1500 TRUCK TAKEN TO DEALER PREVIOUSLY FOR FRONT END VIBRATION. DEALER SAID TIRE PROBLEM. TIRE MAKER REPLACED TIRES. ON DAY OF INCIDENT, AT SPEED OF 10 MPH, DRIVE SHAFT FELL OUT WHILE TRUCK JUMPED UP/DOWN ON STREET. TRUCK TOWED TO DEALER LOCATION. OWNER TERRIFIED BY EXPERIENCE. IF HAD BEEN DRIVING AT NORMAL HIGHWAY SPEED WOULD HA…
Read full complaint
1500 TRUCK TAKEN TO DEALER PREVIOUSLY FOR FRONT END VIBRATION. DEALER SAID TIRE PROBLEM. TIRE MAKER REPLACED TIRES. ON DAY OF INCIDENT, AT SPEED OF 10 MPH, DRIVE SHAFT FELL OUT WHILE TRUCK JUMPED UP/DOWN ON STREET. TRUCK TOWED TO DEALER LOCATION. OWNER TERRIFIED BY EXPERIENCE. IF HAD BEEN DRIVING AT NORMAL HIGHWAY SPEED WOULD HAVE RESULTED IN CRASH.
NHTSA ODI #701208
Mileage unknown · Nov 11, 1998
Power Train
THE DEALERS WERE NOTIFIED AND THEY WEREN'T ABLE TO FIX THE PROBLEM. I WAS TOLD THAT OTHER PEOPLE HAVE REPORTED SIMILAR PROBLEM AND THAT IT HAPPENS ON HOT DAYS. SINCE THEY WERE NOT ABLE TO REPEAT THE PROBLEM WHEN THEY TEST DROVE MY VEHICLE THEY WERE NOT ABLE TO PIN POINT THE PROBLEM TO ATTEND TO. THEY DIDN'T THINK IT WAS A SAF…
Read full complaint
THE DEALERS WERE NOTIFIED AND THEY WEREN'T ABLE TO FIX THE PROBLEM. I WAS TOLD THAT OTHER PEOPLE HAVE REPORTED SIMILAR PROBLEM AND THAT IT HAPPENS ON HOT DAYS. SINCE THEY WERE NOT ABLE TO REPEAT THE PROBLEM WHEN THEY TEST DROVE MY VEHICLE THEY WERE NOT ABLE TO PIN POINT THE PROBLEM TO ATTEND TO. THEY DIDN'T THINK IT WAS A SAFETY ISSUE. I DISAGREE! HERE IS THE PROBLEM. AFTER A COMPLETE STOP THE VEHICLE SOMETIMES WOULD HESITATE TO ACCEL WHEN I STEP ON THE GAS PEDDLE. I HEAR THE RPM GOING UP AS I PRESS THE GAS BUT THE VEHICLE DOESN'T RESPOND ACCORDINGLY. I SEE THE SAFETY ISSUE IN THESE POSSIBLE SITUATIONS: WHEN I AM MAKING A LEFT TURN AFTER A COMPLETE STOP IF MY VEHICLE DOESN'T GET OUT OF THE INTERSECTION AS I EXPECT IT TO, IT COULD TURN INTO A DANGEROUS SITUATION FOR ME AND THE ON COMING TRAFFIC. ANOTHER SITUATION WOULD BE WHEN I ENTER THE FREEWAY AFTER A COMPLETE STOP. THE VEHICLE MUST ACCELERATE ADAQUATELY IN ORDER FOR IT TO JOIN THE ON COMING TRAFFIC. I THANK YOU SO MUCH FOR YOUR SERVICES. I'M GLAD THAT I CAN TURN TO SOMEONE WHO WILL LISTEN TO MY CONCERNS. MY ENCOUNTERS WITH THE DEALERS WERE NOT PLEASANT SOON AFTER THEY SOLD ME THE CAR. THANK YOU AGAIN. I HOPE TO HEAR FROM YOU SOON.
