Electrical System. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

16 crash reports18 fire reports12 injury reports

Seat Belts complaints

5 reports

Clear category filter

140,000 miles · Jul 9, 2006

Seat Belts

WENT TO INSTALL CAR SEAT IN THREE ROW, PASSENGER SIDE AND THE SEAT BELT CAME UNLATCHED. IT WILL NOT STAY BUCKLED AT ALL. WENT TO A DEALERSHIP AND THEY WANT TO CHARGE US OVER $100 FOR BUCKLE AND AN HOURS WORTH OF LABOR. WE ARE DUE IN 2 WEEKS WITH THIRD CHILD AND THAT IS THE ONLY SPOT LEFT IN THE VAN THAT THE CAR SEAT FITS IN. *N…

Read full complaint

NHTSA ODI #10161916

Mileage unknown · Nov 3, 2000

Seat Belts

Read full complaint

BOTH SHOULDER SEAT BELTS IN THE MIDDLE SEAT OF THIS 1995 AEROSTAR MINI VAN STOPPED WORKING THIS WEEK, ONE SEAT BELT HAS NO HOLD MEANING YOU CAN PULL IT ALL THE WAY OUT OF THE PANEL AND IT DOES NOT GRAB AND SECURE MY CHILD, THE OTHER SEAT BELT WONT COME OUT OF THE HOLDER AT ALL, SO IT IS USELESS AS WELL. THIS VAN HAS CHILD SAFETY SEATS BUILT IN READY ACCESSABLE IN THE MIDDLE SEAT, BUT MY 12 YEAR OLD AND MY 9 YEAR OLD ARE TOO BIG FOR THEM SO THEY MUST HAVE THE SEAT BELTS TO WORK PROPERLY AND THEY BOTH STOPPED WORKING THIS WEEK, I HAVE OWNED THIS VEHICLE APPX A YEAR AND NEVER HAD ANY PROBLEMS BEFORE THIS WEEK. MY VAN IS IN EXCCELLENT CONDITION, WITH ONE MINOR SCRATCH ON THE SLIDING DOOR, I DID A LEMON CHECK AND FOUND NOTHING, ALTHOUGH WE HAVE HAD TO HAVE RECALL WORK DONE ON THE ACCESSORY POWER CIRCUIT. I THANK YOU FOR ALL YOUR TIME AND HELP. DAWN DOWLING MIZZOU@MCMSYS.COM. *AK

NHTSA ODI #735688

Mileage unknown · Dec 4, 1995

Air BagsSeat BeltsCrash

VAN WAS TOTAL LOSS. DRIVERS AIR BAG DID NOT DEPLOY UPON IMPACT, SEAT BELTS ALSO CAME UNLATCHED. PLEASE DESCRIBE. TT

NHTSA ODI #975935

Mileage unknown · Jun 19, 1995

Seat Belts

DURING INSTALLATION OF CARPETING, CUTOUTS PARTIALLY COVERED HOLES AND BOLT WAS FORCED INTO HOLE WITH EDGE OF CARPET, CAUSING CROSS-THREADING. *AK

NHTSA ODI #485329

Mileage unknown · May 19, 1995

Seat Belts

THE MIDDLE SEAT BELT IN THE THIRD ROW GOT STUCK AND A CHILD HAD TO FORCED OUT OF IT. TT

NHTSA ODI #965572

Official recalls

99V028000 · Electrical System:wiring:front Underhood

Feb 9, 1999

VEHICLE DESCRIPTION: MINI VANS. HEAT GENERATION IN THE WIRING HARNESS TO THE FUEL PUMP/SENDER ASSEMBLY CAN CAUSE AN ELECTRICAL SHORT. THE VEHICLE COULD EXPERIENCE A LOSS OF POWER AND BECOME IMMOBILIZED AND THE FUEL GAUGE MAY BE ERRATIC.

Consequence & remedy

Consequence: HEAT DAMAGE, INCLUDING MELTING OR CHARRING OF THE FUEL PUMP AND SENDER ASSEMBLY WIRE HARNESS AND ASSOCIATED WIRING HARNESSES CAN ALSO RESULT. THE SHORT CIRCUIT COULD ALSO HAVE THE POTENTIAL FOR A VEHICLE FIRE.

Remedy: DEALERS WILL INSTALL A FUSED JUMPER HARNESS IN THE FUEL PUMP GROUND CIRCUIT THAT WILL BE INSTALLED AT THE FUEL PUMP INERTIA SHUT-OFF SWITCH.

