NHTSA owner reports · September 18, 2026 snapshot.
Tires complaints
18 reportsClear category filter193,000 miles · Jan 28, 2012
StructureTires
THE SPARE TIRE MECHANISM THAT HOLD THE TIRE UNDER THE BED BROKE. THIS FAILURE WAS VERY DANGEROUS SINCE IT OCCURRED WHILE I WAS DRIVING, MY SPARE TIRE FELL ONTO THE STREET AND ROLLED. LUCKILY I WAS IN A 35 MPH AREA, BUT CARS STILL HAD TO MOVE OUT OF THE WAY OF THE ROLLING TIRE. HAD I BEEN ON THE INTERSTATE, IT COULD HAVE BEEN …
Read full complaint
THE SPARE TIRE MECHANISM THAT HOLD THE TIRE UNDER THE BED BROKE. THIS FAILURE WAS VERY DANGEROUS SINCE IT OCCURRED WHILE I WAS DRIVING, MY SPARE TIRE FELL ONTO THE STREET AND ROLLED. LUCKILY I WAS IN A 35 MPH AREA, BUT CARS STILL HAD TO MOVE OUT OF THE WAY OF THE ROLLING TIRE. HAD I BEEN ON THE INTERSTATE, IT COULD HAVE BEEN DISASTROUS. *TR
NHTSA ODI #10445718
20,000 miles · May 14, 2004
Tires
GOODYEAR, WRANGLER, P265/75R16 , DOT#4B73D5DR1900 SIDEWALL SEPARATION ON FRONT PASSENGER'S SIDE. CONSUMER WAS DRIVING AT HIGHWAY SPEED WHEN SEPARATION OCCURRED. TIRES HAD LESS THAN 20,000 MILES ON THEM. *AK
NHTSA ODI #10073674
Mileage unknown · Feb 16, 2002
Tires
DRIVING AT 55 MPH THE TIRE SEPARATED THE TREAD FROM THE SIDEWALL AND PEELED ALL THE WAY AROUND. THE TREAD IS STILL LIKE NEW.*AK (TIRESIZE: LT26575R16)
NHTSA ODI #758338
Mileage unknown · Dec 28, 2001
Fuel System, GasolinePower TrainService Brakes, Hydraulic
CONSUMERS VEHICLE RAN INTO A TRAILER ON HIS PROPERTY AND ABS WAS DEFECTIVE, ALSO BRAKE DRUMS WERE RUSTED, DEALERSHIP WAS AWARE OF PROBLEM. *AK CONSUMER STATED THAT HEADACHE BAR AND FUEL TANK, TIRES, FUEL FILTER, STEERING STABILIZER, FRONT SHOCKS, REAR SHOCKS, AIR FILTER, REAR AXLE SEAL AND FLUID, REAR TRANSFER CASE SEAL AND U-…
Read full complaint
CONSUMERS VEHICLE RAN INTO A TRAILER ON HIS PROPERTY AND ABS WAS DEFECTIVE, ALSO BRAKE DRUMS WERE RUSTED, DEALERSHIP WAS AWARE OF PROBLEM. *AK CONSUMER STATED THAT HEADACHE BAR AND FUEL TANK, TIRES, FUEL FILTER, STEERING STABILIZER, FRONT SHOCKS, REAR SHOCKS, AIR FILTER, REAR AXLE SEAL AND FLUID, REAR TRANSFER CASE SEAL AND U-JOINTS IN REAR DRIVE SHAFT FAILED AND REPLACED.*YD
NHTSA ODI #8001228
Mileage unknown · Dec 20, 2001
Tires
THIS IS A "LOAD RANGE E" GOODYEAR TIRE PROBLEM. AT 30081, 30805, 35213, AND 38060 MILES ONE EACH OF THE ORIGINAL EQUIPMENT TIRES FAILED DUE TO SIDEWALL SEPARATION AND WAS REPLACED AT VARYING CHARGES BY GOODYEAR. NOW, AT ABOUT 50,000 MILES, ONE OF THE REPLACEMENT TIRES HAS FAILED FOR THE SAME REASON. GOODYEAR IS GIVING ME A "…