NHTSA ODI #700517
Mileage unknown · Oct 16, 1998
Power Train
TRANSMISSION IS LEAKING. DEALER REFUSING TO REPAIR VEHICLE ON WARRANTY. *AK
NHTSA ODI #829082
Mileage unknown · Oct 13, 1998
Power Train
CONSUMER EXPERIENCING PROBLEM WITH TRANSMISSION FAILING TO OPERATE PROPERLY. VEHICLE HAS HAD TWO TRANSMISSION REPLACEMENTS, AND PROBLEM APPEARS TO BE UNRESOLVED AT THIS TIME. DEALER NOTIFIED. *AK
NHTSA ODI #828855
Mileage unknown · Oct 7, 1998
Power TrainFire
TRANMISSION FLUID TEMPERATURE EXCEEDED, CAUSING THE VEHICLE TO CATCH ON FIRE, MELTING EVERYTHING UNDER THE HOOD. THE FIRE DEPARTMENT CAME OUT TO PUT OUT THE FIRE OUT AND FOUND OUT THAT THE TRANMISSION COOLING LINES CAUGHT ON FIRE. *AK
NHTSA ODI #828702
Mileage unknown · May 18, 1998
Power TrainSteering
STEERING BOX FAILED.
NHTSA ODI #535592
Mileage unknown · Mar 2, 1998
Power TrainCrash
TRUCK WAS IN PARK POSITION AND THE TRUCK SLIPPED OUT OF GEAR AND WENT FORWARD AND WENT INTO SOMEONES YARD. THEN THE TRUCK FINALLY HIT A TREE WHICH CAUSED THE TRUCK TO COME TO A STOP. *AK
NHTSA ODI #821777
Mileage unknown · Jan 21, 1998
Power TrainService Brakes, Hydraulic
TRANSMISSION HAS FAILED SEVERAL TIMES.
NHTSA ODI #528635
Mileage unknown · Sep 22, 1997
Power TrainSuspension
VEHICLE VIBRATES CONTINUOUSLY.
NHTSA ODI #522270
Mileage unknown · Jun 4, 1997
Power Train
WHILE SHIFTING FROM PARK INTO REVERSE VEHICLE WILL STALL. DEALERS DID CHECK VEHICLE AND REPLACED VARIOUS SENSORS, BUT PROBLEM REMAINS. OWNER IS VERY CONCERNED FOR HIS SAFETY. *AK
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH DIESEL ENGINES ONLY, THE THROTTLE LINKAGE JOINTS CAN CORRODE AND CAUSE THE THROTTLE TO BIND OR STICK.
Consequence & remedy
Consequence: THIS COULD POTENTIALLY RESULT IN A LOSS OF THROTTLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ROD ENDS AND BALL STUDS. OWNER NOTIFICATION BEGAN JULY 29, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: PICKUP TRUCKS. SOUND DEADENER MATERIAL INSIDE THE STEERING WHEEL COULD BECOME DETACHED FROM THE COVER AND HOUSING. NOTE: THE RAM PICKUP TRUCKS WERE BUILT AT THE WARREN ASSEMBLY PLANT ("S" IN THE 11TH VIN POSITION) FROM MAY 16, 2000 THROUGH OCTOBER 23, 2000; ST. LOUIS NORTH ASSEMBLY PLANT ("J" IN THE 11TH VIN POSITION) FROM MAY 19, 2000 THROUGH OCTOBER 23, 2000; LAGO ALBERTO ASSEMBLY PLANT ("M" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000; AND SALTILLO ASSEMBLY PLANT ("G" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000. IMPORTANT: VEHICLES THAT HAVE ALREADY HAD THE PROPER CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN EXCLUDED FROM THIS RECALL. IN ADDITION, 1997-2000 MODEL YEAR VEHICLES THAT HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN ADDED TO THIS RECALL.
Consequence & remedy
Consequence: WHEN THIS OCCURS, THE MATERIAL COULD INTERFERE WITH THE CLOCKSPRING RIBBON AND CAUSE AN OPEN CIRCUIT. THE DRIVER AIR BAG SYSTEM WILL BECOME DISABLED, AND THE AIR BAG WARNING LAMP WILL ILLUMINATE ON THE INSTRUMENT PANEL.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY. OWNER NOTIFICATION BEGAN JUNE 18, 2001. ALSO SOME 1997-200 MODEL YEAR VEHICLES THAT, ACCORDING TO WARRANTY RECORDS, HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, WILL ALSO BE INCLUDED IN THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN PICKUP TRUCKS ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING "SALT BELT" STATES: MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, AND MISSOURI. CORROSION OF THE RETURN SPRING ON THE HOOD SECONDARY LATCH COULD CAUSE THE MECHANISM TO BIND IN THE "RELEASE POSITION."
Consequence & remedy
Consequence: IF THE PRIMARY LATCH IS NOT ENGAGED, THE HOOD COULD OPEN UNEXPECTEDLY.
Remedy: DEALERS WILL REPLACE THE SECONDARY HOOD LATCH. OWNER NOTIFICATION BEGAN SEPTEMBER 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSION, V10 ENGINES AND FOUR-WHEEL-DRIVE TRANSFER CASES. UNDER SUSTAINED MAXIMUM RATED VEHICLE LOAD, WHILE DRIVING UP A STEEP GRADE IN FOUR-WHEEL-DRIVE LOW RANGE IN HOT AMBIENT CONDITIONS, THE LOCAL EXHAUST TEMPERATURE PROXIMATE TO THE HYDRAULIC CLUTCH LINE CAN GENERATE LINE TEMPERATURES THAT EXCEED THE TEMPERATURE LIMIT OF THE CLUTCH LINE MATERIAL. IF THIS CONDITION OCCURS AND THE CLUTCH IS DEPRESSED, THE LINE COULD RUPTURE.
Consequence & remedy
Consequence: THE FLUID COULD IGNITE ON THE HOT EXHAUST POSSIBLY RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL REPLACE THE HYDRAULIC CLUTCH ASSEMBLY.
VEHICLE DESCRIPTION: VAN AND WAGON MODEL PASSENGER VEHICLES. IF WATER/ROAD SALT GETS ON THE INTERIOR FLOOR OF THE VEHICLE IN THE PROXIMITY OF THE AIR BAG ELECTRONIC CONTROL MODULE (AECM), THE AECM CAN CORRODE. THE RESULTING CORROSION CAN CAUSE THE DRIVER SIDE AIR BAG TO DEPLOY INADVERTENTLY.
Consequence & remedy
Consequence: DEPLOYMENT OF THE AIR BAG WITHOUT WARNING COULD CAUSE A DRIVER TO LOSE VEHICLE CONTROL, INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WIL REPLACE THE AECM WITH AN AECM THAT IS SEALED FROM MOISTURE INTRUSION.
VEHICLE DESCRIPTION: LIGHT DUTY TRUCKS EQUIPPED WITH DIESEL ENGINES. THE EXHAUST PIPE CONTACTS OR IS IN CLOSE PROXIMITY TO THE OUTER DASH PANEL SILENCER PAD.
Consequence & remedy
Consequence: IF THE EXHAUST PIPE GENERATES SUFFICIENT HEAT, THE PAD MATERIAL CAN SMOLDER AND IGNITE ADJACENT MATERIALS RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL REMOVE THE DASH SILENCER PAD ADJACENT TO THE EXHAUST PIPE AND REPLACE THIS PAD WITH A THERMAL HEAT SHIELD ON THE EXHAUST PIPE.
UNDER CERTAIN HIGH LOAD OPERATING CONDITIONS, THE TRANSMISSION FLUID TEMPERATURE CAN EXCEED THE MELTING POINT OF THE MATERIAL USED IN THE CONNECTOR TO RETAIN THE FLUID LINE TO THE TRANSMISSION.
Consequence & remedy
Consequence: WHEN THESE TEMPERATURES OCCUR, THE FLUID LINE WILL NOT STAY CONNECTED WITH THE TRANSMISSION AND FLUID CAN SPRAY ONTO THE EXHAUST MANIFOLD, RESULTING IN SMOKE OR FIRE.
Remedy: DEALERS WILL REPLACE THE HIGH TEMPERATURE SIDE OF THE TRANSMISSION FLUID COOLER LINE CONNECTOR FITTINGS WITH CONNECTORS THAT INCORPORATE A STAINLESS STEEL RETAINER.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5
DP03006 · Seat Back Failure
Opened Sep 23, 2003 · Closed Apr 8, 2004
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:recliner
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
Additional source detail variants (2)
Seats
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
Seats:front Assembly:recliner
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
RQ00012 · Hood Latch
Opened May 3, 2000 · Closed Apr 20, 2001
Status: closed (inferred from source dates) · Structure
ONMARCH 20, 1995, DAIMLERCHRYSLER FILED A DEFECT REPORT FOR 181,008 1994 AND 1995 DODGE RAM TRUCKS MANUFACTUREDC FROM JANUARY 21, 1994 - OCTOBER 25, 1994 AT THE DODGE CITY ASSEMBLY PLANT AND FROM MARCH 26, 1994 - DECEMBER 8, 1994 AT THE LAGO ALBERTO ASSEMBLY PLANT.THE SECONDARY HOOD LATCH ROD COULD BIND ON THE GUIDE BRACKET AND PREVENT ENGAGEMENT OF THE SECONDARY LATCH.IF THIS OCCURS WHEN THE PRIMARY LATCH IS NOT ENGAGED, THE HOOD COULD FLY UP WHEN THE VEHICLE IS BEING DRIVEN AND OBSTRUCT THE DRIER'S VISION INCREASING THE POTENTIAL FOR A CRASH.THE RECALL REMEDY WAS TO REPLACE THE SEDCONDARY HOOD LATCH.OWNERS WERE NOTIFIED IN AUGUST OF 1995.THIS RECALL RATE AS OF 2/97 WAS 68%
Additional source detail variants (2)
Structure
ONMARCH 20, 1995, DAIMLERCHRYSLER FILED A DEFECT REPORT FOR 181,008 1994 AND 1995 DODGE RAM TRUCKS MANUFACTUREDC FROM JANUARY 21, 1994 - OCTOBER 25, 1994 AT THE DODGE CITY ASSEMBLY PLANT AND FROM MARCH 26, 1994 - DECEMBER 8, 1994 AT THE LAGO ALBERTO ASSEMBLY PLANT.THE SECONDARY HOOD LATCH ROD COULD BIND ON THE GUIDE BRACKET AND PREVENT ENGAGEMENT OF THE SECONDARY LATCH.IF THIS OCCURS WHEN THE PRIMARY LATCH IS NOT ENGAGED, THE HOOD COULD FLY UP WHEN THE VEHICLE IS BEING DRIVEN AND OBSTRUCT THE DRIER'S VISION INCREASING THE POTENTIAL FOR A CRASH.THE RECALL REMEDY WAS TO REPLACE THE SEDCONDARY HOOD LATCH.OWNERS WERE NOTIFIED IN AUGUST OF 1995.THIS RECALL RATE AS OF 2/97 WAS 68%
Structure
ONMARCH 20, 1995, DAIMLERCHRYSLER FILED A DEFECT REPORT FOR 181,008 1994 AND 1995 DODGE RAM TRUCKS MANUFACTUREDC FROM JANUARY 21, 1994 - OCTOBER 25, 1994 AT THE DODGE CITY ASSEMBLY PLANT AND FROM MARCH 26, 1994 - DECEMBER 8, 1994 AT THE LAGO ALBERTO ASSEMBLY PLANT.THE SECONDARY HOOD LATCH ROD COULD BIND ON THE GUIDE BRACKET AND PREVENT ENGAGEMENT OF THE SECONDARY LATCH.IF THIS OCCURS WHEN THE PRIMARY LATCH IS NOT ENGAGED, THE HOOD COULD FLY UP WHEN THE VEHICLE IS BEING DRIVEN AND OBSTRUCT THE DRIER'S VISION INCREASING THE POTENTIAL FOR A CRASH.THE RECALL REMEDY WAS TO REPLACE THE SEDCONDARY HOOD LATCH.OWNERS WERE NOTIFIED IN AUGUST OF 1995.THIS RECALL RATE AS OF 2/97 WAS 68%
RQ98002 · Transmission Quick Connectors
Opened Mar 10, 1998 · No close date supplied
Status: open (inferred from source dates) · Power Train:automatic Transmission:cooling Unit And Lines
ON APRIL 17, 1997, THE CHRYSLER CORPORATION FILED A DEFECT INFORMATION REPORT CONCERNING APPROXIMATELY 800,000 1994 THROUGH 1997 DODGE RAM PICKUPS EQUIPPED WITH V6 OR V8 ENGINES AND AUTOMATIC TRANSMISSIONS, 1995 THROUGH 1997DODGE RAM PICKUPS EQUIPPED WITH THE V10 ENGINE AND AUTOMATIC TRANSMISSION, AND THE 1995 AND 1996 DODGE RAM VAN/WAGON EQUIPPED WITH AUTOMATIC TRANSMISSION.ODI HAS RECEIVED ELEVEN REPORTS CONCERNING TRANSMISSION LEAKAGES FROM THE QUICK CONNECTOR JOINTS RESULTING IN EIGHT FIRES.THE REPORTED VEHICLES INCLUDED ARE THE 1994 AND 1995 JEEP WRANGLER, 1995 AND 1996 CHEROKEE, 1993 THROUGH 1996 GRAND CHEROKEE, AND 1994 AND 1995 DODGE DAKOTA.THE PURPOSE OF THIS INVESTIGATION IS TO EXAMINE THE SCOPE OF RECALL 97V-084.CLOSING SUMMARY: FURTHER INVESTIGATION OF CONSUMER REPORTS REVEALED THAT SOME OF THE TRANSMISSION LEAKAGE WAS DUE TO OTHER CONNECTIONS ALONG THE COOLING LINES.IN THE FIRE INCIDENTS, THERE WERE INDICATIONS THAT SOME OF THESE VEHICLES WERE EITHER USED BEYOND THE VEHICLE'S TOWING CAPABILITY OR HAD IMPROPER TRANSMISSION REPAIR.IN ADDITION, THE RECALLED RAM PICKUP TRUCKS, 98V-084, HAVE AN EXHAUST MANIFOLD NEAR THE PLASTIC QUICK CONNECTOR JOINTS WHICH EFFECTIVELY PRESENTS A HEAT SOURCE TO IGNITE THE HOT TRANSMISSION FLUID IN THE EVENT OF A LEAKAGE.THE SUBJECT VEHICLES' QUICK CONNECTOR JOINTS ARE EITHER TOO FAR, OR POSITIONED COMPLETELY AWAY, FROM A HEAT SOURCE OR EXHAUST COMPONENTS.CONSEQUENTLY, THE FIRE REPORTS OF THE SUBJECT VEHICLES ARE SIGNIFICANTLY LESS THAN THOSE OF THE DODGE RAM PICKUP TRUCKS.BASED ON THE AVAILABLE INFORMATION, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY FUTURE CIRCUMSTANCES.
EA98005 · Clutch Hydraulic Line
Opened Feb 27, 1998 · Closed May 24, 1999
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
ALLEGED PLASTIC CLUTCH TUBE MAY FAIL FROM EXPOSURE TO EXHAUST HEAT, RESULTING IN LOSS OF CLUTCH FUNCTION AND POSSIBLE VEHICLE FIRE.
PE97043 · Clutch Hydraulic Line Failure
Opened Oct 20, 1997 · Closed Feb 27, 1998
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
ALLEGED CLUTCH LINE MAY MELT AND LEAK HYDRAULIC FLUID IN THE VICINITY OF THE EXHAUST MANIFOLD.LEAKED HYDRAULIC FLUID COULD IGNITE AND CAUSE A VEHICLE FIRE.
1997 Dodge RAM Problems, Complaints & Recalls | Skip That Year
Illustration