IllustrationRETURNED FROM 75 MILE TRIP, RIGHT REAR BRAKE AND WHEEL LINER VERY HOT AND SMELL OF BRAKE BURNING. *TR
2003 Fleetwood Southwind
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Southwind years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
100–25K
1025–50K
250–75K
075–100K
0100–150K
0150K+
22 reports with mileage · 2 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Equipment. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Air. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports1 fire reports0 injury reports
What owners actually said
24 reportsAFTER 75 MILE TRIP, RIGHT REAR WHEEL WAS HOT AND SMOKING, NO LOSS OF BRAKING, RETURN TRIP 8 DAYS LATER NO PROBLEM. *TR
AFTER 100 MILE TRIP, LOST BRAKING ON MY MOTORHOME, WITH THE SMELL OF BRAKE BURNING, WHILE STOPPED IN TRAFFIC, BRAKE PEDAL WENT TO THE FLOOR. REAR WHEEL LINERS BOTH SIDES WERE TOO HOT TO TOUCH. AFTER ABOUT 30 MINUTES, BRAKE FLUID COOLED OFF AND BRAKING RETURNED. RETURN TRIP OF 100 MILES 3 DAYS LATER WITH NO PROBLEMS. *TR
AFTER 90 MILE TRIP, LOST BRAKING ON MY MOTORHOME, WITH THE SMELL OF BRAKE BURNING, BRAKE PEDAL AT THE FLOOR. REAR WHEEL LINERS BOTH SIDES WERE TOO HOT TO TOUCH. AFTER ABOUT 30 MINUTES, BRAKE FLUID COOLED OFF AND BRAKING RETURNED. RETURN TRIP OF 90 MILES 2 DAYS LATER WITH NO PROBLEMS. *TR
TL*THE CONTACT OWNS A 2003 FLEETWOOD SOUTHWIND RV. ON MAY 15, 2007, THE VEHICLE WAS REPAIRED ACCORDING TO A RECALL FOR THE DOMETIC REFRIGERATOR. RECENTLY, WHEN THE CONTACT OPENED THE REFRIGERATOR, HE NOTICED THAT IT FAILED AND WAS WARM INSIDE. HE WENT TO SERVICE THE UNIT LOCATED OUTSIDE OF THE VEHICLE AND NOTICED A YELLOW SUB…
Read full complaint
TL*THE CONTACT OWNS A 2003 FLEETWOOD SOUTHWIND RV. ON MAY 15, 2007, THE VEHICLE WAS REPAIRED ACCORDING TO A RECALL FOR THE DOMETIC REFRIGERATOR. RECENTLY, WHEN THE CONTACT OPENED THE REFRIGERATOR, HE NOTICED THAT IT FAILED AND WAS WARM INSIDE. HE WENT TO SERVICE THE UNIT LOCATED OUTSIDE OF THE VEHICLE AND NOTICED A YELLOW SUBSTANCE INSIDE THE SERVICE DEPARTMENT OF THE VEHICLE. HE ALSO SMELLED AMMONIA. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT THE LINES FAILED THAT WERE CONNECTED TO THE UNIT, WHICH CAUSED AMMONIA TO LEAK OUT. THE REFRIGERATOR WAS REPLACED AT THE COST OF $1,914.35. THE MANUFACTURER STATED THAT NO COMPENSATION WOULD BE MADE BECAUSE THE WARRANTY WAS EXPIRED. THE NHTSA CAMPAIGN ID NUMBER AND REFRIGERATOR INFORMATION WERE UNKNOWN. THE FAILURE MILEAGE WAS 50,800 AND CURRENT MILEAGE WAS 56,373. UPDATED 08/04/09. *LJ THE CONSUMER STATED THE REFRIGERATOR LEAKED AMMONIA. UPDATED 08/06/09.*JB
COMING THROUGH MOUNTAINS IN PENNSYLVANIA, THE MILLAGE WAS ABOUT 25000. RIGHT REAR BRAKE LOCKED AND OVERHEATED. I WAS NOT RIDING THE BRAKES, ONLY RIGHT REAR BRAKE LOCKED UP. I HAD A SIMILAR PROBLEM WITH BOTH FRONT BRAKES WITH MILLAGE AT 18000 OR SO. *TR
