IllustrationFRAME FAILURE ON A TRAVEL TRAILER. I NOTICED UPON RETURN OF MY LAST CAMPING TRIP THAT I WAS ABLE TO MOVE THE TONGUE OF THE TRAILER UP AND DOWN AROUND 3 INCHES. *TR
2004 Dutchmen Trailer
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Trailer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 5 of 18 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Tires. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Equipment. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
Structure complaints
2 reportsDT: THE CONSUMER HAD A PROBLEM WITH THE TRAVEL TRAILER. WHILE USING THE TRAILER, A FAILURE ON THE RIGHT FRONT TIRE OCCURRED. THE FRONT TIRE WAS RUBBING AGAINST THE REAR TIRE WHICH CAUSED THE TIRE TO BLOW OUT, AND THE TREAD TO SEPARATE. HE REPLACED THE TIRE WITH A SPARE TIRE UNTIL HE COULD REACH A TIRE DEALER. THE TIRE DEALE…
Read full complaint
DT: THE CONSUMER HAD A PROBLEM WITH THE TRAVEL TRAILER. WHILE USING THE TRAILER, A FAILURE ON THE RIGHT FRONT TIRE OCCURRED. THE FRONT TIRE WAS RUBBING AGAINST THE REAR TIRE WHICH CAUSED THE TIRE TO BLOW OUT, AND THE TREAD TO SEPARATE. HE REPLACED THE TIRE WITH A SPARE TIRE UNTIL HE COULD REACH A TIRE DEALER. THE TIRE DEALER ADVISED HIM THAT THE OTHER TIRES WERE ABOUT TO DO THE SAME THING. WHEN THE CONSUMER CONTACTED THE TIRE MANUFACTURER,THEY SAID THAT THERE WAS NO WARRANTY ON THE TIRES AND THERE WAS NOTHING THEY COULD DO. THE CONSUMER HAD ANOTHER SAFETY CONCERN WITH THE TRAILER IN WHICH WHILE REPLACING THE TIRES, HE FOUND A SOFT COPPER TUBING THAT HAD GONE THROUGH THE WHEEL WELL. THIS TUBING CONNECTED THE GAS LINE TO THE WATER HEATER. THERE WAS NO SHIELD OR COVERING FOR THIS TUBING. THE CONSUMER HAD NOT CONTACTED THE SERVICE DEALER OR THE MANUFACTURER TO INFORM THEM OF THIS CONCERN. *AK (11/29/05) THE CONSUMER WAS ALSO CONCERNED WITH THE FACT THAT WHEN THE TRAILER WAS BEING TOWED, THE LP GAS HAD TURNED ON. THE CONSUMER FELT THAT THIS WAS EXTREMELY HAZARDOUS. *SC
Official recalls
104V015000 · Equipment:recreational Vehicle/trailer:lpg Systems:furnace
Jan 5, 2004
ON CERTAIN TRAVELTRAILERS EQUIPPED WITH SUBURBAN FURNACES, THE FURNACE EXHAUST VENT MAY NOT BE PRESENT.
Consequence & remedy
Consequence: WHEN THE FURNACE IS IN USE THIS COULD ALLOW CARBON MONOXIDE FUMES TO VENT INTO THE TRAILER, WHICH COULD RESULT IN SERIOUS INJURY OR DEATH TO THE PASSENGERS.
Remedy: OWNERS AND DEALERS WILL INSPECT FOR THE PRESENCE OF THE EXHAUST VENT AND FOR HOT EXHAUST AIR ESCAPING FROM THE FURNACE EXHAUST. THE RECALL BEGAN FEBRUARY 20, 2004. OWNERS SHOULD CONTACT DUTCHMEN AT 1-219-534-1224.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.