NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
611 reportsMileage unknown · Aug 27, 2001
Vehicle Speed Control
CONSUMER WAS TRAVELING ABOUT 5MPH AND THROTTLE GOT STUCK. DEALERSHIP WAS MADE AWARE OF THE PROBLEM.*AK CONSUMER RECEIVED A RECALL NOTIFICATION IN THE MAIL #970 FOR THE THROTTLE CABLE AND THROTTLE LINKAGE COMPONETS TO BE REPLACED, HOWEVER AFTER BECOMING STRANDED AND THEN HAVING VEHICLE TOWED IT WAS DETERMINED BY A MECHANIC THA…
Read full complaint
CONSUMER WAS TRAVELING ABOUT 5MPH AND THROTTLE GOT STUCK. DEALERSHIP WAS MADE AWARE OF THE PROBLEM.*AK CONSUMER RECEIVED A RECALL NOTIFICATION IN THE MAIL #970 FOR THE THROTTLE CABLE AND THROTTLE LINKAGE COMPONETS TO BE REPLACED, HOWEVER AFTER BECOMING STRANDED AND THEN HAVING VEHICLE TOWED IT WAS DETERMINED BY A MECHANIC THAT NONE OF THE THROTTLE LINKAGES COMPONENTS WERE REPLACED AND MECHANIC INFORMED CONSUMER THAT THE PARTS WERE ON BACK ORDER AND THE THE PREVIOUS DEALER THAT PERFORMED THE WORK MUST HAVE USED A DEFECTIVE PART AND CONSUMER REALIZED THAT THE REPAIR ONLY TOOK AN HOUR.*JB
NHTSA ODI #895242
Mileage unknown · Aug 24, 2001
Electrical SystemFire
I HAVE CONTACTED DODGE REGARDING THIS FAILURE, ARE TECH OR SAFETY BULLETINS BEING GENERATED, ARE OTHERS REPORTING THE FAILURE? RAM DIESEL MODEL FAILURE MODE ALLOWS STARTER TO REMAIN ENGAGED AND ENGINE RUNNING WITH VEHICLE KEY IN THE OFF POSITION. AFTER DIAGNOSING AND FAILURE ANALYSIS IT IS APPARENT THAT THIS FAILURE MODE IS NOT …
Read full complaint
I HAVE CONTACTED DODGE REGARDING THIS FAILURE, ARE TECH OR SAFETY BULLETINS BEING GENERATED, ARE OTHERS REPORTING THE FAILURE? RAM DIESEL MODEL FAILURE MODE ALLOWS STARTER TO REMAIN ENGAGED AND ENGINE RUNNING WITH VEHICLE KEY IN THE OFF POSITION. AFTER DIAGNOSING AND FAILURE ANALYSIS IT IS APPARENT THAT THIS FAILURE MODE IS NOT ONLY COMMON (INPUT FROM VARIOUS WEBSITES) BUT ALSO EXTREMELY DANGEROUS IN MY OPINION. WHILE THE ROOT CAUSE (STARTER FAILURE) IS ACCEPTABLE AND UNDERSTANDABLE WITH AGE OF THE VEHICLE, THE SYMPTOM AND EFFECT IS NOT. INTERNAL SHORTING OF THE STARTER CAUSES 12VDC FEEDBACK THROUGH THE CONTROL CIRCUIT AND ALLOWS THE STARTER TO REMAIN ENGAGED AND VEHICLE TO REMAIN RUNNING WIT THE KEY ON!. IF LUCKY ENOUGH TO REACT TO THE FAILURE IN TIME PRIOR TO