BRAKE FAILURE ON A 2003 FLEETWOOD WORKHORSE CHASSIS MOTORHOME. PEDAL GOES TO THE FLOOR. *TR
LED CLUSTER ON DASH FADED AND BECAME UNREADABLE. COULD NOT READ THE GEAR THE VEHICLE WAS IN, E.G. PARK, REVERSE, OR DRIVE, MILEAGE, AND TRIP MILEAGE WAS ALSO UNREADABLE, BUT DID NOT CREATE SAFETY ISSUE. *TR
TL*THE CONTACT OWNS A 2003 FLEETWOOD SOUTH WIND. THE CONTACT NOTICED THAT THE TRAILER HITCH PUSHED UP INTO HIS COACH. AS A RESULT, THE HITCH CRUSHED THE FIBERGLASS. UPON INSPECTION, HE FOUND THAT THE BOTTOM PART OF THE HITCH WELD HAD NOT PENETRATED THE STEEL. THERE IS A SAFETY RECALL FOR THE TRAILER HITCHES (NHTSA CAMPAIGN I…
Read full complaint
TL*THE CONTACT OWNS A 2003 FLEETWOOD SOUTH WIND. THE CONTACT NOTICED THAT THE TRAILER HITCH PUSHED UP INTO HIS COACH. AS A RESULT, THE HITCH CRUSHED THE FIBERGLASS. UPON INSPECTION, HE FOUND THAT THE BOTTOM PART OF THE HITCH WELD HAD NOT PENETRATED THE STEEL. THERE IS A SAFETY RECALL FOR THE TRAILER HITCHES (NHTSA CAMPAIGN ID 04V352000). THE CURRENT MILEAGE WAS 24,000 AND FAILURE MILEAGE WAS 17,000. THE VEHICLE PURCHASE DATE WAS UNAVAILABLE.
TL*THE CONTACT OWNS A 2003 FLEETWOOD SOUTHWIND W22. ON JULY 3 2007, WHILE DRIVING 45 MPH, THE FRONT PASSENGER SIDE OF THE VEHICLE SHOOK. THE CONTACT SMELLED SOMETHING BURNING AND PULLED OVER TO THE SIDE OF THE ROAD. HE NOTICED THAT THE BRAKE CALIPER LOCKED. THE FAILURE WAS REPAIRED AT THE COST OF $837. ON FEBRUARY 1, 2008, …
Read full complaint
TL*THE CONTACT OWNS A 2003 FLEETWOOD SOUTHWIND W22. ON JULY 3 2007, WHILE DRIVING 45 MPH, THE FRONT PASSENGER SIDE OF THE VEHICLE SHOOK. THE CONTACT SMELLED SOMETHING BURNING AND PULLED OVER TO THE SIDE OF THE ROAD. HE NOTICED THAT THE BRAKE CALIPER LOCKED. THE FAILURE WAS REPAIRED AT THE COST OF $837. ON FEBRUARY 1, 2008, THE DRIVER'S SIDE CALIPER ALSO FAILED. THE CONTACT PULLED OVER AND WAITED UNTIL THE CALIPER RELEASED. SHE THEN DROVE THE VEHICLE TO THE DEALER AND THEY REPAIRED THE FAILURE AT THE COST OF $873. THE MANUFACTURER WAS NOTIFIED. THE CURRENT MILEAGE WAS 25,722 AND FAILURE MILEAGE WAS 24,162. UPDATED 03-11-08 *BF
Official recalls
809V312000 · Equipment
Jul 28, 2009
FLEETWOOD RV IS RECALLING CERTAIN MODEL YEAR 2005 AND 2006 MOTORHOMES MANUFACTURED BETWEEN JULY 24, 2004 AND MARCH 11, 2005, EQUIPPED WITH NORCOLD MODEL 1200LR, 1200LRIM, AND 1201LRIM REFRIGERATORS WITH SERIAL NUMBERS BETWEEN 1273701 AND 1536607, NON-CONSECUTIVELY. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK. IF A LEAK OCCURS AND THE REFRIGERATOR CONTINUES TO BE OPERATED AFTER SOLUTION CIRCULATION HAS CEASED THE HEAT SOURCE COULD GENERATE VERY HIGH TEMPERATURES. AT SUCH HIGH TEMPERATURES, THE COOLING UNIT COULD RUPTURE.
