Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 132 of 583 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Air Bags. Review the 107 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 104 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 102 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
29 crash reports39 fire reports22 injury reports
What owners actually said
583 reports
Mileage unknown · Aug 3, 2001
Child Seat
WITH THE CAR PARKED AND ENGINE TURNED OFF, I WAS UNABLE TO REMOVE MY CHILD FROM THE INTEGRATED CHILD SAFETY SEAT OF MY DODGE GRAND CARAVAN. THE STRAPS ARE SUPPOSED TO PULL FORWARD FREELY, WHICH THEN LOOSENS THEM ENABLING THE STRAPS TO SLIP OVER THE CHILDS HEAD. AFTER SEVERAL TRIES, I WAS UNABLE TO PULL THE STRAPS FORWARD AT AL…
Read full complaint
WITH THE CAR PARKED AND ENGINE TURNED OFF, I WAS UNABLE TO REMOVE MY CHILD FROM THE INTEGRATED CHILD SAFETY SEAT OF MY DODGE GRAND CARAVAN. THE STRAPS ARE SUPPOSED TO PULL FORWARD FREELY, WHICH THEN LOOSENS THEM ENABLING THE STRAPS TO SLIP OVER THE CHILDS HEAD. AFTER SEVERAL TRIES, I WAS UNABLE TO PULL THE STRAPS FORWARD AT ALL. I THEN MANAGED TO UNCLIP THE CLIPS WHICH ARE LOCATED ON THE BOTTOM SIDES OF THE SEAT AND THEN JUST BARELY SLIP THE STRAP AND YOKE OVER HER HEAD TO FREE HER FROM THE SEAT. I CONTACTED THE LOCAL DEALERSHIP AND THE CHRYSLER CORPORATION ABOUT THIS MATTER. I WAS TOLD BY BOTH PARTIES THAT SINCE MY VEHICLE WAS OVER THE 3 YR./36,000 MILE WARRANTY THAT NEITHER WOULD HELP TO ASSIST IN THE REPAIR. I WAS ALSO TOLD THAT IT WOULD COST SOMEWHERE AROUND $700.00 MAKING IT A VERY COSTLY REPAIR!!! I HATE TO THINK OF WHAT MIGHT HAPPEN IF I WERE REALLY IN A CAR ACCIDENT AND HAD TO GET MY CHILD OUT OF THE SEAT QUICKLY, ONLY TO FIND OUT THAT THE BELT SEIZED OR FROZE UP LIKE IT DID UNABLING ME TO GET MY CHILD OUT OF THE VEHICLE!!*AK
NHTSA ODI #749794
Mileage unknown · Aug 2, 2001
Electrical SystemVehicle Speed ControlCrash
WHILE IN DRIVEWAY VEHICLE SUDDENLY ACCELERATED AT A HIGH RATE OF SPEED TO 30-40 MPH IN A SHORT DISTANCE WITH FOOT STILL ON BRAKE, CAUSING VEHICLE TO CRASH INTO A TREE. PRIOR TO INCIDENT CONSUMER SMELLED WIRES BURNING. *AK
NHTSA ODI #893270
Mileage unknown · Jul 30, 2001
Air Bags
SERVICE DETERMINED THAT CLOCKSPRING NEEDED REPLACEMENT CAUSING AIR BAG LIGHT TO STAY ON. I SAW SHOW ON FOX 5 THAT SAID THIS MAY BE A MANUFACTURER'S DEFECT SUBJECT TO RECALL. *AK
NHTSA ODI #749458
Mileage unknown · Jul 25, 2001
Air BagsElectrical System
THE AIRBAG LIGHT IS ON AND THE HORN DOES NOT WORK. *AK
NHTSA ODI #749142
Mileage unknown · Jul 24, 2001
Air Bags
AIR BAG LIGHT COMING ON INTERMITTANTLY DURING TURNS AND BRAKING. TOOK TO A DODGE DEALER WHERE THEY FOUND AN OPEN CLOCKSPRING CIRCUIT. THEY REPLACED THE CLOCKSPRING. I CHECKED THE NHTSA WEBSIGHT AND FOUND AN ODI ACTION FOR THE IDENTICAL PROBLEM ON AN IDENTICAL VEHICLE. THERE WAS ALSO A RECENT CONSUMER COMPLAINTS SUMMARY FOR T…
Read full complaint
AIR BAG LIGHT COMING ON INTERMITTANTLY DURING TURNS AND BRAKING. TOOK TO A DODGE DEALER WHERE THEY FOUND AN OPEN CLOCKSPRING CIRCUIT. THEY REPLACED THE CLOCKSPRING. I CHECKED THE NHTSA WEBSIGHT AND FOUND AN ODI ACTION FOR THE IDENTICAL PROBLEM ON AN IDENTICAL VEHICLE. THERE WAS ALSO A RECENT CONSUMER COMPLAINTS SUMMARY FOR THE SAME PROBLEM ON AN IDENTICAL VEHICLE.*AK
