roush to be equipped with certain propane fuel system conversion kits manufactured January 2011 to August 2012 with an aluminum fuel line fitting. Due to a reaction between the different metals, the affected kits may develop a propane leak where the aluminum fuel line fitting contacts the brass supply valve housing.
Consequence & remedy
Consequence: A propane leak in the presence of an ignition source increases the risk of a fire.
Remedy: Roush will notify owners and will replace the aluminum fuel line fittings with new stainless steel fittings, free of charge. The recall began on September 1, 2014. Owners may contact Roush customer service at 1-800-597-6874.
Mobility Works is recalling certain model year 2006-2012 Ford E-150, E-250 and E-350 vehicles manufactured August 2006 through August 2012. The vehicles are equipped with certain Ricon S series and K Series wheelchair lifts with an optional armored pendant cable. The armored cable may be positioned such that it does not clear the wheelchair lift.
Consequence & remedy
Consequence: If the cable does not clear the wheel chair lift it may contact the power lug and, if it does not have a nonconductive cover, or it has an improperly installed non-conductive cover, a short circuit may occur that could result in a fire.
Remedy: Mobility Works will notify owners and Ricon will provide a supplemental cover kit and instructions, free of charge. This recall campaign is expected to begin July 15, 2013. Owners may contact Mobility Works at 1-877-275-4912 and Ricon at 1-818-267-3000.
ROUSH IS RECALLING CERTAIN MODEL YEAR 2009-2011 FORD E-150, E-250, AND E-350 5.4L ENGIN VANS/WAGONS/CUTAWAYS, AND MODEL YEAR 2010-2011 FORD E-450 6.8L ENGINE CUTAWAY VEHICLES ALTERED BY ROUCH TO OPERATE USING THE ROUSH BRANDED CLEANTECH PROPANE AUTOGAS FUEL SYSTEM. THE FUEL RAILS INCLUDED IN THE KITS CONTAIN IMPROPERLY SEATED INJECTOR RETENTION CLIPS. THIS COULD RESULT IN LEAKAGE OF PROPANE AUTOGAS.
Consequence & remedy
Consequence: A PROPANE LEAK IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: ROUSH WILL NOTIFY OWNERS OF THE VEHICLES OF WHICH THE KITS WERE INSTALLED IN ORDER TO ARRANGE FOR FREE REPLACEMENT OF THE INJECTOR RETENTION CLIPS. THE SAFETY RECALL BEGAN ON SEPTEMBER 26, 2011. OWNERS MAY CONTACT ROUSH AT 1-734-466-6255.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2010 Ford E-150 Problems, Complaints & Recalls | Skip That Year
Illustration