NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
78 reportsClear category filterMileage unknown · Sep 24, 2001
Service Brakes, HydraulicVehicle Speed Control
THE THOTTLE STUCK IN THE WIDE OPEN POSITION AND WOULD NOT RETURN TO IDLE. THE BRAKES WERE JUST ABLE TO STOP THE VEHICLE. SHIFTING TO NEUTRAL CAUSED THE ENGINE TO GO WELL INTO THE REDLINE ON THE RPM INDICATOR. PULLING UP ON THE ACCELERATOR PEDAL DID NOTHING. THE DEALER SAID THE LINKAGE WAS RUSTED TIGHT. THEY DON'T HAVE NEW PARTS…
Read full complaint
THE THOTTLE STUCK IN THE WIDE OPEN POSITION AND WOULD NOT RETURN TO IDLE. THE BRAKES WERE JUST ABLE TO STOP THE VEHICLE. SHIFTING TO NEUTRAL CAUSED THE ENGINE TO GO WELL INTO THE REDLINE ON THE RPM INDICATOR. PULLING UP ON THE ACCELERATOR PEDAL DID NOTHING. THE DEALER SAID THE LINKAGE WAS RUSTED TIGHT. THEY DON'T HAVE NEW PARTS SO THEY SCRAPPED THE RUST OFF, OILED IT AND PUT IT BACK TOGETHER. THEY SAID THE THROTTLE CABLE WAS NOT THE PROBLEM AS IN THE RECALL OF "95-96 VEHICLES. THIS IS A HARD TRUCK TO GET STOPPED WHEN THE THROTTLE IS STUCK WIDE OPEN. GOOD THING MY WIFE WASN'T DRIVING IT.*AK
NHTSA ODI #752500
Mileage unknown · Sep 7, 2001
Service Brakes, Hydraulic
LINE RUBBED AGAINST FRAME, AND RUBBED HOLE INTO BRAKE LINE. *AK
NHTSA ODI #751858
Mileage unknown · Aug 28, 2001
Service Brakes, Hydraulic
A RAPID WEAR OF PADS AND ROTORS.
NHTSA ODI #562683
Mileage unknown · Mar 27, 2001
Service Brakes, Hydraulic
PROBLEM WITH ROTORS. THEY HAD ROTORS REPLACED BECAUSE THEY WERE MAKING SOME NOISES. CONTACTED DEALER ,AND DEALER WAS NOT WILLING TO DO ANYTHING.*AK
NHTSA ODI #884329
Mileage unknown · Mar 7, 2001
Fuel System, GasolineService Brakes, Hydraulic
CONSUMER TOOK VEHICLE IN FOR INSPECTION AND FOUND OUT BRAKE PAD FELL OFF. METAL TO METAL RUINED ROTOR. BOTH HAD TO BE CUT BECAUSE OTHER GOOD ONE WAS WORN DOWN. ALSO, FUEL PUMP WENT BAD FOR SECOND TIME. CONSUMER STOPPED AT A STOP AFTER RETURNING FROM STORE AND VEHICLE STALLED. IT NO LONGER STARTED RIGHT UP, IT ALWAYS HEIT…
Read full complaint
CONSUMER TOOK VEHICLE IN FOR INSPECTION AND FOUND OUT BRAKE PAD FELL OFF. METAL TO METAL RUINED ROTOR. BOTH HAD TO BE CUT BECAUSE OTHER GOOD ONE WAS WORN DOWN. ALSO, FUEL PUMP WENT BAD FOR SECOND TIME. CONSUMER STOPPED AT A STOP AFTER RETURNING FROM STORE AND VEHICLE STALLED. IT NO LONGER STARTED RIGHT UP, IT ALWAYS HEITATED LIKE IT WAS NOT TRYING TO CATCH. DEALER SAID IT LOST ITS PROGRAM BECAUSE IT WAS NOT USED ENOUGH. CONSUMERS WARRANTY WAS EXPIRED, COVERED COST.*AK
NHTSA ODI #882328
Mileage unknown · Jan 29, 2001
Air BagsService Brakes, HydraulicCrashInjury
WHILE DRIVING AT APPROXIMATELY 45 MPH CONSUMER APPLIED BRAKE AND SKIDDED ABOUT 10 FEET,HIT ANOTHER VEHICLE HEAD-ON. UPON IMPACT,DRIVER AIRBAGS DID NOT DEPLOY WHICH HAVE CAUSED INJURIES.*AK THE INSPECTORS FROM THE MANUFACTURER INDICATED THAT THE AIR BAGS DID NOT DEPLOY BECAUSE THE IMPACT DISSIPATED. *YH
NHTSA ODI #879163
Mileage unknown · Jan 12, 2001
Service Brakes, HydraulicSuspension
