IllustrationEVENTS INCLUDE NORMAL USE OF VEHICLE. THE FAILURE IS THE STRUT TOWERS ON A 1997 DODGE GRAND CARAVAN HAVE RUST THROUGH CAUSING A SAFETY ISSUE, STRUT COULD BREAK THROUGH THE HOUSING. DODGE HAS DONE NOTHING TO CORRECT THE ISSUE. *TR
1997 Dodge Grand Caravan
Owner reports · Recalls · Investigations
More warning signs than most Grand Caravan years
Owner complaints for the 1997 Dodge Grand Caravan are substantially higher than the model-year median of 284.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 132 of 583 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 107 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 104 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 102 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
29 crash reports39 fire reports22 injury reports
Structure complaints
18 reportsTL*THE CONTACT OWNS A 1997 DODGE GRAND CARAVAN. WHENEVER THE CONTACT SHIFTS, THE VEHICLE MAKES AN UNFAMILIAR NOISE. WHEN THE VEHICLE IS PARKED, IT OPERATES NORMALLY. THE TRANSMISSION STALLS AND WILL START BACK UP, BUT IT IS UNRELIABLE. THE VEHICLE WOULD REV AND HAVE TO BE RESTARTED IN ORDER FOR THE REVVING TO STOP. IF THERE…
Read full complaint
TL*THE CONTACT OWNS A 1997 DODGE GRAND CARAVAN. WHENEVER THE CONTACT SHIFTS, THE VEHICLE MAKES AN UNFAMILIAR NOISE. WHEN THE VEHICLE IS PARKED, IT OPERATES NORMALLY. THE TRANSMISSION STALLS AND WILL START BACK UP, BUT IT IS UNRELIABLE. THE VEHICLE WOULD REV AND HAVE TO BE RESTARTED IN ORDER FOR THE REVVING TO STOP. IF THERE IS A POWER FLUCTUATION, THE REAR WIPERS WILL TURN ON AND OFF AT RANDOM. THE HIGH BEAMS ON THE HEADLIGHTS DO NOT WORK, BUT THE FAILURE WAS REPAIRED. THE PARKING LIGHT ON THE FRONT DRIVER'S SIDE FAILED. HE REPLACED THE BULB, BUT IT STILL DOES NOT WORK. THE CONTACT STATED THAT HE IS CONSTANTLY REPLACING THE LOW BEAM LIGHTS. THE SERPENTINE BELT SLIPS OFF; HOWEVER, IT HAS BEEN REPAIRED. THE CHECK ENGINE LIGHT FLASHES ON AND OFF AND THERE IS A BURNING ELECTRICAL SMELL COMING FROM THE VEHICLE. THE FRONT STRUT ASSEMBLY IS RUSTING AND ROTTING. THE ROCKER PANEL ON THE DRIVER'S SIDE IS RUSTED COMPLETELY. THE CURRENT MILEAGE WAS 186,000 AND FAILURE MILEAGE WAS 149,766. UPDATED 09/10/08 *BF UPDATED 09/11/08.*JB
TL*THE CONTACT OWNS A 1997 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE HATCHBACK LIFTGATE ON THE PASSENGER SIDE OF THE VEHICLE FELL APART. THE HATCHBACK PUSHED A PORTION OF THE SUPPORT BRACKET INTO THE VEHICLE AND CAUSED INTERIOR DAMAGE. THE ARM OF THE LIFTGATE SNAPPED AND FELL ON THE CONTACT'S HEAD. SHE CHECKED THE MAN…
Read full complaint
TL*THE CONTACT OWNS A 1997 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE HATCHBACK LIFTGATE ON THE PASSENGER SIDE OF THE VEHICLE FELL APART. THE HATCHBACK PUSHED A PORTION OF THE SUPPORT BRACKET INTO THE VEHICLE AND CAUSED INTERIOR DAMAGE. THE ARM OF THE LIFTGATE SNAPPED AND FELL ON THE CONTACT'S HEAD. SHE CHECKED THE MANUFACTURER'S WEBSITE TO FIND OUT IF HER VIN WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER 97V079000 (STRUCTURE:BODY:HATCHBACK/LIFTGATE:SUPPORT DEVICE). SHE DISCOVERED THAT HER VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CURRENT MILEAGE WAS 218,523 AND FAILURE MILEAGE WAS APPROXIMATELY 217,000.
