IllustrationCONSUMER IS STILL HAVING PROBLEMS WITH FUEL TANK LEAKING AFTER RECALL 98V190000 REPAIRS WERE DONE. CONSUMER SMELLS GAS FUMES INSIDE VEHICLE . *AK *NM
1988 Ford Aerostar
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1988 Ford Aerostar do not stand out strongly from the model-year median of 135.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Aerostar years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 8 of 177 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 52 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Seat Belts. Review the 28 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports41 fire reports5 injury reports
What owners actually said
177 reportsTHE VAN WAS UNABLE TO PASS STATE INSPECTION DUE TO A GAS LEAK FROM THE TOP OF THE FUEL TANK. THERE WAS A FUEL TANK CRACK RECALL, BUT THE VEHICLE IDENTIFICATION NUMBER WAS OUTSIDE THE REMEDY SCOPE. *JB *MR *NM
GAS TANK WAS RECALLED 12/98 UNDER 98MO3. GAS TANK DID DEVELOP CRACKS AND WAS REPLACED BY FORD IN 8/01. REPLACEMENT GAS TANK DEVELOPED CRACKS IN 9/03. THE LOCAL FORD DEALERSHIP THAT PERFORMED ORIGINAL WARRANTY WORK STATES THE REPLACEMENT GAS TANK HAS FAILED BECAUSE OF MANUFACTURER'S DEFECT. BUT FORD REFUSES TO REPLACE GAS TAN…
Read full complaint
GAS TANK WAS RECALLED 12/98 UNDER 98MO3. GAS TANK DID DEVELOP CRACKS AND WAS REPLACED BY FORD IN 8/01. REPLACEMENT GAS TANK DEVELOPED CRACKS IN 9/03. THE LOCAL FORD DEALERSHIP THAT PERFORMED ORIGINAL WARRANTY WORK STATES THE REPLACEMENT GAS TANK HAS FAILED BECAUSE OF MANUFACTURER'S DEFECT. BUT FORD REFUSES TO REPLACE GAS TANK AGAIN, EVEN KNOWING THEIR LOCAL DEALERSHIP STATES THIS IS A FORD PRODUCT DEFECT. BASICALLY, FORD REALIZED IT HAD A DEFECTIVE PART (GAS TANK), OFFERED A REMEDY TO FIX THE DEFECTIVE PART, BUT THE REMEDY FAILED IN THE SAME WAY AS THE ORIGINAL DEFECTIVE PART. FORD SAYS IT IS NO LONGER THEIR RESPONSIBILITY.
I WAS TOLD NOTHING WAS WRONG WITH THE TRUCK AND THAT I COULD GET IN IT AND DRIVE TO FLORIDA RIGHT NOW. WELL IT HASN'T EVEN BEEN TWO WEEKS SINCE I HAVE HAD THE TRUCK AND SO FAR THE SHOCK MOUNT IS BUSTED (WAS BROKE BEFORE I EVEN BOUGHT THE TRUCK) VALVE COVER GASKETS ARE LEAKING, POWER STEERING BOX BLEW OUT AND THE FLOOR OF THE TRU…
Read full complaint
I WAS TOLD NOTHING WAS WRONG WITH THE TRUCK AND THAT I COULD GET IN IT AND DRIVE TO FLORIDA RIGHT NOW. WELL IT HASN'T EVEN BEEN TWO WEEKS SINCE I HAVE HAD THE TRUCK AND SO FAR THE SHOCK MOUNT IS BUSTED (WAS BROKE BEFORE I EVEN BOUGHT THE TRUCK) VALVE COVER GASKETS ARE LEAKING, POWER STEERING BOX BLEW OUT AND THE FLOOR OF THE TRUCK IN THE CAB IS ALL ROTTTED AWAY. THERE IS A HUGE HOLE ON THE DRIVERS SIDE TO WHERE I COULD PUT BOTH MY LEGS THROUGH AND HE WOULDN'T GIVE ME MY MONEY BACK FOR THE VEHICLE. I TOOK PHOTOS OF ALL THIS TO PROVE MY DEFECTS OF THE TRUCK.