WHILE BRAKING, VEHICLE WILL NOT STOP, DEALER STATES BRAKES ARE WITHING SPECIFICATION. FRONT TIRES KEEP WEARING, DEALER CAN NOT FIND REASON FOR WEAR. *SLC
NHTSA ODI #878123
Mileage unknown · Dec 29, 2000
Parking BrakeService Brakes, HydraulicSteering
POWER STEERING AND BRAKES WENT OUT AT THE SAME TIME WHILE DRIVING, NO ACCIDENT. TRIED TO USE EMERGENCY BRAKE , DID NOT WORK EITHER. CONSUMER USED GEARS TO STOP VEHICLE. REPAIRED, DODGE WILL NOT REIMBURSE BECAUSE REPAIR NOT DONE AT DODGE DEALER. *AK DEALER REPLACED STEERING PUMP AND HET ASSEMBLY FOR EMERGENCY BRAKE. *SLC
NHTSA ODI #877185
Mileage unknown · Dec 18, 2000
Service Brakes, Hydraulic
ALL THREE HAVE BEEN IN TO THE DEALER REGARDING THE SAME EXACT CONCERN. DIFFERENT DRIVERS OPERATE EACH OF THESE VEHICLES. THIS WILL BEE THE SECOND TIME THIS VEHICLE WILL BE GOING BACK TO THE DEALER FOR THE SAME REPAIR. WE ARE CONCERNED ABOUT ALL LIKE VEHICLES HAVING THE SAME CONCERN. WITH THE REAR BRAKES GETTING SEVERELY OUT OF A…
Read full complaint
ALL THREE HAVE BEEN IN TO THE DEALER REGARDING THE SAME EXACT CONCERN. DIFFERENT DRIVERS OPERATE EACH OF THESE VEHICLES. THIS WILL BEE THE SECOND TIME THIS VEHICLE WILL BE GOING BACK TO THE DEALER FOR THE SAME REPAIR. WE ARE CONCERNED ABOUT ALL LIKE VEHICLES HAVING THE SAME CONCERN. WITH THE REAR BRAKES GETTING SEVERELY OUT OF ADJUSTMENT LIKE THEY DO WITH THESE VEHICLES IT IS VERY POSSIBLE THAT A CRASH OCCURS DURING A PANIC STOP DUE TO THE VEHICLE SWERVING. *AK
NHTSA ODI #737941
Mileage unknown · Sep 25, 2000
Air BagsSeat BeltsService Brakes, HydraulicCrashInjury
CONSUMER RAN INTO THE BACK OF ANOTHER TRUCK BECAUSE BRAKES DID NOT CATCH.- ALSO, AIRBAGS DID NOT DEPLOY.*AK DRIVER SIDE SEAT BELT FAILED. *YH
NHTSA ODI #871470
Official recalls
7Jun 14, 2002
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH DIESEL ENGINES ONLY, THE THROTTLE LINKAGE JOINTS CAN CORRODE AND CAUSE THE THROTTLE TO BIND OR STICK.
Consequence & remedy
Consequence: THIS COULD POTENTIALLY RESULT IN A LOSS OF THROTTLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ROD ENDS AND BALL STUDS. OWNER NOTIFICATION BEGAN JULY 29, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
May 8, 2001
VEHICLE DESCRIPTION: PICKUP TRUCKS. SOUND DEADENER MATERIAL INSIDE THE STEERING WHEEL COULD BECOME DETACHED FROM THE COVER AND HOUSING. NOTE: THE RAM PICKUP TRUCKS WERE BUILT AT THE WARREN ASSEMBLY PLANT ("S" IN THE 11TH VIN POSITION) FROM MAY 16, 2000 THROUGH OCTOBER 23, 2000; ST. LOUIS NORTH ASSEMBLY PLANT ("J" IN THE 11TH VIN POSITION) FROM MAY 19, 2000 THROUGH OCTOBER 23, 2000; LAGO ALBERTO ASSEMBLY PLANT ("M" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000; AND SALTILLO ASSEMBLY PLANT ("G" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000. IMPORTANT: VEHICLES THAT HAVE ALREADY HAD THE PROPER CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN EXCLUDED FROM THIS RECALL. IN ADDITION, 1997-2000 MODEL YEAR VEHICLES THAT HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN ADDED TO THIS RECALL.