NHTSA ODI #749063
Mileage unknown · Jul 23, 2001
Air BagsElectrical System
OUR HORN DOES NOT WORK ANYMORE AND AIR BAG LIGHT HAS BEEN ON FOR OVER A YEAR.*AK
NHTSA ODI #749015
Mileage unknown · Jul 19, 2001
Visibility
WINDSHIELD WIPERS BEGAN TURNING ON WHEN LEFT SIGNAL SWITCHED ON; NOW COME ON OFTEN FOR NO REASON, AND NEED TO BE MANUALLY SHUT OFF; AND WHERE EVER THE BLADES ARE WHEN SWITCHED OFF IS WHERE THEY STAY. VERY DISTRACTING AND HUGE ANNOYANCE. INTERMEDIATE FEATURE NO LONGER WORKS. *AK
NHTSA ODI #748750
Mileage unknown · Jul 12, 2001
Engine And Engine CoolingFire
CONSUMER STARTED VEHICLE AND HEARD A LOUD NOISE, SMOKE STARTED COMING OUT FROM THE FRONT, CONSUMER TURNED OFF ENGINE, BUT IT KEPT ON RUNNING, CONSUMER CALLED FIRE DEPARTMENT, CLAIM 05-4650-711. *SLC
NHTSA ODI #6900658
Mileage unknown · Jul 10, 2001
Air BagsElectrical System
AIR BAG LIGHT ON, NO HORN, HAUNTED WIPERS WORK WITHOUT ACTIVATION
NHTSA ODI #748240
Mileage unknown · Jul 10, 2001
Tires
THESE TIRES WERE REPLACED AS PART OF A RECALL IN APPROXIMATELY 1998. THE THREAD ON THIS TIRE HAS VIRTUALLY NO WEAR. THERE IS PROBABLY ABOUT 12-15,000 MILES ON THESE TIRES. MY SON AND I WERE DRIVNG DOWN THE HIGHWAY WHEN THE TIRE COMPLETELY BLEW OUT, NEARLY CAUSING AN ACCIDENT. I HATE TO THINK WHAT WOULD HAVE HAPPENED HAD A CA…
Read full complaint
THESE TIRES WERE REPLACED AS PART OF A RECALL IN APPROXIMATELY 1998. THE THREAD ON THIS TIRE HAS VIRTUALLY NO WEAR. THERE IS PROBABLY ABOUT 12-15,000 MILES ON THESE TIRES. MY SON AND I WERE DRIVNG DOWN THE HIGHWAY WHEN THE TIRE COMPLETELY BLEW OUT, NEARLY CAUSING AN ACCIDENT. I HATE TO THINK WHAT WOULD HAVE HAPPENED HAD A CAR BEEN CLOSER TO US THAN THEY WERE, AND WE WERE NOT ABLE TO GET TO THE SIDE OF THE HIGHWAY SAFELY AND QUICKLY. UPON INSPECTION OF THE TIRE, I SAW THAT THE THREAD HAD COMPLETELY COME OFF THE SIDES OF THE TIRE. THE TIRE WAS IN THREE DISTINCTLY DIFFERENT PARTS. THE TOW TRUCK DRIVER WHO CAME TO CHANGE THE TIRE WAS FLABERGASTED AT THE CONDITION OF THE TIRE. HE SAID THAT THE ONLY OTHER TIRES HE HAS SEEN THAT LOOKED LIKE THIS WERE THE FIRESTORE TIRES ON THE SUVS. WHEN I WENT TO THE TIRE DEALER TO REPLACE THE TIRE, HE HAD THE SAME TYPE OF COMMENTS. IT WAS OBVIOUS TO THE TWO REPAIR MEN THAT THESE TIRES WERE DEFECTVIE. BOTH SAID WE WERE LUCKY TO BE ALIVE GIVEN THE CONDITION OF THE TIRE. MY QUESTION IS NOW, WHAT SHOULD I DO WITH THE OTHER ONE THAT IS ON THERE, AND CAN I GET RETRIBUTION FOR THE COST OF THESE TIRES. ALSO, HOW CAN I FIND OUT IF THIS HAS HAPPENED TO OTHERS IN THE PAST? SHOULD I CONTACT THE DEALERSHIP OR THE MANUFACTURER. IF YOU COULD SUPPLY ME WITH THIS INFORMATION, I WOULD APPRECIATE IT. THANK YOU. *AK (TIRESIZE: P215/65R15)
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
Consequence & remedy
Consequence: THIS CONDITION WILL MANIFEST ITSELF THROUGH ILLUMINATION OF THE AIR BAG WARNING LAMP, AND COULD EVENTUALLY RESULT IN A DRIVER'S AIR BAG OPEN CIRCUIT, IF THE PART IS NOT REPLACED IN A REASONABLE AMOUNT OF TIME.