IllustrationVEHICLE HAS SETUP FOR DUAL SYSTEM BRAKES IN CASE OF A BRAKE LINE FAILURE. MY MASTER CYLINDER DOES NOT HAVE TWO SEPARATE RESERVOIRS SO WHEN I HAD A BRAKE LINE BREAK, WHILE IN MOTION, I LOST ALL THE BRAKES ON THE VEHICLE. THE RESERVOIR HAS SEPARATE TUBING FOR A DUAL SYSTEM.
2002 Fleetwood Southwind
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Southwind years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 4 of 4 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
4 reportsTHE REAR BRAKE CALIPERS WHERE APPLYING BRAKE PRESSURE ON THE BRAKE ROTORS. THIS CAUSED THE BRAKE CALIPER TO GET SO HOT THAT A PART OF THE CALIPER TO MELT AND DROP ON TO THE INSIDE REAR TIRE. THIS CAUSED THE REAR TIRE TO BLOW OUT AND THE OUT SIDE TIRE TO GET SO HOT TO THE TOUCH THAT IT FELT HOT ENOUGH TO THE POINT THAT I THOUGHT …
Read full complaint
THE REAR BRAKE CALIPERS WHERE APPLYING BRAKE PRESSURE ON THE BRAKE ROTORS. THIS CAUSED THE BRAKE CALIPER TO GET SO HOT THAT A PART OF THE CALIPER TO MELT AND DROP ON TO THE INSIDE REAR TIRE. THIS CAUSED THE REAR TIRE TO BLOW OUT AND THE OUT SIDE TIRE TO GET SO HOT TO THE TOUCH THAT IT FELT HOT ENOUGH TO THE POINT THAT I THOUGHT IT WAS GOING TO CATCH FIRE. LUCKY FOR ME THIS HAPPENED JUST AS I WAS RETURNING FROM A WEEK LONG CAMPING TRIP WITH OUR GRAND CHILDREN. I HAD JUST BACKED THE MOTOR HOME INTO MY DRIVE WAY AND AS SOON AS I GOT OUT OF THE COACH I COULD SEE SMOKE COMING FROM THE PASSENGER SIDE REAR TIRES. I GOT MY GARDEN HOSE AND STARTED TO POUR WATER ON THE TIRES TO COOL THEM OFF. THE DRIVER SIDE REAR TIRES WHERE ALSO VERY HOT SO I GOT ANOTHER HOSE AND STARTED POURING WATER ON THEM AS WELL. I LATER FOUND OUT THAT THE BRAKE CALIPERS ON MY MOTOR HOME WHERE ON RECALL BUT I HAD NEVER BEEN NOTIFIED. NOW THE MANUFACTURER WILL NOT REIMBURSE ME THE $ 3,199.00 THAT IT COST ME TO HAVE MY MOTOR HOME REPAIRED.
WE RETURNED FROM A TRIP (DROVE ABOUT 50 MILES) AND PARKED THE VEHICLE IN FRONT OF OUR HOME. WHEN I STARTED IT BACK UP TO TAKE IT BACK TO INDOOR STORAGE, THE SPARK PLUG BLEW OUT OF THE FORD V10 ENGINE AND STRIPPED OUT THE THREADS ON THE CYLINDER HEAD. I HAVE NEVER HEARD OF THIS HAPPENING BEFORE, BUT THE DEALER INDICATED THAT IT…
Read full complaint
WE RETURNED FROM A TRIP (DROVE ABOUT 50 MILES) AND PARKED THE VEHICLE IN FRONT OF OUR HOME. WHEN I STARTED IT BACK UP TO TAKE IT BACK TO INDOOR STORAGE, THE SPARK PLUG BLEW OUT OF THE FORD V10 ENGINE AND STRIPPED OUT THE THREADS ON THE CYLINDER HEAD. I HAVE NEVER HEARD OF THIS HAPPENING BEFORE, BUT THE DEALER INDICATED THAT IT HAPPENS QUITE OFTEN ON THESE EARLIER FORD V10'S. BEFORE FORD CHANGED THE DESIGN OF THE CYLINDER HEADS. I SEARCHED THE INTERNET AND DISCOVERED A SIGNIFICANT NUMBER OF COMPLAINTS REGARDING THIS ISSUE. I JUST WANT TO LOG IN MY ENGINE FAILURE AS YET ANOTHER INCIDENT OF THIS FREQUENT FAILURE. I THINK FORD SHOULD COVER THE REPAIR WHEN IT OCCURS AND CHANGE BOTH CYLINDER HEADS WITH THE NEW DESIGN (IF POSSIBLE) ONCE A VEHICLE EXPERIENCES SPARK PLUG BLOW OUT FAILURE. *TR
2002 FLEETWOOD SOUTHWIND MOTORHOME. HEADLIGHTS ARE CLOUDING OVER. CONSUMER STATES THE CLOUDED LENSES DRASTICALLY REDUCED THE EFFECTIVENESS OF THE HEADLIGHTS. *KB
Official recalls
509V312000 · Equipment
Jul 28, 2009
FLEETWOOD RV IS RECALLING CERTAIN MODEL YEAR 2005 AND 2006 MOTORHOMES MANUFACTURED BETWEEN JULY 24, 2004 AND MARCH 11, 2005, EQUIPPED WITH NORCOLD MODEL 1200LR, 1200LRIM, AND 1201LRIM REFRIGERATORS WITH SERIAL NUMBERS BETWEEN 1273701 AND 1536607, NON-CONSECUTIVELY. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK. IF A LEAK OCCURS AND THE REFRIGERATOR CONTINUES TO BE OPERATED AFTER SOLUTION CIRCULATION HAS CEASED THE HEAT SOURCE COULD GENERATE VERY HIGH TEMPERATURES. AT SUCH HIGH TEMPERATURES, THE COOLING UNIT COULD RUPTURE.
Consequence & remedy
Consequence: IF A LEAK OCCURS AND THE UNIT IS CONTINUES TO OPERATE, HYDROGEN GAS MAY BE EXPELLED AND CAN BE IGNITED, RESULTING IN A FIRE, POSSIBLY CAUSING SERIOUS INJURY OR DEATH.
Remedy: FLEETWOOD RV WILL NOTIFY OWNERS AND THE VEHICLE'S REFRIGERATOR WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING SEPTEMBER 2009. OWNERS MAY CONTACT FLEETWOOD RV AT 1-800-509-3418 OR NORCOLD'S RECALL CENTER AT 1-800-767-9101.
09V198000 · Service Brakes, Air
Jun 2, 2009
FLEETWOOD IS RECALLING 509 MY 2001-2008 CLASS A MOTOR HOMES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.
Consequence & remedy
Consequence: THE DRIVER WOULD NORMALLY DETECT THE BRAKE DRAG BUT IF UNDETECTED THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS FREE OF CHARGE. WORKHORSE IS HANDLING THE REMEDY FOR THIS CAMPAIGN PLEASE SEE 09V-110. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731. WORKHORSE WILL CONDUCT THE OWNER AND DEALER NOTIFICATION.
07V120000 · Equipment:recreational Vehicle/trailer
Mar 19, 2007
CERTAIN MOTOR HOMES AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Consequence & remedy
Consequence: RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.
Remedy: FLEETWOOD WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST YOU IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR FLEETWOOD AT 1-800-322-8216.
03V452000 · Equipment:recreational Vehicle/trailer
Nov 4, 2003
ON CERTAIN TRAVEL TRAILERS EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE OVENS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.
Consequence & remedy
Consequence: AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.
Remedy: SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 800-932-3837 OR FLEETWOOD AT 1-800-629-8454.
03V066000 · Service Brakes, Hydraulic:brake Fluid Low Warning: Lamp
Mar 4, 2003
CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY STANDARD.
Consequence & remedy
Consequence: IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE BRAKE SYSTEM WARNING INDICATOR.
Remedy: DEALERS WILL REPAIR THESE VEHICLES. OWNER NOTIFICATION BEGAN APRIL 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FLEETWOOD AT 1-800-445-3307.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE06005 · Inadvertent SLIDE-OUT Extension Movement
Opened Jan 20, 2006 · Closed May 2, 2006
Status: closed (inferred from source dates) · Equipment:recreational Vehicle/trailer
THIS INVESTIGATION WAS OPENED BASED ON ODI'S RECEIPT OF A CONGRESSIONAL LETTER ON BEHALF OF A CONSTITUENT.THE CONSTITUENT REPORTED INCIDENTS WHERE THE SLIDE OUT ROOM OF HIS MOTOR HOME WOULD INADVERTENTLY MOVE (EXTEND) DURING HIGHWAY USE.ODI WAS CONCERNED THAT A FULLY EXTENDED SLIDE OUT WOULD DEGRADE THE VEHICLE'S DYNAMIC HANDLING CHARACTERISTICS AND/OR POSSIBLY IMPACT AN OBJECT OR ANOTHER VEHICLE, RESULTING IN A CRASH.ODI CONTACTED FLEETWOOD AND DISCOVERED THAT SLIDE OUT ROOMS WERE INSTALLED IN MOTOR HOMES, TRAVEL TRAILERS AND FOLDING TRAILERS. AS PART OF THE INVESTIGATION ODI VISITED A RV SHOW AND THE FLEETWOOD PAXINOS PLANT TO EXAMINE SLIDE OUTS IN VARIOUS NEW MAKE AND MODEL VEHICLES AND GAIN AN UNDERSTANDING OF HOW THE SYSTEMS WORK.DURING THE INVESTIGATION ODI LEARNED THAT THERE ARE TWO METHODS USED TO EXTEND SLIDE OUT ROOMS.SOME MANUFACTURERS USE HYDRAULIC SYSTEMS AND OTHERS, SUCH AS FLEETWOOD, USE AN ELECTRIC MOTOR. (CONTINUED ON PAGE 2)