Consequence & remedy
Consequence: WHEN THIS OCCURS, THE MATERIAL COULD INTERFERE WITH THE CLOCKSPRING RIBBON AND CAUSE AN OPEN CIRCUIT. THE DRIVER AIR BAG SYSTEM WILL BECOME DISABLED, AND THE AIR BAG WARNING LAMP WILL ILLUMINATE ON THE INSTRUMENT PANEL.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY. OWNER NOTIFICATION BEGAN JUNE 18, 2001. ALSO SOME 1997-200 MODEL YEAR VEHICLES THAT, ACCORDING TO WARRANTY RECORDS, HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, WILL ALSO BE INCLUDED IN THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Feb 12, 2001
ON CERTAIN PICKUP TRUCKS ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING "SALT BELT" STATES: MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, AND MISSOURI. CORROSION OF THE RETURN SPRING ON THE HOOD SECONDARY LATCH COULD CAUSE THE MECHANISM TO BIND IN THE "RELEASE POSITION."
Consequence & remedy
Consequence: IF THE PRIMARY LATCH IS NOT ENGAGED, THE HOOD COULD OPEN UNEXPECTEDLY.
Remedy: DEALERS WILL REPLACE THE SECONDARY HOOD LATCH. OWNER NOTIFICATION BEGAN SEPTEMBER 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
May 6, 1999
VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSION, V10 ENGINES AND FOUR-WHEEL-DRIVE TRANSFER CASES. UNDER SUSTAINED MAXIMUM RATED VEHICLE LOAD, WHILE DRIVING UP A STEEP GRADE IN FOUR-WHEEL-DRIVE LOW RANGE IN HOT AMBIENT CONDITIONS, THE LOCAL EXHAUST TEMPERATURE PROXIMATE TO THE HYDRAULIC CLUTCH LINE CAN GENERATE LINE TEMPERATURES THAT EXCEED THE TEMPERATURE LIMIT OF THE CLUTCH LINE MATERIAL. IF THIS CONDITION OCCURS AND THE CLUTCH IS DEPRESSED, THE LINE COULD RUPTURE.
Consequence & remedy
Consequence: THE FLUID COULD IGNITE ON THE HOT EXHAUST POSSIBLY RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL REPLACE THE HYDRAULIC CLUTCH ASSEMBLY.
Feb 5, 1999
VEHICLE DESCRIPTION: VAN AND WAGON MODEL PASSENGER VEHICLES. IF WATER/ROAD SALT GETS ON THE INTERIOR FLOOR OF THE VEHICLE IN THE PROXIMITY OF THE AIR BAG ELECTRONIC CONTROL MODULE (AECM), THE AECM CAN CORRODE. THE RESULTING CORROSION CAN CAUSE THE DRIVER SIDE AIR BAG TO DEPLOY INADVERTENTLY.
Consequence & remedy
Consequence: DEPLOYMENT OF THE AIR BAG WITHOUT WARNING COULD CAUSE A DRIVER TO LOSE VEHICLE CONTROL, INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WIL REPLACE THE AECM WITH AN AECM THAT IS SEALED FROM MOISTURE INTRUSION.
Aug 18, 1997
VEHICLE DESCRIPTION: LIGHT DUTY TRUCKS EQUIPPED WITH DIESEL ENGINES. THE EXHAUST PIPE CONTACTS OR IS IN CLOSE PROXIMITY TO THE OUTER DASH PANEL SILENCER PAD.
Consequence & remedy
Consequence: IF THE EXHAUST PIPE GENERATES SUFFICIENT HEAT, THE PAD MATERIAL CAN SMOLDER AND IGNITE ADJACENT MATERIALS RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL REMOVE THE DASH SILENCER PAD ADJACENT TO THE EXHAUST PIPE AND REPLACE THIS PAD WITH A THERMAL HEAT SHIELD ON THE EXHAUST PIPE.
