NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
469 reportsMileage unknown · Oct 31, 2024
SuspensionVehicle Speed Control
The contact owns a 1994 Dodge Ram 2500. The contact became aware that the VIN was included in NHTSA Campaign Numbers: 01V037000 (Vehicle Speed Control) and 99V214000 (Suspension); however, the parts to do the recall repairs were not yet available. The local dealer and a second dealer, Chrysler Dodge Jeep Ram (5401 I-30 Frontage …
Read full complaint
The contact owns a 1994 Dodge Ram 2500. The contact became aware that the VIN was included in NHTSA Campaign Numbers: 01V037000 (Vehicle Speed Control) and 99V214000 (Suspension); however, the parts to do the recall repairs were not yet available. The local dealer and a second dealer, Chrysler Dodge Jeep Ram (5401 I-30 Frontage Rd, Greenville, TX 75402), were contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and informed the contact that they were not required to perform the recall repair because the vehicle was more than 10 years old. However, the vehicle was not more than 10 years old on the date the defect or noncompliance was determined. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA ODI #11622978
125,254 miles · Dec 14, 2004
Power Train
CONSUMER'S VEHICLE EXPERIENCED THE SAME PROBLEMS AS MENTIONED IN RECALL 97V084000 CONCERNING TRANSMISSION COOLING LINES. DEALERSHIP WOULD NOT REPAIR VEHICLE FREE OF CHARGE BECAUSE THE VIN WAS NOT INCLUDED. *AK THE TRUCK'S TRANSMISSION LOCKED UP WHILE DRIVING WHICH CAUSED THE IT TO STALL. THE VEHICLE WAS TAKEN TO THE DEALER …
Read full complaint
CONSUMER'S VEHICLE EXPERIENCED THE SAME PROBLEMS AS MENTIONED IN RECALL 97V084000 CONCERNING TRANSMISSION COOLING LINES. DEALERSHIP WOULD NOT REPAIR VEHICLE FREE OF CHARGE BECAUSE THE VIN WAS NOT INCLUDED. *AK THE TRUCK'S TRANSMISSION LOCKED UP WHILE DRIVING WHICH CAUSED THE IT TO STALL. THE VEHICLE WAS TAKEN TO THE DEALER WHO DETERMINED THAT THE COOLING LINE CONNECTION CAME APART FROM THE TRANSMISSION WHICH CAUSE ALL THE TRANSMISSION FLUID TO LEAK FROM THE VEHICLE. *NM
NHTSA ODI #10099874
139,000 miles · Sep 24, 2004
Engine And Engine Cooling
WHILE THE VEHICLE WAS PARKED AND RUNNING AND CONSUMER WAS STANDING IN THE REAR OF VEHICLE WHITE SMOKE CAME FROM THE REAR OF THE VEHICLE. THIS CAUSED HEALTH PROBLEMS TO THE CONSUMER. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
NHTSA ODI #10094285
30,000 miles · Jul 29, 2004
Power Train
TRANSMISSION FAILED AFTER 30000 MILE WARRANTY PERIOD. CONSUMER STATED HE OWNED FOUR OF THE SAME VEHICLES, AND THE SAME THING HAPPENED WITH THE TRANSMISSION. *AK
NHTSA ODI #10083814
Mileage unknown · Jul 23, 2004
Power Train
WHILE DRIVING 45 MPH VEHICLE SHIMMIED VIOLENTLY. CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE, AND DROVE IT TO THE DEALER FOR INSPECTION. MECHANIC COULD NOT DUPLICATE THE PROBLEM. *AK
NHTSA ODI #10083586
133,000 miles · Mar 23, 2004
Latches/locks/linkages
WHILE DRIVING 45 MPH HOOD LATCH SNAPPED. THIS CAUSED THE HOOD TO FLY BACK ONTO THE WINDSHIELD. CONSUMER MANAGED TO PULL OVER. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. THE CONSUMER HAD THE PROBLEM RESOLVED BY AN INDEPENDENT MECHANIC. *AK
