Counts are not failure probabilities and are not adjusted for sales, age, mileage exposure or reporting. One report may name several categories. Comparison method and limitations.
WHILE IN TRANSIT THE DINING ROOM SLIDE FAILS AND THE SLIDE WILL SLIDE OUT DUE TO AN ELECTRICAL BRAKE FAILURE. ADDITIONALLY, THE SLIDE IS PULLED OUT DURING TRANSIT WHEN HIT BY CROSS WINDS. THE SLIDE WILL THEN SLIDE OUT FROM THE BODY OF THE COACH ANYWHERE FROM ONE TO EIGHT INCHES. THIS HAS BEEN REPORTED TO FLEETWOOD ENTERPRISES ON…
Read full complaint
WHILE IN TRANSIT THE DINING ROOM SLIDE FAILS AND THE SLIDE WILL SLIDE OUT DUE TO AN ELECTRICAL BRAKE FAILURE. ADDITIONALLY, THE SLIDE IS PULLED OUT DURING TRANSIT WHEN HIT BY CROSS WINDS. THE SLIDE WILL THEN SLIDE OUT FROM THE BODY OF THE COACH ANYWHERE FROM ONE TO EIGHT INCHES. THIS HAS BEEN REPORTED TO FLEETWOOD ENTERPRISES ON SEVERAL OCCASIONS BEGINNING IN JANUARY 2006 AND MOST RECENTLY IN JANUARY 2007. THERE HAVE BEEN A TOTAL OF FOUR FAILURES AND THREE MOTORS REPLACED IN A 12 MONTH PERIOD. THE COACH HAS BEEN IN SERVICE FOR THE ABOVE RELATED PROBLEMS FOR APPROXIMATELY SIX MONTHS WHEREBY THE DEFECT STILL EXISTS. THIS ULTIMATELY RESULTS IN A MAJOR MECHANICAL AND STRUCTURAL FAILURE. IT IS ALSO THE ONLY PLACE IN WHICH SAFETY RESTRAINTS ARE INSTALLED. THEREBY POSING A SIGNIFICANT HEALTH AND SAFETY RISK TO THE PASSENGERS OF THE VEHICLE AND OTHER DRIVERS AND VEHICLES ON THE COUNTRY'S HIGHWAYS. AFTER NUMEROUS FAILURES AND IN TALKING WITH OTHER OWNERS WHO HAVE EXPERIENCED THE SAME PROBLEM, THIS PROBLEM MUST BE ADDRESSED. DURING MY INVESTIGATION OF OTHER FLEETWOOD PRODUCTS, FLEETWOOD HAS INSTALLED SLIDE LOCKS ON OTHER MODELS TO PREVENT THE SLIDE FROM RELEASING DURING TRANSIT OR UNEXPECTEDLY. *NM
FLEETWOOD IS RECALLING 509 MY 2001-2008 CLASS A MOTOR HOMES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.
Consequence & remedy
Consequence: THE DRIVER WOULD NORMALLY DETECT THE BRAKE DRAG BUT IF UNDETECTED THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS FREE OF CHARGE. WORKHORSE IS HANDLING THE REMEDY FOR THIS CAMPAIGN PLEASE SEE 09V-110. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731. WORKHORSE WILL CONDUCT THE OWNER AND DEALER NOTIFICATION.
FLEETWOOD IS RECALLING 70,101 MY 2003-2007 SOUTHWIND, PACE ARROW, BOUNDER, FLAIR, STORM, FIESTA, TERRA GAS CLASS A MOTOR HOMES; BOUNDER, DISCOVERY, PROVIDENCE, EXCURSION, EXPEDITION, REVOLUTION, AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION DIESEL CLASS A MOTOR HOMES; JAMBOREE TIOGA CLASS C MOTOR HOMES; AND PROWLER, WILDERNESS, TERRY, MALLARD, PIONEER, PRIDE AND TRIUMPH CONVENTIONAL AND FIFTH WHEEL TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATORS MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Consequence & remedy
Consequence: IF THIS SOLUTION IS EXPOSED TO AN IGNITION SOURCE UNDER CERTAIN SPECIFIC CIRCUMSTANCES, IT CAN RESULT IN A VEHICLE FIRE.