COMPONENTS AND WIRING BURNING UP AND MELTING, YOU MUST GET UNDER THE HOOD TO DISCONNECT "2" BATTERIES, OR CLIMB UNDER THE VEHICLE TO HIT THE STARTER TO SHUT DOWN ENGINE AND DISENGAGE STARTER, EITHER AGAIN WHILE THE VEHICLE IS RUNNING WITH THE KEY OFF AND START ENGAGED IN FLYWHEEL, IF THE VEHICLE WERE TO JUMP IN GEAR (STD TRANSMISSION) BODILY INJURY WOULD CERTAINLY TAKE PLACE. AFTER MY FIRST FAILURE THE DEALER REPLACED THE DAMAGED COMPONENTS AT A COST OF >$700 BUT FAILED TO IDENTIFY THE ROOT CAUSE. ONLY AFTER INFORMATION LOCATED IN THE "TURBODIESEL WEBSITE" AND REPEAT FAILURE WAS I ABLE TO IDENTIFY AND CORRECT ROOT CAUSE!*AK
NHTSA ODI #751061
Mileage unknown · Aug 20, 2001
Vehicle Speed Control
CONSUMER'S VEHICLE WAS NOT COVERED UNDER RECALL 01V037OOO DUE TO VIN. DEALER DENIED REPAIRS DUE TO LACK OF PARTS. DEALER ADVISED THAT PARTS WERE 8,000 IN BACK ORDER.*AK
NHTSA ODI #894767
Mileage unknown · Aug 16, 2001
Tires
THE SET OF 5 TIRES WAS PURCHASED IN MARCH AND HAD 6300 MILES ON THEM. THE TIRE SEPARATED AND BLEWOUT LEAVING THE SIDE WALL INTACT AND SPLIT FROM TOP OF TIRE TO RIM. THE SEPERATION PATTERN IS CONSIDERABLY NOTICABLE. THIS BLOW OUT CAUSED EXTENSIVE DAMAGE TO SIDE PANEL OF TRUCK, RIPPING OUT THE SIDEWALL PLASTIC COVER AND MUD FLA…
Read full complaint
THE SET OF 5 TIRES WAS PURCHASED IN MARCH AND HAD 6300 MILES ON THEM. THE TIRE SEPARATED AND BLEWOUT LEAVING THE SIDE WALL INTACT AND SPLIT FROM TOP OF TIRE TO RIM. THE SEPERATION PATTERN IS CONSIDERABLY NOTICABLE. THIS BLOW OUT CAUSED EXTENSIVE DAMAGE TO SIDE PANEL OF TRUCK, RIPPING OUT THE SIDEWALL PLASTIC COVER AND MUD FLAP. THE SUDDEN FAILURE OF THIS TIRE HAS MADE ME VERY LEARY OF DRIVING WITH THE OTHERS.*AK (TIRESIZE: 245 75/R16)
NHTSA ODI #750582
Mileage unknown · Aug 13, 2001
Steering
RECALL 96 V 230 000/STEERING COLUMN: VEHICLE EXPEREINCED A LOSS OF CONTROL WHILE DRIVING AT LOW SPEED. DEALER WAS NOTIFIED, AND INFORMED CONSUMER THAT THIS VEHICLE WAS NOT COVERED UNDER THAT RECALL DUE TO VIN. *AK
NHTSA ODI #894159
Mileage unknown · Aug 13, 2001
Electrical SystemVehicle Speed Control
1. ROUGH IDLE AND SLIGHT LOSS OF POWER I'VE REPLACED PLUGS,WIRES,ROTOR, DISTRIBUTOR CAP,CLEANED INJECTORS,BUT NOTHING SEEMS TO HELP 2. THE CABLE WIRE ON THE THROTTLE BODY IS FRAYED2.
NHTSA ODI #750356
Mileage unknown · Aug 8, 2001
Fuel System, Gasoline
FUEL GAUGE DOES NOT INDICATE THE CORRECT AMOUNT OF FUEL, EVEN AFTER FILLING UP TANK. GAUGE WILL MOVE FROM FULL TO EMPTY INTERMITTENTLY. PLEASE PROVIDE FURTHER INFORMATION. *AK THE CONSUMER IS CONCERNED THAT THE ELECTRIC GAUGE WHICH IS LOCATED INSIDE THE FUEL TANK IS A FIRE HAZARD. NLM
NHTSA ODI #893851
Mileage unknown · Aug 4, 2001
SuspensionTrailer Hitches
THE TRAILER HITCH ISSUE, I BELEVE, IS SERIOUS. "OUT OF SIGHT, OUT OF MIND" A RECALL HAS BEEN ISSUED FOR 1998 TO 2001.5 MODELS. INVESTAGTION SHOULD BE EXTENDED TO THE 1994 MODELS THIS IS SERIOUS. ALSO THE TRACK BAR ISSUE, THIS EFFECTS THE HANDLING OF THE VEHICLE THE SO CALLED "SHIMMY" THIS ALSO NEEDS TO BE LOOKED IN TO.*AK
NHTSA ODI #749843
Mileage unknown · Aug 3, 2001
Suspension
CONSUMER RECEIVED RECALL NOTICE 99V214000. SERVICE WAS REFUSED BY DEALERSHIP(S) BECAUSE DEALERSHIP DID NOT HAVE A 'CERTIFIED WELDER' AND VEHICLE COULD NOT FIT INTO THEIR GARAGE. *AK *JB
NHTSA ODI #893336
Mileage unknown · Jun 26, 2001
Fuel System, Gasoline
A FUEL ODOR IN PASSENGER'S COMPARTMENT. ALSO, VEHICLE IS VERY DIFFICULT TO START, AND FUEL IS LEAKING. CONSUMER HAS CONTACTED DEALER, OWNER NOTICED A FUEL LEAK ON THE RUBBER FUEL LINE BEHIND THE FUEL FILTER. VEHICLE IS A 3500 SERIES.*AK WHEN THE RUBBER HOSE FROM THE FUEL FILTER TO THE FUEL RETURN LINE WAS REMOVED, IT APPEAR…
Read full complaint
A FUEL ODOR IN PASSENGER'S COMPARTMENT. ALSO, VEHICLE IS VERY DIFFICULT TO START, AND FUEL IS LEAKING. CONSUMER HAS CONTACTED DEALER, OWNER NOTICED A FUEL LEAK ON THE RUBBER FUEL LINE BEHIND THE FUEL FILTER. VEHICLE IS A 3500 SERIES.*AK WHEN THE RUBBER HOSE FROM THE FUEL FILTER TO THE FUEL RETURN LINE WAS REMOVED, IT APPEARED TO BE ROTTED THROUGH ALLOWING FUEL TO LEAK OUT ALONG THE ENTIRE LENGTH AND WHEN THE VEHICLE WAS PARKED ON AN INCLINE WITH THE FRONT END DOWN, THE FUEL DRIPPED CONTINUOUSLY. *SLC
NHTSA ODI #891194
Official recalls
12Feb 12, 2001
VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH DIESEL ENGINES. THE THROTTLE CABLE COULD UNRAVEL (FRAY) OR BREAK RESULTING IN LOSS OF THROTTLE CONTROL.
Consequence & remedy
Consequence: A THROTTLE THAT DOES NOT RETURN TO IDLE COULD RESULT IN UNEXPECTED ACCELERATION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE THROTTLE CABLE AND UPPER BELL CRANK LEVER. OWNER NOTIFICATION BEGAN AUGUST 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Feb 12, 2001
ON CERTAIN PICKUP TRUCKS ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING "SALT BELT" STATES: MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, AND MISSOURI. CORROSION OF THE RETURN SPRING ON THE HOOD SECONDARY LATCH COULD CAUSE THE MECHANISM TO BIND IN THE "RELEASE POSITION."
Consequence & remedy
Consequence: IF THE PRIMARY LATCH IS NOT ENGAGED, THE HOOD COULD OPEN UNEXPECTEDLY.
Remedy: DEALERS WILL REPLACE THE SECONDARY HOOD LATCH. OWNER NOTIFICATION BEGAN SEPTEMBER 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
May 10, 2000
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS. THE AFFECTED VEHICLES WERE BUILT WITH AN IGNITION SWITCH AND WIRING THAT COULD OVERHEAT. HIGH ELECTRICAL CURRENT LOADS PASS THROUGH THE SWITCH WHEN THE BLOWER MOTOR IS OPERATED ON HIGH FOR AN EXTENDED PERIODS OF TIME.
Consequence & remedy
Consequence: THIS COULD CAUSE THE IGNITION SWITCH AND WIRING TO OVERHEAT.
Remedy: DEALERS WILL INSTALL A RELAY AND OVERLAY HARNESS.
Aug 9, 1999
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS. (2500 AND 3500 SERIES 4X4 REGULAR CAB PICKUP PRODUCED BEFORE MARCH 21, 1995; 2500 AND 3500 SERIES 4X4 CLUB CAB PICKUP PRODUCED BEFORE JUNE 8, 1995; AND 3500 SERIES 4X2/4X4 CHASSIS CAB TRUCKS PRODUCED BEFORE JUNE 21, 1995). THE FRONT SUSPENSION SPRING/SHOCK TOWERS CAN CRACK AND EVENTUALLY SEPARATE FROM THE VEHICLE FRAME. THE SHOCK TOWER COULD DAMAGE THE REAR WHEEL BRAKE LINES RESULTING IN LOSS OF REAR BRAKE SYSTEM PRESSURE.
Consequence & remedy
Consequence: THIS WOULD CREATE THE POTENTIAL FOR INCREASED STOPPING DISTANCES.
Remedy: DEALERS WILL INSPECT THE SPRING/SHOCK TOWER AND ANY VEHICLES EXHIBITING CRACKING WILL HAVE THE TOWER REPLACED. VEHICLES THAT ARE DO NOT SHOW ANY CRACKING WILL HAVE A WELD-ON REINFORCEMENT ADDED.
May 6, 1999
VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSION, V10 ENGINES AND FOUR-WHEEL-DRIVE TRANSFER CASES. UNDER SUSTAINED MAXIMUM RATED VEHICLE LOAD, WHILE DRIVING UP A STEEP GRADE IN FOUR-WHEEL-DRIVE LOW RANGE IN HOT AMBIENT CONDITIONS, THE LOCAL EXHAUST TEMPERATURE PROXIMATE TO THE HYDRAULIC CLUTCH LINE CAN GENERATE LINE TEMPERATURES THAT EXCEED THE TEMPERATURE LIMIT OF THE CLUTCH LINE MATERIAL. IF THIS CONDITION OCCURS AND THE CLUTCH IS DEPRESSED, THE LINE COULD RUPTURE.
Consequence & remedy
Consequence: THE FLUID COULD IGNITE ON THE HOT EXHAUST POSSIBLY RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL REPLACE THE HYDRAULIC CLUTCH ASSEMBLY.
Feb 5, 1999
VEHICLE DESCRIPTION: VAN AND WAGON MODEL PASSENGER VEHICLES. IF WATER/ROAD SALT GETS ON THE INTERIOR FLOOR OF THE VEHICLE IN THE PROXIMITY OF THE AIR BAG ELECTRONIC CONTROL MODULE (AECM), THE AECM CAN CORRODE. THE RESULTING CORROSION CAN CAUSE THE DRIVER SIDE AIR BAG TO DEPLOY INADVERTENTLY.
Consequence & remedy
Consequence: DEPLOYMENT OF THE AIR BAG WITHOUT WARNING COULD CAUSE A DRIVER TO LOSE VEHICLE CONTROL, INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WIL REPLACE THE AECM WITH AN AECM THAT IS SEALED FROM MOISTURE INTRUSION.
Nov 13, 1997
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH GASOLINE ENGINES. THE FUEL TANK MOUNTED ROLLOVER VALVE CAN ALLOW LIQUID FUEL TO LEAK ONTO THE GROUND UNDER CERTAIN VEHICLE OPERATING CONDITIONS.
Consequence & remedy
Consequence: FUEL LEAKAGE COULD RESULT IN A FIRE IF AN IGNITION SOURCE WAS PRESENT.
Remedy: DEALERS WILL REPLACE THE FUEL TANK ROLLOVER VALVE WITH A FLOAT TYPE ROLLOVER VALVE.
May 5, 1997
UNDER CERTAIN HIGH LOAD OPERATING CONDITIONS, THE TRANSMISSION FLUID TEMPERATURE CAN EXCEED THE MELTING POINT OF THE MATERIAL USED IN THE CONNECTOR TO RETAIN THE FLUID LINE TO THE TRANSMISSION.
Consequence & remedy
Consequence: WHEN THESE TEMPERATURES OCCUR, THE FLUID LINE WILL NOT STAY CONNECTED WITH THE TRANSMISSION AND FLUID CAN SPRAY ONTO THE EXHAUST MANIFOLD, RESULTING IN SMOKE OR FIRE.
Remedy: DEALERS WILL REPLACE THE HIGH TEMPERATURE SIDE OF THE TRANSMISSION FLUID COOLER LINE CONNECTOR FITTINGS WITH CONNECTORS THAT INCORPORATE A STAINLESS STEEL RETAINER.
Apr 28, 1997
VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH DIESEL ENGINES. THE ENGINE DRIVEN VACUUM PUMP CAN ALLOW ENGINE OIL INTO THE VACUUM HOSES DUE TO THE ABSENCE OF AN INTERNAL CHECK VALVE. THE OIL CAN CAUSE THE HOSE TO DETERIORATE AND PARTIALLY COLLAPSE, REDUCING THE VACUUM SUPPLY TO THE BRAKE BOOSTER.
Consequence & remedy
Consequence: REDUCED POWER BRAKE ASSIST CAN RESULT INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL ADD A VACUUM PUMP CHECK VALVE TO THE VACUUM PUMP. IN ADDITION, THE VACUUM HOSE CONNECTED TO THE VACUUM PUMP WILL BE REPLACED WITH A HOSE THAT IS ENGINE OIL RESISTANT.
Nov 18, 1996
IF THE PLASTIC PINS AND METAL CLIP THAT RETAIN THE LOWER STEERING SHAFT IN THE UPPER SHAFT BREAK, THE LOWER STEERING SHAFT CAN SEPARATE FROM THE UPPER SHAFT.
Consequence & remedy
Consequence: IF THE LOWER STEERING SHAFT SEPARATES FROM THE UPPER SHAFT, LOSS OF VEHICLE CONTROL CAN OCCUR INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL ADD A RESTRAINING SLEEVE TO THE INTERMEDIATE STEERING SHAFT TO LIMIT THE AMOUNT OF AXIAL STEERING COLUMN SHAFT MOVING IN THE EVENT THE PLASTIC PINS AND METAL CLIP ARE BROKEN.
May 12, 1995
WHILE MAKING A TURN, THE EXTRA KEYS ON A VEHICLE OPERATOR'S KEY RING CAN BECOME TEMPORARILY LODGED IN THE SCREW ACCESS HOLES IN THE BACK COVER OF THE STEERING WHEEL.
Consequence & remedy
Consequence: THIS CONDITION CAN HAMPER THE STEERING WHEEL RETURN ORCAUSE THE IGNITION TO BE TURNED OFF, RESULTING IN LOSS OF VEHICLE CONTROL AND AN ACCIDENT.
Remedy: DEALERS WILL REPLACE THE STEERING WHEEL BACK COVER WITH A REDESIGNED COVER.
Mar 21, 1995
THE SECONDARY HOOD LATCH ROD CAN BIND ON THE GUIDE BRACKET AND PREVENT ENGAGEMENT OF THE SECONDARY LATCH.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE THE HOOD TO FLY UP OBSTRUCTING THE DRIVER'S VISION INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE SECONDARY HOOD LATCH BRACKET.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
10DP03006 · Seat Back Failure
Opened Sep 23, 2003 · Closed Apr 8, 2004
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:recliner
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
Additional source detail variants (2)
Seats
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
Seats:front Assembly:recliner
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
RQ00012 · Hood Latch
Opened May 3, 2000 · Closed Apr 20, 2001
Status: closed (inferred from source dates) · Structure
ONMARCH 20, 1995, DAIMLERCHRYSLER FILED A DEFECT REPORT FOR 181,008 1994 AND 1995 DODGE RAM TRUCKS MANUFACTUREDC FROM JANUARY 21, 1994 - OCTOBER 25, 1994 AT THE DODGE CITY ASSEMBLY PLANT AND FROM MARCH 26, 1994 - DECEMBER 8, 1994 AT THE LAGO ALBERTO ASSEMBLY PLANT.THE SECONDARY HOOD LATCH ROD COULD BIND ON THE GUIDE BRACKET AND PREVENT ENGAGEMENT OF THE SECONDARY LATCH.IF THIS OCCURS WHEN THE PRIMARY LATCH IS NOT ENGAGED, THE HOOD COULD FLY UP WHEN THE VEHICLE IS BEING DRIVEN AND OBSTRUCT THE DRIER'S VISION INCREASING THE POTENTIAL FOR A CRASH.THE RECALL REMEDY WAS TO REPLACE THE SEDCONDARY HOOD LATCH.OWNERS WERE NOTIFIED IN AUGUST OF 1995.THIS RECALL RATE AS OF 2/97 WAS 68%
Additional source detail variants (2)
Structure
ONMARCH 20, 1995, DAIMLERCHRYSLER FILED A DEFECT REPORT FOR 181,008 1994 AND 1995 DODGE RAM TRUCKS MANUFACTUREDC FROM JANUARY 21, 1994 - OCTOBER 25, 1994 AT THE DODGE CITY ASSEMBLY PLANT AND FROM MARCH 26, 1994 - DECEMBER 8, 1994 AT THE LAGO ALBERTO ASSEMBLY PLANT.THE SECONDARY HOOD LATCH ROD COULD BIND ON THE GUIDE BRACKET AND PREVENT ENGAGEMENT OF THE SECONDARY LATCH.IF THIS OCCURS WHEN THE PRIMARY LATCH IS NOT ENGAGED, THE HOOD COULD FLY UP WHEN THE VEHICLE IS BEING DRIVEN AND OBSTRUCT THE DRIER'S VISION INCREASING THE POTENTIAL FOR A CRASH.THE RECALL REMEDY WAS TO REPLACE THE SEDCONDARY HOOD LATCH.OWNERS WERE NOTIFIED IN AUGUST OF 1995.THIS RECALL RATE AS OF 2/97 WAS 68%
Structure
ONMARCH 20, 1995, DAIMLERCHRYSLER FILED A DEFECT REPORT FOR 181,008 1994 AND 1995 DODGE RAM TRUCKS MANUFACTUREDC FROM JANUARY 21, 1994 - OCTOBER 25, 1994 AT THE DODGE CITY ASSEMBLY PLANT AND FROM MARCH 26, 1994 - DECEMBER 8, 1994 AT THE LAGO ALBERTO ASSEMBLY PLANT.THE SECONDARY HOOD LATCH ROD COULD BIND ON THE GUIDE BRACKET AND PREVENT ENGAGEMENT OF THE SECONDARY LATCH.IF THIS OCCURS WHEN THE PRIMARY LATCH IS NOT ENGAGED, THE HOOD COULD FLY UP WHEN THE VEHICLE IS BEING DRIVEN AND OBSTRUCT THE DRIER'S VISION INCREASING THE POTENTIAL FOR A CRASH.THE RECALL REMEDY WAS TO REPLACE THE SEDCONDARY HOOD LATCH.OWNERS WERE NOTIFIED IN AUGUST OF 1995.THIS RECALL RATE AS OF 2/97 WAS 68%
DP00002 · Steering Column Fire
Opened Jan 20, 2000 · Closed Apr 24, 2000
Status: closed (inferred from source dates) · Steering
ALLEGES THAT THE POOR DESIGN OF THE IGNITION SWITCH ASSEMBLY AND//OR THE KEY CYLINDER ASSEMBLY IN THE MODEL YEAR 1991-2000 VEHICLES MAY CAUSE THE STEERING COLUMN TO CATCH FIRE
EA99027 · Steering Column Fires
Opened Sep 10, 1999 · Closed May 30, 2000
Status: closed (inferred from source dates) · Power Train
ODI has received 33 complaints alleging excessive heat in the ignition switch and related circuitry in 1994-1996 Dodge Ram trucks.The root cause is an excessive current draw through the ignition switch result in fire, smoke, melting of surrounding plastics, stalling and the illumination of air bag and anti-lock brake system (ABS) warnig lights. DaimlerChrsler has been aware of the potential for this failure and implemented a design change to reduce the current draw through the switch.This design change involved the installation of a relay in the blower motor circuitry for all Ram trucks built after March 15,1996.DaimlerChrysler also made available an ignition switch repair package (PN 4874996) which includes the necessary components to upgrade vehicles built prior to the implementation date.DaimleChrysler also issued a correspondence to its zones instructing technicians to replace failed ignition switches in the subject population with the sevice kit only.An Engineering Analysis is necessary to determine if a safety defect trend exists.ODI will focus its investigation on fires in the steering column area as well as the effects of switch failure on the ABS and air bag system.
PE99031 · Ignition Switch
Opened May 5, 1999 · Closed Sep 10, 1999
Status: closed (inferred from source dates) · Power Train
COMPLAINANTS ALLEGE FIRES, MELTING, SMOKE OR EXCESSIVE HEAT IN THE VICINITY OF THE IGNITION SWITCH
RQ98002 · Transmission Quick Connectors
Opened Mar 10, 1998 · No close date supplied
Status: open (inferred from source dates) · Power Train:automatic Transmission:cooling Unit And Lines
ON APRIL 17, 1997, THE CHRYSLER CORPORATION FILED A DEFECT INFORMATION REPORT CONCERNING APPROXIMATELY 800,000 1994 THROUGH 1997 DODGE RAM PICKUPS EQUIPPED WITH V6 OR V8 ENGINES AND AUTOMATIC TRANSMISSIONS, 1995 THROUGH 1997DODGE RAM PICKUPS EQUIPPED WITH THE V10 ENGINE AND AUTOMATIC TRANSMISSION, AND THE 1995 AND 1996 DODGE RAM VAN/WAGON EQUIPPED WITH AUTOMATIC TRANSMISSION.ODI HAS RECEIVED ELEVEN REPORTS CONCERNING TRANSMISSION LEAKAGES FROM THE QUICK CONNECTOR JOINTS RESULTING IN EIGHT FIRES.THE REPORTED VEHICLES INCLUDED ARE THE 1994 AND 1995 JEEP WRANGLER, 1995 AND 1996 CHEROKEE, 1993 THROUGH 1996 GRAND CHEROKEE, AND 1994 AND 1995 DODGE DAKOTA.THE PURPOSE OF THIS INVESTIGATION IS TO EXAMINE THE SCOPE OF RECALL 97V-084.CLOSING SUMMARY: FURTHER INVESTIGATION OF CONSUMER REPORTS REVEALED THAT SOME OF THE TRANSMISSION LEAKAGE WAS DUE TO OTHER CONNECTIONS ALONG THE COOLING LINES.IN THE FIRE INCIDENTS, THERE WERE INDICATIONS THAT SOME OF THESE VEHICLES WERE EITHER USED BEYOND THE VEHICLE'S TOWING CAPABILITY OR HAD IMPROPER TRANSMISSION REPAIR.IN ADDITION, THE RECALLED RAM PICKUP TRUCKS, 98V-084, HAVE AN EXHAUST MANIFOLD NEAR THE PLASTIC QUICK CONNECTOR JOINTS WHICH EFFECTIVELY PRESENTS A HEAT SOURCE TO IGNITE THE HOT TRANSMISSION FLUID IN THE EVENT OF A LEAKAGE.THE SUBJECT VEHICLES' QUICK CONNECTOR JOINTS ARE EITHER TOO FAR, OR POSITIONED COMPLETELY AWAY, FROM A HEAT SOURCE OR EXHAUST COMPONENTS.CONSEQUENTLY, THE FIRE REPORTS OF THE SUBJECT VEHICLES ARE SIGNIFICANTLY LESS THAN THOSE OF THE DODGE RAM PICKUP TRUCKS.BASED ON THE AVAILABLE INFORMATION, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY FUTURE CIRCUMSTANCES.
RQ97012 · Steering Wheel And Column
Opened Sep 25, 1997 · No close date supplied
Status: open (inferred from source dates) · Steering: Steering Wheel/handle Bar
There is no summary currently available
PE96070 · Transmission Fluid Fires
Opened Nov 26, 1996 · Closed May 15, 1997
Status: closed (inferred from source dates) · Power Train
TRANSMISSION FLUID LEAKAGE AT COOLER TUBE DISCONNECTS IS ALLEGED TO HAVE RESULTED IN VEHICLE FIRES.(this resume was revises on 12/3/96 to include the 1996 model year truck equipped with the subject equipment)
Additional source detail variants (2)
Power Train
TRANSMISSION FLUID LEAKAGE AT COOLER TUBE DISCONNECTS IS ALLEGED TO HAVE RESULTED IN VEHICLE FIRES.(this resume was revises on 12/3/96 to include the 1996 model year truck equipped with the subject equipment)
Power Train
TRANSMISSION FLUID LEAKAGE AT COOLER TUBE DISCONNECTS IS ALLEGED TO HAVE RESULTED IN VEHICLE FIRES.(this resume was revises on 12/3/96 to include the 1996 model year truck equipped with the subject equipment)
EA96018 · Evaporative Canister Leakage
Opened Jul 29, 1996 · Closed Nov 10, 1997
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
FUEL MAY LEAK FROM THE EVAPORATIVE CANISTER AFTER TANK FILL.
Illustration