Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 132 of 583 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Air Bags. Review the 107 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 104 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 102 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
29 crash reports39 fire reports22 injury reports
What owners actually said
583 reports
Mileage unknown · Sep 29, 1999
Power Train
THIS VAN AT VARIOUS SPEEDS WILL JERK SUDDENLY AS IF IT IS LOSING POWER. IT ALSO STALLS OUT AND HAS DONE THIS AT SPEEDS AS HIGH AS 40 MPH DRIVING IN TRAFFIC. I ADMIT THAT THIS IS A INTERMMITENT PROBLEM. I HAVE HAD IT TO THE DEALER SEVERAL TIMES AND THE PROBLEM HAS NOT BEEN DIAGNOSED. OBVIOUSLY THIS IS AN ACCIDENT WAITING TO H…
Read full complaint
THIS VAN AT VARIOUS SPEEDS WILL JERK SUDDENLY AS IF IT IS LOSING POWER. IT ALSO STALLS OUT AND HAS DONE THIS AT SPEEDS AS HIGH AS 40 MPH DRIVING IN TRAFFIC. I ADMIT THAT THIS IS A INTERMMITENT PROBLEM. I HAVE HAD IT TO THE DEALER SEVERAL TIMES AND THE PROBLEM HAS NOT BEEN DIAGNOSED. OBVIOUSLY THIS IS AN ACCIDENT WAITING TO HAPPEN THAT COULD BRING SEVERE INJURY TO MY FAMILY.
NHTSA ODI #712449
Mileage unknown · Sep 27, 1999
Electrical SystemFire
WE RETURNED HOME AT 1:00 PM. WE WERE LEAVING AGAIN AT 1:20 PM. MY WIFE NOTICED THE VEHICLE SMOKING IN THE DRIVEWAY. THE KEY WAS NOT IN THE IGNITION AND THE CAR WAS NOT RUNNING. I OPENED THE HOOD AND NOTED A SMALL FIRE DOWN NEAR THE OIL FILTER. WE CALLED THE FIRE DEPARTMENT. THEY ARRIVED AND STATED THE PROBABLE CAUSE OF THE…
Read full complaint
WE RETURNED HOME AT 1:00 PM. WE WERE LEAVING AGAIN AT 1:20 PM. MY WIFE NOTICED THE VEHICLE SMOKING IN THE DRIVEWAY. THE KEY WAS NOT IN THE IGNITION AND THE CAR WAS NOT RUNNING. I OPENED THE HOOD AND NOTED A SMALL FIRE DOWN NEAR THE OIL FILTER. WE CALLED THE FIRE DEPARTMENT. THEY ARRIVED AND STATED THE PROBABLE CAUSE OF THE FIRE WAS A SHORT CIRCUIT AT OR NEAR THE STARTER. DODGE WAS CONTACTED AND BEGAN A FILE (#6224504) ON THE EVENT. THEY SENT A REPRESENTATIVE, MIKE GIGANTE, TO OUR HOME ON 09/16/99 TO DETERMINE THE CAUSE. HE COULD NOT SPECIFICALLY SAY WHAT CAUSED THE FIRE BUT HE DID STATE THAT THE FIRE OCURRED AT THE STARTER. WE ARE NOT PRIVY TO THE REPORT FILED BY MR. GIGANTE. DODGE CLAIMS THAT A LETTER WAS MAILED TO US ON THE 21ST OF SEPTEMBER. TODAY IS THE 27TH OF SEPTEMBER AND WE HAVE NOT RECEIVED IT. THE WOMAN AT CUSTOMER SERVICE READ THE LETTER TO ME ON 09/27/99 WHICH STATED THAT THE FIRE WAS NOT CAUSED BY A MANUFACTURER'S DEFECT AND THAT THEY ARE NOT RESPONSIBLE FOR THE COST OF REPAIRS. THIS IS NOT ACCEPTABLE TO US. WE STILL DO NOT KNOW WHAT CAUSED THE FIRE; WE CURRENTLY HAVE NO CONFIDENCE IN THE VEHICLE EVEN IF IT IS REPAIRED UNLESS WE KNOW THE CAUSE ; DODGE'S RESPONSE IS UNACCEPTABLE TO US; THEY HAVE NOT MADE ANY REASONABLE CONCLUSION AS TO THE CAUSE OF THE FIRE. AFTER WE GET THE BURNT STARTER MOTOR REPLACED COULD IT SPONTANEOUSLY SHORT CIRCUIT AND CAUSE A FIRE AGAIN? WE HAVE THREE YOUNG CHILDREN AND FEAR DRIVING THE CAR AFTER IT IS REPAIRED. WE CANNOT PARK THE CAR ANYWHERE WITHOUT WONDERING WHAT COULD HAPPEN IF A FIRE STARTS AT NIGHT TIME OR WHEN THE CAR IS PARKED OUTSIDE OR INSIDE OUR ATTACHED GARAGE. PLEASE INVESTIGATE THIS MATTER; WE ARE CONCERNED FOR OURSELVES AS WELL AS FOR OTHERS DRIVING THE 1997 GRAND CARAVAN.
NHTSA ODI #712259
Mileage unknown · Sep 24, 1999
Engine And Engine Cooling
THE ENGINE IS REQUIRING AN EXCESSIVE AMOUNT OF COLLANT TO KEEP FROM OVER HEATING . DLR CANT FIND PROBLEM.
