AFTER THE VEHICLE IS TURNED ON ENGINE SURGES, CAUSING THE FORWARD MOVEMENT OF APPROXIMATELY 1 TO 1 1/2 INCHES. ALSO, A "GRINDING NOISE" COMING FROM THE REAR OF VEHICLE DURING NORMAL OPERATION. DEALERSHIP RECOMMENDED USE OF A SPECIAL SYNTHETIC OIL AND PERFORMING A SERIES OF MANEUVERS IN A PARKING LOT TO LOOSEN THE CLUTCH. …
Read full complaint
AFTER THE VEHICLE IS TURNED ON ENGINE SURGES, CAUSING THE FORWARD MOVEMENT OF APPROXIMATELY 1 TO 1 1/2 INCHES. ALSO, A "GRINDING NOISE" COMING FROM THE REAR OF VEHICLE DURING NORMAL OPERATION. DEALERSHIP RECOMMENDED USE OF A SPECIAL SYNTHETIC OIL AND PERFORMING A SERIES OF MANEUVERS IN A PARKING LOT TO LOOSEN THE CLUTCH. PLEASE PROVIDE ANY ADDITIONAL INFORMATION / DOCUMENTATION.*AK
NHTSA ODI #8002240
Mileage unknown · Oct 27, 2001
Vehicle Speed Control
VEHICLE ACCELERATES WHEN BRAKING DO TO ACCELERATORS DESIGN AND PROXIMITY TO THE BRAKE. *AK
NHTSA ODI #753790
Mileage unknown · Nov 28, 2000
Power TrainVehicle Speed Control
CRUISE CONTROL ENGAGES AT ANY GIVEN TIME. DEALER NOTICED TRANSMISSION SENDING UNIT CABLE GOT LOOSE. *AK CONSUMER STATES MOST COMMON SCENARIO IS CRUISE CONTROL BEING SET AT SPEED, THEN BEING CANCELLED BY CONSUMER EITHER BY CANCEL BUTTON OR BY BRAKING, CRUISE WILL THEN REENGAGE AT SET SPEED. *SLC
NHTSA ODI #875580
Mileage unknown · May 24, 2000
Vehicle Speed Control
INTERMITTENTLY VEHICLE ACCELERATED UNEXPECTEDLY. DEALER HAS INSPECTED THE VEHICLE, AND HAS NOT BEEN ABLE TO DUPLICATE THE PROBLEM. *AK
ON CERTAIN VAN AND WAGON VEHICLES EQUIPPED WITH 4-WHEEL ANTILOCK BRAKE SYSTEMS (ABS), AFTERMARKET BATTERIES MAY LEAK ELECTROLYTE ONTO THE ABS CONTROL MODULE CONNECTOR, WHICH CAN COMPROMISE SEALING INTEGRITY OF THE CONNECTOR.
Consequence & remedy
Consequence: THIS MAY ALLOW DEVELOPMENT OF A SHORT CIRCUIT IN THE CONNECTOR, WHICH COULD EVENTUALLY LEAD TO A FIRE.
Remedy: DEALERS WILL INSPECT THE ABS CONTROL MODULE CONNECTOR FOR ELECTROLYTE DAMAGE AND REPLACE THE CONNECTOR AS NECESSARY. THE RECALL WILL BEGIN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: VANS AND WAGONS NOT EQUIPPED WITH POWER FRONT SEATS. IN THE PRESENCE OF ROAD SALT, WATER, AND POSSIBLY OTHER DEBRIS, THE POWER SEAT CONNECTOR LOCATED BENEATH THE DRIVER'S SEAT COULD DEVELOP A HIGH RESISTIVE SHORT CIRCUIT THAT CYCLES THE CIRCUIT BREAKER.
Consequence & remedy
Consequence: IF THE CIRCUIT BREAKER CYCLES FOR AN EXTENDED PERIOD OF TIME, HEAT COULD BUILD UP IN THE CONNECTOR, POSSIBLY RESULTING IN A FIRE.