Read full complaint
THIS IS A "LOAD RANGE E" GOODYEAR TIRE PROBLEM. AT 30081, 30805, 35213, AND 38060 MILES ONE EACH OF THE ORIGINAL EQUIPMENT TIRES FAILED DUE TO SIDEWALL SEPARATION AND WAS REPLACED AT VARYING CHARGES BY GOODYEAR. NOW, AT ABOUT 50,000 MILES, ONE OF THE REPLACEMENT TIRES HAS FAILED FOR THE SAME REASON. GOODYEAR IS GIVING ME A "RUN AROUND" AS HAS BEEN THE CASE IN ALL PREVIOUS OCCURANCES, VARIOUSLY CLAIMING THAT THE TIRE IS "NO LONGER AVAAILABLE" "ON BACKORDER" "NO LONGER MANUFACTURED" "NOT ADJUSTABLE" ETC. IT HAS NOW BEEN TWO WEEKS SINCE THE LAST FAILURE WAS SHOWN TO GOODYEAR, AND THEY CLAIM NOT TO BE ABLE TO LOCATE A REPLACEMENT. I HAVE COMPLETE DOCUMENTATION OF EACH OF THESE SITUATIONS, DEALER NAMES AND LOCATIONS, AND AM READY TO ASSIST YOU IN WHATEVER WAY IS APPROPRIATE.*AK (DOT NUMBER: UNKNOWN TIRESIZE: LT24575R16)
NHTSA ODI #755884
Mileage unknown · Aug 18, 2001
Tires
TIRE SHREDED AT HIGHWAY SPEED. DISTROYED WHEEL AND NEARLY LOST CONTROL. *AK (DOT NUMBER: 377 TIRESIZE: P265/75R16)
NHTSA ODI #750709
Mileage unknown · Jul 12, 2001
Tires
BELT SEPARATED FROM TIRE. SIDEWALLS WAS SHREDDED. *AK (TIRESIZE: P225/75R16)
NHTSA ODI #748345
Mileage unknown · Jan 18, 2001
Tires
TREAD SEPARATION ON MY GOODYEAR WRANGLERS RT/S LT245-75R16 LOAD E. CONTACTED GOODYEAR CUSTOMER SERVICE HOWEVER THEY STATED NOTHING IS WRONG WITH THOSE TIRES. TIRES ARE ON A DODGE RAM 2500 HD, DIESEL. DISCOVERED FLAW WHEN AFTER NOTICING THE TIRE WAS LOW ON AIR. *AK (TIRESIZE: LT24575R16)( DOT NUMBER: TIRE SIZE: LT24575R16 )
NHTSA ODI #739573
Mileage unknown · Nov 21, 2000
Tires
PE00.046; CONSUMER WAS TRAVELING ABOUT 65MPH ON HIGHWAY AND SUDDENLY DRIVER'S FRONT SIDE TIRE EXPLODED. HE WAS ABLE TO PULL OVER TO SHOULDERS. GOODYEAR, LT245/75R16, THERE WERE NO INJURIES. RIGHT REAR TIRE TREAD HAD SEPARATED FROM RIM. THERE WERE TWO TIRE TREAD SEPARATIONS. GOODYEAR LT245/7516. THERE WERE NO INJURIES.*…
Read full complaint
PE00.046; CONSUMER WAS TRAVELING ABOUT 65MPH ON HIGHWAY AND SUDDENLY DRIVER'S FRONT SIDE TIRE EXPLODED. HE WAS ABLE TO PULL OVER TO SHOULDERS. GOODYEAR, LT245/75R16, THERE WERE NO INJURIES. RIGHT REAR TIRE TREAD HAD SEPARATED FROM RIM. THERE WERE TWO TIRE TREAD SEPARATIONS. GOODYEAR LT245/7516. THERE WERE NO INJURIES.*AK