99V029000 · Electrical System:ignition:switch

Feb 9, 1999

VEHICLE DESCRIPTION: MINI VANS. THESE VEHICLES WERE PRODUCED WITH A HIGHER THAN SPECIFIED ELECTRICAL LOAD THROUGH THE ACCESSORY POWER FEED CIRCUIT. THE POTENTIAL FOR CONTACT BETWEEN THE B2 (BATTERY), A2 (ACCESSORY), AND P1 (PROOF) CIRCUITS CAN OCCUR, CREATING A SHORT CIRCUIT, ALLOWING CURRENT TO FLOW THROUGH THE GROUND WIRE.

Consequence & remedy

Consequence: THIS CAN CAUSE OVER HEATING AND THE POTENTIAL FOR A VEHICLE FIRE.

Remedy: DEALERS WILL INSTALL A JUMPER HARNESS WITH A RELAY WHICH WILL RE-ROUTE AND ACTIVATE ALL A2 ACCESSORIES THROUGH THE RELAY.

97V204000 · Power Train:transfer Case (4-WHEEL Drive)

Nov 13, 1997

VEHICLE DESCRIPTION: ALL WHEEL DRIVE PASSENGER MINIVANS. THESE VEHICLES CAN DEVELOP POWERTRAIN BENDING RESONANCE OR TRANSFER CASE OUTPUT SHAFT BUSHING DISPLACEMENT. THE POWERTRAIN BENDING RESONANCE OR THE OUTPUT SHAFT BUSHING DISPLACEMENT CAN RESULT IN STRUCTURAL FAILURE OF THE TRANSMISSION AND/OR TRANSFER CASE. FLUID EXPLUSION, DRIVESHAFT SEPARATION OR LOSS OF VEHICLE DRIVE CAN RESULT.

Consequence & remedy

Consequence: THIS CONDITION CAN CAUSE A LOSS OF VEHICLE CONTROL, AND, IF THE EXPELLED FLUID CONTACTS THE EXHAUST SYSTEM, A VEHICLE FIRE COULD OCCUR.

Remedy: DEALERS WILL INSTALL A NEW TRANSFER CASE REAR OUTPUT SHAFT BUSHING AND AN ALUMINUM DRIVESHAFT WILL BE INSTALLED.

95V037000 · Equipment:other:labels

Feb 28, 1995

THE CERTIFICATION LABEL ON THESE VEHICLES HAVE INCORRECT REAR TIRE SIZES LISTED. P215/70R14SL SHOULD BE P215/75R14SL. THIS DOES NOT COMPLY WITH FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."

Consequence & remedy

Consequence: CONSEQUENCE OF NON-COMPLIANCE: THE INCORRECTLY SIZED REAR TIRE WOULD NOT HAVE SUFFICIENT LOAD CAPACITY FOR THE VEHICLE'S SPECIFIED GROSS AXLE WEIGHT RATING, INCREASING THE POTENTIAL FOR PREMATURE TIRE FAILURE.

Remedy: OWNERS WILL BE MAILED A SUPPLEMENTARY LABEL CONTAINING THE CORRECT REAR TIRE INFORMATION AND INSTRUCTIONS FOR INSTALLING THE LABEL ON THEIR VEHICLES. IF OWNERS PREFER, THEIR DEALER CAN INSTALL THE LABEL FOR THEM.

94V239000 · Equipment:mechanical:carrier/rack

Dec 1, 1994

THE SPARE TIRE SUPPLIED WITH THE VEHICLE CAN CONTACT THE BRAKE LINES ON THE REAR AXLE IF IT IS MOUNTED IN THE UNDERBODY SPARE TIRE CARRIER. SUCH CONTACT COULD RESULT IN FRACTURE OF A REAR BRAKE LINE.

Consequence & remedy

Consequence: THIS CAN RESULT IN REDUCED VEHICLE BRAKE CAPABILITY.

Remedy: DEALERS WILL INSTALL A LOWER PROFILE MINI-SPARE TIRE ON THE EXISTING MINI-SPARE WHEEL. THE NEW TIRE WILL ALLOW THE MINI-SPARE TO BE INSTALLED WITH APPROPRIATE CLEARANCES IN THE UNDERBODY SPARE TIRE CARRIER.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