1997 Dodge Grand Caravan

1) DRIVING NORMALLY THROUGH WATER SEVERAL INCHES DEEP - CERTAINLY NOT AN UNUSUAL SITUATION CONSIDERING THE AMOUNT OF AFTERNOON STORMS WE HAVE RECEIVED THIS SUMMER IN MIDDLE GEORGIA. 2) SERPENTINE BELT SLIPS FROM PULLEYS CAUSING LOSE OF POWER STEERING, WATER PUMP, AIR CONDITIONING, ALTERNATOR. ON FIRST OCCASION AND WITH GREAT DIFFICULTY, MY WIFE WAS ABLE TO PULL OVER AND AVOID A COLLISION. 3) BELT APPEARED UNDAMAGED BUT I REPLACED BELT WITH NEW APPROVED BELT. THE SAME THING HAPPENED ON AUGUST 22, 2005 WHILE I WAS DRIVING ON GEORGIA 87 (RURAL HIGHWAY) IN A SEVERE DOWNPOUR/THUNDERSTORM. THE RAIN AND STORM CONDITIONS WERE SO LOUD I DID NOT NOTICE THE TEMPERATURE GAGE, INDICATOR LIGHTS AND WARNING-BUZZER WARNING ME OF SOME ENGINE FAILURE. I WAS ABLE TO DRIVE TO AN INTERSECTION AND PULL OUT OF TRAFFIC, AGAIN WITH GREAT DIFFICULTY DUE TO POWER STEERING FAILURE. ULTIMATELY, PEOPLE WILL LOSE LIVES OVER THIS ISSUE IF THEY HAVE NOT ALREADY. THERE ARE MANY OF THESE ISSUES POSTED ALL OVER THE INTERNET. PLEASE PURSUE THIS ISSUE SO SOMEONE'S LIFE CAN BE SAVED. *JB

DT: DT: THE CONSUMER PURCHASED THE VEHICLE FROM AN INDIVIDUAL. THE VEHICLE CAUGHT ON FIRE AND WAS DEEMED TOTALED. AFTER THE ACCIDENT THE CONSUMER LEARNED OF TWO RECALLS ON THE VEHICLE, ONE FOR THE FUEL RAIL AND ONE FOR THE AIR BAGS. THE AIR BAG DID NOT DEPLOY DURING THE ACCIDENT. THE MANUFACTURER SENT AN INVESTIGATOR TO INSPECT THE VEHICLE. THERE WAS CONFLICTING INFORMATION ON THE LETTER SENT TO CONSUMER. THIS HAPPENED ON JANUARY 17, 2005 . *AK *NM

THIS IS ON A '97 DODGE GRAND CARAVAN, 3.8 LITER. 1) ORIGINALLY THE BRAKES WERE TERRIBLE, (HARD FOOT PRESSURE WAS NEEDED TO STOP THE VEHICLE.). AFTER 30KMILES, I TOOK IT IN TO A MECHANIC. IN HIS EXPERIENCE, THE DEALER EQUIPPED FRONT DISC "PISTONS MADE OF PHEOLIC MATERIAL" WOULD OFTEN 'STICK'.. AFTER REPLACING W/ "STEEL" PISTONS THIS PROBLEM WAS REPAIRED. 2) THE PROBLEMATIC 'CLOCK-SPRING' FAILED RIGHT BEFORE I RECEIVED A RECALL NOTICE! BUT, AFTER 30K MORE MILES, IT FAILED AGAIN... THIS TIME THE DEALER REFUSED TO REPAIR IT FREE. OF COURSE THE "LEGALLY REQUIRED HORN" IS ALSO NO-FUNCTIONING. 3) THE POWER LOCKS FIGHT ME WHEN OPENING WITH A KEY. ON REMOVING SAID KEY, THEY THEN 'RELOCK' BEFORE I CAN OPEN THE DOOR. I MUST OPEN THE DOOR WITH KEY TURNED IN THE LOOK. (SAFETY, NO, INCONVENIENT YES.) HOWEVER, NOW THE POWER LOCKS "SOMETIMES UNLOCK THEMSELVES" WHEN LEFT IN A LOCKED POSITION, OR WHEN DRIVING. 4) THE ELECTRIC COOLING FAN, THOUGH IT COMES ON WHEN THE NEEDED, "SHUTS OFF" WHEN THE IGNITION IS TURNED OFF. SHOULDN'T' IT "STAY ON" TILL THE RADIATOR COOLS A BIT?? 5) THE "ENGINE STALLED" AND HESITATED/MISFIRED?. NUMEROUS TIMES THE DEALER COULD NOT FIND THE PROBLEM.. FINALLY AN INDEPENDENT "REPLACED CAM SENSOR". THANK YOU IN ADVANCE FOR YOUR "IMPORTANT SERVICES". SINCERELY, [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TERRIBLE SQUEALING NOISE IN BELT AREA. DEALER CHARGED ~$250 FOR BELT AND TENSIONER REPLACEMENT AND NOISE WAS GREATLY REDUCED. SEVERAL YEARS LATER THE NOISE RETURNED AND GREW EVEN WORSE. REPLACED THE WORN BELT AND NOISE WAS GREATLY REDUCED FOR ABOUT TWO WEEKS. AFTER THE NOISE RETURNED, REMOVED THE BELT AND CHECKED ALL PULLEYS - FOUND NO PROBLEMS. REPLACED TENSIONER AND IDLER PULLEYS ANYWAY (~$20 EACH FROM DEALER) AND REINSTALLED BELT. NOISE WAS REDUCED FOR ABOUT TWO DAYS. TOOK VAN TO DEALER WHO SAID THAT IT WAS THE TENSIONER AND WERE SURPISED THAT IT HAD LASTED AS LONG AS IT DID. I PURCHASED AND INSTALLED A NEW ALTERNATOR, POWER STEERING PUMP AND TENSIONER. THE NOISE WAS GREATLY REDUCED, BUT RETURNED FULL FORCE WITHIN A COUPLE OF DAYS. IN DESPERATION I TURNED TO BELT DRESSING AS A POSSIBLE SOLUTION SINCE I HAD CLEANED ALL OF THE PULLEYS PRIOR TO BELT REINSTALLATION. WHEN THE BELT DRESSING WAS SPRAYED ON THE TENSIONER PULLEY THE SOUND DISAPPEARED FOR A FEW SECONDS, THEN RETURNED. BELT DRESSING HAD SMALL OR NO EFFECT WHEN SPRAYED AT OTHER LOCATIONS ALONG THE SERPENTINE BELT.