NHTSA ODI #10064696
120,000 miles · Dec 3, 2003
Power Train
RECALL NO. 97V084000: CONSUMER NOTICED THAT ON SEVERAL OCCASIONS TRANSMISSION FLUID WAS LEAKING ON THE GROUND UNDER THE VEHICLE. UPON LOOKING UNDER THE VEHICLE IT WAS DISCOVERED THAT THE COOLING UNIT LINE RETAINER WAS MISSING, CAUSING THE FLUID TO LEAK. DEALER INSPECTED THE VEHICLE, AND INFORMED THE CONSUMER THAT THE AUTOM…
Read full complaint
RECALL NO. 97V084000: CONSUMER NOTICED THAT ON SEVERAL OCCASIONS TRANSMISSION FLUID WAS LEAKING ON THE GROUND UNDER THE VEHICLE. UPON LOOKING UNDER THE VEHICLE IT WAS DISCOVERED THAT THE COOLING UNIT LINE RETAINER WAS MISSING, CAUSING THE FLUID TO LEAK. DEALER INSPECTED THE VEHICLE, AND INFORMED THE CONSUMER THAT THE AUTOMATIC COOLING UNIT LINE WAS LEAKING. A RECALL FOR THIS PROBLEM WAS ISSUED, BUT CONSUMER'S VEHICLE WAS NOT INCLUDED DUE TO VIN. *AK
NHTSA ODI #10049958
Mileage unknown · Aug 27, 2003
Service Brakes, HydraulicVehicle Speed ControlCrash
THE ABS LIGHT ILLUMINATED ON THE DASH. THEN VEHICLE SUDDENLY ACCELERATED TOWARDS TRAFFIC WHICH RESULTEDC IN AN A COLLISION WITH ANOTHER VEHICLE. *AK
NHTSA ODI #10037773
Mileage unknown · Aug 14, 2003
Vehicle Speed ControlCrash
TRUCK WAS IN PARK AND WITHOUT PRIOR WARNING IT SUDDENLY JUMPED OUT GEAR, ACCELERATING UP TO 50 MPH. UPON UNCONTROLLABLE ACCELERATION THE TRUCK HIT A TREE. *AK
NHTSA ODI #10033952
143,000 miles · Jun 30, 2003
Tires
WHILE DRIVING DRIVER SIDE REAR TIRE OUTTER TREAD FLEW OFF AND IMPACTED THE SIDE OF THE VEHICLE.*AK
NHTSA ODI #10026247
Official recalls
18Feb 12, 2001
VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH DIESEL ENGINES. THE THROTTLE CABLE COULD UNRAVEL (FRAY) OR BREAK RESULTING IN LOSS OF THROTTLE CONTROL.
Consequence & remedy
Consequence: A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN UNEXPECTED ACCELERATION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE THROTTLE CABLE AND UPPER BELL CRANK LEVER. OWNER NOTIFICATION BEGAN AUGUST 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Feb 12, 2001
ON CERTAIN PICKUP TRUCKS ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING "SALT BELT" STATES: MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, AND MISSOURI. CORROSION OF THE RETURN SPRING ON THE HOOD SECONDARY LATCH COULD CAUSE THE MECHANISM TO BIND IN THE "RELEASE POSITION."
Consequence & remedy
Consequence: IF THE PRIMARY LATCH IS NOT ENGAGED, THE HOOD COULD OPEN UNEXPECTEDLY.
Remedy: DEALERS WILL REPLACE THE SECONDARY HOOD LATCH. OWNER NOTIFICATION BEGAN SEPTEMBER 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
May 10, 2000
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS. THE AFFECTED VEHICLES WERE BUILT WITH AN IGNITION SWITCH AND WIRING THAT COULD OVERHEAT. HIGH ELECTRICAL CURRENT LOADS PASS THROUGH THE SWITCH WHEN THE BLOWER MOTOR IS OPERATED ON HIGH FOR AN EXTENDED PERIODS OF TIME.
Consequence & remedy
Consequence: THIS COULD CAUSE THE IGNITION SWITCH AND WIRING TO OVERHEAT.
Remedy: DEALERS WILL INSTALL A RELAY AND OVERLAY HARNESS.
