NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
161 reportsMileage unknown · Mar 10, 2015
Electrical System
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY AWD. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 11V139000 (ELECTRICAL SYSTEM); HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AW…
Read full complaint
TL* THE CONTACT OWNS A 2009 DODGE JOURNEY AWD. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 11V139000 (ELECTRICAL SYSTEM); HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
NHTSA ODI #10693202
Mileage unknown · Feb 26, 2015
Unknown Or Other
GOT A RECALL FOR THE FOBIK IN SEPTEMBER WENT TO THE DEALER COURTESY MOTORS THEY SAID THEY PUT OUR NAME ONLIST SHOULD BE IN DECEMBER WELL HERE IT IS END OF FEB. AND STILL NO PART IS THERE STILL AHO;D UP ON THIS PART? ALSO MY AIRVBBAG LIGHT HAS BEEN ON SINCE THEN IS THIS PART OF THE PROBLEM WITH THAT PART.
NHTSA ODI #10690770
Mileage unknown · Jan 16, 2015
Electrical SystemElectronic Stability Control (esc)
2009 DODGE JOURNEY HAS A RECALL ( L25) ON THE WIN MODULE DETENT RING , THIS VEHICLE WAS SOLD TO ME BY A DEALERSHIP IN 2012 WITH NOTHING SHOWING ON THE CAR FAX OF THIS RECALL. THE RECALL CAUSE THE KEY TO SLIP FROM THE IGNITION AND COMPLETELY SHUTTING THE CAR DOWN WHILE MOVING. THE KEY INADVERTENTLY MOVES AND THE ENGINE SHUT DOWN …
Read full complaint
2009 DODGE JOURNEY HAS A RECALL ( L25) ON THE WIN MODULE DETENT RING , THIS VEHICLE WAS SOLD TO ME BY A DEALERSHIP IN 2012 WITH NOTHING SHOWING ON THE CAR FAX OF THIS RECALL. THE RECALL CAUSE THE KEY TO SLIP FROM THE IGNITION AND COMPLETELY SHUTTING THE CAR DOWN WHILE MOVING. THE KEY INADVERTENTLY MOVES AND THE ENGINE SHUT DOWN , DEPOWERING THE AIR BAGS, POWER STEERING AND POWER BRAKING. WHEN INITIALLY CALLING IN THE COMPLAINT , CHRYSLER/ DODGE EXPLAINED THAT THERE IS NO FIX OR PART YET AVAILABLE. I FURTHER EXPLAINED AS A SINGLE MOTHER THIS WAS A HUGE SAFETY HAZARD , BECAUSE IN MULTIPLE OCCASIONS I HAVE BEEN ON A FREEWAY OR STREET AND ALMOST ROLLED INTO ANOTHER CAR , ROLLING DOWN BACKWARDS ON A FREEWAY RAMP UNABLE TO BRAKE OR TELEPHONE POLE. DODGE/CHRYSLER STATED I WOULD JUST HAVE TO WAIT OR TAKE IT TO A DEALERSHIP FOR A TEMPORARY FIX.( THIS SAME TEMPORARY FIX IS NOTED IN THE DODGE DEALER SYSTEM NOT TO PUT IN THE NEWER YEAR PARTS INTO AN OLDER MODEL CAR ) AFTER CALLING AND GOING UP TO THEIR RECOMMENDED DEALERSHIPS FOR DODGE THE SERVICE DEPARTMENT STATES THEY HAVE THEIR HANDS TIED BECAUSE THERE IS STILL NO PART AVAILABLE FOR THE YEAR OF MY CAR. THEY ALSO STATED I WOULD HAVE TO PAY OUT OF POCKET ALMOST 700 DOLLARS FOR A TEMP FIX USING A NEWER MODEL CAR THAT MAY OR MAY NOT FIX IT . I AM COMPLETELY TERRIFIED TO DRIVE MY CAR THAT I HAVE TO CONTINUE TO PAY ON AND DODGE/CHRYSLER IS COMPLETELY BRUSHING OFF THE ISSUE. GOD FORBID IF WE ARE HARMED OR EVENTUALLY IN AN ACCIDENT WAITING 3 YEARS LATER FOR A REPAIR FOR THIS VEHICLE PART. *TR
NHTSA ODI #10676136
83,000 miles · Jan 2, 2015
Engine
AS I WAS TURNING INTO A SUBDIVISION A LOUD KNOCKING NOISE FOLLOWED BY A SQUEAL AND MY ENGINE COMPLETELY SHUT DOWN AND SEIZED. I HAVE A LITTLE OVER 83,000 MILES ON MY 2009 DODGE JOURNEY. THERE WERE NO INDICATIONS OF ANY PROBLEMS. IT WAS ONE OF THE QUIETEST VEHICLES I HAVE EVER OWNED, AND THIS HAPPENED OUT OF NO WHERE. THE SHO…
Read full complaint
