2004 Fleetwood Pace Arrow

2004 WORKHORSE PACE ARROW RV. CONSUMER WRITES IN REGARDS TO BRAKE CONCERNS RECALL NOTICE. *SMD THE CONSUMER STATED IN 2010, WHILE HIS SON WAS DRIVING THE RV, HE EXPERIENCED A TOTAL LOSS OF BRAKE FAILURE. THE RV WAS TAKEN TO A REPAIR SHOP, BUT NO PROBLEM WAS FOUND. THE RECALL WAS PERFORMED IN AUGUST 2011. AFTER THE RECALL WAS PERFORMED, THE BRAKES AND CALIPERS HAD TO BE REPLACED AGAIN. THE REPAIR SHOP STATED THE BRAKES WERE SIGNIFICANTLY INADEQUATE. THE CONSUMER STATED THE RECALL, DID NOT ELIMINATE THE PROBLEM. *JB

HAD A TIRE BLOW OUT WITH METAL TIRE MESH TEARING OUT MAJOR GROUND FAULT OUT AND SHORTING MOTOR HOME. STATED LED MILEAGE AND GEAR POSITION NOT IN CIRCUIT WITH GROUND SHORT. NOW LED HAS LINES IN LED AND HARD TO TELL WHAT GEAR MOTOR HOME IS IN. RESEARCH SO FAR INDICATES THAT WORKHORSE AND EVERYONE KNOWS THE LED IS DEFECTIVE BUT STILL NO SAFETY RECALL ON THE LED. IT COSTS $800 PLUS FOR LED REPLACEMENT AND ALL FORUMS HAVE INFORMATION ON HOW MAJOR THIS PROBLEM OF LED FAILURE IS. *JS

A FEW YEARS AGO I BEGAN NOTICING THAT THE PASSENGER SIDE DUAL PANE WINDOWS WERE LOOKING SORT OF SMOKY OR FOGGY LOOKING. EVEN THOUGH I'VE TRIED CLEANING THEM OVER AND OVER AGAIN THE SITUATION HAS CONTINUED TO WORSEN SO MUCH THAT I AM NOW HAVING A HARD TIME SEEING TO TURN AND SWITCH LANES SAFELY. YOUR ASSISTANCE IN THIS MATTER WOULD BE GREATLY APPRECIATED. *TR

UNDER NORMAL DRIVING CONDITIONS THE BRAKES ON MY 2004 FLEETWOOD PACE ARROW MOTORHOME (WORKHORSE CHASSIS)WILL PERIODICALLY NOT RELEASE AFTER BEING USED TO SLOW OR STOP THE MOTORHOME. THIS CAUSES SEVERE OVERHEATING AT THE EFFECTED BRAKE AND NECESSITATES TO PULL OFF THE ROAD, LET THE BRAKE COOL, AND HOPE IT RELEASES. THE FIRST INCIDENT OCCURRED AROUND APRIL 2009 AND I THOUGHT MAYBE IT WAS DUE TO STOP AND GO TRAFFIC BUT I WAS SUSPICIOUS OF THE SMELL OF BURNING BRAKES. I RECEIVED THE FIRST SAFETY RECALL NOTICE FROM WORKHORSE IN APRIL OF 2009, BUT NO PARTS WERE AVAILABLE TO FIX THE PROBLEM. I HAD BEEN ADVISED BY A WORKHORSE SERVICE CENTER THAT IF I TAP ON THE OVERHEATED BRAKE WITH A HAMMER IT MAY RELEASE SOONER (NORMAL COOL-DOWN TIME WOULD BE ABOUT 1 TO 1 1/2 HOURS . THE FOURTH INCIDENT OCCURRED IN EARLY OCT 2009 AND WAS QUITE SEVERE. WHEN I TAPPED ON THE BRAKE WITH A HAMMER, BURNING EMBERS FELL FROM THE BRAKE. I LET IT COOL AWHILE AND THEN BEGAN TO POUR WATER ON IT. I COOLED IT WITH WATER FOR ABOUT 1 HOUR AND FINALLY IT RELEASED. TOTAL TIME OFF THE ROAD WAS AROUND 2 1/2 HOURS. THE NEXT DAY I CALLED MY LOCAL AUTHORIZED WORKHORSE SERVICE CENTER (KELLEY CHEVROLET) AND MADE AN APPT.. UPON EXAMINING THE PROBLEM, KELLEY DETERMINED THAT THE VISIBLE CRITERIA ON THE BRAKE DID NOT MATCH THE CRITERIA FOR THE RECALL. KELLEY CALLED THE WORKHORSE REP WHO SUGGESTED TO LUBRICATE THE SLIDERS, WHICH KELLEY DID. (MY $200 EXPENSE) I PUT THE MOTORHOME IN STORAGE IN MID OCT 2009. I RECEIVED AN INTERIM RECALL NOTICE FROM WORKHORSE DECEMBER 2009 STATING THE PARTS ARE STILL NOT AVAILABLE. I RE-ACTIVATED THE MOTORHOME EARLY APRIL 2010 TO PREPARE FOR MY APRIL 16 TRIP. THE NORMAL 2 1/2 HOUR TRIP TOOK ABOUT 4 1/4 HOURS AS I WAS OFF THE ROAD POURING WATER ON THE BRAKES. I CALLED WORKHORSE WHO SAID THEY CAN ONLY AUTHORIZE WORK PER THE RECALL. I TOOK THE RV BACK TO KELLY APRIL 19. I AM IN CONSTANT FEAR OF A FIRE OR LOOSING BRAKES ALTOGETHER CAUSING AN ACCIDENT. LEGAL ACTION WILL BE TAKEN IF NEED. *TR

TL* THE CONTACT OWNS A 2004 FLEETWOOD PACE ARROW RV, WITH A WORKHORSE CHASSIS. AFTER EXITING THE VEHICLE THERE WAS A STRONG BURNING ODOR COMING FROM THE PASSENGER SIDE REAR WHEEL. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR INSPECTION. THE FAILURE WAS CONTRIBUTED TO THE BRAKES LOCKING. THE REAR PASSENGER ROTORS WERE RESURFACED. THE VEHICLE IDENTIFICATION NUMBER WAS EXCLUDED FROM RECALL CAMPAIGN ID NUMBER 09V198000 (SERVICE BRAKES, AIR). THE FAILURE MILEAGE WAS 21,776. THE CURRENT MILEAGE WAS 43,988. UPDATED 2/17/10 *CN UPDATED 02/22/10