Aug 9, 1999
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS. (2500 AND 3500 SERIES 4X4 REGULAR CAB PICKUP PRODUCED BEFORE MARCH 21, 1995; 2500 AND 3500 SERIES 4X4 CLUB CAB PICKUP PRODUCED BEFORE JUNE 8, 1995; AND 3500 SERIES 4X2/4X4 CHASSIS CAB TRUCKS PRODUCED BEFORE JUNE 21, 1995). THE FRONT SUSPENSION SPRING/SHOCK TOWERS CAN CRACK AND EVENTUALLY SEPARATE FROM THE VEHICLE FRAME. THE SHOCK TOWER COULD DAMAGE THE REAR WHEEL BRAKE LINES RESULTING IN LOSS OF REAR BRAKE SYSTEM PRESSURE.
Consequence & remedy
Consequence: THIS WOULD CREATE THE POTENTIAL FOR INCREASED STOPPING DISTANCES.
Remedy: DEALERS WILL INSPECT THE SPRING/SHOCK TOWER AND ANY VEHICLES EXHIBITING CRACKING WILL HAVE THE TOWER REPLACED. VEHICLES THAT ARE DO NOT SHOW ANY CRACKING WILL HAVE A WELD-ON REINFORCEMENT ADDED.
May 6, 1999
VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSION, V10 ENGINES AND FOUR-WHEEL-DRIVE TRANSFER CASES. UNDER SUSTAINED MAXIMUM RATED VEHICLE LOAD, WHILE DRIVING UP A STEEP GRADE IN FOUR-WHEEL-DRIVE LOW RANGE IN HOT AMBIENT CONDITIONS, THE LOCAL EXHAUST TEMPERATURE PROXIMATE TO THE HYDRAULIC CLUTCH LINE CAN GENERATE LINE TEMPERATURES THAT EXCEED THE TEMPERATURE LIMIT OF THE CLUTCH LINE MATERIAL. IF THIS CONDITION OCCURS AND THE CLUTCH IS DEPRESSED, THE LINE COULD RUPTURE.
Consequence & remedy
Consequence: THE FLUID COULD IGNITE ON THE HOT EXHAUST POSSIBLY RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL REPLACE THE HYDRAULIC CLUTCH ASSEMBLY.
Nov 13, 1997
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH GASOLINE ENGINES. THE FUEL TANK MOUNTED ROLLOVER VALVE CAN ALLOW LIQUID FUEL TO LEAK ONTO THE GROUND UNDER CERTAIN VEHICLE OPERATING CONDITIONS.
Consequence & remedy
Consequence: FUEL LEAKAGE COULD RESULT IN A FIRE IF AN IGNITION SOURCE WAS PRESENT.
Remedy: DEALERS WILL REPLACE THE FUEL TANK ROLLOVER VALVE WITH A FLOAT TYPE ROLLOVER VALVE.
May 5, 1997
UNDER CERTAIN HIGH LOAD OPERATING CONDITIONS, THE TRANSMISSION FLUID TEMPERATURE CAN EXCEED THE MELTING POINT OF THE MATERIAL USED IN THE CONNECTOR TO RETAIN THE FLUID LINE TO THE TRANSMISSION.
Consequence & remedy
Consequence: WHEN THESE TEMPERATURES OCCUR, THE FLUID LINE WILL NOT STAY CONNECTED WITH THE TRANSMISSION AND FLUID CAN SPRAY ONTO THE EXHAUST MANIFOLD, RESULTING IN SMOKE OR FIRE.
Remedy: DEALERS WILL REPLACE THE HIGH TEMPERATURE SIDE OF THE TRANSMISSION FLUID COOLER LINE CONNECTOR FITTINGS WITH CONNECTORS THAT INCORPORATE A STAINLESS STEEL RETAINER.
Nov 18, 1996
IF THE PLASTIC PINS AND METAL CLIP THAT RETAIN THE LOWER STEERING SHAFT IN THE UPPER SHAFT BREAK, THE LOWER STEERING SHAFT CAN SEPARATE FROM THE UPPER SHAFT.
Consequence & remedy
Consequence: IF THE LOWER STEERING SHAFT SEPARATES FROM THE UPPER SHAFT, LOSS OF VEHICLE CONTROL CAN OCCUR INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL ADD A RESTRAINING SLEEVE TO THE INTERMEDIATE STEERING SHAFT TO LIMIT THE AMOUNT OF AXIAL STEERING COLUMN SHAFT MOVING IN THE EVENT THE PLASTIC PINS AND METAL CLIP ARE BROKEN.