THE STRUT TOWER THAT HOLDS THE UPPER PART OF BOTH FRONT STRUTS WAS RUST OUT. IF I HADN'T HAD THIS REPAIRED, THE FRONT STRUT COULD HAVE BROKEN THROUGH THE STRUT TOWER. CHANCES ARE THIS WOULD HAVE BROKEN THROUGH WHILE GOING DOWN THE HIGHWAY (BECAUSE THE FORCES ON THE STRUT TOWERS WOULD HAVE BEEN THE GREATEST THEN). THIS COULD V…
Read full complaint
THE STRUT TOWER THAT HOLDS THE UPPER PART OF BOTH FRONT STRUTS WAS RUST OUT. IF I HADN'T HAD THIS REPAIRED, THE FRONT STRUT COULD HAVE BROKEN THROUGH THE STRUT TOWER. CHANCES ARE THIS WOULD HAVE BROKEN THROUGH WHILE GOING DOWN THE HIGHWAY (BECAUSE THE FORCES ON THE STRUT TOWERS WOULD HAVE BEEN THE GREATEST THEN). THIS COULD VERY PROBABLY HAVE CAUSED A FATAL ACCIDENT. I FEAR THAT MOST CARAVAN OWNERS ARE NOT AWARE OF THIS PROBLEM AND WILL EVENTUALLY BE INVOLVED IN A POTENTIALLY VERY SERIOUS ACCIDENT. I HAD THIS REPAIRED AT MY EXPENSE IN NOVEMBER 2004.*AK
MY 1997 DODGE GRAND CARAVAN HAS BEEN A HEADACHE SINCE I GOT IT. RIGHT AFTER I GOT IT I HAD TO PAY $600 TO GET MY DASHBOARD FIXED BECAUSE ALL MY GAUGES QUIT COMPLETELY. NOW MY WINDSHIELD WIPERS WILL GO OFF BY THEMSELVES EVEN WHEN THEY ARE OFF. THIS HAPPENS WHEN I HIT THE BRAKES OR UNLOCK THE DOORS OR OPEN THE DRIVER SIDE DOOR. MY…
Read full complaint
MY 1997 DODGE GRAND CARAVAN HAS BEEN A HEADACHE SINCE I GOT IT. RIGHT AFTER I GOT IT I HAD TO PAY $600 TO GET MY DASHBOARD FIXED BECAUSE ALL MY GAUGES QUIT COMPLETELY. NOW MY WINDSHIELD WIPERS WILL GO OFF BY THEMSELVES EVEN WHEN THEY ARE OFF. THIS HAPPENS WHEN I HIT THE BRAKES OR UNLOCK THE DOORS OR OPEN THE DRIVER SIDE DOOR. MY CHECK ENGINE LIGHT STAYS ON ALL THE TIME. WE HAVE IT PUT ON A TESTER AND THEY CANT FIND WHY ITS ON. THE REAR END RATTLES PRETTY BAD ALSO AND SOMETIMES THERE IS NO PICK UP AND GO.*AK
WHILE TRAVELING ABOUT 65 MPH ON THE HIGHWAY WITHOUT PRIOR WARNING THE VEHICLE HOOD BECAME ATTACH FROM THE PANEL. AND FLEW IN THE WINDOW THE DEALERSHIP IS AWARE OF THE PROBLEM. MR
WHEN IT RAINS IT LEAKS INSIDE OF VEHICLE. HAD TO REMOVE CARPET BECAUSE OF ODOR. TOOK VEHICLE TO DEALER, AND DEALER REPAIRED VEHICLE, BUT PROBLEM STILL EXISTS. *AK
VEHICLES ELECTRICAL SYSTEM HAS CONSISTENTLY AND RAPIDLY CONSUMED BATTERIES, ALL BATTERIES WERE UNABLE TO BE INSTALLED. *JG
THE AIRBAG WARNING LIGHT ON THE DASH HAS BEEN ACTIVATED. THE HORN AND SPEED CONTROL ARE ALSO INOPERABLE WHICH OCCURRED ABOUT THE SAME TIME THE AIRBAG LIGHT WENT ON. ALSO, THE WINDSHIELD WIPERS ACTIVATE OCCASIONALLY EVEN THOUGH THE SWITCH IS IN THE OFF POSITION. THE OUTSIDE MIRRORS ALSO MOVE WHEN THE AUTOMATIC DOOR LOCKS ARE ACTI…
Read full complaint
THE AIRBAG WARNING LIGHT ON THE DASH HAS BEEN ACTIVATED. THE HORN AND SPEED CONTROL ARE ALSO INOPERABLE WHICH OCCURRED ABOUT THE SAME TIME THE AIRBAG LIGHT WENT ON. ALSO, THE WINDSHIELD WIPERS ACTIVATE OCCASIONALLY EVEN THOUGH THE SWITCH IS IN THE OFF POSITION. THE OUTSIDE MIRRORS ALSO MOVE WHEN THE AUTOMATIC DOOR LOCKS ARE ACTIVATED. IT IS MY UNDERSTANDING THAT THE AIR BAG, HORN AND SPEED CONTROL PROBLEMS ARE CURRENTLY BEING INVESTIGATED BY NHTSA. A FAULTY CLOCKSPRING ASSEMBLY IS THE POSSIBLE CULPRIT.*AK