NHTSA ODI #848645
Mileage unknown · Sep 24, 1999
Service Brakes, Hydraulic
ORIGINAL ROTORS FAILED AFTER 17K MI. (VAN STARTED VIBRATING DURING BRAKING ) DEALER REPLACED ROTORS. REPLACEMENTS STARTED TO VIBRATE SEVERELY AFTER 17,000 MILES. DEALER SAID THEY ARE PITTED ON THE INSIDE, MUST BE REPLACED TO STOP THE VIBRATION BUT THEY ARE SAFE TO DRIVE. THE VIBRATION MAKES ME QUESTION THEIR SAFETY.
NHTSA ODI #712045
Mileage unknown · Sep 24, 1999
Visibility
THE FRONT WIPERS COME ON FOR NO REASON. SOMETIMES THEY JUST WIPE ONCE. OTHER TIMES THEY KEEP WIPING UNTIL WE TURN THE SWITCH "ON" AND THEN BACK TO "OFF." IT IS SURPRISING TO BE DRIVING AND HAVE THE WIPERS START WORKING.
NHTSA ODI #712043
Mileage unknown · Sep 10, 1999
Latches/locks/linkages
LOCKS ON THE DOOR WILL NOT UNLOCK.THE KEY CONSTANTLY TURNED, AROUND AND THE DOORS COULD NOT BE UNLOCKED MANUALLY EITHER. *AK
NHTSA ODI #847470
Mileage unknown · Sep 8, 1999
Engine And Engine CoolingCrash
LOST CONTROL OF VEHICLE, DUE TO TENSION PULLEY SNAPPING OFF AT ENGINE BLOCK AND CAUSING BRAKE + STEERING ON THE ONE BELT SYSTEM. SERVICEMAN STATED THAT THIS IS A COMMON PROBLEM?DOESN'T SOUND SAFE TO ME!
NHTSA ODI #711084
Mileage unknown · Sep 5, 1999
Visibility
PHANTOM WINDSHIELD WIPER TURNS ITSELF ON, MAKES ONE SWIPE, TURNS OFF. FREQUENCY INCREASING. NOW YOU HAVE TO TURN THE WINDSHIELD WIPERS ON TO GET THEM TO TURN OFF. HAPPENS ABOUT EVERY FIFTEEN MINUTES
NHTSA ODI #710937
Mileage unknown · Sep 1, 1999
Visibility
VEHICLE EXPERIENCING PROBLEM WITH WINDSHEILD WIPERS OPERATING WHILE IN AN OFF MODE. DEALER NOTIFIED, AND INFORMED CONSUMER THAT REPAIRS WOULD ONLY BE DONE IF VEHICLE WAS UNDER WARRANTY. *AK
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT ON THE INTEGRATED CHILD SEAT CAN BECOME DIFFICULT TO EXTRACT WHEN THE SAFETY BELT LATCH PLATE BECOMES CONTAMINATED.
Consequence & remedy
Consequence: THIS CAN CAUSE DIFFICULTY IN RELEASING A CHILD FROM THE RESTRAINT.
Remedy: DEALERS WILL CLEAN THE LATCH MECHANISM. AN EXTENDER WILL BE ADDED TO THE EMERGENCY RELEASE ANCHOR FOR THE CHILD SEAT SAFETY BELTS SO THAT THE RELEASE CLIPS ARE MORE VISIBLE AND ACCESSIBLE TO THE OPERATOR IN THE EVENT THAT THE RETRACTOR MECHANISM CAN NOT BE UNLOCKED. IN ADDITION, AN INSTRUCTIONAL OWNER'S MANUAL SUPPLEMENT CARD WILL BE PROVIDED.
VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH P215/65R15 GOODYEAR CONQUEST TIRES MOUNTED ON STEEL WHEEL. THE TIRES CAN EXPERIENCE A SUDDEN AIR PRESSURE LOSS WITHOUT WARNING.
Consequence & remedy
Consequence: SUDDEN TIRE FAILURE COULD RESULT IN A LOSS OF DRIVER CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE TIRES THAT WERE MOUNTED ON STEEL WHEELS.
THE MASTER CYLINDER REAR SEAL, BETWEEN THE HYDRAULIC FLUID AND THE VACUUM RESERVOIR, MAY NOT SEAL ADEQUATELY ALLOWING HYDRAULIC FLUID TO BE DRAWN INTO THE POWER ASSIST VACUUM RESERVOIR.
Consequence & remedy
Consequence: AS THE HYDRAULIC FLUID IN THE MASTER CYLINDER RESERVOIR DECREASES, THE LEVEL SENSOR WILL DETECT THE LOSS OF FLUID AND ILLUMINATE THE INSTRUMENT PANEL BRAKE WARNING LAMP. CONTINUED OPERATION OF THE VEHICLE WITH THE WARNING LAMP ILLUMINATED CAN RESULT IN EXTENDED STOPPING DISTANCES.
Remedy: DEALERS WILL REPLACE THE BRAKE MASTER CYLINDER ON ALL AFFECTED VEHICLES. ADDENDUM (4-14-97): VEHICLES INSPECTED PER CHRYSLER RECALL NO. 707 AND FOUND TO BE OUTSIDE THE LISTED SUSPECT MASTER CYLINDER DATE CODE RANGE, MUST NOW HAVE THE MASTER CYLINDER PRIMARY PISTON REPLACED (CHRYSLER RECALL NO. 714).
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.
1997 Dodge Grand Caravan Problems, Complaints & Recalls | Skip That Year
Illustration