NHTSA ODI #875327
Mileage unknown · Nov 3, 2000
Tires
TIRE SIZE IS LT265/75R-16/C. THE TIRE FAILED WHILE RETURNING FROM OMAHA WITH MY WIFE AND 8 MONTH OLD SON. I HAVE DIGITAL PICTURES OF THE TIRE AND TRUCK THAT CAN BE SENT OVER E-MAIL. I HAVE CONTACTED PIRELLI AND THEY WANT ME TO SEND THE TIRE ALONG WITH ESTIMATES TO FIX THE TRUCK. I SPOKE WITH NADINE CALDERWOOD AT 1-800-243-5105 E…
Read full complaint
TIRE SIZE IS LT265/75R-16/C. THE TIRE FAILED WHILE RETURNING FROM OMAHA WITH MY WIFE AND 8 MONTH OLD SON. I HAVE DIGITAL PICTURES OF THE TIRE AND TRUCK THAT CAN BE SENT OVER E-MAIL. I HAVE CONTACTED PIRELLI AND THEY WANT ME TO SEND THE TIRE ALONG WITH ESTIMATES TO FIX THE TRUCK. I SPOKE WITH NADINE CALDERWOOD AT 1-800-243-5105 EXT 387. SHE DID NOT SEEM TO CARE IF ANYONE WAS INJURED OR NOT AND SEEMED TO BE EXACTLY LIKE HER TITLE A RISK MANAGER. THE TIRES HAVE APROX 20,000 MILES ON THEM. I WAS DRIVING 75 MPH AND THE TRUCK HAD A SLIGHT VIBRATION I CHECKED TIRE PRESSURE WHEN WE STOPPED AND VISUALLY INSPECTED THE TIRES. AFTER WE FILLED WITH GAS THE VIBRATION WAS NO LONGER THERE. AFTER OUR SECOND STOP THE VIBRATION RETURNED AND THEN THE TREAD SEPARATED WITH A VIOLENT CRASH DESTROYING THE ENTIRE SIDE OF THE TRUCK AND CAUSING THE TRUCK TO ALMOST LOOSE CONTROL AND SHAKE VIOLENTLY. I UNDERSTAND THAT A LARGE TIRE CO LIKE PIRELLI HAS TO WATCH OUT FOR THEIR BEST INTEREST HOWEVER THEY SHOULD PUT THE CUSTOMERS WELL BEING AT THE TOP. I WOULD APPRECIATE ANY INFORMATION YOU HAVE ABOUT OTHER PIRELLI TIRE SEPARATIONS THAT HAVE BEEN FILED. THANK YOU. *AK (DOT NUMBER: CHW8GP4419 TIRESIZE: 265 75R16C)
NHTSA ODI #735687
Official recalls
13Apr 12, 2004
ON CERTAIN VAN AND WAGON VEHICLES EQUIPPED WITH 4-WHEEL ANTILOCK BRAKE SYSTEMS (ABS), AFTERMARKET BATTERIES MAY LEAK ELECTROLYTE ONTO THE ABS CONTROL MODULE CONNECTOR, WHICH CAN COMPROMISE SEALING INTEGRITY OF THE CONNECTOR.
Consequence & remedy
Consequence: THIS MAY ALLOW DEVELOPMENT OF A SHORT CIRCUIT IN THE CONNECTOR, WHICH COULD EVENTUALLY LEAD TO A FIRE.
Remedy: DEALERS WILL INSPECT THE ABS CONTROL MODULE CONNECTOR FOR ELECTROLYTE DAMAGE AND REPLACE THE CONNECTOR AS NECESSARY. THE RECALL WILL BEGIN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Jun 14, 2002
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH DIESEL ENGINES ONLY, THE THROTTLE LINKAGE JOINTS CAN CORRODE AND CAUSE THE THROTTLE TO BIND OR STICK.