WHILE PUMPING FUEL INTO VEHICLE SLIDING DOOR HAS CAME BACK AND BROKE FUEL COVER DOOR,KNOCKING HANDLE OUT OF TANK, AND OUT OF CONSUMER'S HAND. SOME OF THE FUEL SPILLED ONTO CONSUMER. DEALER WAS NOTIFIED, AND UNWILLING TO ASSIST. PROVIDE ANY FURTHER INFORMATION. *AK
Official recalls
502V293000 · Air Bags:frontal
Nov 7, 2002
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
00V268000 · Fuel System, Gasoline:fuel Injection System
Sep 13, 2000
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
98V185000 · Child Seat
Aug 6, 1998
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT ON THE INTEGRATED CHILD SEAT CAN BECOME DIFFICULT TO EXTRACT WHEN THE SAFETY BELT LATCH PLATE BECOMES CONTAMINATED.
Consequence & remedy
Consequence: THIS CAN CAUSE DIFFICULTY IN RELEASING A CHILD FROM THE RESTRAINT.
Remedy: DEALERS WILL CLEAN THE LATCH MECHANISM. AN EXTENDER WILL BE ADDED TO THE EMERGENCY RELEASE ANCHOR FOR THE CHILD SEAT SAFETY BELTS SO THAT THE RELEASE CLIPS ARE MORE VISIBLE AND ACCESSIBLE TO THE OPERATOR IN THE EVENT THAT THE RETRACTOR MECHANISM CAN NOT BE UNLOCKED. IN ADDITION, AN INSTRUCTIONAL OWNER'S MANUAL SUPPLEMENT CARD WILL BE PROVIDED.
97V200000 · Tires:bead
Nov 13, 1997
VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH P215/65R15 GOODYEAR CONQUEST TIRES MOUNTED ON STEEL WHEEL. THE TIRES CAN EXPERIENCE A SUDDEN AIR PRESSURE LOSS WITHOUT WARNING.
Consequence & remedy
Consequence: SUDDEN TIRE FAILURE COULD RESULT IN A LOSS OF DRIVER CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE TIRES THAT WERE MOUNTED ON STEEL WHEELS.
96V215000 · Service Brakes, Hydraulic:foundation Components:master Cylinder
Oct 29, 1996
THE MASTER CYLINDER REAR SEAL, BETWEEN THE HYDRAULIC FLUID AND THE VACUUM RESERVOIR, MAY NOT SEAL ADEQUATELY ALLOWING HYDRAULIC FLUID TO BE DRAWN INTO THE POWER ASSIST VACUUM RESERVOIR.
Consequence & remedy
Consequence: AS THE HYDRAULIC FLUID IN THE MASTER CYLINDER RESERVOIR DECREASES, THE LEVEL SENSOR WILL DETECT THE LOSS OF FLUID AND ILLUMINATE THE INSTRUMENT PANEL BRAKE WARNING LAMP. CONTINUED OPERATION OF THE VEHICLE WITH THE WARNING LAMP ILLUMINATED CAN RESULT IN EXTENDED STOPPING DISTANCES.
Remedy: DEALERS WILL REPLACE THE BRAKE MASTER CYLINDER ON ALL AFFECTED VEHICLES. ADDENDUM (4-14-97): VEHICLES INSPECTED PER CHRYSLER RECALL NO. 707 AND FOUND TO BE OUTSIDE THE LISTED SUSPECT MASTER CYLINDER DATE CODE RANGE, MUST NOW HAVE THE MASTER CYLINDER PRIMARY PISTON REPLACED (CHRYSLER RECALL NO. 714).
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
SQ96016 · Integrated Child Seat Belt Lockup
Opened Sep 18, 1996 · Closed Feb 4, 1997
Status: closed (inferred from source dates) · Seat Belts:integrated Child Seat
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.