May 12, 1995
WHILE MAKING A TURN, THE EXTRA KEYS ON A VEHICLE OPERATOR'S KEY RING CAN BECOME TEMPORARILY LODGED IN THE SCREW ACCESS HOLES IN THE BACK COVER OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION CAN HAMPER THE STEERING WHEEL RETURN ORCAUSE THE IGNITION TO BE TURNED OFF, RESULTING IN LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Remedy: DEALERS WILL REPLACE THE STEERING WHEEL BACK COVER WITH A REDESIGNED COVER.
Mar 21, 1995
THE SECONDARY HOOD LATCH ROD CAN BIND ON THE GUIDE BRACKET AND PREVENT ENGAGEMENT OF THE SECONDARY LATCH.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE THE HOOD TO FLY UP OBSTRUCTING THE DRIVER'S VISION INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE SECONDARY HOOD LATCH BRACKET.
Feb 14, 1995
THE RIGHT OUTSIDE REARVIEW MIRROR CONTAINS CONVEX GLASS RATHER THAN FLAT. THEREFORE, THESE VEHICLES FAIL TO COMPLY WITH FMVSS NO. 111, "REARVIEW MIRRORS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: THE IMAGES PRESENTED IN THE MIRROR ARE CLOSER THAN THEY APPEAR WHICH MAY CAUSE THE DRIVER TO MISJUDGE THE DISTANCE FROM THE OBJECT TO THE REAR OF THE VEHICLE, AND COULD RESULT IN AN ACCIDENT.
Remedy: DEALERS WILL REPLACE THE RIGHT OUTSIDE REARVIEW MIRROR WITH A MIRROR HAVING A FLAT SURFACE.
Jan 18, 1995
THE CINCH BAR COMPONENT WITHIN THE PASSENGER SIDE SAFETY BELT BUCKLE ASSEMBLY SHATTERS CAUSING THE BELT TO RELEASE.
Consequence & remedy
Consequence: THE PASSENGER WOULD NOT BE PROPERLY RESTRAINED AND COULD BE INJURED IN THE EVENT OF A SUDDEN STOP OR ACCIDENT.
Remedy: DEALERS WILL REPLACE THE CINCH BAR WITH A NEWLY DESIGNED PART.
Oct 18, 1994
THE FRONT SUSPENSION TRACK BAR BRACKET ATTACHMENT HAS INADEQUATE FATIGUE STRENGTH AND CAN FAIL, CAUSING FRONT AXLE VIBRATION.
Consequence & remedy
Consequence: THIS CAN RESULT IN LOSS OF STEERING CONTROL AND AN ACCIDENT.
Remedy: A FRONT SUSPENSION TRACK BAR BRACKET REINFORCEMENT STRUT WILL BE INSTALLED.
Jul 11, 1994
THE TRANSFORMER USED TO POWER THE NEON CENTER LIGHTBEAM CAN OVERHEAT AND CATCH ON FIRE.
Consequence & remedy
Consequence: THE OVERHEATING AND FIRES CAUSED BY THE NEON TRANSFORMER CAN RESULT IN DAMAGE TO THE LIGHTBEAM ASSEMBLY, THE ROOF OF THE VEHICLE, AND COULD RESULT IN A VEHICLE FIRE.
Remedy: MARK III DEALERS WILL MODIFY THE ASSEMBLIES TO ELIMINATE THE NEON LIGHTING FIXTURE IN THE VEHICLE AND REPLACE IT WITH INCANDESCENT LIGHTS OPERATING DIRECTLY FROM THE VEHICLE 12-VOLT BATTERY.
Jun 20, 1994
THESE VEHICLES DO NOT MEET THE REAR IMPACT TEST REQUIREMENTS OF FMVSS 301, "FUEL SYSTEM INTEGRITY."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: THE VEHICLE S HAVE AN INCREASED RISK OF A FUEL SPILL IN THE EVENT OF A REAR END COLLISION.
Remedy: DEALERS WILL STRENGTHEN THE LEFT FRAME RAIL BY INSTALLING A FRAME RAIL REINFORCEMENT BRACKET.