Consequence & remedy
Consequence: THIS COULD POTENTIALLY RESULT IN A LOSS OF THROTTLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ROD ENDS AND BALL STUDS. OWNER NOTIFICATION BEGAN JULY 29, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
May 8, 2001
VEHICLE DESCRIPTION: PICKUP TRUCKS. SOUND DEADENER MATERIAL INSIDE THE STEERING WHEEL COULD BECOME DETACHED FROM THE COVER AND HOUSING. NOTE: THE RAM PICKUP TRUCKS WERE BUILT AT THE WARREN ASSEMBLY PLANT ("S" IN THE 11TH VIN POSITION) FROM MAY 16, 2000 THROUGH OCTOBER 23, 2000; ST. LOUIS NORTH ASSEMBLY PLANT ("J" IN THE 11TH VIN POSITION) FROM MAY 19, 2000 THROUGH OCTOBER 23, 2000; LAGO ALBERTO ASSEMBLY PLANT ("M" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000; AND SALTILLO ASSEMBLY PLANT ("G" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000. IMPORTANT: VEHICLES THAT HAVE ALREADY HAD THE PROPER CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN EXCLUDED FROM THIS RECALL. IN ADDITION, 1997-2000 MODEL YEAR VEHICLES THAT HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN ADDED TO THIS RECALL.
Consequence & remedy
Consequence: WHEN THIS OCCURS, THE MATERIAL COULD INTERFERE WITH THE CLOCKSPRING RIBBON AND CAUSE AN OPEN CIRCUIT. THE DRIVER AIR BAG SYSTEM WILL BECOME DISABLED, AND THE AIR BAG WARNING LAMP WILL ILLUMINATE ON THE INSTRUMENT PANEL.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY. OWNER NOTIFICATION BEGAN JUNE 18, 2001. ALSO SOME 1997-200 MODEL YEAR VEHICLES THAT, ACCORDING TO WARRANTY RECORDS, HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, WILL ALSO BE INCLUDED IN THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Feb 12, 2001
ON CERTAIN PICKUP TRUCKS ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING "SALT BELT" STATES: MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, AND MISSOURI. CORROSION OF THE RETURN SPRING ON THE HOOD SECONDARY LATCH COULD CAUSE THE MECHANISM TO BIND IN THE "RELEASE POSITION."
Consequence & remedy
Consequence: IF THE PRIMARY LATCH IS NOT ENGAGED, THE HOOD COULD OPEN UNEXPECTEDLY.
Remedy: DEALERS WILL REPLACE THE SECONDARY HOOD LATCH. OWNER NOTIFICATION BEGAN SEPTEMBER 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Apr 11, 2000
VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH OPTIONAL TRAILER HITCH. THE TRAILER HITCH SIDE BRACKETS WERE MANUFACTURED USING MATERIAL WITH INSUFFICIENT STRENGTH.
Consequence & remedy
Consequence: BRACKETS BUILT WITHOUT PROPER MATERIAL COULD FATIGUE AND FRACTURE IN THE AREA WHERE THE TRAILER HITCH MOUNTS TO THE FRAME.
Remedy: DEALERS WILL INSPECT THE TRAILER HITCHES AND REPLACE ANY TRAILER HITCH SHOWING SIGNS OF FATIGUE CRACKING. IF NO EVIDENCE OF CRACKING EXISTS, THE DEALER WILL INSTALL TWO REINFORCEMENT BRACKETS.
May 6, 1999
VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSION, V10 ENGINES AND FOUR-WHEEL-DRIVE TRANSFER CASES. UNDER SUSTAINED MAXIMUM RATED VEHICLE LOAD, WHILE DRIVING UP A STEEP GRADE IN FOUR-WHEEL-DRIVE LOW RANGE IN HOT AMBIENT CONDITIONS, THE LOCAL EXHAUST TEMPERATURE PROXIMATE TO THE HYDRAULIC CLUTCH LINE CAN GENERATE LINE TEMPERATURES THAT EXCEED THE TEMPERATURE LIMIT OF THE CLUTCH LINE MATERIAL. IF THIS CONDITION OCCURS AND THE CLUTCH IS DEPRESSED, THE LINE COULD RUPTURE.
Consequence & remedy
Consequence: THE FLUID COULD IGNITE ON THE HOT EXHAUST POSSIBLY RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL REPLACE THE HYDRAULIC CLUTCH ASSEMBLY.