ON MARCH 3RD, OF 2005, WHILE RETURNING HOME FROM AN OUTING WITH MY FOUR CHILDREN, I NOTICED THAT THE POWER STEERING WENT OUT IN OUR 1997 DODGE GRAND CARAVAN AS I WAS PULLING INTO MY DRIVEWAY. WITHIN MOMENTS AFTER GETTING THE KIDS OUT OF THE VEHICLE, THE FRONT OF OUR MINIVAN WAS FULLY ENGULFED IN FLAMES. BEFORE THE FIRE WAS EXTINGUISHED BY THE LOCAL FIRE DEPARTMENT, THE ENTIRE ENGINE COMPARTMENT, ALONG WITH THE WINDSHIELD AND HOOD WAS DESTROYED AND THE VEHICLE IS NOW A COMPLETE LOSS. SINCE WE DID NOT CARRY COMPREHENSIVE INSURANCE ON THIS VEHICLE DUE TO ITS AGE, I CONTACTED DAIMLER-CHRYSLER TO MAKE A CLAIM FOR DAMAGES, WHICH CAME TO JUST AROUND $5,300. DAIMLER-CHRYSLER SENT AN INDEPENDENT INSPECTOR TO OUR RESIDENCE TO INVESTIGATE THE INCIDENT. THE RESULTS WERE TURNED OVER TO THEIR CLAIM BOARD AND WE WERE ADVISED ON 3-18-05 THAT THEIR COMPANY REFUSED TO ACCEPT RESPONSIBILITY FOR THE FIRE THAT NOT ONLY DESTROYED OUR VEHICLE BUT COULD HAVE EASILY CAUSED INJURY OR DEATH TO MYSELF OR OUR FOUR CHILDREN. IT IS MY UNDERSTANDING FROM THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION WEBSITE THAT THERE HAS BEEN NUMEROUS FIRE-RELATED RECALLS ON THE 1997 DODGE MINIVANS. SPECIFICALLY, AN ARTICLE SHOWED THAT A RECALL EXISTED ON THIS TYPE OF VEHICLE AFTER SEVERAL DEATHS WERE REPORTED AS A RESULT OF FUEL RAIL AND O-RING DEFECTS (DAIMLER CHRYSLER RECALL #895). AT NO TIME SINCE OUR PURCHASE OF THIS VEHICLE, WAS THERE ANY NOTIFICATION CONCERNING SAFETY RECALLS AND AFTER SPECIFICALLY ASKING A DODGE DEALERSHIP, I WAS TOLD THAT THERE WAS NOT. AFTER RECEIVING THE DENIAL LETTER FROM DAIMLER-CHRYSLER, I SPOKE WITH A REPRESENTATIVE FROM THEIR CLAIMS RESOLUTION GROUP, WHO WOULD NOT GIVE ME A REASON WHY THE CLAIM WAS DENIED AND REFUSED TO SEND ME A COPY OF THEIR INVESTIGATOR'S REPORT.

OVER THE PAST 2 YEARS WE HAVE HAD TO REPLACE THE STRUTS MULTIPLE TIMES. WE HAVE NOW BEEN TOLD THAT THE STRUT MOUNT HOUSING THAT HOLDS THE STRUT MOUNT PLATE HAS BECOME OVAL AND NOT ROUND AND THEREFORE IT SOUNDS LIKE A BAD CLUNKING NOISE WHENEVER GOING OVER LARGER BUMPS....WHAT DO WE DO NOW? I AM A MECHANIC AND HAVE NO IDEA WHAT TO DO AND HAVE BEEN TOLD THERE IS NOTHING I CAN DO BY ANOTHER AUTO REPAIR. WE ALSO HAVE HAD PROBLEMS WITH THE TRANSMISSION SHIFTING SINCE BASICALLY WHEN WE BOUGHT IT ABOUT 3 YEARS AGO AND WOULD LIIKE TO KNOW IF YOU HAVE HAD PROBLEMS WITH OTHER 97 GRAND CARAVANS. PLEASE HELP. WE HAVE 4 CHILDREN AND CAN NOT BE WITHOUT A VAN. THANKS.

1997 DODGE GRAND CARAVAN 3.0 6 CYL BELT CAME OFF IN RAIN STORM LEFT ME STRANDED AND MISSED WORK THE BELT WAS IN ONE PIECE AND GOT IT HOME AND HAD A NEW BELT INSTALLED AND PULLEY UPPER FRONT NON GROOVED. AGAIN BELT CAME OFF BRAN NEW BELT NEW BELT PUT ON AGAIN BELT NOW SQUEALING IN THE BACK BELT TENSION ARM NOR SQUEALING BELT RIDES THE PULLEY L/R ABOUT 1/4 INCH THAN BACK. IT SEEMS TO ME. *NM