AS I WAS TURNING INTO A SUBDIVISION A LOUD KNOCKING NOISE FOLLOWED BY A SQUEAL AND MY ENGINE COMPLETELY SHUT DOWN AND SEIZED. I HAVE A LITTLE OVER 83,000 MILES ON MY 2009 DODGE JOURNEY. THERE WERE NO INDICATIONS OF ANY PROBLEMS. IT WAS ONE OF THE QUIETEST VEHICLES I HAVE EVER OWNED, AND THIS HAPPENED OUT OF NO WHERE. THE SHOP HAS INFORMED US THAT THE ENGINE IS COMPLETELY SEIZED AND NEEDS TO BE REPLACED. THE MECHANIC HAS NOT SEEN SUCH SILVERY OIL IN A LONG TIME. THIS COMES ACROSS LIKE A MANUFACTURE ERROR SUCH AS YOUR RECALL FOR THE ROD BEARING IN YOUR 2012. CAN SOMEONE PLEASE INVESTIGATE THIS. I JUST MADE MY THIRD PAYMENT ON THIS VEHICLE, AND NOW I AM WITHOUT A VEHICLE, AFTER OWNING IT FOR 87 DAYS AT THE TIME OF INCIDENT. AN OIL CHANGE WAS DONE APPROXIMATELY 1000 MILES PRIOR TO THE INCIDENT AND THERE WERE ABSOLUTELY NO WARNING SIGNS. WE NEED OUR VEHICLE, AND IT IS GOING TO COST $4000 TO FIX, AND WE STILL OWE OVER $10,000 BECAUSE WE PURCHASED IT ON SEPTEMBER 25, 2014 AND THIS HAPPENED ON DECEMBER 22, 2014. THIS HAS TO BE A MANUFACTURING ISSUE. PLEASE ADVISE AS TO WHAT TO DO TO HAVE THIS FIXED. *TR
NHTSA ODI #10669690
Mileage unknown · Dec 29, 2014
Electrical System
SAFETY RECALL ON CHRYSLER. UPON STARTING YOUR VEHICLE THE FREQUENCY OPERATED BUTTON IGNITION KEY (FOBIK), MAY NOT FULLY SEAT IN THE "ON" POSITION. *MW THE CONSUMER WAS INFORMED THE PART WAS NOT AVAILABLE. *JB
NHTSA ODI #10661717
61,750 miles · Nov 29, 2014
Electrical SystemEngineUnknown Or Other
I JUST BOUGHT THIS CAR IN JULY 2014 USED WITH 56,000 MILES ON IT. AND I ALREADY HAD IT IN THE SHOP JUST IN THE BEGINNING OF AUGUST BECAUSE THERE WAS A KNOCKING NOISE COMING FROM THE ENGINE. IT SOUNDED LIKE A NORMAL "MORNING KNOCK" BUT IT WAS ALWAYS THERE AND WHEN YOU DROVE IT SOUNDED WORSE. I HAVE NOT STARTED MY CAR ALL DAY TOD…
Read full complaint
I JUST BOUGHT THIS CAR IN JULY 2014 USED WITH 56,000 MILES ON IT. AND I ALREADY HAD IT IN THE SHOP JUST IN THE BEGINNING OF AUGUST BECAUSE THERE WAS A KNOCKING NOISE COMING FROM THE ENGINE. IT SOUNDED LIKE A NORMAL "MORNING KNOCK" BUT IT WAS ALWAYS THERE AND WHEN YOU DROVE IT SOUNDED WORSE. I HAVE NOT STARTED MY CAR ALL DAY TODAY, THEN WHEN I WENT TO GO SOMEWHERE I TRIED TO START MY CAR AND IT JUST GAVE ME TICK NOISES IT WOULD NOT TURN OVER. I KNOW THE BATTERY WASN'T DEAD BECAUSE THE CAR DOOR WAS OPEN AND THERE WAS THE DING NOISES AND THE LIGHTS WERE ALL ON IN THE CAR WHEN THE DOORS WERE OPEN. NOW I HAVE GOTTEN THE VEHICLE TO TURN OVER, BUT WITH A 1 YEAR OLD I AM TERRIFIED TO DRIVE MY ALMOST NEW CAR! I NEED SOMETHING FIXED. *TR
NHTSA ODI #10661293
Mileage unknown · Nov 9, 2014
Electrical System
MY VEHICLE WILL TURN OFF AS I AM DRIVING AND SOMETIMES THE CAR WILL NOT START, IT WILL CLICK AND ONLY AFTER ME SWITCHING MY GEAR INTO NEUTRAL AND STARTING THE CAR AGAIN WILL IT START. I HAVE LITERALLY SEEN AND HEARD A CLICK THE KEY SWITCHING TO THE "ACCESSORY" POSITION, THEN THE ENGINE SHUTS OFF. *TR
NHTSA ODI #10653721
130,000 miles · Nov 6, 2014
Electrical System
I AM TRYING TO GET ENFORCEMENT ON AN ALREADY RELEASED RECALL. THIS I MY DAUGHTERS VEHICLE, RECALLED DUE TO FAULTY KEY AND IGNITION. HERS HAS THE ISSUE AND WHEN SHE TRIED TO GET THE REMEDY SHE WAS INFORMED THEY CAN NOT FIX THE PROBLEM DUE TO LACK OF PARTS AND THAT THEY HAVE NO INTENTIONS OF PRODUCING THE PARTS NEEDED. ALSO THEY W…
Read full complaint
I AM TRYING TO GET ENFORCEMENT ON AN ALREADY RELEASED RECALL. THIS I MY DAUGHTERS VEHICLE, RECALLED DUE TO FAULTY KEY AND IGNITION. HERS HAS THE ISSUE AND WHEN SHE TRIED TO GET THE REMEDY SHE WAS INFORMED THEY CAN NOT FIX THE PROBLEM DUE TO LACK OF PARTS AND THAT THEY HAVE NO INTENTIONS OF PRODUCING THE PARTS NEEDED. ALSO THEY WOULD FIX A 2010 BUT THE 2009 IS A BIGGER ISSUE AND NOT EASILY SOLVED. HER RECALL IS L25/NHTSA 14V-373. *TR