Consequence & remedy
Consequence: IF A LEAK OCCURS AND THE UNIT IS CONTINUES TO OPERATE, HYDROGEN GAS MAY BE EXPELLED AND CAN BE IGNITED, RESULTING IN A FIRE, POSSIBLY CAUSING SERIOUS INJURY OR DEATH.
Remedy: FLEETWOOD RV WILL NOTIFY OWNERS AND THE VEHICLE'S REFRIGERATOR WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING SEPTEMBER 2009. OWNERS MAY CONTACT FLEETWOOD RV AT 1-800-509-3418 OR NORCOLD'S RECALL CENTER AT 1-800-767-9101.
09V198000 · Service Brakes, Air
Jun 2, 2009
FLEETWOOD IS RECALLING 509 MY 2001-2008 CLASS A MOTOR HOMES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.
Consequence & remedy
Consequence: THE DRIVER WOULD NORMALLY DETECT THE BRAKE DRAG BUT IF UNDETECTED THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS FREE OF CHARGE. WORKHORSE IS HANDLING THE REMEDY FOR THIS CAMPAIGN PLEASE SEE 09V-110. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731. WORKHORSE WILL CONDUCT THE OWNER AND DEALER NOTIFICATION.
08V320000 · Equipment:recreational Vehicle/trailer
Jul 15, 2008
FLEETWOOD IS RECALLING 70,101 MY 2003-2007 SOUTHWIND, PACE ARROW, BOUNDER, FLAIR, STORM, FIESTA, TERRA GAS CLASS A MOTOR HOMES; BOUNDER, DISCOVERY, PROVIDENCE, EXCURSION, EXPEDITION, REVOLUTION, AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION DIESEL CLASS A MOTOR HOMES; JAMBOREE TIOGA CLASS C MOTOR HOMES; AND PROWLER, WILDERNESS, TERRY, MALLARD, PIONEER, PRIDE AND TRIUMPH CONVENTIONAL AND FIFTH WHEEL TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATORS MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Consequence & remedy
Consequence: IF THIS SOLUTION IS EXPOSED TO AN IGNITION SOURCE UNDER CERTAIN SPECIFIC CIRCUMSTANCES, IT CAN RESULT IN A VEHICLE FIRE.
Remedy: FLEETWOOD IS WORKING WITH DOMETIC TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR FLEETWOOD AT 1-800-322-8216.
07V120000 · Equipment:recreational Vehicle/trailer
Mar 19, 2007
CERTAIN MOTOR HOMES AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Consequence & remedy
Consequence: RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.
Remedy: FLEETWOOD WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST YOU IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR FLEETWOOD AT 1-800-322-8216.
06V115000 · Electrical System
Apr 12, 2006
CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH ACTIA CORPORATE INSTRUMENT CLUSTERS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 101 "CONTROLS AND DISPLAYS" AND NO. 105 "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." IF THE BRAKE FAIL INPUT FALLS BELOW A VOLTAGE OF 1.5V, THE BRAKE FAILURE LAMP AND ALARM WILL BE ACTIVATED. ALSO ACTIVATION OF THE ABS TELLTALE WHEN THE ABS IS NOT PROPERLY FUNCTIONING DOES NOT ALWAYS OCCUR.
Consequence & remedy
Consequence: AT NIGHT THE INSTRUMENT CLUSTER LIGHTS MAY FAIL AND THE DRIVER MAY NOT BE ABLE TO SEE THE INSTRUMENT PANEL GAUGES AND THE BRAKE WARNING LIGHT INDICATOR WHICH COULD INCREASING THE RISK OF A CRASH.
Remedy: WORKHORSE IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN AND REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731 OR FLEETWOOD AT 1-800-322-8216.
04V352000 · Trailer Hitches
Jul 20, 2004
CERTAIN MOTOR HOMES EQUIPPED WITH DRAW TITE HITCH RECEIVERS MAY BE MISSING ONE OR MORE WELDS BETWEEN THE HITCH RECEIVER BOX AND THE BOTTOM SUPPORT PLATE.
Consequence & remedy
Consequence: THE WELDS COULD BREAK, ALLOWING THE HITCH RECEIVER BOX AND THE TOWED LOAD TO SEPARATE FROM THE TOWING VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE HITCH RECEIVER. THE RECALL IS EXPECTED TO BEGIN DURING AUGUST 2004. OWNERS SHOULD CONTACT FLEETWOOD AT 1-800-322-8216.
03V452000 · Equipment:recreational Vehicle/trailer
Nov 4, 2003
ON CERTAIN TRAVEL TRAILERS EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE OVENS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.
Consequence & remedy
Consequence: AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.
Remedy: SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 800-932-3837 OR FLEETWOOD AT 1-800-629-8454.
03V344000 · Equipment:mechanical:integrated Jack/leveler/stabilizer
Sep 16, 2003
ON CERTAIN MOTORHOMES BUILT ON WORKHORSE CHASSIS, THE HYDRAULIC HOSE OPERATING THE LEVELING JACK SYSTEM WAS ROUTED SO IT PLACES THE HOSE TOO CLOSE TO THE ENGINE EXHAUST. THE HOT EXHAUST CAN CAUSE THE HYDRAULIC HOSE TO MELT OR ABRADE, RELEASING HYDRAULIC FLUID.
Consequence & remedy
Consequence: IF THE HYDRAULIC FLUID SHOULD IGNITE BY AN EXHAUST GAS RECIRCULATING TUBE OR OTHER HEAT SOURCE, THIS COULD CAUSE A FIRE.
Remedy: DEALERS WILL INSPECT AND REPLACE DAMAGED HOSES AND RELOCATE THE AFFECTED HYDRAULIC LINES. OWNER NOTIFICATION IS EXPECTED TO BEGIN OCTOBER 3, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FLEETWOOD AT 1-800-322-8216.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE06005 · Inadvertent SLIDE-OUT Extension Movement
Opened Jan 20, 2006 · Closed May 2, 2006
Status: closed (inferred from source dates) · Equipment:recreational Vehicle/trailer
THIS INVESTIGATION WAS OPENED BASED ON ODI'S RECEIPT OF A CONGRESSIONAL LETTER ON BEHALF OF A CONSTITUENT.THE CONSTITUENT REPORTED INCIDENTS WHERE THE SLIDE OUT ROOM OF HIS MOTOR HOME WOULD INADVERTENTLY MOVE (EXTEND) DURING HIGHWAY USE.ODI WAS CONCERNED THAT A FULLY EXTENDED SLIDE OUT WOULD DEGRADE THE VEHICLE'S DYNAMIC HANDLING CHARACTERISTICS AND/OR POSSIBLY IMPACT AN OBJECT OR ANOTHER VEHICLE, RESULTING IN A CRASH.ODI CONTACTED FLEETWOOD AND DISCOVERED THAT SLIDE OUT ROOMS WERE INSTALLED IN MOTOR HOMES, TRAVEL TRAILERS AND FOLDING TRAILERS. AS PART OF THE INVESTIGATION ODI VISITED A RV SHOW AND THE FLEETWOOD PAXINOS PLANT TO EXAMINE SLIDE OUTS IN VARIOUS NEW MAKE AND MODEL VEHICLES AND GAIN AN UNDERSTANDING OF HOW THE SYSTEMS WORK.DURING THE INVESTIGATION ODI LEARNED THAT THERE ARE TWO METHODS USED TO EXTEND SLIDE OUT ROOMS.SOME MANUFACTURERS USE HYDRAULIC SYSTEMS AND OTHERS, SUCH AS FLEETWOOD, USE AN ELECTRIC MOTOR. (CONTINUED ON PAGE 2)