Remedy: OWNERS WILL RECEIVE INSTRUCTIONS FOR REMOVING THE CIRCUIT BREAKER FROM THE FUSE PANEL. IF AN OWNER DESIRES, THEIR DEALER CAN PERFORM THE REPAIR. OWNER NOTIFICATION BEGAN AUGUST 27, 2001. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: PICKUP TRUCKS. SOUND DEADENER MATERIAL INSIDE THE STEERING WHEEL COULD BECOME DETACHED FROM THE COVER AND HOUSING. NOTE: THE RAM PICKUP TRUCKS WERE BUILT AT THE WARREN ASSEMBLY PLANT ("S" IN THE 11TH VIN POSITION) FROM MAY 16, 2000 THROUGH OCTOBER 23, 2000; ST. LOUIS NORTH ASSEMBLY PLANT ("J" IN THE 11TH VIN POSITION) FROM MAY 19, 2000 THROUGH OCTOBER 23, 2000; LAGO ALBERTO ASSEMBLY PLANT ("M" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000; AND SALTILLO ASSEMBLY PLANT ("G" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000. IMPORTANT: VEHICLES THAT HAVE ALREADY HAD THE PROPER CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN EXCLUDED FROM THIS RECALL. IN ADDITION, 1997-2000 MODEL YEAR VEHICLES THAT HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN ADDED TO THIS RECALL.
Consequence & remedy
Consequence: WHEN THIS OCCURS, THE MATERIAL COULD INTERFERE WITH THE CLOCKSPRING RIBBON AND CAUSE AN OPEN CIRCUIT. THE DRIVER AIR BAG SYSTEM WILL BECOME DISABLED, AND THE AIR BAG WARNING LAMP WILL ILLUMINATE ON THE INSTRUMENT PANEL.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY. OWNER NOTIFICATION BEGAN JUNE 18, 2001. ALSO SOME 1997-200 MODEL YEAR VEHICLES THAT, ACCORDING TO WARRANTY RECORDS, HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, WILL ALSO BE INCLUDED IN THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH AN ANTI-LOCK BRAKING SYSTEM (ABS). SOME VEHICLES MAY HAVE INADEQUATE CLEARANCE BETWEEN THE FRONT TIRE/WHEEL AND THE BRAKE HOSE/ABS SENSOR WIRE ASSEMBLY. DURING FULL LOCK TURNS, IT IS POSSIBLE FOR THE TIRE OR WHEEL TO CONTACT THE BRAKE HOSE/ABS SENSOR WIRE ASSEMBLY.
Consequence & remedy
Consequence: THIS COULD ULTIMATELY RESULT IN WIRE DAMAGE AND/OR A HOLE IN THE BRAKE LINE, AFFECTING BRAKE EFFECTIVENESS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE FRONT BRAKE HOSE ASSEMBLIES, AND THE ABS SENSOR WIRE WILL BE INSPECTED AND REPLACED IF NECESSARY. OWNER NOTIFICATION BEGAN MARCH 8, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH OPTIONAL TRAILER HITCH. THE TRAILER HITCH SIDE BRACKETS WERE MANUFACTURED USING MATERIAL WITH INSUFFICIENT STRENGTH.
Consequence & remedy
Consequence: BRACKETS BUILT WITHOUT PROPER MATERIAL COULD FATIGUE AND FRACTURE IN THE AREA WHERE THE TRAILER HITCH MOUNTS TO THE FRAME.
Remedy: DEALERS WILL INSPECT THE TRAILER HITCHES AND REPLACE ANY TRAILER HITCH SHOWING SIGNS OF FATIGUE CRACKING. IF NO EVIDENCE OF CRACKING EXISTS, THE DEALER WILL INSTALL TWO REINFORCEMENT BRACKETS.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS. THE WELDS AT THE RIGHT SIDE LOWER CONTROL ARM BRACKET TO AXLE TUBE ATTACHMENT MAY HAVE INADEQUATE FATIGUE LIFE DUE TO POOR WELD QUALITY. THIS CAN LEAD TO SEPARATION OF THE CONTROL ARM BRACKET FROM THE AXLE TUBE.