THE CONSUMER STATED SHE NEVER RECEIVED THE RECALL NOTICE # 98V190000. THE RECALL WAS IN REFERENCE TO THE UPPER PORTION OF THE FUEL TANK CRACKING. THE DEALER STATED THIS RECALL EXPIRED ON MARCH 31/02 AND WILL NOW COST $700.00 TO FIX IT. *NLM
TRUCK EXPERIENCED ELECTRICAL SYSTEM FAILURE. AS A RESULT THE TRUCK CAUGHT ON FIRE WITHIN TWO HOURS AFTER BEING PARKED. THE FIRE ORIGINATED UNDER THE HOOD. ALL THE UNDER HOOD ELECTRICAL COMPONENTS WERE MELTED. THE HEAT ALSO CRACKED THE WINDSHIELD.*AK
GAS TANK DEFECT STATED IN RECALL 98V190000 OCCURRED AFTER THE RECALL REPAIRS WERE PERFORMED.*AK
THE ELECTRICAL SYSTEM FAILED AND CAUSED THE IGNITION SWITCH TO BE INOPERATIVE. THE DEALER WAS NOTIFIED. *AK *SCC *NLM
NHTSA#8767-98-V-190-000 FUEL TANK CRACKS: CONSUMER STATES CAN SMELL STRONG CHEMICAL FUMES THROUGHOUT OUT THE VEHICLE. MR HERRERA. DEALER WILL REPLACE THE FUEL TANK REGARDLESS OF MILEAGE THROUGH MARCH 31, PLEASE PROVIDE FURTHER INFORMATION. TS
THE BRAKE PEDAL WENT DOWN WHEN THE BRAKE WAS APPLIED. ALSO THE MASTER CYLINDER RESERVOIR HAD TO BE TOPPED UP CONSTANTLY DUE TO BRAKE FLUID DRIPPING FROM A CRACK IN THE BRAKE HOSE. THE MECHANIC EXAMINED A SIMILAR FORD AEROSTAR 1990 AND STATED THAT THE PROBLEM WAS THE SAME LIKE THE 1988 FORD AEROSTAR.( WRITTEN IN BY A PROFFESSION…
Read full complaint
THE BRAKE PEDAL WENT DOWN WHEN THE BRAKE WAS APPLIED. ALSO THE MASTER CYLINDER RESERVOIR HAD TO BE TOPPED UP CONSTANTLY DUE TO BRAKE FLUID DRIPPING FROM A CRACK IN THE BRAKE HOSE. THE MECHANIC EXAMINED A SIMILAR FORD AEROSTAR 1990 AND STATED THAT THE PROBLEM WAS THE SAME LIKE THE 1988 FORD AEROSTAR.( WRITTEN IN BY A PROFFESSIONAL MECHANIC)*YH
Official recalls
498V190000 · Fuel System, Gasoline:storage:tank Assembly
Aug 11, 1998
VEHICLE DESCRIPTION: MINI VANS ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA (10 SOUTHERN COUNTIES OF LOS ANGELES, ORANGE, SAN BERNADINO, SAN DIEGO, RIVERSIDE, VENTURA, SANTA BARBARA, SAN LUIS OBISPO, IMPERIAL, AND KERN), FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NEVADA (CLARK COUNTY), OKLAHOMA, SOUTH CAROLINA, AND TEXAS, AND IN THE U.S. TERRITORIES COVERED BY THE FEDERAL STATUTES. THE UPPER PORTION OF THE FUEL TANK CAN DEVELOP SMALL CRACKS DUE TO EXTENDED EXPOSURE TO VERY HIGH AMBIENT TEMPERATURES. FUEL VAPOR OR LEAKAGE COULD OCCUR AT THESE CRACKS.
Consequence & remedy
Consequence: IF AN IGNITION SOURCE IS PRESENT, A FIRE COULD RESULT.
Remedy: DEALERS WILL REPLACE THE FUEL TANK, REGARDLESS OF MILEAGE, THROUGH MARCH 31, 2002. THIS COVERAGE WILL ONLY BE FOR STRUCTURAL CRACKS AT THE TOP OF THE TANK AND WILL NOT INCLUDE OTHER DAMAGE CAUSED BY AN ACCIDENT OR ROAD DEBRIS.