NHTSA ODI #10652976
90,000 miles · Oct 24, 2014
Electrical System
THERE IS A RECALL ON THE CARE PREVENTING IT FROM STARTING OR THE CAR CAN SUDDENLY STOP AND CRASH. I NEED THE PARTS, AND CHRYSLER HAS NO IDEA WHEN THE PARTS WILL BE RECEIVED. I ASKED FOR A RENTAL IN THE MEANTIME AS TO STOP DRIVING MY CAR BECAUSE I DO NOT WANT TO CONTINUE TO GET STRANDED WITH MYSELF AND CHILDREN. THEY CANNOT GIVE …
Read full complaint
THERE IS A RECALL ON THE CARE PREVENTING IT FROM STARTING OR THE CAR CAN SUDDENLY STOP AND CRASH. I NEED THE PARTS, AND CHRYSLER HAS NO IDEA WHEN THE PARTS WILL BE RECEIVED. I ASKED FOR A RENTAL IN THE MEANTIME AS TO STOP DRIVING MY CAR BECAUSE I DO NOT WANT TO CONTINUE TO GET STRANDED WITH MYSELF AND CHILDREN. THEY CANNOT GIVE ME A TIME FRAME AND I NEED TO GET TO WORK AND DRIVE SAFELY. UPDATED 12/17/14. *JB
NHTSA ODI #10649689
66,000 miles · Oct 15, 2014
Electrical System
RECALL NHTSA 14V-373 DEALER TOLD ME THEY DO NOT HAVE PART TO DO THE REPAIR. I CONTACTED DODGE/CHRYSLER - ANSWER, WE DO NOT HAVE THE PART AND DO NOT KNOW WHEN THE PART BECOMES AVAILABLE. THE DODGE / MOPAR WEBSITE FOR THE RECALL STATUS OF THE CAR STATES "INCOMPLETE BUT REPAIR PARTS ARE AVAILABLE". *TR
NHTSA ODI #10644973
NHTSA investigations
4EA24003 · Vehicle Entrapment
Opened Aug 1, 2024 · No close date supplied
Status: open (inferred from source dates) · Latches/locks/linkages
The Office of Defects Investigation (ODI) opened PE23-008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During the investigation, ODI collected information from the manufacturer and involved parties to confirm or refute the defect allegation. ODI has determined that additional reports of vehicle entrapment exist for other model year Dodge Journey vehicles. ODI continues to explore the cause of the thermal event and its potential effect on the actuation of the door locks. ODI also continues to explore other potential causes for door lock malfunction. ODI has determined that an upgrade to an Engineering Analysis (EA) is necessary to continue the review of the investigative material and to assess the risk to motor vehicle safety . To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE23008 · Vehicle Entrapment
Opened May 1, 2023 · Closed Aug 15, 2024
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Latches/locks/linkages:doors:lock; Latches/locks/linkages:electronic Lock/latch Actuator
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Latches/locks/linkages:doors:lock
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Latches/locks/linkages:electronic Lock/latch Actuator
The Office of Defects Investigation (ODI) opened PE23008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During this investigation, ODI collected information and evidence related to the defect allegation and incident, from the manufacturer and involved parties. The information and evidence collected in this initial phase was insufficient to make a defect determination. ODI has upgraded this investigation to an Engineering Analysis (EA24003) to develop a more comprehensive understanding of whether a potential safety defect exists. To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
RQ14002 · Air Bag Non-Deployment/Engine Stall
Opened Jun 16, 2014 · Closed Mar 2, 2015
Status: closed (inferred from source dates) · Air Bags; Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Additional source detail variants (2)
Air Bags
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Illustration