HAVING BEEN DRIVING AT A LOW SPEED THE BREAK IN THE LOWER ARM DID NOT CAUSE AN ACCIDENT. AT A HIGHER SPEED THE VAN COULD HAVE ROLLED VERY EASY. KNOW ING NOW THAT YOU HAD A REPORT ON THE RIVETS POPING, I FEEL MY LIFE WAS PUT IN DANGER ALONG WITH MY SON'S KNOWING THAT NOTHING ELSE BEEN BROUGHT TO THE ATTENTION OF AEROSTAR OWNERS. …
Read full complaint
HAVING BEEN DRIVING AT A LOW SPEED THE BREAK IN THE LOWER ARM DID NOT CAUSE AN ACCIDENT. AT A HIGHER SPEED THE VAN COULD HAVE ROLLED VERY EASY. KNOW ING NOW THAT YOU HAD A REPORT ON THE RIVETS POPING, I FEEL MY LIFE WAS PUT IN DANGER ALONG WITH MY SON'S KNOWING THAT NOTHING ELSE BEEN BROUGHT TO THE ATTENTION OF AEROSTAR OWNERS. I HOPE THAT YOU WILL CONTACT ME OR TONY MENDEZ THAT HAS WORKED ON THE VAN . I FEEL THAT THERE HAS BEEN ACCIDENTS BECAUSE OF THIS BUT NO ONE KNEW WHY. IT IS A DESIGN FLAW THAT MUST BE FIXED AS MOST PEOPLE THAT OWN VANS HAVE CHILDREN. THANK YOU
NHTSA ODI #728672
Mileage unknown · May 5, 1999
Air BagsSteeringCrashInjury
1. POWER STEERING BELT SHEARED OFF WHICH COULD CAUSE LOSS OF STEERING AND CONTROL OF VEHICLE. 2. CONSUMER WAS DRIVING AT APPROXIMATELY 30-35 MPH WHEN IT FISHTALED AND HIT A POLE HEAD-ON AND THEN CAR ON BUMPER. UPON IMPACT, DRIVER'S SIDE AIRBAG DID NOT DEPLOY, RESULTING IN INJURIES. *AK
NHTSA ODI #837488
Mileage unknown · Nov 23, 1998
Steering
IGNITION SWITCH CYLINDER CAME OUT. DEALER WAS CONTACTED AND STATED A ROD WAS MISSING FROM THE STEERING COLUMN SHAFT. DEALER STILL HAS THE VEHICLE AND IS ATTEMPTING TO REPAIR IT. *AK
NHTSA ODI #831163
Mileage unknown · Jul 23, 1998
SteeringSuspension
WHILE DRIVING VEHICLE FRONT END SHAKES. DEALERS HAS REPLACED BUSHINGS. ALSO POWER STEERING PUMP FAILED, CAUSING POWER STEERING TO LOCK UP. *AK
NHTSA ODI #825773
Mileage unknown · Mar 11, 1998
Steering
FLUID LEAK CAUSED POWER STEERING PRESSURE.
NHTSA ODI #532469
Mileage unknown · Apr 15, 1996
Steering
WHEN TURNING THE VEHICLE TO THE LEFT OR RIGHT THE WHEEL WILL NOT STRAIGHTEN UP WHEN COMING OUT OF THE TURN. PLEASE DESCRIBE. *AK
VEHICLE DESCRIPTION: MINI VANS. HEAT GENERATION IN THE WIRING HARNESS TO THE FUEL PUMP/SENDER ASSEMBLY CAN CAUSE AN ELECTRICAL SHORT. THE VEHICLE COULD EXPERIENCE A LOSS OF POWER AND BECOME IMMOBILIZED AND THE FUEL GAUGE MAY BE ERRATIC.
Consequence & remedy
Consequence: HEAT DAMAGE, INCLUDING MELTING OR CHARRING OF THE FUEL PUMP AND SENDER ASSEMBLY WIRE HARNESS AND ASSOCIATED WIRING HARNESSES CAN ALSO RESULT. THE SHORT CIRCUIT COULD ALSO HAVE THE POTENTIAL FOR A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL A FUSED JUMPER HARNESS IN THE FUEL PUMP GROUND CIRCUIT THAT WILL BE INSTALLED AT THE FUEL PUMP INERTIA SHUT-OFF SWITCH.
