THIS HAS NOT ONLY HAPPENED TO ME!! I HAVE SEEN FROM REPAIR SHOPS THAT THIS IS A REGULAR THING. THE TIMING COVER WILL START LEAKING AT SEAM WITH BLOCK. AT THE CHANEL WHERE WATER GOES TO WATERPUMP. THE METAL THERE GETS ATE UP BY THE ANTIFREEZE AND THINS THE WALL TILL THERE IS A CUPPED OUT PLACE AT THE SEAM . THE ALUMINUM GETS EROD…
Read full complaint
THIS HAS NOT ONLY HAPPENED TO ME!! I HAVE SEEN FROM REPAIR SHOPS THAT THIS IS A REGULAR THING. THE TIMING COVER WILL START LEAKING AT SEAM WITH BLOCK. AT THE CHANEL WHERE WATER GOES TO WATERPUMP. THE METAL THERE GETS ATE UP BY THE ANTIFREEZE AND THINS THE WALL TILL THERE IS A CUPPED OUT PLACE AT THE SEAM . THE ALUMINUM GETS ERODED THERE. I HAVE NEVER SEEN THIS HAPPEN ON ANY OTHER CAR. 5.9 LITER V8, 360 CUBICINCH ENGINE. THE METAL THERE HAS TO BE SUBSTANDARD!! IT IS NOT THE GASKET BUT THE TIMING COVER THAT IS DEFECTIVE. IT WILL CAUSE THE ENGINE TO RUN HOT. THE TIMING COVER IS SUB STANDARD. *TR
NHTSA ODI #10554856
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
DP03006 · Seat Back Failure
Opened Sep 23, 2003 · Closed Apr 8, 2004
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:recliner
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
Additional source detail variants (2)
Seats
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
Seats:front Assembly:recliner
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
EA98010 · Headlight Circuit
Opened May 8, 1998 · Closed Dec 10, 1999
Status: closed (inferred from source dates) · Exterior Lighting
THE HEADLAMP SWITCH IN THE SUBJECT VEHICLES CAN OVER-HEAT AND FAIL RESULTING IN LOSS OF HEAD LAMPS AND POSSIBLY OTHER LIGHTS.DAIMLERCHRYSLER CONDUCTED A SERIES OF TESTS AND DETERMINED THAT THE 3500 SERIES IS PRONE TO GENERATING HEAD LAMP SWITCH TEMPERATURES IN EXCESS OF THE SWITCH LUBRICANT THRESHOLD OF 100 DEGREES CENTIGRADE.WHEN THIS OCCURS, THE LUBRICANT SOLIDIFIES AND ADHERES TO THE SWITCH CONTACH SURFACES INCREASING INTERNAL RESISTANCE AND THERFORE, TEMPERATURE.DAIMLERCHRYSLER INFORMED THE NHTSA THAT IT WOULD INITIATE A RECALL OF 79,3665 MODEL YEAR 1994-1997 DODGE 3500 SERIES RAM TRUCKS ONLY BASED ON ADDITIONAL TESTING FROM WHICH IT DETERMINED THAT THE 1500/2500 SERIES VEHICLES NOMINALLY OPERATE SIGNIFICANTLY BELOW THE TEMPERATURE THRESHOLD OF THE SWITCH LUBRICANT.OWNERS OF 1500/2500 SERIES TRUCKS WERE SENT A NOTIFICATION LETTER ADVISING OF THE PROPER METHODS FOR ADDING AFTERMARKET LIGHTING ACCESSORIES.
PE96022 · Alleged Failure Of Steering Pitman Shaft
Opened Mar 22, 1996 · Closed Jul 31, 1996
Status: closed (inferred from source dates) · Steering:gear Box:shaft Pitman
STEERING BOX OUTPUT (PITMAN) SHAFT BREAKAGE RESULTING IN LOSS OF CONTROL.
1995 Dodge RAM 1500 Problems, Complaints & Recalls | Skip That Year
Illustration