Consequence & remedy
Consequence: IF THE BRACKET SEPARATES THE VEHICLE COULD EXPERIENCE REDUCED DIRECTIONAL STABILITY, BRAKING DEGRADATION AND/OR VEHICLE PULL UNDER BRAKING.
Remedy: DEALERS WILL REPLACE THE FRONT AXLE WITH A PROPERLY WELDED FRONT AXLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE08047 · 2000-2001 Dodge RAM Pickup Hood Latch
Opened Jul 25, 2008 · Closed Dec 17, 2008
Status: closed (inferred from source dates) · Latches/locks/linkages:hood:latch; Structure:body:hood:hinge And Attachments
THE AGENCY OPENED THIS INVESTIGATION BASED ON 30 COMPLAINTS ALLEGING THAT THE HOODS ON MODEL YEAR (MY) 2000 AND 2001 DODGE RAM PICKUP TRUCKS FLEW UP AND BLOCKED THE DRIVER'S VISION.THESE VEHICLES HAVE A PRIMARY HOOD LATCH AND A SECONDARY (BACKUP) HOOD LATCH.THE SECONDARY LATCH IS DESIGNED TO SECURE THE HOOD IF THE PRIMARY HOOD LATCH IS NOT PROPERLY CLOSED OR OTHERWISE MALFUNCTIONS.IN THESE COMPLAINTS, THE SECONDARY HOOD LATCH MALFUNCTIONED, APPARENTLY DUE TO CORROSION, AND DID NOT LATCH.DODGE CONDUCTED RECALL 01V-040 IN 1999 TO ADDRESS SIMILAR PROBLEMS ON MODEL YEAR 1994-1997 DODGE RAM PICKUP TRUCKS.THE INFORMATION CHRYSLER PROVIDED IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER INDICATED THAT THE MY 2000 AND 2001 VEHICLES WERE EQUIPPED WITH SECONDARY HOOD LATCHES WITH STAINLESS STEEL RETURN SPRINGS, AS OPPOSED TO THE EARLIER RECALLED TRUCKS THAT HAD ZINC COATED CARBON STEEL RETURN SPRINGS.THE RECALLED COMPONENTS WERE SUSCEPTIBLE TO CORROSION-INDUCED FAILURE DUE TO THE TYPE OF MATERIAL USED, WHEREAS THE CORROSION FAILURES IN THE NEWER MODELS APPEAR TO BE DUE TO LUBRICATION LOSS OVER TIME (REGULAR APPLICATION OF GREASE IS ADVISED PER INSTRUCTIONS IN THE OWNERS' MANUAL). ODI'S REVIEW OF CHRYSLER'S WARRANTY, COMPLAINT, AND INJURY DATA FOR THE 2000 AND 2001 VEHICLES INDICATES THAT THE RATES FOR SUBJECT VEHICLES ARE LOW AND ARE DECLINING.A POTENTIAL DEFECT TREND HAS NOT BEEN IDENTIFIED.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Latches/locks/linkages:hood:latch
THE AGENCY OPENED THIS INVESTIGATION BASED ON 30 COMPLAINTS ALLEGING THAT THE HOODS ON MODEL YEAR (MY) 2000 AND 2001 DODGE RAM PICKUP TRUCKS FLEW UP AND BLOCKED THE DRIVER'S VISION.THESE VEHICLES HAVE A PRIMARY HOOD LATCH AND A SECONDARY (BACKUP) HOOD LATCH.THE SECONDARY LATCH IS DESIGNED TO SECURE THE HOOD IF THE PRIMARY HOOD LATCH IS NOT PROPERLY CLOSED OR OTHERWISE MALFUNCTIONS.IN THESE COMPLAINTS, THE SECONDARY HOOD LATCH MALFUNCTIONED, APPARENTLY DUE TO CORROSION, AND DID NOT LATCH.DODGE