Jan 7, 1999
VEHICLE DESCRIPTION: VANS AND VANS USED FOR CONVERSION. IF A HEAVY OBJECT IMPACTS THE METAL CASING OF THE AIR BAG ELECTRONIC CONTROL MODULE (AECM), LOCATED UNDER THE DRIVER SEAT, THE MODULE COULD INADVERTENTLY DEPLOY THE AIR BAGS.
Consequence & remedy
Consequence: UNEXPECTED AIR BAG DEPLOYMENT CAN RESULT IN OCCUPANT INJURY.
Remedy: DEALERS WILL REPLACE THE AECM WITH A MODULE THAT INCORPORATES REVISED HARDWARE AND SOFTWARE ON ALL AFFECTED VEHICLES.
Sep 8, 1998
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH 5.9L - 24 VALVE DIESEL ENGINE. THE LOW PRESSURE DIESEL FUEL SUPPLY TUBE LOCATED IN THE ENGINE COMPARTMENT BETWEEN THE FILTER AND THE HIGH PRESSURE PUMP CAN FRACTURE.
Consequence & remedy
Consequence: THIS CONDITION CAN ALLOW FUEL TO LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, FUEL LEAKAGE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE LOW PRESSURE DIESEL FUEL SUPPLY TUBE.
Sep 8, 1998
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS. THESE VEHICLES MAY HAVE BEEN BUILT WITH BOLTS THAT WERE NOT PROPERLY HARDENED. THE BOLTS WERE USED TO ATTACH THE CAB AND THE CORE SUPPORT TO THE FRAME.
Consequence & remedy
Consequence: THIS CONDITION CAN ALLOW THE CAB TO SEPARATE FROM THE FRAME INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THESE BOLTS WITH PROPERLY HARDENED BOLTS.
Sep 8, 1998
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH 5.9L - 24 VALVE DIESEL ENGINE. AN INTERMITTENT HIGH ENGINE IDLE CONDITION CAN OCCUR DUE TO A MALFUNCTION OF THE VEHICLE SPEED SENSOR.
Consequence & remedy
Consequence: THIS CREATES A SIGNAL WHICH IS MISINTERPRETED BY THE ENGINE CONTROL SOFTWARE, CAUSING A HIGH IDLE SPEED CONDITION.
Remedy: DEALERS WILL REPLACE THE ENGINE CONTROLLER SOFTWARE TO CORRECT ERRONEOUS SPEED SENSOR SIGNALS.
Aug 6, 1998
VEHICLE DESCRIPTION: LIGHT DUTY TRUCKS EQUIPPED WITH EITHER A 8.0L V-10 ENGINE OR A 5.9L V-8 HEAVY DUTY GASOLINE ENGINE. AN EXHAUST SYSTEM HEAT SHIELD ATTACHING SCREW IS TOO CLOSE TO THE UNDERBODY FUEL LINE. THE LINE CAN RUB AGAINST THE SCREW, POSSIBLY CAUSING FUEL LEAKAGE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL REMOVE THE UNDERBODY HEAT SHIELD ATTACHING SCREW AND REPLACE IT WITH RUBBER ADHESIVE. THE CHASSIS FUEL LINE WILL BE INSPECTED FOR SIGNS OF WEAR AND ANY TUBES INDICATING WEAR WILL BE REPLACED.
May 14, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FRONT SEAT BELT BUCKLES WERE NOT PROPERLY RIVETED TO THE SUPPORT STRAP.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE SEAT BELT ASSEMBLY WOULD HAVE REDUCED STRENGTH, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE FRONT OUTER SEAT BELT BUCKLES WITH BUCKLES THAT HAVE BEEN PROPERLY RIVETED.
Apr 8, 1998
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS. THE BRAKE ROTOR MATERIAL STRENGTH IS NOT SUFFICIENT CAUSING A HUB FATIGUE FRACTURE.
Consequence & remedy
Consequence: THIS FRACTURE CAN RESULT IN CRACK PROPAGATION AROUND THE WHEEL MOUNTING BOLT CIRCULE ULTIMATELY RESULTING IN A WHEEL SEPARATION.
Remedy: DEALERS WILL INSPECT THE BRAKE ROTORS AND IF NECESSARY, REPLACE THESE ROTORS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration