NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
13 reportsClear category filterMileage unknown · Nov 28, 2017
Engine And Engine CoolingFuel/propulsion System
TL* THE CONTACT OWNS A 1995 DODGE RAM 1500. THE CONTACT STATED THAT THE DEALER (BERT OGDEN CHRYSLER DODGE JEEP RAM, 8421 W EXPY 83, HARLINGEN, TX 78552, (956) 734-2462) INSPECTED THE VEHICLE AND INDICATED THAT THE VAPOR CANISTER PURGE VALVE NEEDED TO BE REPLACED; HOWEVER, THE PART WAS NO LONGER IN PRODUCTION. THE CONTACT WAS UNA…
Read full complaint
TL* THE CONTACT OWNS A 1995 DODGE RAM 1500. THE CONTACT STATED THAT THE DEALER (BERT OGDEN CHRYSLER DODGE JEEP RAM, 8421 W EXPY 83, HARLINGEN, TX 78552, (956) 734-2462) INSPECTED THE VEHICLE AND INDICATED THAT THE VAPOR CANISTER PURGE VALVE NEEDED TO BE REPLACED; HOWEVER, THE PART WAS NO LONGER IN PRODUCTION. THE CONTACT WAS UNABLE TO DETERMINE IF THE MANUFACTURER WOULD BE ABLE TO PROVIDE THE PART FOR THE DEALER TO COMPLETE THE REPAIR. IN ADDITION, THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 00V135000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS CONTACTED TO DETERMINE A SOLUTION. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #11048885
Mileage unknown · Aug 1, 2003
Engine And Engine CoolingFuel System, Gasoline
THE VEHICLE HAD AN EXHAUST LEAK. THE MANUFACTURER WAS CONTACTED, AND STATED THERE WAS NO RECALL. *AK THERE WAS A LEAK IN THE GAS TANK WHERE THE GAS TANK ENTERED. THERE WAS A RUBBER SEAL WHERE THE METAL PIPE WENT INTO THE TANK. THE RUBBER DISSOLVED FROM THE GAS TANK AND CAUSED GAS TO LEAK OUT. *SCC *JB
NHTSA ODI #10026696
Mileage unknown · Jun 9, 2003
Engine And Engine Cooling
CONSUMER STATES THAT WHILE DRIVING AT ANY SPEED AND WITHOUT WARNING THE VEHICLE WILL SHUT OFF CAUSING CONSUMER TO PULL OVER. DEALER NOTIFIED. *MR THE DEALER COULD NOT DIAGNOSE THE PROBLEM. ON ONE OCCASION IT HAD TAKEN THREE HOURS TO DRIVE FIVE MILES. THE CONSUMER WAS GIVEN AN EXPERT OPINION AND WAS TOLD IT WAS TOLD THAT IT W…
Read full complaint
CONSUMER STATES THAT WHILE DRIVING AT ANY SPEED AND WITHOUT WARNING THE VEHICLE WILL SHUT OFF CAUSING CONSUMER TO PULL OVER. DEALER NOTIFIED. *MR THE DEALER COULD NOT DIAGNOSE THE PROBLEM. ON ONE OCCASION IT HAD TAKEN THREE HOURS TO DRIVE FIVE MILES. THE CONSUMER WAS GIVEN AN EXPERT OPINION AND WAS TOLD IT WAS TOLD THAT IT WAS THE CATALYTIC CONVERTER WHICH WAS REPLACED BUT LATER CUT OFF FOUR MORE TIMES. THE SECOND EXPERT OPINION WAS THAT THE PROBLEM WAS THE FUEL PUMP BUT IT WAS IN WORKING ORDER. THE ENGINE LIGHT HAD COME ON AND READ FAULTY CRANK POSITIONING SENSOR WHICH WAS ALSO REPLACED. THE VEHICLE CUT OFF AGAIN WITHIN A MONTH, IN FACT THE VEHICLE CONTINUED TO SHUT OFF. ANOTHER EXPERT STATED THAT HE WAS SURE THE FUEL PUMP WAS THE PROBLEM WHICH WAS REPLACED. EACH INCIDENT HAPPENED THE SAME WAY; 1/4 TO 1/2 TANK OF GAS. THE CONSUMER REQUESTED A TRADE, RECALL, AND OR A PROPER FIX. *SCC 10/17/03 - CONSUMER STATES THE DEALER HAD THE VEHICLE FOR EIGHT MONTHS AND STILL HAVE NOT FOUND A REMEDY.
NHTSA ODI #10018165
Mileage unknown · Jun 12, 2002
Engine And Engine Cooling
VEHICLE WAS LEAKING OIL, AND ENGINE BLEW UP. CONTACTED DEALER ,PROBLEM DUE TO A HEAD GASKET FAILURE.*AK
NHTSA ODI #8011623
Mileage unknown · Apr 29, 2002
Electrical SystemEngine And Engine CoolingService Brakes, HydraulicFire
HAD A RECALL ON IGNITION WIRING & ABS---REPLACED WIRING HARNESS UNDER DASH ONLY WITH THE STEERING COLUMN---A MONTH OR SO LATER BATTERY COMPLETELY MELTED, THE CHECK ENGINE LIGHT WAS STAYING ON---THEY WERE TO RESET THE COMPUTER--INSTEAD WITHOUT BEING CONSULTED TOOK THE TRUCK MOTOR APART
NHTSA ODI #9006790
Mileage unknown · May 17, 2001
Engine And Engine Cooling
AT 85,000 MILES CRANKSHAFT NEEDED TO BE REPLACED EVERY 10,000 MILES. ALL REPAIRS WERE DONE BY VARIOUS INDEPENDENT REPAIR SHOPS. DEALER / MANUFACTURER WERE NOTIFIED. FEEL FREE TO PROVIDE US WITH ANY FURTHER DETAILS ON THIS MATTER. *AK
NHTSA ODI #888545
Mileage unknown · May 30, 2000
Engine And Engine CoolingFuel System, GasolineService Brakes, Hydraulic
BRAKE SHOES AND PADS FAILED. NLM
NHTSA ODI #784668
Mileage unknown · Dec 18, 1999
Engine And Engine Cooling
THIS OCCURS IN ALL THE 6CYLS OF THIS SIZE AND YEAR THAT I HAVE SEEN. NO MECHANIC HAS BEEN ABLE TO OFFER ANY ADVICE NO SAFETY DEFECT (S) LISTED IN SUMMARY. .
NHTSA ODI #716197
Mileage unknown · Feb 9, 1999
Engine And Engine CoolingPower TrainService Brakes, Hydraulic
ENGINE NEEDS TO BE REPLACED.
NHTSA ODI #530850
Mileage unknown · Nov 24, 1998
Engine And Engine CoolingUnknown Or Other
WHILE DRIVING AT 60 MPH THE OIL LIGHT CAME ON, CAUSING THE CONSUMER TO PULL OVER, AND THE VEHICLE DIED OUT. THE VEHILCE WOULDN'T MOVE ANYWHERE. TOOK THE VEHICLE TO THE DEALER AND THE DEALER SAID THE ENGINE BLEW OUT. *AK
NHTSA ODI #831250
NHTSA investigations
4DP03006 · Seat Back Failure
Opened Sep 23, 2003 · Closed Apr 8, 2004
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:recliner
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
Additional source detail variants (2)
Seats
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
Seats:front Assembly:recliner
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
EA98010 · Headlight Circuit
Opened May 8, 1998 · Closed Dec 10, 1999
Status: closed (inferred from source dates) · Exterior Lighting
THE HEADLAMP SWITCH IN THE SUBJECT VEHICLES CAN OVER-HEAT AND FAIL RESULTING IN LOSS OF HEAD LAMPS AND POSSIBLY OTHER LIGHTS.DAIMLERCHRYSLER CONDUCTED A SERIES OF TESTS AND DETERMINED THAT THE 3500 SERIES IS PRONE TO GENERATING HEAD LAMP SWITCH TEMPERATURES IN EXCESS OF THE SWITCH LUBRICANT THRESHOLD OF 100 DEGREES CENTIGRADE.WHEN THIS OCCURS, THE LUBRICANT SOLIDIFIES AND ADHERES TO THE SWITCH CONTACH SURFACES INCREASING INTERNAL RESISTANCE AND THERFORE, TEMPERATURE.DAIMLERCHRYSLER INFORMED THE NHTSA THAT IT WOULD INITIATE A RECALL OF 79,3665 MODEL YEAR 1994-1997 DODGE 3500 SERIES RAM TRUCKS ONLY BASED ON ADDITIONAL TESTING FROM WHICH IT DETERMINED THAT THE 1500/2500 SERIES VEHICLES NOMINALLY OPERATE SIGNIFICANTLY BELOW THE TEMPERATURE THRESHOLD OF THE SWITCH LUBRICANT.OWNERS OF 1500/2500 SERIES TRUCKS WERE SENT A NOTIFICATION LETTER ADVISING OF THE PROPER METHODS FOR ADDING AFTERMARKET LIGHTING ACCESSORIES.
PE96022 · Alleged Failure Of Steering Pitman Shaft
Opened Mar 22, 1996 · Closed Jul 31, 1996
Status: closed (inferred from source dates) · Steering:gear Box:shaft Pitman
STEERING BOX OUTPUT (PITMAN) SHAFT BREAKAGE RESULTING IN LOSS OF CONTROL.
Illustration