May 20, 1994
THE FRONT SUSPENSION TRACK BAR HAS INADEQUATE FATIGUE STRENGTH.
Consequence & remedy
Consequence: FAILURE OF THE TRACK BAR CAN RESULT IN FRONT AXLE VIBRATION AND LOSS OF STEERING CONTROL.
Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION TRACK BAR.
Dec 14, 1993
THE SEAT BACK LATCH LEVER PIVOT RIVETS ARE SUSCEPTIBLE TO DISTORTION. THE DISTORTED ASSEMBLIES ALLOW THE SEAT BACK RELEASE LATCH LEVER TO REMAIN IN THE RELEASED POSITION WHICH IS IN NON-COMPLIANCE WITH FMVSS NO. 207, "SEATING SYSTEMS."
Consequence & remedy
Consequence: IN THE EVENT OF A SUDDEN STOP OR ACCIDENT THE FORCES ONTHE SEAT BACK MAY SUBJECT SEAT OCCUPANTS TO AN INCREASED RISK OF INJURY.
Remedy: DEALERS WILL REPLACE THE SUSPECT SEAT BACK LATCH ASSEMBLY WITH A REVISED ASSEMBLY.
Oct 22, 1993
FRONT SUSPENSION TRACK BAR ATTACHMENT TO THE AXLE MAY NOT BE ADEQUATELY TIGHTENED.
Consequence & remedy
Consequence: LOSS OF THE TRACK BAR ATTACHMENT CAN CAUSE AXLEVIBRATION AND DIRECTIONAL CONTROL DIFFICULTY WHICH COULD RESULT IN LOSS OFVEHICLE CONTROL AND AN ACCIDENT.
Remedy: TIGHTEN FRONT SUSPENSION TRACK BAR AXLE ATTACHMENT TO THE SPECIFIED TORQUE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
13DP03006 · Seat Back Failure
Opened Sep 23, 2003 · Closed Apr 8, 2004
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:recliner
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
Additional source detail variants (2)
Seats
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
Seats:front Assembly:recliner
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
RQ00012 · Hood Latch
Opened May 3, 2000 · Closed Apr 20, 2001
Status: closed (inferred from source dates) · Structure
ONMARCH 20, 1995, DAIMLERCHRYSLER FILED A DEFECT REPORT FOR 181,008 1994 AND 1995 DODGE RAM TRUCKS MANUFACTUREDC FROM JANUARY 21, 1994 - OCTOBER 25, 1994 AT THE DODGE CITY ASSEMBLY PLANT AND FROM MARCH 26, 1994 - DECEMBER 8, 1994 AT THE LAGO ALBERTO ASSEMBLY PLANT.THE SECONDARY HOOD LATCH ROD COULD BIND ON THE GUIDE BRACKET AND PREVENT ENGAGEMENT OF THE SECONDARY LATCH.IF THIS OCCURS WHEN THE PRIMARY LATCH IS NOT ENGAGED, THE HOOD COULD FLY UP WHEN THE VEHICLE IS BEING DRIVEN AND OBSTRUCT THE DRIER'S VISION INCREASING THE POTENTIAL FOR A CRASH.THE RECALL REMEDY WAS TO REPLACE THE SEDCONDARY HOOD LATCH.OWNERS WERE NOTIFIED IN AUGUST OF 1995.THIS RECALL RATE AS OF 2/97 WAS 68%
Additional source detail variants (2)
Structure