CONDUCTED RECALL 01V-040 IN 1999 TO ADDRESS SIMILAR PROBLEMS ON MODEL YEAR 1994-1997 DODGE RAM PICKUP TRUCKS.THE INFORMATION CHRYSLER PROVIDED IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER INDICATED THAT THE MY 2000 AND 2001 VEHICLES WERE EQUIPPED WITH SECONDARY HOOD LATCHES WITH STAINLESS STEEL RETURN SPRINGS, AS OPPOSED TO THE EARLIER RECALLED TRUCKS THAT HAD ZINC COATED CARBON STEEL RETURN SPRINGS.THE RECALLED COMPONENTS WERE SUSCEPTIBLE TO CORROSION-INDUCED FAILURE DUE TO THE TYPE OF MATERIAL USED, WHEREAS THE CORROSION FAILURES IN THE NEWER MODELS APPEAR TO BE DUE TO LUBRICATION LOSS OVER TIME (REGULAR APPLICATION OF GREASE IS ADVISED PER INSTRUCTIONS IN THE OWNERS' MANUAL). ODI'S REVIEW OF CHRYSLER'S WARRANTY, COMPLAINT, AND INJURY DATA FOR THE 2000 AND 2001 VEHICLES INDICATES THAT THE RATES FOR SUBJECT VEHICLES ARE LOW AND ARE DECLINING.A POTENTIAL DEFECT TREND HAS NOT BEEN IDENTIFIED.THIS INVESTIGATION IS CLOSED.
Structure:body:hood:hinge And Attachments
THE AGENCY OPENED THIS INVESTIGATION BASED ON 30 COMPLAINTS ALLEGING THAT THE HOODS ON MODEL YEAR (MY) 2000 AND 2001 DODGE RAM PICKUP TRUCKS FLEW UP AND BLOCKED THE DRIVER'S VISION.THESE VEHICLES HAVE A PRIMARY HOOD LATCH AND A SECONDARY (BACKUP) HOOD LATCH.THE SECONDARY LATCH IS DESIGNED TO SECURE THE HOOD IF THE PRIMARY HOOD LATCH IS NOT PROPERLY CLOSED OR OTHERWISE MALFUNCTIONS.IN THESE COMPLAINTS, THE SECONDARY HOOD LATCH MALFUNCTIONED, APPARENTLY DUE TO CORROSION, AND DID NOT LATCH.DODGE CONDUCTED RECALL 01V-040 IN 1999 TO ADDRESS SIMILAR PROBLEMS ON MODEL YEAR 1994-1997 DODGE RAM PICKUP TRUCKS.THE INFORMATION CHRYSLER PROVIDED IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER INDICATED THAT THE MY 2000 AND 2001 VEHICLES WERE EQUIPPED WITH SECONDARY HOOD LATCHES WITH STAINLESS STEEL RETURN SPRINGS, AS OPPOSED TO THE EARLIER RECALLED TRUCKS THAT HAD ZINC COATED CARBON STEEL RETURN SPRINGS.THE RECALLED COMPONENTS WERE SUSCEPTIBLE TO CORROSION-INDUCED FAILURE DUE TO THE TYPE OF MATERIAL USED, WHEREAS THE CORROSION FAILURES IN THE NEWER MODELS APPEAR TO BE DUE TO LUBRICATION LOSS OVER TIME (REGULAR APPLICATION OF GREASE IS ADVISED PER INSTRUCTIONS IN THE OWNERS' MANUAL). ODI'S REVIEW OF CHRYSLER'S WARRANTY, COMPLAINT, AND INJURY DATA FOR THE 2000 AND 2001 VEHICLES INDICATES THAT THE RATES FOR SUBJECT VEHICLES ARE LOW AND ARE DECLINING.A POTENTIAL DEFECT TREND HAS NOT BEEN IDENTIFIED.THIS INVESTIGATION IS CLOSED.
2000 Dodge RAM Problems, Complaints & Recalls | Skip That Year
Illustration