Electrical SystemEngine And Engine CoolingLatches/locks/linkages
TL*THE CONTACT OWNS A 1992 FORD AEROSTAR. UPON PURCHASING THE VEHICLE, THE CONTACT STATED THAT THE MUFFLER WAS RUSTED AND CRACKED. THE DEALER STATED THAT THE VEHICLE WAS FINE AND THE FUMES WOULD EXIT OUT OF THE REAR OF THE VEHICLE. THE FIRE DEPARTMENT STATED THAT THE FUMES WERE ENTERING THE VEHICLE DUE TO THE HOLES. THE DEAL…
Read full complaint
TL*THE CONTACT OWNS A 1992 FORD AEROSTAR. UPON PURCHASING THE VEHICLE, THE CONTACT STATED THAT THE MUFFLER WAS RUSTED AND CRACKED. THE DEALER STATED THAT THE VEHICLE WAS FINE AND THE FUMES WOULD EXIT OUT OF THE REAR OF THE VEHICLE. THE FIRE DEPARTMENT STATED THAT THE FUMES WERE ENTERING THE VEHICLE DUE TO THE HOLES. THE DEALER STATED THAT THEY SEALED THE HOLES AND THE VEHICLE WAS FINE. THE MIDAS MECHANIC STATED THAT THE DEALER NEVER SEALED THE HOLES ON THE MUFFLER AND IT NEEDED TO BE REPLACED COMPLETELY. HE ALSO STATED THAT THE FUMES COULD IN FACT GET INSIDE THE PASSENGER COMPARTMENT. ALSO, THE HORN HAS NEVER WORKED ON THE VEHICLE SINCE IT WAS PURCHASED; THEREFORE, THE DEALER CONSTRUCTED THEIR OWN HORN TO CORRECT THE FAILURE. THE SLIDING DOOR ON THE VEHICLE WOULD NOT OPEN AND THE VEHICLE WOULD NOT UNLOCK FROM THE PASSENGER COMPARTMENT. IN ADDITION, THE REAR LIFTGATE FELL ON THE CONTACT'S HEAD SEVERAL TIMES. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #10239623
Mileage unknown · Oct 20, 2000
StructureInjury
CONSUMER WAS REMOVING ITEMS FROM THE REAR CARGO AREA AND LIFTGATE CAME SLAMMING DOWN ON CONSUMER'S HEAD. TOOK TO DEALER, AND THEY SAID SHOCKS NEED TO BE REPLACED.*AK DUE TO INCIDENT, CERVICAL DISCS IN CONSUMER'S NECK WERE HERNIATED, BOTH DISCS HAD TO BE REPLACED, CONSUMER HAS PERMANENT AND LIMITED CAPACITY. *SLC
NHTSA ODI #873500
Mileage unknown · Jun 20, 1999
Structure
RIGHT SIDE SLIGHT DOOR FAILED. NLM
NHTSA ODI #547380
Mileage unknown · Apr 12, 1999
Electrical SystemStructure
RECALL ON THE IGNITION SWITCH (99V-029) NOT COMPLETED DUE TO LACK OF PARTS. MJS
NHTSA ODI #544961
Mileage unknown · Feb 5, 1999
Structure
SIDE PANEL SLIDING DOOR IS STUCK SHUT. CONSUMER SAYS THAT THE CHILDREN SHUT THE DOOR, AND IT WON'T OPEN NO MORE. DEALER HAS BEEN CONTACTED. *AK
NHTSA ODI #834539
Mileage unknown · Jan 12, 1999
Structure
WHILE OPENING THE SLIDING DOOR OF THE VAN THE DOOR CAME OFF TRACK AND FELL APART. MECHANIC PUT DOOR BACK ON TRACK. *AK
NHTSA ODI #833408
Mileage unknown · Dec 30, 1997
Structure
VEHICLE EXPERIENCING THE SAME FAILURES AS SERVICE BULLETIN 96-10-13 REGARDING THE LEFT REAR TIRE RUBBING ON THE WHEELHOUSE INNER PANEL CAUSING FAILURE. *YC
NHTSA ODI #527387
Mileage unknown · Oct 8, 1997
Electrical SystemEngine And Engine CoolingEquipment
AIR CONDITIONING COMPRESSOR MALFUNCTIONED. IN ADDITION, NOISY ABS BRAKES/DEFECTIVE FRONT/REAR CV JOINTS/PREMATURE WEAR OF FRONT BRAKE PADS AND ROTORS/ELECTRIC DOOR LOCKS MALFUNCTIONED/LOWER BALL JOINT NOISE/ RADIATOR HOSE FAILURE AND PREMATURE DISTRIBUTOR/CAP/ROTOR WEAR. *AK
NHTSA ODI #523850
Mileage unknown · Mar 3, 1997
Structure
DOOR ASSEMBLY FAILURE, SLIDING DOOR WILL NOT OPEN FROM INSIDE OR OUTSIDE, IN FOR REPAIR, WILL PROVIDE REPAIR RECEIPT. *AK
NHTSA ODI #809612
Mileage unknown · Sep 24, 1996
Structure
THE SLIDING DOOR ON THE PASSENGER'S SIDE WILL NOT OPEN AND THE HATCHBACK WILL NOT OPEN ALSO.*AK
VEHICLE DESCRIPTION: ALL WHEEL DRIVE PASSENGER MINIVANS. (THIS INCLUDES ALL 1992 AWD AEROSTARS NOT PREVIOUSLY INCLUDED IN SAFETY RECALL 97V-204/97S83). THESE VEHICLES CAN DEVELOP POWERTRAIN BENDING RESONANCE OR TRANSFER CASE OUTPUT SHAFT BUSHING DISPLACEMENT. THE POWERTRAIN BENDING RESONANCE OR THE OUTPUT SHAFT BUSHING DISPLACEMENT CAN RESULT IN STRUCTURAL FAILURE OF THE TRANSMISSION AND/OR TRANSFER CASE. FLUID EXPLUSION, DRIVESHAFT SEPARATION OR LOSS OF VEHICLE DRIVE CAN RESULT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE A LOSS OF VEHICLE CONTROL, AND, IF THE EXPELLED FLUID CONTACTS THE EXHAUST SYSTEM, A VEHICLE FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW TRANSFER CASE REAR OUTPUT SHAFT BUSHING AND AN ALUMINUM DRIVESHAFT WILL BE INSTALLED.