ONMARCH 20, 1995, DAIMLERCHRYSLER FILED A DEFECT REPORT FOR 181,008 1994 AND 1995 DODGE RAM TRUCKS MANUFACTUREDC FROM JANUARY 21, 1994 - OCTOBER 25, 1994 AT THE DODGE CITY ASSEMBLY PLANT AND FROM MARCH 26, 1994 - DECEMBER 8, 1994 AT THE LAGO ALBERTO ASSEMBLY PLANT.THE SECONDARY HOOD LATCH ROD COULD BIND ON THE GUIDE BRACKET AND PREVENT ENGAGEMENT OF THE SECONDARY LATCH.IF THIS OCCURS WHEN THE PRIMARY LATCH IS NOT ENGAGED, THE HOOD COULD FLY UP WHEN THE VEHICLE IS BEING DRIVEN AND OBSTRUCT THE DRIER'S VISION INCREASING THE POTENTIAL FOR A CRASH.THE RECALL REMEDY WAS TO REPLACE THE SEDCONDARY HOOD LATCH.OWNERS WERE NOTIFIED IN AUGUST OF 1995.THIS RECALL RATE AS OF 2/97 WAS 68%
Structure
ONMARCH 20, 1995, DAIMLERCHRYSLER FILED A DEFECT REPORT FOR 181,008 1994 AND 1995 DODGE RAM TRUCKS MANUFACTUREDC FROM JANUARY 21, 1994 - OCTOBER 25, 1994 AT THE DODGE CITY ASSEMBLY PLANT AND FROM MARCH 26, 1994 - DECEMBER 8, 1994 AT THE LAGO ALBERTO ASSEMBLY PLANT.THE SECONDARY HOOD LATCH ROD COULD BIND ON THE GUIDE BRACKET AND PREVENT ENGAGEMENT OF THE SECONDARY LATCH.IF THIS OCCURS WHEN THE PRIMARY LATCH IS NOT ENGAGED, THE HOOD COULD FLY UP WHEN THE VEHICLE IS BEING DRIVEN AND OBSTRUCT THE DRIER'S VISION INCREASING THE POTENTIAL FOR A CRASH.THE RECALL REMEDY WAS TO REPLACE THE SEDCONDARY HOOD LATCH.OWNERS WERE NOTIFIED IN AUGUST OF 1995.THIS RECALL RATE AS OF 2/97 WAS 68%
DP00002 · Steering Column Fire
Opened Jan 20, 2000 · Closed Apr 24, 2000
Status: closed (inferred from source dates) · Steering
ALLEGES THAT THE POOR DESIGN OF THE IGNITION SWITCH ASSEMBLY AND//OR THE KEY CYLINDER ASSEMBLY IN THE MODEL YEAR 1991-2000 VEHICLES MAY CAUSE THE STEERING COLUMN TO CATCH FIRE
EA99027 · Steering Column Fires
Opened Sep 10, 1999 · Closed May 30, 2000
Status: closed (inferred from source dates) · Power Train
ODI has received 33 complaints alleging excessive heat in the ignition switch and related circuitry in 1994-1996 Dodge Ram trucks.The root cause is an excessive current draw through the ignition switch result in fire, smoke, melting of surrounding plastics, stalling and the illumination of air bag and anti-lock brake system (ABS) warnig lights. DaimlerChrsler has been aware of the potential for this failure and implemented a design change to reduce the current draw through the switch.This design change involved the installation of a relay in the blower motor circuitry for all Ram trucks built after March 15,1996.DaimlerChrysler also made available an ignition switch repair package (PN 4874996) which includes the necessary components to upgrade vehicles built prior to the implementation date.DaimleChrysler also issued a correspondence to its zones instructing technicians to replace failed ignition switches in the subject population with the sevice kit only.An Engineering Analysis is necessary to determine if a safety defect trend exists.ODI will focus its investigation on fires in the steering column area as well as the effects of switch failure on the ABS and air bag system.
