AN OIL PLUG FRONT LEFT OF ENGINE BLOCK BLEW OUT PUMPING OIL ONTO CATALYTIC CONVERTER. OPEN FLAMES MELTED WHEEL WELL, BACK BUMPER, AND FUEL HOSES OFF OF GAS TANK. FIRE WENT OUT WENT ALL THE OIL WAS PUMPED OUT OF ENGINE AND CAR STOPPED MOVING. I CONTACTED CHRYSLER SAFETY, THEY REFERRED ME TO DODGE CUSTOMER CARE; THEY INITIALLY CRE…
Read full complaint
AN OIL PLUG FRONT LEFT OF ENGINE BLOCK BLEW OUT PUMPING OIL ONTO CATALYTIC CONVERTER. OPEN FLAMES MELTED WHEEL WELL, BACK BUMPER, AND FUEL HOSES OFF OF GAS TANK. FIRE WENT OUT WENT ALL THE OIL WAS PUMPED OUT OF ENGINE AND CAR STOPPED MOVING. I CONTACTED CHRYSLER SAFETY, THEY REFERRED ME TO DODGE CUSTOMER CARE; THEY INITIALLY CREATED A CASE #31892226 BUT THEN SENT A LETTER SAYING THEY WERE NOT RESPONSIBLE BECAUSE THE CAR WAS OUT OF A THREE-YEAR WARRANTY PERIOD AND ALSO UNSPECIFIED ENVIRONMENTAL FACTORS. ALTHOUGH MY WIFE AND SON WERE ALMOST IMMOLATED, IT WASN'T IMPORTANT ENOUGH FOR THEM TO CHECK INTO. THE CAR REMAINS PARKED AT A LOCAL GARAGE AWAITING INVESTIGATION.
NHTSA ODI #11003653
145,000 miles · Jun 10, 2016
EngineFuel/propulsion System
TL* THE CONTACT OWNS A 2002 DODGE INTREPID. THE CONTACT STATED THAT FUEL FUMES WERE EMITTING IN AND AROUND THE VEHICLE. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT FUEL WAS LEAKING FROM THE TOP OF THE ENGINE AND THE CHECK WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWA…
Read full complaint
TL* THE CONTACT OWNS A 2002 DODGE INTREPID. THE CONTACT STATED THAT FUEL FUMES WERE EMITTING IN AND AROUND THE VEHICLE. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT FUEL WAS LEAKING FROM THE TOP OF THE ENGINE AND THE CHECK WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 145,000.
NHTSA ODI #10873686
111,000 miles · Aug 2, 2014
Engine
ENGINE FAILURE 2.7L 2002 DODGE INTREPID VEHICLE OWNED OVER 10 YEARS 111K MILES CURRENT ODM, OIL CHANGE WAS NOT DUE AT THE TIME OF ENGINE FAILURE. *TR
NHTSA ODI #10618378
111,000 miles · Aug 2, 2014
Engine
ENGINE FAILURE SLUDGE , ENGINE DESIGN. *TR
NHTSA ODI #10618372
129,000 miles · Feb 28, 2013
EngineFuel System, Gasoline
TL* THE CONTACT OWNS A 2002 DODGE INTREPID. THE CONTACT STATED THAT WHEN DRIVING APPROXIMATELY 55 MPH OR LESS, SHE WOULD HEAR A LOUD KNOCKING NOISE WITH THE ILLUMINATION OF THE LOW OIL WARNING LIGHT. THE VEHICLE WAS TAKEN TO A DEALER WHERE THEY ADVISED HER THAT THERE WAS SLUDGE IN THE MOTOR, WHICH NEEDED TO BE CLEANED. THE VEHIC…
Read full complaint
TL* THE CONTACT OWNS A 2002 DODGE INTREPID. THE CONTACT STATED THAT WHEN DRIVING APPROXIMATELY 55 MPH OR LESS, SHE WOULD HEAR A LOUD KNOCKING NOISE WITH THE ILLUMINATION OF THE LOW OIL WARNING LIGHT. THE VEHICLE WAS TAKEN TO A DEALER WHERE THEY ADVISED HER THAT THERE WAS SLUDGE IN THE MOTOR, WHICH NEEDED TO BE CLEANED. THE VEHICLE WAS REPAIRED BY CLEANING THE SLUDGE OUT OF THE ENGINE HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE THEY ADVISED THAT THE FUEL AND THE CAM SENSOR COULD HAVE BEEN THE CAUSE OF THE FAILURE. THE VEHICLE WAS REPAIRED FOR BOTH COMPONENTS. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 129,000. THE CURRENT MILEAGE WAS APPROXIMATELY 130,000. UPDATED 04/02/13*LJ
ON CERTAIN PASSENGER VEHICLES, SEAT BACK RECLINER BOLT BREAKAGE CAN OCCUR RESULTING IN THE SEAT BACK RECLINING UNEXPECTEDLY.
Consequence & remedy
Consequence: IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE RECLINER BOLTS. OWNER NOTIFICATION BEGAN ON APRIL 23, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
BASED ON THE LOW FAILURE RATE, THE ABSENCE OF FAILURES OVER THE PAST YEAR, THE ABSENCE OF INJURIES, AND ODI'S FIELD INVESTIGATION OF INCIDENT VEHICLES, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (4)
Vehicle Speed Control:accelerator Pedal
BASED ON THE LOW FAILURE RATE, THE ABSENCE OF FAILURES OVER THE PAST YEAR, THE ABSENCE OF INJURIES, AND ODI'S FIELD INVESTIGATION OF INCIDENT VEHICLES, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Vehicle Speed Control:cables
BASED ON THE LOW FAILURE RATE, THE ABSENCE OF FAILURES OVER THE PAST YEAR, THE ABSENCE OF INJURIES, AND ODI'S FIELD INVESTIGATION OF INCIDENT VEHICLES, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Vehicle Speed Control
BASED ON THE LOW FAILURE RATE, THE ABSENCE OF FAILURES OVER THE PAST YEAR, THE ABSENCE OF INJURIES, AND ODI'S FIELD INVESTIGATION OF INCIDENT VEHICLES, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Vehicle Speed Control:linkages
BASED ON THE LOW FAILURE RATE, THE ABSENCE OF FAILURES OVER THE PAST YEAR, THE ABSENCE OF INJURIES, AND ODI'S FIELD INVESTIGATION OF INCIDENT VEHICLES, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
2002 Dodge Intrepid Problems, Complaints & Recalls | Skip That Year
Illustration