IllustrationOF 5 (5) TIRES ON OUR TRAVEL TRAILER, FOUR OF THEM BLEW IN LESS THAN ONE YEAR. TWO IN ONE WEEKEND.*AK
2004 Dutchmen Trailer
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Trailer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 5 of 18 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Tires. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Equipment. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
Tires complaints
13 reportsWHILE DRIVING FRONT/REAR PASSENGER SIDE TIRE BLEW OUT. CONSUMER MANAGED TO PULL OVER AND CHANGED THE TIRE. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. DUNLOP, CARLI, 235/85R16. *AK
2 OF THE 4 TIRES ON OUR 2004 FOUR WINDS (DUTCHMEN) WINNERS CIRCLE 5TH WHEEL RV 35 FOOT UNIT. TIRES WERE MADE BY CARLISLE (RADIAL TRAIL 16" SERIES), AND AFTER RESEARCH IT WAS FOUND THESE CERTAIN TIRES (OURS INCLUDED) HAD A HISTORY OF FAILURES. BOTH TIRES FAILED CAUSING BLOWOUTS, 1 TIRE WAS NEARLY DISENGRATED, THE OTHER HAD A SEC…
Read full complaint
2 OF THE 4 TIRES ON OUR 2004 FOUR WINDS (DUTCHMEN) WINNERS CIRCLE 5TH WHEEL RV 35 FOOT UNIT. TIRES WERE MADE BY CARLISLE (RADIAL TRAIL 16" SERIES), AND AFTER RESEARCH IT WAS FOUND THESE CERTAIN TIRES (OURS INCLUDED) HAD A HISTORY OF FAILURES. BOTH TIRES FAILED CAUSING BLOWOUTS, 1 TIRE WAS NEARLY DISENGRATED, THE OTHER HAD A SECTION 7X12" MISSING FROM IT. THE OTHER TWO HAD NOT BLOWN OUT, BUT AFTER THEY WERE INSPECTED BY A TIRE DEALER, IT WAS NOTED THEY WOULD HAVE FAILED SHORTLY WAS NOTED THEY FAILED DUE TO TREAD SEPARATION. CAUSED MASSIVE DAMAGE ($3-5K POSSIBLY MORE) DAMAGE TO TRAILER. DUE TO WEIGHT OF TRAILER (NOT OVERLOADED - WAS BEING HAULED NEARLY EMPTY), FRAME DAMAGE MAY HAVE OCCURED AS THERE ARE SIGNS OF THE FRAME HAVING TWISTED. FAILURES HAPPENS 315 MILES APARTS, AND THE TIRES HAD LESS THAN 2000 MILES ON THEM, ALL PRESSURES WERE NOTED AS GOOD AND IN OPERATING/LOAD RANGE. A 4 TIRES WERE REPLACED WITH 4 LIKE TIRES FROM BF GOODRICH. IT IS UNKNOWN IF THERE WERE ANY INJURIES OR DAMAGES TO OTHER CARS FROM DEBRIS OR PARTS FROM TRAILER YET. SPEED OF TRAVEL WAS AROUND 60-65 ON A FLAT LEVEL SURFACE. ALL FOUR TIRES FAILED, THE 2 THAT BLEW OUT WERE THE: FRONT RIGHT, AND REAR LEFT TIRES. *LA
Official recalls
104V015000 · Equipment:recreational Vehicle/trailer:lpg Systems:furnace
Jan 5, 2004
ON CERTAIN TRAVELTRAILERS EQUIPPED WITH SUBURBAN FURNACES, THE FURNACE EXHAUST VENT MAY NOT BE PRESENT.
Consequence & remedy
Consequence: WHEN THE FURNACE IS IN USE THIS COULD ALLOW CARBON MONOXIDE FUMES TO VENT INTO THE TRAILER, WHICH COULD RESULT IN SERIOUS INJURY OR DEATH TO THE PASSENGERS.
Remedy: OWNERS AND DEALERS WILL INSPECT FOR THE PRESENCE OF THE EXHAUST VENT AND FOR HOT EXHAUST AIR ESCAPING FROM THE FURNACE EXHAUST. THE RECALL BEGAN FEBRUARY 20, 2004. OWNERS SHOULD CONTACT DUTCHMEN AT 1-219-534-1224.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.