VEHICLE DESCRIPTION: MINI VANS. THESE VEHICLES WERE PRODUCED WITH A HIGHER THAN SPECIFIED ELECTRICAL LOAD THROUGH THE ACCESSORY POWER FEED CIRCUIT. THE POTENTIAL FOR CONTACT BETWEEN THE B2 (BATTERY), A2 (ACCESSORY), AND P1 (PROOF) CIRCUITS CAN OCCUR, CREATING A SHORT CIRCUIT, ALLOWING CURRENT TO FLOW THROUGH THE GROUND WIRE.
Consequence & remedy
Consequence: THIS CAN CAUSE OVER HEATING AND THE POTENTIAL FOR A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL A JUMPER HARNESS WITH A RELAY WHICH WILL RE-ROUTE AND ACTIVATE ALL A2 ACCESSORIES THROUGH THE RELAY.
VEHICLE DESCRIPTION: ALL WHEEL DRIVE PASSENGER MINIVANS. THESE VEHICLES CAN DEVELOP POWERTRAIN BENDING RESONANCE OR TRANSFER CASE OUTPUT SHAFT BUSHING DISPLACEMENT. THE POWERTRAIN BENDING RESONANCE OR THE OUTPUT SHAFT BUSHING DISPLACEMENT CAN RESULT IN STRUCTURAL FAILURE OF THE TRANSMISSION AND/OR TRANSFER CASE. FLUID EXPLUSION, DRIVESHAFT SEPARATION OR LOSS OF VEHICLE DRIVE CAN RESULT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE A LOSS OF VEHICLE CONTROL, AND, IF THE EXPELLED FLUID CONTACTS THE EXHAUST SYSTEM, A VEHICLE FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW TRANSFER CASE REAR OUTPUT SHAFT BUSHING AND AN ALUMINUM DRIVESHAFT WILL BE INSTALLED.
THE CERTIFICATION LABEL ON THESE VEHICLES HAVE INCORRECT REAR TIRE SIZES LISTED. P215/70R14SL SHOULD BE P215/75R14SL. THIS DOES NOT COMPLY WITH FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: THE INCORRECTLY SIZED REAR TIRE WOULD NOT HAVE SUFFICIENT LOAD CAPACITY FOR THE VEHICLE'S SPECIFIED GROSS AXLE WEIGHT RATING, INCREASING THE POTENTIAL FOR PREMATURE TIRE FAILURE.
Remedy: OWNERS WILL BE MAILED A SUPPLEMENTARY LABEL CONTAINING THE CORRECT REAR TIRE INFORMATION AND INSTRUCTIONS FOR INSTALLING THE LABEL ON THEIR VEHICLES. IF OWNERS PREFER, THEIR DEALER CAN INSTALL THE LABEL FOR THEM.
THE SPARE TIRE SUPPLIED WITH THE VEHICLE CAN CONTACT THE BRAKE LINES ON THE REAR AXLE IF IT IS MOUNTED IN THE UNDERBODY SPARE TIRE CARRIER. SUCH CONTACT COULD RESULT IN FRACTURE OF A REAR BRAKE LINE.
Consequence & remedy
Consequence: THIS CAN RESULT IN REDUCED VEHICLE BRAKE CAPABILITY.
Remedy: DEALERS WILL INSTALL A LOWER PROFILE MINI-SPARE TIRE ON THE EXISTING MINI-SPARE WHEEL. THE NEW TIRE WILL ALLOW THE MINI-SPARE TO BE INSTALLED WITH APPROPRIATE CLEARANCES IN THE UNDERBODY SPARE TIRE CARRIER.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA99002 · Transfer Cases And Rear Drive Shaft
Opened Jan 7, 1999 · Closed Nov 14, 2000
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
RQ98012 · Transfer Cases And Rear Driveshaft
Opened Jul 31, 1998 · Closed Jan 7, 1999
Status: closed (inferred from source dates) · Power Train:transfer Case (4-WHEEL Drive)
There is no summary currently available
EA98016 · Fuel Sender Assembly Fires
Opened Jul 14, 1998 · Closed Feb 12, 1999
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
Additional source detail variants (2)
Vehicle Speed Control:linkages
There is no summary currently available
Vehicle Speed Control:linkages
There is no summary currently available
1995 Ford Aerostar Problems, Complaints & Recalls | Skip That Year
Illustration