96V071000 · Electrical System:ignition
Apr 25, 1996
THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE IGNITION SWITCH.
91V136000 · Structure:body:hatchback/liftgate:support Device/strut
Aug 19, 1991
SOME LIFTGATE GAS CYLINDER-TO-BODY ATTACHMENT BALL STUDS MAY FRACTURE IN EITHER THE OPEN OR CLOSED POSITION.
Consequence & remedy
Consequence: IF A BALL STUD FRACTURES, THE LIFTGATE WILL NOT REMAIN INTHE OPEN POSITION. BODILY INJURY COULD RESULT IF THE LIFTGATE DROPS WHILESOMEONE IS UNDER IT.
Remedy: REPLACE THE GAS CYLINDER-TO-BODY ATTACHMENT BALL STUDS.
88V091000 · Electrical System:wiring
Jun 6, 1988
VEHICLES EQUIPPED WITH TRAILER TOW PACKAGE HAVE A TRAILER TAILLIGHT RELAY ASSEMBLY THAT CONTAINS WIRES OF SMALLER GAUGE THAN THE FUSE LINK WHICH PROTECTS THE CIRCUIT.
Consequence & remedy
Consequence: SHOULD A SHORT CIRCUIT OCCUR IN THE WIRING WITHIN THERELAY OR IF WATER INTRUSION OCCURS THE SMALLER GAUGE WIRE IN THE RELAY WILLFUNCTION AS A FUSE LINK AND OVERHEAT. THE POSSIBILITY EXISTS FOR A FIRE IF THEWIRES ARE EXPOSED TO COMBUSTIBLE MATERIALS.
Remedy: INSTALLATION OF A RELAY WITH WIRES OF GAUGE ADEQUATE TO PROTECT THE CIRCUIT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
12EA96030 · Cracked Fuel Tanks
Opened Dec 20, 1996 · Closed Aug 13, 1998
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
CRACKED FUEL TANKS ARE LEAKING FUEL
PE96050 · Cracked Fuel Tanks
Opened Aug 6, 1996 · Closed Dec 20, 1996
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
CRACKED FUEL TANKS ARE LEAKING FUEL
EA94025 · Seat Belt Buckle Failure
Opened Jul 19, 1994 · Closed Sep 30, 1997
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
There is no summary currently available
PE94021 · Seat Belt Buckle Failure
Opened Mar 4, 1994 · Closed Jul 19, 1994
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
There is no summary currently available
PE91127 · Park Pawl Bending
Opened Sep 16, 1991 · Closed Nov 8, 1991
Status: closed (inferred from source dates) · Power Train:automatic Transmission
There is no summary currently available
Additional source detail variants (2)
Power Train:automatic Transmission
There is no summary currently available
Power Train:automatic Transmission
There is no summary currently available
EA91015 · Liftgate Failure
Opened Feb 1, 1991 · Closed Sep 20, 1991
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE91005 · Liftgate Failure
Opened Oct 18, 1990 · Closed Feb 1, 1991
Status: closed (inferred from source dates) · Structure
There is no summary currently available
EA90042 · Throttle Sticking
Opened Aug 31, 1990 · Closed Dec 31, 1991
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA89021 · Windshield Wiper Motor
Opened Mar 23, 1989 · Closed May 4, 1990
Status: closed (inferred from source dates) · Visibility
===
PE89092 · Power Steering Locking
Opened Feb 23, 1989 · Closed Jul 20, 1989
Status: closed (inferred from source dates) · Steering
SUMMARY:THE COMPLAINTS ALLEGE THAT POWER STEERING WAS STIFF ORSTEERING LOCKED.FORD HAS ISSUED TWO SERVICE BULLETINS:ONE ON LEAKINGSEALS AND ONE ON COMPLAINTS OF STIFF STEERING.===
PE89021 · Seat Belt Cutting
Opened Dec 9, 1988 · Closed Aug 3, 1989
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
PE89010 · Windshield Wiper Motor
Opened Nov 1, 1988 · Closed Mar 23, 1989
Status: closed (inferred from source dates) · Visibility
There is no summary currently available