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY ON ALL VEHICLES WITH 70,000 MILES OR LESS. AN EXTENDED LIFETIME WARRANTY WILL ALSO BE PLACED ON THIS COMPONENT FOR ALL AFFECTED VEHICLES, REGARDLESS OF MILEAGE. DAIMLERCHRYSLER WILL ALSO REIMBURSE OWNERS WHO HAVE PAID TO HAVE THE CLOCKSPRING REPLACED ON THEIR VEHICLES. OWNER NOTIFICATION BEGAN NOVEMBER 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A SEAL ON THE VEHICLE FUEL RAILS TO PREVENT EXTERNAL LEAKAGE OF FUEL FROM THE FUEL RAIL CROSSOVER TUBE, SHOULD THE EXISTING O-RINGS CONTINUE TO DEGRADE. OWNER NOTIFICATION BEGAN ON JANUARY 25, 2002. DUE TO THE LARGE QUANTITY OF VEHICLES INVOLVED IN THIS CAMPAIGN, THE OWNER NOTIFICATION WILL BE PHASED OVER THE NEXT SEVERAL MONTHS. HOWEVER, IF A VEHICLE IS LEAKING FUEL FROM THE O-RINGS, THE VEHICLE SHOULD BE TAKEN INTO A DEALER TO HAVE THIS REPAIRED AS SOON AS POSSIBLE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: MINI VANS EQUIPPED WITH INTEGRATED CHILD SEATS. THE SHOULDER HARNESS RESTRAINT ON THE INTEGRATED CHILD SEAT CAN BECOME DIFFICULT TO EXTRACT WHEN THE SAFETY BELT LATCH PLATE BECOMES CONTAMINATED.
Consequence & remedy
Consequence: THIS CAN CAUSE DIFFICULTY IN RELEASING A CHILD FROM THE RESTRAINT.
Remedy: DEALERS WILL CLEAN THE LATCH MECHANISM. AN EXTENDER WILL BE ADDED TO THE EMERGENCY RELEASE ANCHOR FOR THE CHILD SEAT SAFETY BELTS SO THAT THE RELEASE CLIPS ARE MORE VISIBLE AND ACCESSIBLE TO THE OPERATOR IN THE EVENT THAT THE RETRACTOR MECHANISM CAN NOT BE UNLOCKED. IN ADDITION, AN INSTRUCTIONAL OWNER'S MANUAL SUPPLEMENT CARD WILL BE PROVIDED.
VEHICLE DESCRIPTION: PASSENGER MINIVANS EQUIPPED WITH P215/65R15 GOODYEAR CONQUEST TIRES MOUNTED ON STEEL WHEEL. THE TIRES CAN EXPERIENCE A SUDDEN AIR PRESSURE LOSS WITHOUT WARNING.
Consequence & remedy
Consequence: SUDDEN TIRE FAILURE COULD RESULT IN A LOSS OF DRIVER CONTROL OF THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE TIRES THAT WERE MOUNTED ON STEEL WHEELS.
THE MASTER CYLINDER REAR SEAL, BETWEEN THE HYDRAULIC FLUID AND THE VACUUM RESERVOIR, MAY NOT SEAL ADEQUATELY ALLOWING HYDRAULIC FLUID TO BE DRAWN INTO THE POWER ASSIST VACUUM RESERVOIR.
Consequence & remedy
Consequence: AS THE HYDRAULIC FLUID IN THE MASTER CYLINDER RESERVOIR DECREASES, THE LEVEL SENSOR WILL DETECT THE LOSS OF FLUID AND ILLUMINATE THE INSTRUMENT PANEL BRAKE WARNING LAMP. CONTINUED OPERATION OF THE VEHICLE WITH THE WARNING LAMP ILLUMINATED CAN RESULT IN EXTENDED STOPPING DISTANCES.
Remedy: DEALERS WILL REPLACE THE BRAKE MASTER CYLINDER ON ALL AFFECTED VEHICLES. ADDENDUM (4-14-97): VEHICLES INSPECTED PER CHRYSLER RECALL NO. 707 AND FOUND TO BE OUTSIDE THE LISTED SUSPECT MASTER CYLINDER DATE CODE RANGE, MUST NOW HAVE THE MASTER CYLINDER PRIMARY PISTON REPLACED (CHRYSLER RECALL NO. 714).
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6
EA01007 · Air Bag Clockspring
Opened Feb 21, 2001 · Closed Nov 22, 2002
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ00008 · Dc Minivan Fuel Injector Rail Leak
Opened Mar 9, 2000 · Closed Mar 18, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA99013 · Post Collision Fuel System
Opened Jun 11, 1999 · Closed Aug 10, 2001
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
No summary supplied.
PE99010 · POST-COLLISION Fuel System Integrity
Opened Feb 3, 1999 · Closed Jun 11, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
There is no summary currently available
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.
1997 Dodge Grand Caravan Problems, Complaints & Recalls | Skip That Year
Illustration