May 5, 1997
UNDER CERTAIN HIGH LOAD OPERATING CONDITIONS, THE TRANSMISSION FLUID TEMPERATURE CAN EXCEED THE MELTING POINT OF THE MATERIAL USED IN THE CONNECTOR TO RETAIN THE FLUID LINE TO THE TRANSMISSION.
Consequence & remedy
Consequence: WHEN THESE TEMPERATURES OCCUR, THE FLUID LINE WILL NOT STAY CONNECTED WITH THE TRANSMISSION AND FLUID CAN SPRAY ONTO THE EXHAUST MANIFOLD, RESULTING IN SMOKE OR FIRE.
Remedy: DEALERS WILL REPLACE THE HIGH TEMPERATURE SIDE OF THE TRANSMISSION FLUID COOLER LINE CONNECTOR FITTINGS WITH CONNECTORS THAT INCORPORATE A STAINLESS STEEL RETAINER.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5DP03006 · Seat Back Failure
Opened Sep 23, 2003 · Closed Apr 8, 2004
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:recliner
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
Additional source detail variants (2)
Seats
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
Seats:front Assembly:recliner
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
RQ00012 · Hood Latch
Opened May 3, 2000 · Closed Apr 20, 2001
Status: closed (inferred from source dates) · Structure
ONMARCH 20, 1995, DAIMLERCHRYSLER FILED A DEFECT REPORT FOR 181,008 1994 AND 1995 DODGE RAM TRUCKS MANUFACTUREDC FROM JANUARY 21, 1994 - OCTOBER 25, 1994 AT THE DODGE CITY ASSEMBLY PLANT AND FROM MARCH 26, 1994 - DECEMBER 8, 1994 AT THE LAGO ALBERTO ASSEMBLY PLANT.THE SECONDARY HOOD LATCH ROD COULD BIND ON THE GUIDE BRACKET AND PREVENT ENGAGEMENT OF THE SECONDARY LATCH.IF THIS OCCURS WHEN THE PRIMARY LATCH IS NOT ENGAGED, THE HOOD COULD FLY UP WHEN THE VEHICLE IS BEING DRIVEN AND OBSTRUCT THE DRIER'S VISION INCREASING THE POTENTIAL FOR A CRASH.THE RECALL REMEDY WAS TO REPLACE THE SEDCONDARY HOOD LATCH.OWNERS WERE NOTIFIED IN AUGUST OF 1995.THIS RECALL RATE AS OF 2/97 WAS 68%
Additional source detail variants (2)
Structure
ONMARCH 20, 1995, DAIMLERCHRYSLER FILED A DEFECT REPORT FOR 181,008 1994 AND 1995 DODGE RAM TRUCKS MANUFACTUREDC FROM JANUARY 21, 1994 - OCTOBER 25, 1994 AT THE DODGE CITY ASSEMBLY PLANT AND FROM MARCH 26, 1994 - DECEMBER 8, 1994 AT THE LAGO ALBERTO ASSEMBLY PLANT.THE SECONDARY HOOD LATCH ROD COULD BIND ON THE GUIDE BRACKET AND PREVENT ENGAGEMENT OF THE SECONDARY LATCH.IF THIS OCCURS WHEN THE PRIMARY LATCH IS NOT ENGAGED, THE HOOD COULD FLY UP WHEN THE VEHICLE IS BEING DRIVEN AND OBSTRUCT THE DRIER'S VISION INCREASING THE POTENTIAL FOR A CRASH.THE RECALL REMEDY WAS TO REPLACE THE SEDCONDARY HOOD LATCH.OWNERS WERE NOTIFIED IN AUGUST OF 1995.THIS RECALL RATE AS OF 2/97 WAS 68%
Structure
ONMARCH 20, 1995, DAIMLERCHRYSLER FILED A DEFECT REPORT FOR 181,008 1994 AND 1995 DODGE RAM TRUCKS MANUFACTUREDC FROM JANUARY 21, 1994 - OCTOBER 25, 1994 AT THE DODGE CITY ASSEMBLY PLANT AND FROM MARCH 26, 1994 - DECEMBER 8, 1994 AT THE LAGO ALBERTO ASSEMBLY PLANT.THE SECONDARY HOOD LATCH ROD COULD BIND ON THE GUIDE BRACKET AND PREVENT ENGAGEMENT OF THE SECONDARY LATCH.IF THIS OCCURS WHEN THE PRIMARY LATCH IS NOT ENGAGED, THE HOOD COULD FLY UP WHEN THE VEHICLE IS BEING DRIVEN AND OBSTRUCT THE DRIER'S VISION INCREASING THE POTENTIAL FOR A CRASH.THE RECALL REMEDY WAS TO REPLACE THE SEDCONDARY HOOD LATCH.OWNERS WERE NOTIFIED IN AUGUST OF 1995.THIS RECALL RATE AS OF 2/97 WAS 68%
RQ98002 · Transmission Quick Connectors
Opened Mar 10, 1998 · No close date supplied
Status: open (inferred from source dates) · Power Train:automatic Transmission:cooling Unit And Lines
ON APRIL 17, 1997, THE CHRYSLER CORPORATION FILED A DEFECT INFORMATION REPORT CONCERNING APPROXIMATELY 800,000 1994 THROUGH 1997 DODGE RAM PICKUPS EQUIPPED WITH V6 OR V8 ENGINES AND AUTOMATIC TRANSMISSIONS, 1995 THROUGH 1997DODGE RAM PICKUPS EQUIPPED WITH THE V10 ENGINE AND AUTOMATIC TRANSMISSION, AND THE 1995 AND 1996 DODGE RAM VAN/WAGON EQUIPPED WITH AUTOMATIC TRANSMISSION.ODI HAS RECEIVED ELEVEN REPORTS CONCERNING TRANSMISSION LEAKAGES FROM THE QUICK CONNECTOR JOINTS RESULTING IN EIGHT FIRES.THE REPORTED VEHICLES INCLUDED ARE THE 1994 AND 1995 JEEP WRANGLER, 1995 AND 1996 CHEROKEE, 1993 THROUGH 1996 GRAND CHEROKEE, AND 1994 AND 1995 DODGE DAKOTA.THE PURPOSE OF THIS INVESTIGATION IS TO EXAMINE THE SCOPE OF RECALL 97V-084.CLOSING SUMMARY: FURTHER INVESTIGATION OF CONSUMER REPORTS REVEALED THAT SOME OF THE TRANSMISSION LEAKAGE WAS DUE TO OTHER CONNECTIONS ALONG THE COOLING LINES.IN THE FIRE INCIDENTS, THERE WERE INDICATIONS THAT SOME OF THESE VEHICLES WERE EITHER USED BEYOND THE VEHICLE'S TOWING CAPABILITY OR HAD IMPROPER TRANSMISSION REPAIR.IN ADDITION, THE RECALLED RAM PICKUP TRUCKS, 98V-084, HAVE AN EXHAUST MANIFOLD NEAR THE PLASTIC QUICK CONNECTOR JOINTS WHICH EFFECTIVELY PRESENTS A HEAT SOURCE TO IGNITE THE HOT TRANSMISSION FLUID IN THE EVENT OF A LEAKAGE.THE SUBJECT VEHICLES' QUICK CONNECTOR JOINTS ARE EITHER TOO FAR, OR POSITIONED COMPLETELY AWAY, FROM A HEAT SOURCE OR EXHAUST COMPONENTS.CONSEQUENTLY, THE FIRE REPORTS OF THE SUBJECT VEHICLES ARE SIGNIFICANTLY LESS THAN THOSE OF THE DODGE RAM PICKUP TRUCKS.BASED ON THE AVAILABLE INFORMATION, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY FUTURE CIRCUMSTANCES.
EA98005 · Clutch Hydraulic Line
Opened Feb 27, 1998 · Closed May 24, 1999
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
ALLEGED PLASTIC CLUTCH TUBE MAY FAIL FROM EXPOSURE TO EXHAUST HEAT, RESULTING IN LOSS OF CLUTCH FUNCTION AND POSSIBLE VEHICLE FIRE.
PE97043 · Clutch Hydraulic Line Failure
Opened Oct 20, 1997 · Closed Feb 27, 1998
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
ALLEGED CLUTCH LINE MAY MELT AND LEAK HYDRAULIC FLUID IN THE VICINITY OF THE EXHAUST MANIFOLD.LEAKED HYDRAULIC FLUID COULD IGNITE AND CAUSE A VEHICLE FIRE.
Illustration