Remedy: FLEETWOOD IS WORKING WITH DOMETIC TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR FLEETWOOD AT 1-800-322-8216.
ON CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH GENERAL MOTORS 8.1L V8 ENGINES, IMPROPER HARDENING DURING THE HEAT TREATMENT PROCESS CAN CAUSE THE FUEL RAIL PULSE DAMPER RETAINER CLIP TO FRACTURE, RESULTING IN INADEQUATE RETENTION OF THE DAMPER. IF THE DAMPER BECOMES LOOSE, FUEL COULD BE PUMPED BY THE FUEL PUMP INTO THE UNDER HOOD AREA.
Consequence & remedy
Consequence: IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD RESULT.
Remedy: WORKHORSE IS HANDLING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN (PLEASE SEE 06V225). DEALERS WILL REPLACE THE FUEL RAIL PULSE DAMPER RETAINER CLIPS ON THESE ENGINES FREE OF CHARGE. OWNERS MAY CONTACT WORKHORSE AT 877-294-6773 OR FLEETWOOD AT 1-800-322-8216.
ON CERTAIN CLASS A MOTOR HOMES BUILT ON WORKHORSE CHASSIS MAY HAVE BEEN EQUIPPED WITH INCORRECT STEERING INTERMEDIATE SHAFTS. THE SPLINE CAN STRIP WHILE THE STEERING WHEEL IS BEING TURNED.
Consequence & remedy
Consequence: THIS STEERING CONDITION COULD RESULT IN A LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: WORKHORSE IS CONDUCTING THIS RECALL (PLEASE SEE 06V148000) AND WILL INSPECT AND, IF NECESSARY, REPLACE THE STEERING INTERMEDIATE SHAFTS. OWNERS MAY CONTACT WORKHORSE AT 1-877-294-6773 OR FLEETWOOD AT 1-800-322-8216.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Defect investigations
1
PE06005 · Inadvertent SLIDE-OUT Extension Movement
Opened Jan 20, 2006 · Closed May 2, 2006
Status: closed (inferred from source dates) · Equipment:recreational Vehicle/trailer
THIS INVESTIGATION WAS OPENED BASED ON ODI'S RECEIPT OF A CONGRESSIONAL LETTER ON BEHALF OF A CONSTITUENT.THE CONSTITUENT REPORTED INCIDENTS WHERE THE SLIDE OUT ROOM OF HIS MOTOR HOME WOULD INADVERTENTLY MOVE (EXTEND) DURING HIGHWAY USE.ODI WAS CONCERNED THAT A FULLY EXTENDED SLIDE OUT WOULD DEGRADE THE VEHICLE'S DYNAMIC HANDLING CHARACTERISTICS AND/OR POSSIBLY IMPACT AN OBJECT OR ANOTHER VEHICLE, RESULTING IN A CRASH.ODI CONTACTED FLEETWOOD AND DISCOVERED THAT SLIDE OUT ROOMS WERE INSTALLED IN MOTOR HOMES, TRAVEL TRAILERS AND FOLDING TRAILERS. AS PART OF THE INVESTIGATION ODI VISITED A RV SHOW AND THE FLEETWOOD PAXINOS PLANT TO EXAMINE SLIDE OUTS IN VARIOUS NEW MAKE AND MODEL VEHICLES AND GAIN AN UNDERSTANDING OF HOW THE SYSTEMS WORK.DURING THE INVESTIGATION ODI LEARNED THAT THERE ARE TWO METHODS USED TO EXTEND SLIDE OUT ROOMS.SOME MANUFACTURERS USE HYDRAULIC SYSTEMS AND OTHERS, SUCH AS FLEETWOOD, USE AN ELECTRIC MOTOR. (CONTINUED ON PAGE 2)
An investigation is not a finding of a defect, and closure does not prove a vehicle is problem-free.
Illustration