VEHICLE DESCRIPTION: MINI VANS. THESE VEHICLES WERE PRODUCED WITH A HIGHER THAN SPECIFIED ELECTRICAL LOAD THROUGH THE ACCESSORY POWER FEED CIRCUIT. THE POTENTIAL FOR CONTACT BETWEEN THE B2 (BATTERY), A2 (ACCESSORY), AND P1 (PROOF) CIRCUITS CAN OCCUR, CREATING A SHORT CIRCUIT, ALLOWING CURRENT TO FLOW THROUGH THE GROUND WIRE.
Consequence & remedy
Consequence: THIS CAN CAUSE OVER HEATING AND THE POTENTIAL FOR A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL A JUMPER HARNESS WITH A RELAY WHICH WILL RE-ROUTE AND ACTIVATE ALL A2 ACCESSORIES THROUGH THE RELAY.
VEHICLE DESCRIPTION: ALL WHEEL DRIVE PASSENGER MINIVANS. THESE VEHICLES CAN DEVELOP POWERTRAIN BENDING RESONANCE OR TRANSFER CASE OUTPUT SHAFT BUSHING DISPLACEMENT. THE POWERTRAIN BENDING RESONANCE OR THE OUTPUT SHAFT BUSHING DISPLACEMENT CAN RESULT IN STRUCTURAL FAILURE OF THE TRANSMISSION AND/OR TRANSFER CASE. FLUID EXPLUSION, DRIVESHAFT SEPARATION OR LOSS OF VEHICLE DRIVE CAN RESULT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE A LOSS OF VEHICLE CONTROL, AND, IF THE EXPELLED FLUID CONTACTS THE EXHAUST SYSTEM, A VEHICLE FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW TRANSFER CASE REAR OUTPUT SHAFT BUSHING AND AN ALUMINUM DRIVESHAFT WILL BE INSTALLED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5
PE02076 · Luggage Compartment Door Drops Abruptly
Opened Oct 10, 2002 · Closed Mar 10, 2003
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
ODI HAS IDENTIFIED 30 INCIDENTS RESULTING IN MINOR TO MODERATE PERSONAL INJURIES THAT HAVE BEEN CAUSED BY ABRUPT DOOR DROPS OVER THE APPROXIMATELY EIGHT - TWELVE YEAR PERIOD OF PRODUCT USAGE AND EXPOSURE (1991-1995 TO 2003).MOST OF THE INJURY INCIDENTS APPEAR TO HAVE BEEN CAUSED BY A FRACTURE OF THE GAS FILLED LIFT ASSIST CYLINDER MOUNTING STUD.STUD FRACTURES HAVE OCCURRED RANDOMLY OVER TIME AND DO NOT EXHIBIT ANY APPARENT TREND RELATING TO DATE OF VEHICLE PRODUCTION OR TIME-IN-SERVICE (EXPOSURE).THE ODI CLOSING REPORT SUMMARIZES THE DETAILS OF THIS INVESTIGATION.
PE99035 · Front Brake Hose
Opened May 12, 1999 · Closed Sep 23, 1999
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
ALLEGED THAT A FRONT BRAKE HOSE RUPTURES OR FAILS AT THE INTERFACE BETWEEN THE RUBBER HOSE AND THE BRASS FITTING
EA99002 · Transfer Cases And Rear Drive Shaft
Opened Jan 7, 1999 · Closed Nov 14, 2000
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
RQ98012 · Transfer Cases And Rear Driveshaft
Opened Jul 31, 1998 · Closed Jan 7, 1999
Status: closed (inferred from source dates) · Power Train:transfer Case (4-WHEEL Drive)
There is no summary currently available
RQ97015 · Parking Pawl
Opened Oct 29, 1997 · Closed Apr 1, 1999
Status: closed (inferred from source dates) · Power Train:automatic Transmission
WHEN THE AUTOMATIC SHIFT LEVER IS PLACED IN THE PARK POSITION, THE PARKING PAWL DOES NOT ALWAYS ENGAGE THE PARK GEAR.THIS CAN LEAD TO THE VEHICLE JUMPING OUT OF GEAR UNINTENTIONALLY AND CAUSE THE VEHICLE TO START ROLLING INADVERTENTLY
1992 Ford Aerostar Problems, Complaints & Recalls | Skip That Year
Illustration