PE99031 · Ignition Switch
Opened May 5, 1999 · Closed Sep 10, 1999
Status: closed (inferred from source dates) · Power Train
COMPLAINANTS ALLEGE FIRES, MELTING, SMOKE OR EXCESSIVE HEAT IN THE VICINITY OF THE IGNITION SWITCH
RQ98002 · Transmission Quick Connectors
Opened Mar 10, 1998 · No close date supplied
Status: open (inferred from source dates) · Power Train:automatic Transmission:cooling Unit And Lines
ON APRIL 17, 1997, THE CHRYSLER CORPORATION FILED A DEFECT INFORMATION REPORT CONCERNING APPROXIMATELY 800,000 1994 THROUGH 1997 DODGE RAM PICKUPS EQUIPPED WITH V6 OR V8 ENGINES AND AUTOMATIC TRANSMISSIONS, 1995 THROUGH 1997DODGE RAM PICKUPS EQUIPPED WITH THE V10 ENGINE AND AUTOMATIC TRANSMISSION, AND THE 1995 AND 1996 DODGE RAM VAN/WAGON EQUIPPED WITH AUTOMATIC TRANSMISSION.ODI HAS RECEIVED ELEVEN REPORTS CONCERNING TRANSMISSION LEAKAGES FROM THE QUICK CONNECTOR JOINTS RESULTING IN EIGHT FIRES.THE REPORTED VEHICLES INCLUDED ARE THE 1994 AND 1995 JEEP WRANGLER, 1995 AND 1996 CHEROKEE, 1993 THROUGH 1996 GRAND CHEROKEE, AND 1994 AND 1995 DODGE DAKOTA.THE PURPOSE OF THIS INVESTIGATION IS TO EXAMINE THE SCOPE OF RECALL 97V-084.CLOSING SUMMARY: FURTHER INVESTIGATION OF CONSUMER REPORTS REVEALED THAT SOME OF THE TRANSMISSION LEAKAGE WAS DUE TO OTHER CONNECTIONS ALONG THE COOLING LINES.IN THE FIRE INCIDENTS, THERE WERE INDICATIONS THAT SOME OF THESE VEHICLES WERE EITHER USED BEYOND THE VEHICLE'S TOWING CAPABILITY OR HAD IMPROPER TRANSMISSION REPAIR.IN ADDITION, THE RECALLED RAM PICKUP TRUCKS, 98V-084, HAVE AN EXHAUST MANIFOLD NEAR THE PLASTIC QUICK CONNECTOR JOINTS WHICH EFFECTIVELY PRESENTS A HEAT SOURCE TO IGNITE THE HOT TRANSMISSION FLUID IN THE EVENT OF A LEAKAGE.THE SUBJECT VEHICLES' QUICK CONNECTOR JOINTS ARE EITHER TOO FAR, OR POSITIONED COMPLETELY AWAY, FROM A HEAT SOURCE OR EXHAUST COMPONENTS.CONSEQUENTLY, THE FIRE REPORTS OF THE SUBJECT VEHICLES ARE SIGNIFICANTLY LESS THAN THOSE OF THE DODGE RAM PICKUP TRUCKS.BASED ON THE AVAILABLE INFORMATION, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY FUTURE CIRCUMSTANCES.
RQ97012 · Steering Wheel And Column
Opened Sep 25, 1997 · No close date supplied
Status: open (inferred from source dates) · Steering: Steering Wheel/handle Bar
There is no summary currently available
PE96070 · Transmission Fluid Fires
Opened Nov 26, 1996 · Closed May 15, 1997
Status: closed (inferred from source dates) · Power Train
TRANSMISSION FLUID LEAKAGE AT COOLER TUBE DISCONNECTS IS ALLEGED TO HAVE RESULTED IN VEHICLE FIRES.(this resume was revises on 12/3/96 to include the 1996 model year truck equipped with the subject equipment)
Additional source detail variants (2)
Power Train
TRANSMISSION FLUID LEAKAGE AT COOLER TUBE DISCONNECTS IS ALLEGED TO HAVE RESULTED IN VEHICLE FIRES.(this resume was revises on 12/3/96 to include the 1996 model year truck equipped with the subject equipment)
Power Train
TRANSMISSION FLUID LEAKAGE AT COOLER TUBE DISCONNECTS IS ALLEGED TO HAVE RESULTED IN VEHICLE FIRES.(this resume was revises on 12/3/96 to include the 1996 model year truck equipped with the subject equipment)
EA96018 · Evaporative Canister Leakage
Opened Jul 29, 1996 · Closed Nov 10, 1997
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
FUEL MAY LEAK FROM THE EVAPORATIVE CANISTER AFTER TANK FILL.
PE96020 · Air Bag Inflator Failure
Opened Mar 8, 1996 · Closed Oct 29, 1996
Status: closed (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module
There is no summary currently available
EA94019 · Seat Belt Buckle Failure
Opened Jun 29, 1994 · Closed Jan 30, 1995
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
There is no summary currently available
PE94008 · Seat Belt
Opened Jan 28, 1994 · Closed Jun 29, 1994
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
CHRYSLER IS CONTINUING ITS INVESTIGATION OF THE SUBJECT BUCKLE ENGAGMENT. UPGRADED TO EA94-019.
Illustration